Crazy Foil ACROBATIC STANDARD User manual

ACROBATIC
PRE ASSEMBLED
ASSEMBLY GUIDE
STANDARD EASY
KITE/WAKE/SURF

OPTIONS
FROM STANDARD TO EASY P.10
FROM EASY TO STANDARD P.17
FROM ACROBATIC TO GLIDER P.28
SUMMARY
PRE ASSEMBLED PIECES
IN YOUR BOX P.1
STANDARD CONFIGURATION P.2
BOARD FIXING
ANY BOARD P.30
BAREFOOT/STRAPS BOARDS P.39
WARNINGS
SECURITY & IMPORTANT NOTICES

WARNINGS
Product involving inherent risks of injury or death. Sharp edges and corners may be very dangerous while manipulating
and using. It is highly recommended to take lessons and/or professionnal advice before starting to use.
•This product should not be used by small children and is reserved to experienced riders.
• Alwayswearahelmetandaproperlyttedlifejacketapprovedbyyourcountry’sagency.
• Consult your physician prior to use.
• ReadtheWarningsandfollowtherightAssemblyGuidetoassembleanduseyourhydrofoilproperlybeforestarting
 tofoil.
• Checkyourequipmentpriortouseforsignsofwearorfailure.
• Manufacturer,distributor,resellerandafliatesshallnotbeheldliableforanyinjuryordeatharisingfromtheuseofa
Crazy Foil product.
• Alwaysuseboardswithproperbindingsorstrapsmaintainingfeetrmlytotheboard.Thebarefootpracticeincreases
 signicantlytherisksofinjuryordeath.Reservedtoveryexperiencedfoilriders.
• Failuretouseanappropriateleashwhilepracticingbarefootmayleadtoinjuryordeathtoyourandothers.
• Neverridealone,alwaysbeaccompaniedbyapersonabletocallemergenciesincaseofincident.
• Usewithsurveillance;keepcontrolatanappropriatespeedforyourabilitylevel.Thefasteryouride,thegreaterthe
 risk.
• Knowthatdockstartsoruseofman-madefeatureincreasesrisks.
• Donotuseinshallowwatersornearshore,seaweeds,docks,pilings,swimmers, otherwatercraftsoranyother 
obstacle.
• Useonlyonwaterwithaqualiedwatercraftdriverandobserver.
•BypurchasingaCrazyFoilproduct,youassumeallresponsibilitiesforitsuseandanyresultinginjuryordeathtoyou
and others.
USE AT YOUR OWN RISK.
TouploadourfullWarnings&Precautionsle,gotowww.crazyfoil.com/warnings-precautions/

IMPORTANT NOTICE
STRENGTH OF THE SCREWS
ALL SCREWS NEED TO BE TIGHTEN WITH THE ALLEN KEY AT HAND-FORCE FIRST.
WHEN THE MAXIMUM IS REACHED, TAKE CLAMPS AND SCREW BY A QUARTER TO A HALF TURN MORE.

IMPORTANT NOTICE
SPECIAL CARE
DISMENTAL YOUR FOIL ON A REGULAR BASIS TO WASH ALL THE PARTS SEPARATELY WITH UNSALTED
WATER. FOR A SPECIAL CARE,, USE AN ANTI-SEIZE GREASE ON BOLTS.

IMPORTANT NOTICE
SOFT FOAM BOARDS
IF USING A BOARD MADE OF SOFT FOAM INSIDE (EXTRUDED POLYSTYREN, EPS)
TAKE SPECIAL CARE TO FIX THE HYDROFOIL.
SEAL YOUR BOARD WEN USING
CRAZY FOIL SANDWICH SYSTEM
USE A MOUNTING SYSTEM

IN YOUR BOX
PRE ASSEMBLED PIECES
Foil 16’’/40cm
Foil 22’’/56cm
Fuselage
Mast base+screws+nuts
1
Stripes
Boots kit
Mast 26’’/66cm or 34’’/86cm

STANDARD

1. REAR FOIL
Foil 16’’/40cm
Fuselage
2
IN YOUR BOX
REAR FOIL

STANDARD CONFIGURATION
FRONT FOIL
Foil 23’’
Fuselage
FRONT FOIL
2. 3
Foil 22’’/56cm

STANDARD CONFIGURATION
MAST & FUSELAGE
3.
MAST
Fuselage
4
BMF
MAST
FUSELAGE
SLIDE
The arrow beside the letter(s)
must point toward the center
of the mast
screw with
ALLEN KEY
ACROBATIC ACROBATIC
USING TRACK SYSTEM
MAST POSITION FUSELAGE:

STANDARD CONFIGURATION
MAST BASE
4.
Mast base
Mast
5

5.
STANDARD CONFIGURATION
MAST FIXING
MAST BASE
A
B
IF USING TRACK SYSTEM
C
IF USING SANDWICH SYSTEM
MAST
BMF
(or NON THREADED T-SLOT)
MAST
MAST BASE
M8 60 SCREWS
MAST
USE BOARD SCREW AND T-NUT FOR ASSEMBLY TO BOARD
C
rear foot
rear foot
center of
the rear foot
6
M8 30
MAST BASE
LOGO
PLATE
MAST
B O A R D
M8 NUT M8 NUT
M8 40
M8 60

STANDARD CONFIGURATION
MAST POSITION
7
ACROBATIC
USING SANDWICH SYSTEM
ACROBATIC
USING TRACK SYSTEM
rear foot rear foot
Position of the fuselage is good only if you position the mast on the board at 25 cm with sandwich installation and 15 cm
with track system.
If you cannot respect these measurements for any reason, compensate by sliding the mast into the fuselage of the
corresponding mesurement difference.
Example:
if the mast center on the board is 5 cm closer to the middle of the rear foot, move the mast forward on the fuselage 5 cm
towards the n.
If the mast center on the board is 5 cm further to the middle of the rear foot, move the mast forward on the fuselage 5 cm
towards the nose.
center of
the rear foot

OPTIONS

FROM STANDARD TO EASY
▶

IN YOUR BOX
OVERVIEW
EASY KIT
FC
M8 40
MINI MAST
BTP AL
or BT
10
BBP AL
or BB
WHAT YOU NEED
from STANDARD
to EASY
BIG FOIL 22’’/56cm
SMALL FOIL 16’’/40cm
BIG FOIL 22’’/56cm
SMALL FOIL 16’’/40cm

1.
FROM STANDARD TO EASY
REMOVE FRONT FOIL
AFOIL 22’’/56cm (BIGGEST)
FT-AL M8 40
11
FB-AL
REMOVE SCREWS, FT-AL,
FB-AL AND BIGGEST FOIL

2.
STANDARD CONFIGURATION
REMOVE REAR FOIL
12
AFOIL 16’’/40cm
(REAR)
BT-AL
M8 40
REMOVE SCREWS, BT-AL,
BB-AL AND SMALLEST FOIL
BB-AL

3.
FROM STANDARD TO EASY
MINI MAST UNDER REAR FOIL
B
CD
MINI MAST
FC
M8 50 M8 50
SCREW WITH ALLEN KEY
BBP AL
or BB
MINI MAST
13
FC
INSERT M8 50 SCREWS FROM THE BOTTOM OF
THE FUSELAGE SO THEY POINT TOWARD THE
SKY
THEN PLACE THE FC PART: THE ARROW MUST
POINT TOWARD THE FRONT OF THE FUSELAGE
M8 50 M8 50
FUSELAGE
A