Direct Healthcare Group GATE Bure Rise & Go User manual

A DIRECT HEALTHCARE GROUP COMPANY
GATERD.SE
Bure Rise & Go
Technical Manual

BURE RISE & GO
GATERD.SE2

TECHNICAL MANUAL
3
GATERD.SE
Bure Rise & Go is a complete walking aid with the possibility of moving patients as well as simple, stable and
safe raising. The solution is based on a newly developed harness that is attached to the Bure Walking Table
whose electrically driven height adjustment helps the patient from sitting to standing. There are both walking
training harnesses and raising harnesses for Bure Rise & Go.
Contents
1. Replacement parts list 04
2. Accessories 04
3. Electrical system – Technical data 06
4. Remote Control Plus 06
5. Control box wiring 07
6. Battery charging 07
7. LED on controlbox and battery 07
8. Maintenance 08
9. General safety/maintenance advice 09
10. ID label 09
11. Recycling/Scrapping 10
12. Warranty 10
13. Technical specications 10
Bure Rise & Go

BURE RISE & GO
GATERD.SE4
1. Replacement parts list
158-306-L Arm rest, left 16 58-313 Lower frame
258-304-L/R Support for arm rest, left, right 17 58-302 Bushing, PA6
357-352 Lock lever 18 57-710 Knob, hook adjustment, L=27
458-305 Arm rest plate, centre section 19 57-839 Knob, knee plate adjustment,
L=15
558-303 Support for arm rest, centre 20 58-323 Plastic bushing, lower
658-301 Clamp, aluminium 21 58-308-1-L/R Hinged arm/knee support, left,
right
758-306-R Arm rest, right 22 58-309 Adjuster plate, knee support
858-311 Telescopic internal tube incl.
slide bearing
23 58-312 Knee support
958-322 Strap holder, green 24 56-361 Castor with brake, 125 mm
10 58-327 Handle, foam 25 58-314 Battery tray
11 58-307 Vertical frame 26 58-376 Battery
12 57-310 Plastic bushing, upper 27 57-341-1 Stirrup bar
13 58-373 Control box 220 V 28 57-353 Plastic bushing, stirrup
13 58-373-1 Control box 110 V 29 57-340-1 Aluminium cover, stirrup
14 58-377 Actuator
15 58-310-1 Hook (for knee support)
2. Accessories
Art. Nr. Benämning
56-326-0 Handbrake kit, 2 handles
56-326-1 Handbrake kit, 1 handle
56-333-1 Footplate, aluminium, short
56-383 Footplate, aluminium, long
56-334 Chromium drip rod
56-335 Drip rod holder
56-336 Oxygen holder
56-337 Side support
56-338 Drip rod complete with holder
56-384-S/M/L/XL Harness (S=95-150cm, M=105-120cm, L=110-140cm, XL=130-160cm)
56-388-S/M/L/XL Gait training harness (S=95-150cm, M=105-120cm, L=110-140cm, XL=130-
160cm)
56-387 Castor with brake, 75 mm
56-358 Castor with brake, 100 mm
56-361 Castor with brake, 125 mm
58-376 Battery
58-374-1 Hand control, up/down
58-320 (-1, -2, -3) Charge cable, EUR (-UK,-US,-AUS)
58-326 (-1, -2, -3) Spiral cable, EUR (-UK,-US,-AUS)

TECHNICAL MANUAL
5
GATERD.SE
58-328 Heel strap
56-061 Remote control PLUS (TH10) including Holder
57-365 Armrestpad center, PUR
57-366-L/R Armrestpad left/right, PUR

BURE RISE & GO
GATERD.SE6
3. Elsystem - Tekniska Data
Actuator
Manufacturer T-Motion
Voltage 24V
Lifting power 2000N
Traction 2000N
Interlock on lift 1000N
Amperage 4.6A
Colour Black
Stroke 400mm
Min installation dimensions 605 mm retracted length
Protection class IP66
IEC60601-1 issue 3
Control box + battery
Manufacturer T-Motion
Voltage 24V
Capacity 2.0AH
Protection class IP66
Colour Black
Electrical safety Category II (double insulation)
IEC60601-1 issue 3
4. Remote Control Plus
**1. Service indicator – ashes red after 11 months’ operation. Constant light (red) after 12 months’ operation.
The indicator is a reminder to review the maintenance instruction (see Instructions for Use/Technical Manual.
This should be done at least once every 12 months.
Reset: hold down buttons <2a> + <2b> for at least 30 seconds.
**The indicator will go out around 30 seconds after the remote control is activated
(battery conservation function).
1
2a 2b

TECHNICAL MANUAL
7
GATERD.SE
5. Control box wiring
Remove the control box cover to make the connections as described below.
Use a screwdriver or similar; refer to the special labels on the control box.
NOTE: Make sure that plugs are connected to the correct sockets otherwise the
actuators can be damaged.
1. Socket for the raise/lower actuator.
2. Remote control socket.
3. Battery terminal socket.
4. Plug socket NOTE: Plugs must ALWAYS be connected to the control box for
IP classication to be valid.
6. Battery charging
• Connect plug to 230V wall socket. Charging begins automatically and the
battery LED ashes green.
• Make sure the battery is fully charged before using for the rst time. It takes
around 25 h to fully charge the battery.
• We recommend that the battery plug be removed from the control box if the
product will be out of use for an extended period (more than one week) or if
the battery is switched off by means of the ON/OFF switch. This eliminates
the risk of disabling the battery as the control box always uses a small
quantity of electricity even when the walker is not in use.
7. LED on controlbox and battery
Control box – green light when power is available from battery/mains socket.
Battery:
• The LED ashes green during charging.
• ON/OFF: To use the product, press ON.
• The green lamp will begin to ash.
• Use the OFF button (hold down for 5 s) to switch off the battery if the
product will not be used for an extended period.
• The LED will shows a constant green light when the battery is fully charged.
• When the battery is in normal state/in operation, the LED ashes green at
REGULAR intervals, namely 0.5 s ON, 4 s OFF.
• When the battery requires charging (remaining charge <25%) the LED will
ash orange/red at REGULAR intervals, namely 0.5 s ON, 4 s OFF. .
NOTE: The battery has an in-built device that automatically switches it off when
remaining charge is <20%. The LED is then extinguished. The battery must now
be fully charged before the electronics can be used again.
1
4
2
3

BURE RISE & GO
GATERD.SE8
8. Maintenance
Recommended at least once per year.
Check that Action
General
The walker feels rm/free from play.
The walker does not rattle during manoeuvres.
The walker is level and all of its castors are in contact
with the oor.
The walker is not dirty.
Clean with lukewarm soap solution
(no petroleum products).
Arm rests
Arm rests are intact and clean.
Arm rest widening is functional.
Clean; replace if damaged.
Replace lock knob.
Handle
Grips are not damaged/dirty.
Handle adjustment is functional.
Clean with lukewarm soap solution (no petroleum
products).
Replace handle grips.
Fit lock knobs/plates as required.
Battery
Check that the charging cable is connected to the
control box.
Check that the remote control is connected to the
control box.
Check that connections are made according to the
wiring diagram.
Check that the battery, actuators and control box
are not loose.
Fit new cable; this must always be connected to the
control box (IP65 classication).
Connect or t new remote control as required.
Refer to the wiring diagram in the Technical manual.
Tighten; replace with new fasteners as required.
Height adjustment
Raising and lowering are functional.
The walker feels stable at maximum settings.
There is no play between the vertical frame and
bottom frame.
Height adjustment clamps lock.
The electric actuator tting must be free from play.
Height adjustment via remote control is functional.
The electric actuator must run smoothly at a constant
speed.
Fit new guide sleeves (in frame) or end plugs (in
chrome tubes) as required.
Tighten all lock bolts.
Replace clamps.
Tighten the attachment tting concerned; replace
bolts/lock nuts as necessary.
Check that the battery/remote control/actuator are
connected in accordance with the wiring diagram.
Charge the battery. Contact customer services.
Frame parts
There is no mechanical damage.
There are no scratches.
End plugs/lower frame tted.
If damage is present, contact GATE’s customer
services.
Touch up as necessary.
Fit new end plugs.

TECHNICAL MANUAL
9
GATERD.SE
Castors/brakes
Castors roll easily.
Tread not damaged.
The castors are tightly fastened to the lower frame.
Castor brakes functional on all castors.
Handbrake functional.
Clean or replace castors (NOTE! Castors are
always xed to the lower frame with thread locker
or lock nuts. The castors are sealed and we do not
recommend their dismantling; instead, replace the
whole castor assembly.
Tighten the castor bolt and t locking nut or use
thread locker (depends on model).
Replace castor assembly.
Adjust the brake or t new castors.
Harness
Belts, seams and Velcro fasteners are whole/intact.
The walker lock tabs (green) are intact.
Replace harness. Available in four sizes (S, M, L, XL).
Change lock tab.
9. General safety/maintenance advice
The Bure Walker may only be used:
• As a WALKING AID / STAND-UP AID.
• INDOORS on HARD, LEVEL surfaces.
Before use, always check that:
• The product feels rm, secure and stable
• Harnesses, belts and attachments are intact and undamaged
Wipe the walker and its armrests clean as necessary; use soap solution/surface disinfectant. Be aware of
battery charge status (LED) – charge as necessary.
10. ID label
1. Part number
2. Product name
3. Date of manufacture
4. Max user weight
5. Serial number
6. EAN code
56-316
Gåbord Rise & Go
1
5
2
3
4
6

BURE RISE & GO
GATERD.SE10
11. Recycling/Scrapping
When the product is no longer usable it should be recycled in accordance with legislation and regulations
in the country concerned. All electrical parts including batteries must be removed and recycled as electrical
components. (Ask your local recycling station for further information about how the different materials in the
product (metals, plastics, electronics) should be recycled).
12. Warranty
We provide two years’ warranty for manufacturing faults (does not apply to wear parts). For further information
or enquiries please contact:
Gate Rehab Development AB
Industrigatan 2, S-330 21 Reftele
tel [phone]
[email protected]
13. Technical specications
Dimensions apply to walkers with 125 mm castors.
Part no. Product width Max user weight Length Height Weight Armrest/internal dimension
56-316 77cm 150kg 89cm 96-136cm 25kg 34-65cm
A DIRECT HEALTHCARE GROUP COMPANY

TECHNICAL MANUAL
11
GATERD.SE

GATERD.SE
Gate Rehab Development AB
Industrigatan 2
Reftele, Sverige
S-330 21
T: 0371-318 00
F: 0371-318 01
E: [email protected]
LIT-00104 Issue 1
Date: January 2020
A DIRECT HEALTHCARE GROUP COMPANY