EAGLE FLIGHT JH12TC-16 User manual

12-Volt Portable Air Compressor
Operation Manual
Model HP Volts Max. Pressure Tank Capacity
JH12TC16 3/4 12 DC 120 psi 3 Gallon
IMPORTANT
Carefully read and understand these instructions before operating this compressor.

Read and understand the following information and instructions included with
this product before using. This information is for your safety and to prevent
damage to the product.
CAUTION
1. Do not disassemble. Disassembly or attempted repairs if accomplished
incorrectly can create electrical shock hazard. Refer servicing to qualified
service agencies only.
2. Connect compressor to a direct power supply. Never plug into car's cigarette
lighter socket. Compressor must be used with an inline 50 AMP circuit breaker
or fusible link. (Failure to use circuit breaker or fusible link may result in
severe damage to compressor and/or vehicles electrical system.)
3. The air compressor and tank assembly should always be kept dry during
operation and stored in a dry location.
WARNING
1. This product should never be left unattended when turned on.
2. Always turn off after using and store in a dry place.
DANGER :
To reduce risk of explosion or fire....
1. Do not use the product near combustibles, or where aerosol (spray) products
are being used.
2. Do not pump combustible liquids or vapors with the product or use in or near
an area where flammable or explosive liquids or vapors may exist.
3. Do not use this product near flames.
SAFETY
1. Close supervision is necessary when this product is used near children. Never
allow children to operate this unit.
2. Never operate this product: If it has a damaged power cord, if it is not working
properly, if it has been dropped or damaged, or if it has fallen into water.
Return the product to a service center for examination and repair.
3. Keep the power cord away form heated surfaces and sharp edges.
4. Never block any air openings (inlet) of the product or place it on a soft surface
where the openings may be blocked. Keep all air openings free of lint, dirt and
other foreign objects.
5. Never use while sleeping or drowsy.
6. Never drop or insert fingers or any other object into openings.
7. Do not operate this product where oxygen is being administered.

8. Wear safety glasses or goggles when operating this product.
9. Use the product only in well-ventilated areas.
10. Do not use air tools or attachments without first determining maximum air
pressure for that tool or attachment.
11. Never point air nozzle or air sprayer toward a person or any part of the body.
12. All electrical products generate heat. To avoid serious burns never touch unit
during or immediately after operation.
Failure to observe the above safety precautions could result in sever bodily
injury, including death in extreme cases.
DAILY START UP
1. Make sure drain valve is closed.
2. Turn the ON/OFF switch to the ON position.
3. WARNING: High temperatures are generated by the electric motor and pump.
Do not touch compressor while it is running. Allow it to be cooled before
handling or servicing. Keep children away from compressor at all times.
4. NOTE: (If there is a regulator on the air compressor.) When adjusting from a
higher to a lower pressure. Turn the knob counterclockwise past the desired
setting, and then turn clock-wise to the desired pressure setting.
5. If product will not be used for more than 30 minutes, turn the ON/OFF switch
to the OFF position until next use.
DAILY SHUT DOWN
1. Turn the ON/OFF switch to the OFF position.
2. Bleed air to less than 30 psi. Open the drain valve on the tank.
MAINTENANCE
1. Lubrication is not necessary. The compressor never needs lubricating.
Applying oil to any part could result in polluted air delivery to the air-handling
equipment. This product has no user serviceable parts. When not in use, store
in dry place. DO NOT ABUSE PRODUCT.
2. Check all air fitting connections and hoses for air leaks daily. Small air leaks
will result in excessive wear on the product.
WARNING
This compressor is precision-made, and carefully assembled and wired.
Therefore do not disassemble or attempt to repair these products. Only
qualified personnel should perform repair service.

MODEL :
JH12TC16