de Jong Duke NIO User manual

user manual

Contents
1 Safety 6
1.1 Safety use 6
1.2 Installaon 7
1.3 Maintenance 7
1.4 Extendeddownme 8
2 Descriponofthemachine 10
2.1 General 10
2.2 Themachineexteriorandinterior 10
2.3 Displayandselecons 10
2.4 Type plate 10
3 UsingtheNio 12
3.1 Switchon 12
3.2 Switcho 12
3.3 Preparing a drink 12
3.4 Numberselecon 14
3.5 Filling the ingredients 14
3.6 Manualgroundcoeeinsert 15
3.7 Connectthefreshmilk 15
3.8 Servicemenu 17
4 Informaon 18
4.1 Readingoutthecounters 18

5 Maintenanceandcleaning 20
5.1 Dailymaintenance 20
5.2 Weeklymaintenance 25
5.3 Monthlymaintenance 34
5.4 Yearlymaintenance(onlyforoponalfreshmilksystem) 35
6 Messages 36
7 Technicalspecicaons 38
8 Normsandstandards 39

6
1 Safety
1.1 Safety use
• Beforeusingyourcoeemachine,pleasereadthesafety
instruconsandalloftheinformaoninthismanualrstand
keepitforfuturereference.
• Becareful!Thismachineserveshotdrinks.Don’treach
beneaththedispensingnozzlesandhotwaterspoutaer
seleconandduringdispensing.
• Ifafaultoccurs,disconnectthemachinefromtheelectricity
supplyandfromthewatersupply.
• Thisappliancecanbeusedbychildrenaged8yearsand
aboveandpersonswithreducedphysical,sensoryormental
capabiliesorlackofexperienceandknowledgeiftheyhave
beengivensupervisionorinstruconconcerninguseofthe
applianceinasafewayandtheyunderstandthehazards
involved.Childrenshallnotplaywiththeappliance.Cleaning
andusermaintenanceshallnotbedonebychildrenwithout
supervision.
• Themachinemayonlybeinlocaonswhereitcanbe
overseenbytrainedpersonnel.
!

Safety 7
1.2 Installation
• Installaon,transportaonandadjustmentofthemachine
shouldonlybecarriedoutbyproperlytrainedservice
personnel.Theirinstruconsfortransportaon,unpacking
andinstallaonofthemachine,areavailableinthetechnical
manual.
• Checktheappliancefortransportdamage.Donotconnecta
damagedmachine.
• Themachineisnotsuitableforoutdooruse.
• Donotinstallthemachineinanareawhereawaterjetor
similardevicecouldbeused.
• Placethemachineonalevelsurfaceinahygienicdryroom,
withatemperaturebetween5°Cand35°C.(40°F-95°F)
• Donotuseanextensioncord.
• Onlyhose-setsaccordingtoIEC61770maybeusedforthe
connecontothewatersupply.
1.3 Maintenance
• Regularcleaningaccordingthismanualisneededtoensure
hygienicoperaon.

8
• Theapplianceshallnotbecleanedbyawaterjet.
• Donotusewaterinornearthemachineunlessthe
instruconsexplicitlygivedirecontodoso.
• Donotuseaggressivecleaningproductsorabrasivestoclean
(partsof)themachine.
• Ifthepowercordisdamaged,itmustbereplacedbythe
manufacturer,itsserviceagentorsimilarqualiedpersonsin
ordertoavoidasafetyissue.
1.4 Extended down time
• Ifthemachinewillnotbeusedforalongerperiodofme(for
exampleduringtheholidays)itisrecommendedtoswitcho
thewatersupplyandtheelectricity.Themainon/oswitchis
locatedattherearsideofthemachine.
• Inareaswherethetemperaturecandropbelowfreezing,the
boilersmustbeemped.Contacttechnicalsupportofthe
supplier.
• Whenfreezinghasoccurred,pleasecontactthetechnical
supportofyoursupplier.

Safety 9

10
2 Description of the machine
2.1 General
Thisisafullyautomacsinglecupmachineforcoee,cafécrème,espresso,
cappuccino,macchiatoandhotwater.Alwaysplaceacupbeforeselecngadrink
fromthetouchscreen.Youcanadjustforweakerorstrongertasteintheselecon
menu.Yoursuppliercanmakefurtheradjustmentstothestrengthandsizesofthe
drinks.
2.2 The machine exterior and interior
See the foldoutinthebackofthisguide.Theexteriorandinteriornumbersand
leerscorrespondwiththenumbersorleersbetweenthebrackets( ) in the text.
2.3 Display and selections
Themachinecanbeoperatedusingthetouchscreenpanel(6)onthedoor.By
pushingoneoftheseleconbuonsonthescreen,aproductchoicecanbemade.
Beforeyoudispenseabeverage,acupmustbeplacedunderoneoftheoutlets.
2.4 Type plate
Seefoldoutforlocaonofthetypeplate(F).
Thetypeplateshows:
• Manufacturer.
• Serialnumber.
• Type/modelspecicaon.
• Dateofproducon.
• Waterconnecon.

12
3 Using the Nio
3.1 Switch on
1 Checkifthewatersupplyisturned
on.
2 Presstheon/oswitch(14)atthe
rearsideofthemachine.Thecoee
machineswitchesonandheatsup.
3.2 Switch off
Theon/oswitch(14)islocatedatthe
rearsideofthemachine.
1 Press‘O’toswitchothemachine.
2 Ifthemachinewillnotbeused
foralongerperiodofme,itis
recommendedtoturnothewater
supply.
3 Seealsochapter1.4‘Extended
downme’.
3.3 Preparing a drink
1 Placecupunderoutlet.
2 Adjusttheheightofthecoee
outlet(9)tothesizeofyourcup.
Themaximumheightofacupis
135mm/5.3in.Fig.2.
3 Selectabeveragebypushingoneof
thebuonsonthetouchscreen.
4 Ifapulldownarrowisshownin
2
1

UsingtheNio 13
theboomofthemenu,more
seleconsareavailableusingthis
buon.
5 Ifyouwanttochangeyour
selecon,pressthe‘Cancel’buon
onthescreentoreturntothemain
menu.
6 Ifavailable,youmaysetthe
strengthofyourbeverageusingthe
buonsintheseleconmenu,then
pressthe‘Start’buon.
7 Aerthecupislled,themachine
willsignal‘beep’andthescreenwill
indicate‘Ready,takeyourcup’.
8 Youcanstoptheprocessanyme
bypressingthe‘Stop’buononthe
screen.
3

14
3.4 Number selection
Eachselecteddrinkhasitsowncode.
Usingthiscodeyoucandirectlyselect
adrinkwiththe‘Numberselecon’
funcon.Thiscodeisdisplayedinthe
menuwhenpreparingthedrink.
1 Inthemainmenuselectthebuon
‘Numberselecon’.
2 Enterthebeveragecode.
3 Press‘Start’.
3.5 Filling the ingredients
Ingredientcanisterscanbelled
withoutopeningthedooroftheNio.
Whenlling,thecanisters(2)can
remaininthemachine.Justopenthe
lid(1)ofthecanisterandstartlling.
• Donotllcanistersfurtherthan
necessaryforoneortwodays.This
willkeeptheingredientsfresh.
• Eachcanisterisintendedfora
specicingredient.Theingredient
isshownonatextlabelonthe
canister.Useingredientswhichare
recommendedbythesupplierofthe
machine.
• Toremovethecanisterseechapter
5.3.
Opon
5
4

UsingtheNio 15
3.6 Manual ground coffee insert
Theoponalmanualgroundcoee
inletisusedfordecaeinatedand
specialcoeetypes.
1 Touchthe‘Manualcoeeinsert’
buononthescreen.
2 Openthemanualgroundcoee
inlet(4).
3 Insertthedesiredamountofcoee.
4 Closethemanualgroundcoee
inlet.
5 Press‘Start’.
3.7 Connect the fresh milk
1 Slidetheadjustableoutlet(9)tothe
topposion.
2 Removethewastebucket(11).
3 Slidetheadjustableoutlettothe
boomposion.
4 Removethemilkfrotherassembly
(10)bypushingthelockpinonthe
righthandsideoftheadjustable
outletandcatchthemilkfrother.
Fig.7.
5 Removethecoverfromthepump
unit(15)andconnectthemilkhose
tothepumpconnecons,withthe
text‘UP’visiblefromthetopside.
6 Connecttheinletpiecetothe
Opon Opon
7
6

16
shortestpartofthemilkhoseand
routeitthroughtheholeintothe
refrigerator(16).
7 Routethelongestpartofthemilk
hosethroughtheholeintheright
sideofthemachine.Fig.8.
8 Disassemblethemilkfrotherfrom
theholderandroutethehose
throughtheholeintheholder.
Connectthehosewiththemilk
frother.Fig.9.
Reassemblethefrotherinthe
holder.
9 Mountthemilkfrotherassembly
bymovingitupwardinthelocking
mechanismoftheadjustableoutlet
(9).Fig.10.
10 Slidetheadjustableoutletdownto
theboomposion.
11 Gentlypullthehoseandroute
themilkhoseintotheslotatthe
boomoftherighthandpartof
theoutletbracket.Fig.11.
12 Intherefrigerator,openthemilk
containerandplacethemilktubein
themilkcontainer.
OnlyuseUHTmilk!
10
9
8
Opon

UsingtheNio 17
13 Closetherefrigerator(16).
14 Replacethecoveronthepumpunit
(15).
15 Slidetheoutlettothetopposion
andreplacethewastebucket(11).
3.8 Service menu
Theservicemenucanbeenteredby
eitheropeningthedoororbypressing
thelogoattheboomofthescreen
(6)forabout5seconds.Fig.12.
Keepinmindthatthelogoinyour
situaonmaybedierent.
Fromtheservicemenu,thedaily
cleaningcanbestarted(seechapter
5.1)andproductcounterscanberead
(seechapter4.1).
12
11
Press5seconds
Opon

18
4 Information
4.1 Reading out the counters
1 Entertheservicemenubypressingandholdingthelogoattheboomofthe
screenforabout5seconds.
2 Fromtheservicemenu,select‘Beveragecounters’.
3 Thedisplaynowshowsthe‘Freecounter’,‘Paidcounter’and‘Totalcounter’
4 Select‘Exit’and‘Pressheretoquitservice’toreturntothemainmenu.
1413

Informaon 19

20
5 Maintenance and cleaning
5.1 Daily maintenance
Performingdailymaintenancewillensurethequalityofyourbeveragesanda
properoperaonofthemachine.
Dailymaintenancecanbeperformedwithoutopeningthedoorofthemachine.
Toperformthedailymaintenancethefollowingitemsareneeded:
• \_/asdeliveredwiththehygienekit.
• Asodampcloth.
• Ajug,minimum0.6l/20oz.
• Milkfrothercleaningliquid;DeJongDukepartnumber4INF011.
Step 1. Rell
Checkiftherearesllenoughingredientsinthecanisters(2).
Ifnecessary,llupthecanisters.
Ingredientcanisterscanberelledwithoutopeningthedoorofthemachine.
Donotllcanistersmorethannecessaryforoneortwodays.Thiswillkeepthe
ingredients fresh.
Opon