Ducati Multistrada MTS 1200S D-Air User manual

Owner’s manual ENGLISH
1

This manual forms an integral part of the motorcycle and must be kept with it for its whole service life.
If the motorcycle is resold, the manual must always be handed over to the new owner.
This manual must be preserved with care. If it is lost or becomes damaged, contact a Ducati Dealer or
authorised Service Centre without delay to obtain a new copy of the manual.
The quality standards and safety of Ducati motorcycles are steadily improved as new design solutions,
equipment and accessories are developed. While the information contained in this manual is current at the
time of going to print, Ducati Motor Holding S.p.A. reserves the right to make changes at any time without
notice and without any obligations. For this reason, the illustrations in this manual might differ from your
motorcycle.
Any and all reproduction or spreading of the contents herein in whole or in part is forbidden. All rights reserved
to Ducati Motor Holding S.p.A. Any request for written authorisation shall be addressed to this company,
specifying the reasons for request.
Enjoy your ride!
2

Table of contents
Introduction 7
Safety guidelines 7
Warning symbols used in the manual 8
Intended use 9
Rider's obligations 14
Rider's training 15
Apparel 16
Safety "Best Practices" 19
Refuelling 22
Carrying the maximum load allowed 23
Information about carrying capacity 23
Dangerous products - warnings 24
Vehicle identification number 26
Engine identification number 27
Option kits / Customisations 28
Instrument panel (Dashboard) 37
Instrument panel 37
Acronyms and abbreviations used in the
Manual 48
Technological Dictionary 48
Function buttons 51
Parameter setting/displaying 53
Main functions 71
Engine rpm indication (RPM) 73
Motorcycle speed 77
Riding Mode 79
DTC 89
ABS 96
DWC 103
Motorcycle setup 110
DSS 112
Gear 117
Fuel level 118
Odometer (TOT) 120
Engine Coolant temperature 122
Clock 124
Menu Functions 125
Residual range (RANGE) 127
Trip meter 1 (TRIP 1) 129
Trip meter 2 (TRIP 2) 131
Trip time (TRIP TIME) 132
3

LAP time 134
Average fuel consumption 136
Instantaneous fuel consumption 138
Average speed 140
Ambient air temperature 142
TRIP MASTER 144
Jacket battery status indication 146
Auxiliary functions 149
Infotainment 152
Cruise Control 163
Service indication (SERVICE) 166
OIL SERVICE zero warning 167
OIL SERVICE or SERVICE DATE or DESMO SERVICE
countdown indication 168
OIL SERVICE or SERVICE DATE or DESMO SERVICE
indication 169
Warnings/Alarms 170
Error warnings 185
Side stand warning 186
Fog lights 187
Setting MENU 188
Customising the Riding Mode 191
Customising the Riding Mode: Engine
setting 194
Customising the Riding Mode: DTC level
setting 197
Customising the Riding Mode: DWC level
setting 200
Customising the Riding Mode: ABS setting 203
Customising the Riding Mode: DSS suspension
setting 206
Customising the Riding Mode: Reset to default
settings (DEFAULT) 218
Customising the Riding Mode: Reset to default
settings (ALL DEFAULT) 220
Display mode setting 221
Pin Code 225
Changing the PIN CODE 229
LAP 234
Display backlighting setting 240
Date setting 243
Clock setting 249
Setting the units of measurement 254
Bluetooth device setting 263
Information (INFO) 274
Light control 275
Immobilizer system 282
Keys 283
Replacing the battery in the active key 286
Duplicate keys 290
Restoring motorcycle operation via the PIN
CODE 291
4

Controls 295
Position of motorcycle controls 295
"Hands free" system 296
D-Air system 310
D-Air system use 315
D-Air system installation 322
D-Air system maintenance 325
Left-hand switch 329
Clutch lever 333
Right-hand switch 334
Throttle twistgrip 336
Front brake lever 337
Rear brake pedal 338
Gear change pedal 339
Adjusting the position of the gearchange pedal and
rear brake pedal 340
Main components and devices 342
Position on the vehicle 342
Tank filler plug 343
Seat lock 345
Seat height adjustment 348
Side stand 351
Bluetooth control unit 353
Power outlet 355
Centre stand 357
Assembling the Ducati side panniers 359
Using the side panniers 364
USB connection 368
Adjusting windscreen height 369
Adjusting the front fork 370
Adjusting the rear shock absorber 371
Motorcycle track alignment variation 372
Riding the motorcycle 373
Running-in recommendations 373
Pre-ride checks 375
ABS device 377
Engine start/stop 378
Moving off 381
Braking 382
Stopping the motorcycle 384
Parking 385
Refuelling 387
Tool kit and accessories 388
Main use and maintenance
operations 389
5

Checking coolant level and topping up, if
necessary 389
Checking brake and clutch fluid level 391
Checking brake pads for wear 393
Charging the battery 394
Checking drive chain tension 398
Lubricating the drive chain 400
Using the supplied chain tension gauge 401
Rear turn indicators 403
Aligning the headlight 404
Adjusting the rear-view mirrors 406
Tubeless tyres 407
Check engine oil level 410
Cleaning and replacing the spark plugs 412
Cleaning the motorcycle 413
Storing the motorcycle 415
Important notes 415
Scheduled maintenance chart 416
Scheduled maintenance chart: operations to be
carried out by the dealer 416
Scheduled maintenance chart: operations to be
carried out by the Customer 420
Technical data 421
Weights 421
Dimensions 422
Fuel, lubricants and other fluids 423
Engine 425
Desmodromic timing system with variable timing
(DVT) 426
Performance data 427
Spark plugs 427
Fuel system 427
Brakes 427
Transmission 428
Frame 429
Wheels 429
Tyres 429
Suspension 429
Exhaust system 430
Available colours 430
Electric system 431
Routine maintenance record 438
Routine maintenance record 438
6

Introduction
Safety guidelines
We would like to welcome you among Ducati
enthusiasts, and congratulate you on your excellent
choice of motorcycle. We think you will ride your
Ducati motorcycle for long journeys as well as short
daily trips. Ducati Motor Holding S.p.A. wishes you
smooth and enjoyable riding.
Your motorcycle is the result of Ducati Motor Holding
S.p.A.'s on-going research and development efforts.
It is important that you preserve its quality standard
by strictly observing the maintenance plan and using
genuine spare parts. This manual provides
instructions on minor maintenance operations. Major
maintenance operations are described in the
Workshop Manual available to Ducati Authorised
Service Centres.
In your own interest, for your safety and in order to
guarantee product reliability, you are strongly advised
to refer to our authorised Dealers and Service Centres
for any operations listed in the scheduled
maintenance chart, see page 416.
Our highly skilled staff have access to special
implements and appropriate equipment required to
perform any servicing job at best, and use Ducati
original spare parts only as the best guarantee for full
interchangeability, smooth running and long life.
All Ducati motorcycles come with a Warranty Card.
The warranty does not apply to motorcycles used in
racing competitions.
Tampering with or altering any components, even
partially, will make the warranty null and void
effective immediately. Improper or poor
maintenance, using other than original spare parts or
parts not expressly approved by Ducati may invalidate
your warranty rights and lead to damage or loss of
performance.
Your safety and that of other road users are very
important. Ducati Motor Holding S.p.A. recommends
that you ride responsibly.
Before using your motorcycle for the first time, read
this entire manual carefully and closely follow the
guidelines outlined in it. The manual provides full
information on proper motorcycle operation and
7

maintenance. In case of any doubts, please contact a
Dealer or Authorised Service Centre.
Warning symbols used in the manual
Several kinds of warnings are used as an alert of the
possible hazards for you or other persons such as:
- Safety labels on the motorcycle;
-Safety messages preceded by a warning symbol
and either WARNING or IMPORTANT.
Warning
Failure to comply with these instructions may
put you at risk, and could lead to severe injury or even
death of the rider or other persons.
Important
Possibility of damaging the motorcycle and/or
its components.
Note
Additional information about the current
operation.
The terms RIGHT and LEFT are referred to the
motorcycle viewed from the riding position.
8

Intended use
Warning
This motorcycle was designed for both road use
and for light off-road and dirt road use. Heavy duty off-
road use is not advised and can result in the rider
losing control of the vehicle, thereby increasing the
risk of accidents.
Warning
This motorcycle may not be used to tow any
trailers or with a side-car attached; this can lead to
loss of control and result in an accident.
This motorcycle carries the rider and can carry a
passenger.
Warning
The total weight of the motorcycle in running
order including rider, passenger, luggage and
additional accessories should not exceed 450kg/
992lb.
Warning
The maximum weight permitted for the side
panniers, top case and the tank bag must never
exceed 35 kg, divided as follows:
10 kg max. per side pannier;
10 kg max for the top case;
5 kg max. for the tank bag.
9

D-Air®device preliminary instructions and
recommendations
Warning
The D-Air®protection system was developed by
DAINESE and tested by TÜV SÜD to be used on
asphalt only. Therefore, in order to avoid any
undesired activation of the Jacket and/or Waistcoat,
the relevant electronic device must be disabled when
riding off-road - by "off-road" we mean the track use
as well. Warning: with Jacket/Waistcoat electronic
device off, the rider and passenger protection is
disabled.
-The D-Air®system is a new, smart, tested device
conceived to be used on the road only. When
riding on the track or off-road - by "off-road" we
mean on uneven, steep and low-grip roads - it is
compulsory to disable the device on the garment
(jacket or waistcoat) available at a Ducati Dealer
or Ducati authorised service centre. The device
installed on the garment (Jacket or Waistcoat)
communicates with the control unit and the
sensors installed on the motorcycle. There is no
physical/mechanical element linking the
motorcycle and the user. D-Air®is able to identify
front, lateral and rear impacts and skidding, and
to transmit via radio the inflation input to the
system installed in the garment.
10

- Motorcycling is a dangerous activity that might
lead to personal injuries or even death. Ducati
products are conceived to offer comfort and high
protection, however no protection system or
product can ensure a complete protection
against injuries in case of falls, collisions,
impacts, loss of control or other. Riders must be
familiar with the use of motorcycles and relevant
equipment and aware of their skills and limits to
understand any potential risks and therefore
decide whether to take them or not. For these
reasons, and without prejudice to the rights
granted by law are complied with, Ducati shall
not be held liable for injury to people or damage
to property caused, even indirectly, by the use of
any of its products.
-To make the most of its functions, D-Air®must
be installed and worn correctly, respecting the
instructions and warnings provided by this use
and maintenance manual.
-D-Air®does not replace other protection
equipment such as helmet, eye wear, back
protectors, boots, gloves, or other. This System
works together with the specified protections.
Helmet and back protectors must be
compulsorily worn together with the D-Air®
device. Always use the System with the back
protector provided with the D-Air®Jacket/
Waistcoat. Failure to observe this instruction
may lead to personal injuries in case of falls under
particular circumstances.
-People with pacemakers or other electro medical
equipment must not use D-Air® as electric noise
may impair the correct operation of said
equipment.
- People with any kind of back or neck problem
must no use this device.
- Upon airbag inflation, the rider/passenger may
feel a light pressure on the body side covered by
the airbag.
- The passenger must wear helmets with visor
only.
- Neither the rider nor the passenger must be
pregnant. The risk of abortion in case of system
activation has not been assessed.
11

- Piercings could increase the pain perception in
case of activation.
- Neither the rider nor the passenger must have
breast silicone prostheses. The break risk in case
of system activation has not been assessed.
-The D-Air®system of your bike must be used
exclusively within a temperature range of -20 °C
and 80 °C. Prolonged exposure of the System to
a temperature lower than -20 °C or higher than
80 °C could impair System operation.
-The D-Air®device integrated in the jacket must
be used exclusively within a temperature range
of -10 °C to 50 °C, when discharged (normal
usage), and within a temperature range of 0 °C
and +40 °C, when charged. Prolonged exposure
of the System to a temperature lower than -10
°C or higher than 55 °C could impair System
operation.
-D-Air®is subject to wear, depending on its actual
use conditions. Before using or storing the D-Air
Device®, always check for signs of wear or
damage.
- The Device must be overhauled by a Ducati
Dealer or authorised service centre at the time
intervals that will be shown on the display. A
correct maintenance is essential for a correct
operation of the System. For further details, refer
to the specific paragraph about the device.
- Wearing waterproof jackets over the garment is
allowed. The use of waterproof backpacks or
similar items on the garment is allowed. Place
keys, mobiles and other devices and accessories
in the external pockets of your garment.
-Do not modify in any way the D-Air®device and
its components. Any change could affect D-Air®
Device operation, and thus its functions in case
of fall or accident. Do not add decorations,
ribbons or patches on the bag positioning area.
Do not connect any electrical equipment or
external battery to the system's cables. D-Air®
components can be modified exclusively by a
DUCATI Dealer or authorised service centre.
12

-Avoid turning on the D-Air®device on the
garment (jacket/waistcoat) when you are not
wearing it or when you are not using the
motorcycle. If the jacket/waistcoat is used in an
improper way, D-Air®could be triggered in a
wrong way with possible damage to property and
injuries to people. Always make sure that the D-
Air®device installed in the jacket/waistcoat is off
before storing it for transport. When the jacket/
waistcoat is not used, D-Air®must be off.
-Before using D-Air®, it is necessary to check its
operation as specified in paragraph "Using the D-
Air®device". In case of errors or other fault
warnings, do not use the D-Air®device and
contact a DUCATI Dealer or authorised service
centre.
-Do not recharge the D-Air®device while wearing
it.
-Do not leave the D-Air®device in the jacket/
waistcoat recharge near flammable surfaces or
objects.
-Keep D-Air®out of children's reach to avoid any
personal risk.
- In case of any evident malfunction, turn the
device off and contact a DUCATI Dealer or
authorised service centre.
- Once deployed, the Device must not be used
again until its functionality is restored by a Ducati
Dealer or authorised service centre.
-In case of damage to the D-Air®device, contact
a DUCATI Dealer or authorised Service Centre.
Warning
Riders without helmets are more likely to suffer
severe bodily injury or die if they are in an accident.
Warning
Check that your helmet complies with safety
specifications, permits good vision, is the right size
for your head, and carries a certification label
indicating that it conforms to the standards in force in
your state. Road traffic laws differ from state to state.
Learn about traffic laws in your state before riding and
always obey them.
13

Rider's obligations
All riders must hold a valid licence.
Warning
Riding without a licence is illegal and is
prosecuted by law. Always make sure you have your
licence with you when riding. Do not let
inexperienced riders or persons without a valid
licence use your motorcycle.
Do not ride under the influence of alcohol and/or
drugs.
Warning
Riding under the influence of alcohol and/or
drugs is illegal and is prosecuted by law.
Do not take prescription or other drugs before riding
unless you have consulted your doctor about their
side effects.
Warning
Some medications and drugs may cause
drowsiness or other effects that slow down reaction
time and the rider's ability to control the motorcycle,
possibly leading to an accident.
Some states require vehicle insurance.
Warning
Check your state laws. Obtain insurance
coverage and keep your insurance document secure
with the other motorcycle documents.
To protect rider and passenger safety, some states
mandate the use of a certified helmet.
Warning
Check your state laws. Riding without a helmet
may be punishable by law.
Warning
Riders without helmets are more likely to suffer
severe bodily injury or die if they are in an accident.
14

Warning
Check that your helmet complies with safety
specifications, permits good vision, is the right size
for your head, and carries a certification label
indicating that it conforms to the standards in force in
your state. Road traffic laws differ from state to state.
Learn about traffic laws in your state before riding and
always obey them.
Use, conditions and efficiency of D-Air®
The jacket/waistcoat provided with D-Air®must be
worn and turned on correctly. Never remove the
protectors integrated in the D-Air jacket/waistcoat.
After device deployment, have the protector or
garment replaced by a Ducati Dealer or authorised
service centre.
Important
D-Air®has been conceived to reduce the risk of
injuries, by limiting the forces transmitted in case of
falls or impacts against obstacles. Nevertheless, we
remind that no protector is able to protect against
torsions, bending or extreme movements. No back or
lumbar protector is able to protect against severe
spinal injuries. No protection device can protect
against all possible impacts due to accidents, thus
ensuring a complete protection against injuries.
Rider's training
Accidents are frequently due to inexperience. Riding,
manoeuvres and braking must be performed in a
different way than on the other vehicles.
Warning
Untrained riders or a wrong use of the vehicle
may lead to loss of control, serous injuries or even
death.
15

Apparel
Riding gear is very important for safety. Unlike cars,
a motorcycle offers no impact protection in an
accident.
Proper riding gear includes helmet, eye protection,
gloves, boots, long sleeve jacket and long trousers.
- The helmet must meet the requirements listed
at page 14; if your helmet does not have a visor,
use suitable eye wear;
- Use five-finger gloves made from leather or
abrasion-resistant material;
- Riding boots or shoes must have non-slip soles
and offer ankle protection;
-Jacket, trousers or riding suit must be made from
leather or abrasion-resistant material and have
high-visibility colours and inserts.
Important
Never wear loose clothing, items or accessories
that may become tangled in motorcycle parts.
Important
For your safety, always wear suitable protective
gear, regardless of season and weather.
Important
Have your passenger wear proper protective
clothing.
D-Air®intended use
Warning
The D-Air®protection system was developed by
DAINESE and tested by TÜV SÜD to be used on
asphalt only. Therefore, in order to avoid any
undesired activation of the Jacket and/or Waistcoat,
the relevant electronic device must be disabled when
riding off-road - by "off-road" we mean the track use
as well. Warning: with Jacket/Waistcoat electronic
device off, the rider and passenger protection is
disabled.
D-Air®is an innovative system designed for riders'
safety on the road. It has not been conceived for use
on uneven roads or off-road. The Jacket/Waistcoat
provided with the D-Air®Device can be worn by the
motorcycle rider and passenger.
16

Warning
Do not use D-Air®for purposes other than those
it has been designed for.
Warning
Do not use D-Air®for motocross, super-motard,
trial, off-road or other sports.
Warning
D-Air®does not provide additional protection
with respect to the approved garments on the areas
that are not covered by the airbag or upon
circumstances that do not entail its activation and
thus airbag inflation.
Warning
Do not use the D-Air®device without the
integrated protectors.
In particular, the D-Air®jacket/waistcoat:
1) Offers supplementary protection by means of
the airbag in the back area. The D-Air®Device is
certified according to PrEN 1621-4:2010.
2) It limits neck movements upon impacts. D-Air®
prevents the head-neck from bending
excessively and reduces helmet movements
(tested by TÜV SÜD Auto Service GmbH).
3) It offers an "invisible protection". Comfort and
ergonomics are tested by TÜV SÜD Auto Service
GmbH.
To keep the airbags in the correct position upon
inflation in order to reduce neck movements during
possible impacts, limit the head inclination (tested by
TÜV SÜD Auto Service Gmbh), the airbags are
positioned and fixed in the front part of the body.
Important
It is compulsory to use all supplied protections
(for example: back protectors, shoulder protectors,
etc.) with which the inflatable system is designed to
interact. D-Air®does not replace in any way the
standard protections which, indeed, contribute to its
efficacy.
Information about the materials used for D-Air®
17

We hereby certify that the materials that come into
contact with the person have been realised with non-
toxic, harmless products, as per EC Regulation
1907/2006 (R.E.A.C.h.).
Such materials are free of azoic dyes that, by release
of one or more azoic groups, could release dangerous
aromatic amines, as per EC Regulation 1907/2006
(R.E.A.C.h.). Furthermore, marketed items do not
contain more than 0.1% weight/weight of SVCH
substances (Substance of Very High Concern),
specified in article 59 and listed in the "Candidate List"
issued by the European Chemical Agency (ECHA).
18

Safety "Best Practices"
These few simple operations are critical to people
safety and to preserving the full performance of your
motorcycle. Never forget to perform them before,
while and after riding.
Important
Closely follow the indications provided at
chapter "Riding the motorcycle" during the running-in
period.
Failure to follow these instructions releases Ducati
Motor Holding S.p.A. from any liability whatsoever for
any engine damage or shorter engine life.
Warning
Before riding your motorcycle, become familiar
with the controls you will need to use when riding.
Perform the checks recommended in this manual
before each ride (see page 381).
Warning
Failure to carry out these checks before riding
may lead to motorcycle damage and injury to rider
and/or passenger.
Warning
Start the engine outdoors or in a well ventilated
area. The engine should never be started or run
indoors.
Exhaust gases are poisonous and may lead to loss of
consciousness or even death within a short time.
Use proper body position while riding and ensure your
passenger does the same.
Important
Rider must hold the handlebar with both hands
at ALL TIMES while riding.
Important
Both rider and passenger should keep their feet
on the footpegs when the motorcycle is in motion.
Important
The passenger should always hold on to the
grab handles under the seat with both hands.
19