Empire Comfort Systems DVP20CC Series Quick start guide

The Heritage Cast Iron Stoves
INSTALLATION INSTRUCTIONS
AND
OWNER'S MANUAL
This appliance may be installed in an aftermarket
permanentlylocated,manufacturedhome(USAonly)or
mobile home, where not prohibited by local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
FRQYHUWLEOHIRUXVHZLWKRWKHUJDVHVXQOHVVDFHUWL¿HG
kit is used.
CAST IRON
DIRECT VENT STOVE
MODELS:
DVP20CC(30,70)(B,F,M)(N,P)-1
DVP30CC(30,70)(B,F,M,S,W)(N,P)-1
WARNING
If the information in these instructions are not fol-
ORZHGH[DFWO\D¿UHRUH[SORVLRQPD\UHVXOWFDXV-
ing property damage, personal injury or loss of life.
² 'RQRWVWRUHRUXVHJDVROLQHRURWKHUÀDPPDEOH
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
  'RQRWWU\WROLJKWDQ\DSSOLDQFH
  'RQRWWRXFKDQ\HOHFWULFDOVZLWFKGRQRWXVH
any phone in your building.
  ,PPHGLDWHO\ FDOO \RXU JDV VXSSOLHU IURP D
neighbor’s phone. Follow the gas supplier’s
instructions.
  ,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH
¿UHGHSDUWPHQW
— Installation and service must be performed by a
TXDOL¿HGLQVWDOOHUVHUYLFHDJHQF\RUWKHJDVVXS-
plier.
Installer: Leave this manual with the appliance.
Consumer: Retain this manual for future reference.
EMPIRE
EMPIRE
Comfort Systems
GAS-FIRED
WARNING
HOT GLASS
DO NOT TOUCH
NEVER
WILL
CAUSE BURNS.
GLASS
UNTIL COOLED.
ALLOW CHILDREN
TO TOUCH GLASS.
WARNING
Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage.
Refer to this manual. For assistance or additional in-
IRUPDWLRQFRQVXOWDTXDOL¿HGLQVWDOOHUVHUYLFHDJHQF\
or the gas supplier.
Page 1

30794-0-0812Page 2
TABLE OF CONTENTS
IMPORTANT SAFETY INFORMATION.........................................................................................3
SAFETY INFORMATION FOR USERS OF LP-GAS.....................................................................4
REQUIREMENTS FOR MASSACHUSETTS................................................................................5
INTRODUCTION...........................................................................................................................6
SPECIFICATIONS.........................................................................................................................7
GAS SUPPLY ................................................................................................................................8
CLEARANCES .........................................................................................................................9-10
VENTING STOVE...................................................................................................................11-12
TERMINATION CLEARANCES...................................................................................................13
VENT CLEARANCES..................................................................................................................14
VENT SYSTEM IDENTIFICATION..............................................................................................15
FRAMING AND FINISHING....................................................................................................16-17
HORIZONTAL TERMINATION.....................................................................................................17
VERTICAL TERMINATION.....................................................................................................18-19
LOG IDENTIFICATION................................................................................................................20
LOG PLACEMENT......................................................................................................................21
OPERATING INSTRUCTIONS....................................................................................................22
MAIN BURNER FLAME CHARACTERISTICS............................................................................23
WIRING .......................................................................................................................................24
MILLIVOLT LIGHTING INSTRUCTIONS.....................................................................................25
MILLIVOLT WIRING ....................................................................................................................26
MILLIVOLT TROUBLESHOOTING..............................................................................................27
IP OPERATING INSTRUCTIONS................................................................................................28
IP ELECTRONIC SYSTEM WIRING DIAGRAM.........................................................................29
INTERMITTENT PILOT LIGHTING INSTRUCTIONS.................................................................30
INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING..............................................31-33
MAINTENANCE...........................................................................................................................34
MAINTENANCE AND SERVICE .................................................................................................35
DVP20CC(30,70)PARTS LIST.....................................................................................................36
DVP20CC(30,70)PARTS VIEW...................................................................................................37
DVP30CC(30,70) PARTS LIST....................................................................................................38
DVP30CC(30,70) PARTS VIEW..................................................................................................39
CASTING PARTS LIST................................................................................................................40
CASTING PARTS VIEW..............................................................................................................41
MASTER PARTS DISTRIBUTOR LIST.......................................................................................42
HOW TO ORDER REPAIR PARTS .............................................................................................42
ACCESSORY SIDE SHELVES INSTALLATION INSTRUCTIONS..............................................43
CIB3-1 OPTIONAL BLOWER INSTALLATION INSTRUCTIONS - DVP30CC.......................44-46
CIB4-1 OPTIONAL BLOWER INSTALLATION INSTRUCTIONS - DVP20CC.......................47-49
WARRANTY ................................................................................................................................50
APPLIANCE SERVICE HISTORY..........................................................................................51-53
QUICK REFERENCE GUIDE.................................................................................................54-55
SECTION PAGE

30794-0-0812 Page 3
IMPORTANT SAFETY INFORMATION
Before enclosing the vent pipe assembly, operate the appliance to ensure it is venting properly.
DO NOT OPERATE THIS APPLIANCE WITHOUT GLASS FRONT PANEL INSTALLED
 'XHWRKLJKWHPSHUDWXUHVWKHDSSOLDQFHVKRXOG
EHORFDWHGRXWRIWUDI¿FDQGDZD\IURPIXUQLWXUH
and draperies.
 7KH JODVV IURQW RU DQ\ SDUW UHPRYHG IRU
servicingtheappliancemustbereplacedprior
to operating the appliance. Work should be
GRQHE\DTXDOL¿HGVHUYLFHSHUVRQ
 .HHSEXUQHUDQGFRQWUROFRPSDUWPHQWFOHDQ
 9HQWFDSLVKRWZKLOHVWRYHLVLQRSHUDWLRQ
 Installation and repair should be done by a
QUALIFIEDSERVICEPERSON.Theappliance
should be inspected before use and at least
DQQXDOO\E\DTXDOL¿HGVHUYLFHSHUVRQ0RUH
frequent cleaning may be required due
to excessive lint from carpeting, bedding
materials, etc. It is imperative that control
compartments, burners and circulating air
passageways of the appliance be kept clean.
 '2127put anything around the stove that
ZLOOREVWUXFWWKHÀRZRIYHQWLODWLRQDLU
 &OHDUDQFHLQDFFRUGDQFHZLWKORFDOLQVWDOODWLRQ
codes and the requirements of the gas
supplier.
 '2 keep the appliance area clear and free
fromcombustiblematerial,gasolineandother
ÀDPPDEOHYDSRUVDQGOLTXLGV
 '2 examine venting system periodically and
replace damaged parts.
 '2make a periodic visual check of pilot and
burners. Clean and replace damaged parts.
CAUTION
The glass used in your stove is tempered glass.
If the glass is cracked or damaged in any way, it
should be replaced only with a complete glass
frame assembly from Empire. See parts list on
Pages 36 and 38 for ordering.
 '2127use this stove if any part has been
XQGHUZDWHU,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFH
technicianto inspecttheheaterand toreplace
any part of the control system and any gas
control which has been under water.
 $Q\ VDIHW\ VFUHHQ RU JXDUG UHPRYHG IRU
servicing an appliance must be replaced prior
to operating the appliance.
 7KLVDSSOLDQFHPXVWEHLQVWDOOHGRQDÀDWVROLG
continuoussurface(e.g.wood,metal,concrete).
7KLVPD\EHWKHÀRRURULWPD\EHUDLVHGXSRQ
a platform to enhance its visual impact. The
appliance may be installed on carpeting, tile,
ZRRG ÀRRULQJ RU RWKHU FRPEXVWLEOH PDWHULDO
as the appliance's base extends the width and
depth of the appliance.
 &KLOGUHQ DQG DGXOWV VKRXOG EH DOHUWHG WR WKH
hazardsofhighsurfacetemperaturesandshould
stay away to avoid burns or clothing ignition.
 <RXQJFKLOGUHQVKRXOGEHFDUHIXOO\VXSHUYLVHG
when they are in the same room as the
appliance.
 &ORWKLQJRURWKHUÀDPPDEOHPDWHULDOVKRXOGQRW
be placed on or near the appliance.
 $GHTXDWHDFFHVVLELOLW\FOHDUDQFHVIRUVHUYLFLQJ
and proper operation.
 7KLVDSSOLDQFHPXVWQRWVKDUHRUEHFRQQHFWHG
WRDÀXHVHUYLQJDVHSDUDWHVROLGIXHOEXUQLQJ
appliance.
 .HHS WKH DUHD DURXQG \RXU DSSOLDQFH FOHDU
of combustible materials, gasoline and other
ÀDPPDEOHYDSRUDQGOLTXLGV
 8QGHUQRFLUFXPVWDQFHVVKRXOGDQ\VROLGIXHOV
(wood, coal, paper or cardboard etc.) be used
in this appliance.
 7KHÀRZRIFRPEXVWLRQDQGYHQWLODWLRQDLUPXVW
not be obstructed in any way.

30794-0-0812Page 4
SOME POINTS TO REMEMBER
NO ODOR DETECTED - ODOR FADE
LP-GAS WARNING ODOR
If a gas leak happens, you should be able to smell the gas because of the odorant put in the LP-Gas.
That's your signal to go into immediate action!
SAFETY INFORMATION FOR USERS OF LP-GAS
3URSDQH/3*DVLVDÀDPPDEOHJDVZKLFKFDQFDXVH¿UHV
and explosions. In its natural state, propane is odorless and
colorless.Youmaynotknowallthefollowingsafetyprecautions
which can protect both you and your family from an accident.
Read them carefully now, then review them point by point
with the members of your household. Someday when there
may not be a minute to lose, everyone's safety will depend
on knowing exactly what to do. If, after reading the following
information, you feel you still need more information, please
contact your gas supplier.
 'RQRWRSHUDWHHOHFWULFVZLWFKHVOLJKWPDWFKHVXVH\RXUSKRQH
'RQRWGRDQ\WKLQJWKDWFRXOGLJQLWHWKHJDV
 *HWHYHU\RQHRXWRIWKHEXLOGLQJYHKLFOHWUDLOHURUDUHD'R
WKDW,00(',$7(/<
 &ORVHDOOJDVWDQNRUF\OLQGHUVXSSO\YDOYHV
 /3*DVLVKHDYLHUWKDQDLUDQGPD\VHWWOHLQORZDUHDVVXFK
DVEDVHPHQWV:KHQ\RXKDYHUHDVRQWRVXVSHFWDJDVOHDN
NHHS RXW RI EDVHPHQWV DQG RWKHU ORZ DUHDV 6WD\ RXW XQWLO
¿UH¿JKWHUVGHFODUHWKHPWREHVDIH
 8VH\RXUQHLJKERUVSKRQHDQGFDOODWUDLQHG/3*DVVHUYLFH
SHUVRQ DQG WKH ¿UH GHSDUWPHQW (YHQ WKRXJK \RX PD\ QRW
FRQWLQXHWRVPHOOJDVGRQRWWXUQRQWKHJDVDJDLQ'RQRW
UHHQWHUWKHEXLOGLQJYHKLFOHWUDLOHURUDUHD
 Finally,OHWWKHVHUYLFHPDQDQG¿UH¿JKWHUVFKHFNIRUHVFDSHG
JDV+DYHWKHPDLURXWWKHDUHDEHIRUH\RXUHWXUQ3URSHUO\
WUDLQHG /3*DV VHUYLFH SHRSOH VKRXOG UHSDLU WKH OHDN WKHQ
FKHFNDQGUHOLJKWWKHJDVDSSOLDQFHIRU\RX
Somepeoplecannotsmellwell.Somepeoplecannotsmellthe
RGRURIWKHFKHPLFDOSXWLQWRWKHJDV<RXPXVW¿QGRXWLI\RX
can smell the odorant in propane.6PRNLQJFDQGHFUHDVH\RXU
DELOLW\WRVPHOO%HLQJDURXQGDQRGRUIRUDWLPHFDQDIIHFW\RXU
VHQVLWLYLW\RUDELOLW\WRGHWHFWWKDWRGRU6RPHWLPHVRWKHURGRUVLQ
WKHDUHDPDVNWKHJDVRGRU3HRSOHPD\QRWVPHOOWKHJDVRGRU
RUWKHLUPLQGVDUHRQVRPHWKLQJHOVH7KLQNLQJDERXWVPHOOLQJD
JDVRGRUFDQPDNHLWHDVLHUWRVPHOO
TheodorantinLP-gasiscolorless,anditcanfadeundersome
circumstances.)RUH[DPSOHLIWKHUHLVDQXQGHUJURXQGOHDNWKH
PRYHPHQWRIWKHJDVWKURXJKVRLOFDQ¿OWHUWKHRGRUDQW2GRUDQWV
LQ/3*DVDOVRDUHVXEMHFWWRR[LGDWLRQ7KLVIDGLQJFDQRFFXULI
WKHUHLVUXVWLQVLGHWKHVWRUDJHWDQNRULQLURQJDVSLSHV
7KHRGRUDQWLQHVFDSHGJDVFDQDGVRUERUDEVRUERQWRRULQWRZDOOV
PDVRQU\DQGRWKHUPDWHULDOVDQGIDEULFVLQDURRP7KDWZLOOWDNH
VRPHRIWKHRGRUDQWRXWRIWKHJDVUHGXFLQJLWVRGRULQWHQVLW\
/3*DVPD\VWUDWLI\LQDFORVHGDUHDDQGWKHRGRULQWHQVLW\FRXOG
YDU\DWGLIIHUHQWOHYHOV6LQFHLWLVKHDYLHUWKDQDLUWKHUHPD\EH
PRUHRGRUDWORZHUOHYHOV$OZD\VEHVHQVLWLYHWRWKHVOLJKWHVWJDV
RGRU,I\RXGHWHFWDQ\RGRUWUHDWLWDVDVHULRXVOHDN,PPHGLDWHO\
JRLQWRDFWLRQDVLQVWUXFWHGHDUOLHU
 Learn to recognize the odor of LP-gas.<RXUORFDO/3*DV
'HDOHUFDQJLYH\RXD6FUDWFKDQG6QLIISDPSKOHW8VHLWWR
¿QGRXWZKDWWKHSURSDQHRGRUVPHOOVOLNH,I\RXVXVSHFWWKDW
\RXU/3*DVKDVDZHDNRUDEQRUPDORGRUFDOO\RXU/3*DV
'HDOHU
 ,I\RXDUHQRWTXDOL¿HGGRQRWOLJKWSLORWOLJKWVSHUIRUPVHUYLFH
RUPDNHDGMXVWPHQWVWRDSSOLDQFHVRQWKH/3*DVV\VWHP,I
\RXDUHTXDOL¿HGFRQVFLRXVO\WKLQNDERXWWKHRGRURI/3*DV
SULRUWRDQGZKLOHOLJKWLQJSLORWOLJKWVRUSHUIRUPLQJVHUYLFHRU
PDNLQJDGMXVWPHQWV
 6RPHWLPHV D EDVHPHQW RU D FORVHGXS KRXVH KDV D PXVW\
VPHOOWKDWFDQFRYHUXSWKH/3*DVRGRU'RQRWWU\WROLJKW
SLORWOLJKWVSHUIRUPVHUYLFHRUPDNHDGMXVWPHQWVLQDQDUHD
ZKHUHWKHFRQGLWLRQVDUHVXFKWKDW\RXPD\QRWGHWHFWWKHRGRU
LIWKHUHKDVEHHQDOHDNRI/3*DV
 2GRUIDGHGXHWRR[LGDWLRQE\UXVWRUDGVRUSWLRQRQZDOOVRI
QHZF\OLQGHUVDQGWDQNVLVSRVVLEOH7KHUHIRUHSHRSOHVKRXOG
EHSDUWLFXODUO\DOHUWDQGFDUHIXOZKHQQHZWDQNVRUF\OLQGHUV
DUHSODFHGLQVHUYLFH2GRUIDGHFDQRFFXULQQHZWDQNVRU
UHLQVWDOOHGROGWDQNVLIWKH\DUH¿OOHGDQGDOORZHGWRVHWWRR
ORQJEHIRUHUH¿OOLQJ&\OLQGHUVDQGWDQNVZKLFKKDYHEHHQRXW
RIVHUYLFHIRUDWLPHPD\GHYHORSLQWHUQDOUXVWZKLFKZLOOFDXVH
RGRUIDGH,IVXFKFRQGLWLRQVDUHVXVSHFWHGWRH[LVWDSHULRGLF
VQLIIWHVWRIWKHJDVLVDGYLVDEOHIf you have any question
about the gas odor, call your LP-gas dealer. A periodic
sniff test of the LP-gas is a good safety measure under
any condition.
 ,IDWDQ\WLPH\RXGRQRWVPHOOWKH/3*DVRGRUDQWDQG\RX
WKLQN\RXVKRXOGDVVXPH\RXKDYHDOHDN7KHQWDNHWKHVDPH
LPPHGLDWHDFWLRQUHFRPPHQGHGDERYHIRUWKHRFFDVLRQZKHQ
\RXGRGHWHFWWKHRGRUL]HG/3*DV
 ,I\RXH[SHULHQFHDFRPSOHWHJDVRXWWKHFRQWDLQHULVXQGHU
QRYDSRUSUHVVXUHWXUQWKHWDQNYDOYHRIILPPHGLDWHO\,IWKH
FRQWDLQHUYDOYHLVOHIWRQWKHFRQWDLQHUPD\GUDZLQVRPHDLU
WKURXJKRSHQLQJVVXFKDVSLORWOLJKWRUL¿FHV,IWKLVRFFXUVVRPH
QHZLQWHUQDOUXVWLQJFRXOGRFFXU,IWKHYDOYHLVOHIWRSHQWKHQ
WUHDWWKHFRQWDLQHUDVDQHZWDQN$OZD\VEHVXUH\RXUFRQ-
WDLQHULVXQGHUYDSRUSUHVVXUHE\WXUQLQJLWRIIDWWKHFRQWDLQHU
EHIRUHLWJRHVFRPSOHWHO\HPSW\RUKDYLQJLWUH¿OOHGEHIRUHLWLV
FRPSOHWHO\HPSW\

30794-0-0812 Page 5
REQUIREMENTS FOR MASSACHUSETTS
)RUDOOVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQWLQVWDOOHG
LQHYHU\GZHOOLQJEXLOGLQJRUVWUXFWXUHXVHGLQZKROHRULQSDUWIRU
UHVLGHQWLDO SXUSRVHV LQFOXGLQJ WKRVH RZQHG RU RSHUDWHG E\ WKH
&RPPRQZHDOWKDQGZKHUHWKHVLGHZDOOH[KDXVWYHQWWHUPLQDWLRQ
LVOHVVWKDQVHYHQIHHWDERYH¿QLVKHGJUDGHLQWKHDUHDRIWKH
YHQWLQJLQFOXGLQJEXWQRWOLPLWHGWRGHFNVDQGSRUFKHVWKHIROORZLQJ
UHTXLUHPHQWVVKDOOEHVDWLV¿HG
 ,167$//$7,212)&$5%210212;,'('(7(&7256$W
WKHWLPHRILQVWDOODWLRQRIWKHVLGHZDOOKRUL]RQWDOYHQWHGJDVIX-
HOHGHTXLSPHQWWKHLQVWDOOLQJSOXPEHURUJDV¿WWHUVKDOOREVHUYH
WKDWDKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUZLWKDQDODUPDQG
EDWWHU\EDFNXSLVLQVWDOOHGRQWKHÀRRUOHYHOZKHUHWKHJDV
HTXLSPHQWLVWREHLQVWDOOHG,QDGGLWLRQWKHLQVWDOOLQJSOXPEHU
RUJDV¿WWHUVKDOOREVHUYHWKDWDEDWWHU\RSHUDWHGRUKDUGZLUHG
FDUERQPRQR[LGHGHWHFWRUZLWKDQDODUPLVLQVWDOOHGRQHDFK
DGGLWLRQDOOHYHORIWKHGZHOOLQJEXLOGLQJRUVWUXFWXUHVHUYHGE\
WKHVLGHZDOOKRUL]RQWDOYHQWHGJDVIXHOHGHTXLSPHQW,WVKDOOEH
WKHUHVSRQVLELOLW\RIWKHSURSHUW\RZQHUWRVHFXUHWKHVHUYLFHV
RITXDOL¿HGOLFHQVHGSURIHVVLRQDOVIRUWKHLQVWDOODWLRQRIKDUG
ZLUHGFDUERQPRQR[LGHGHWHFWRUV
 D ,QWKHHYHQWWKDWWKHVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIX-
HOHGHTXLSPHQWLVLQVWDOOHGLQDFUDZOVSDFHRUDQDWWLF
WKHKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUZLWKDODUPDQG
EDWWHU\EDFNXSPD\EHLQVWDOOHGRQWKHQH[WDGMDFHQWÀRRU
OHYHO
 E ,QWKHHYHQWWKDWWKHUHTXLUHPHQWVRIWKLVVXEGLYLVLRQFDQQRW
EHPHWDWWKHWLPHRIFRPSOHWLRQRILQVWDOODWLRQWKHRZQHU
VKDOOKDYHDSHULRGRIWKLUW\GD\VWRFRPSO\ZLWKWKH
DERYHUHTXLUHPHQWVSURYLGHGKRZHYHUWKDWGXULQJVDLG
WKLUW\GD\SHULRGDEDWWHU\RSHUDWHGFDUERQPRQR[LGH
GHWHFWRUZLWKDQDODUPVKDOOEHLQVWDOOHG
 $33529('&$5%210212;,'('(7(&7256(DFKFDUERQ
PRQR[LGHGHWHFWRUDVUHTXLUHGLQDFFRUGDQFHZLWKWKHDERYH
SURYLVLRQVVKDOOFRPSO\ZLWK1)3$DQGEH$16,8/
OLVWHGDQG,$6FHUWL¿HG
 6,*1$*($PHWDORUSODVWLFLGHQWL¿FDWLRQSODWHVKDOOEHSHU-
PDQHQWO\PRXQWHGWRWKHH[WHULRURIWKHEXLOGLQJDWDPLQLPXP
KHLJKW RI HLJKW  IHHW DERYH JUDGH GLUHFWO\ LQ OLQH ZLWK WKH
H[KDXVWYHQW WHUPLQDO IRUWKHKRUL]RQWDOO\ YHQWHG JDVIXHOHG
KHDWLQJDSSOLDQFHRUHTXLSPHQW7KHVLJQVKDOOUHDGLQSULQWVL]H
QROHVVWKDQRQHKDOILQFKLQVL]H“GASVENTDIRECTLY
%(/2:.((3&/($52)$//2%6758&7,216´
 ,163(&7,217KHVWDWHRUORFDOJDVLQVSHFWRURIWKHVLGHZDOO
KRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQWVKDOOQRWDSSURYHWKH
LQVWDOODWLRQ XQOHVV XSRQ LQVSHFWLRQ WKH LQVSHFWRU REVHUYHV
FDUERQPRQR[LGHGHWHFWRUVDQGVLJQDJHLQVWDOOHGLQDFFRUGDQFH
ZLWKWKHSURYLVLRQVRI&05DWKURXJK
 E (;(037,2167KHIROORZLQJHTXLSPHQWLVH[HPSWIURP
&05DWKURXJK
   7KHHTXLSPHQWOLVWHGLQ&KDSWHUHQWLWOHG³(TXLS-
PHQW1RW5HTXLUHG7R%H9HQWHG´LQWKHPRVWFXUUHQW
HGLWLRQRI1)3$DVDGRSWHGE\WKH%RDUGDQG
   3URGXFW$SSURYHGVLGHZDOOKRUL]RQWDOO\YHQWHGJDV
IXHOHG HTXLSPHQW LQVWDOOHG LQ D URRP RU VWUXFWXUH
VHSDUDWHIURPWKHGZHOOLQJEXLOGLQJRUVWUXFWXUHXVHG
LQZKROHRULQSDUWIRUUHVLGHQWLDOSXUSRVHV
 G 0$18)$&785(5 5(48,5(0(176  *$6 (48,3-
0(179(17,1*6<67(01273529,'(':KHQWKH
PDQXIDFWXUHURID3URGXFW$SSURYHGVLGHZDOOKRUL]RQWDOO\
YHQWHGJDVIXHOHGHTXLSPHQWGRHVQRWSURYLGHWKHSDUWV
IRUYHQWLQJWKHÀXHJDVHVEXWLGHQWL¿HV³VSHFLDOYHQWLQJ
V\VWHPV´WKHIROORZLQJUHTXLUHPHQWVVKDOOEHVDWLV¿HGE\
WKHPDQXIDFWXUHU
   7KHUHIHUHQFHG³VSHFLDOYHQWLQJV\VWHP´LQVWUXFWLRQV
VKDOO EH LQFOXGHG ZLWK WKH DSSOLDQFH RU HTXLSPHQW
LQVWDOODWLRQLQVWUXFWLRQVDQG
   7KH³VSHFLDOYHQWLQJV\VWHPV´VKDOOEH3URGXFW$S-
SURYHG E\ WKH %RDUG DQG WKH LQVWUXFWLRQV IRU WKDW
V\VWHPVKDOOLQFOXGHDSDUWVOLVWDQGGHWDLOHGLQVWDOOD-
WLRQLQVWUXFWLRQ
 H $FRS\RIDOOLQVWDOODWLRQLQVWUXFWLRQVIRUDOO3URGXFW$SSURYHG
VLGH ZDOO KRUL]RQWDOO\ YHQWHG JDV IXHOHG HTXLSPHQW DOO
YHQWLQJLQVWUXFWLRQVDOOSDUWVOLVWVIRUYHQWLQJLQVWUXFWLRQV
DQGRUDOOYHQWLQJGHVLJQLQVWUXFWLRQVVKDOOUHPDLQZLWKWKH
DSSOLDQFHRUHTXLSPHQWDWWKHFRPSOHWLRQRIWKHLQVWDOOD-
WLRQ

30794-0-0812Page 6
Instructions to Installer
 ,QVWDOOHU PXVW OHDYH LQVWUXFWLRQ PDQXDO ZLWK RZQHU DIWHU
LQVWDOODWLRQ
 ,QVWDOOHUPXVWKDYHRZQHU¿OORXWDQGPDLOZDUUDQW\FDUGVXSSOLHG
ZLWKWKHVWRYH
 ,QVWDOOHUVKRXOGVKRZRZQHUKRZWRVWDUWDQGRSHUDWHWKHVWRYH
7KLVGLUHFWYHQWJDVVWRYHKHDWHULVGHVLJQHGWRRSHUDWHZLWKDOO
FRPEXVWLRQ DLU EHLQJ VLSKRQHG IURP WKH RXWVLGH RI WKH EXLOGLQJ
DQGDOOH[KDXVWJDVHVH[SHOOHGWRWKHRXWVLGHRIWKHEXLOGLQJ7KH
LQIRUPDWLRQFRQWDLQHGLQWKLVPDQXDOSHUWDLQVWRDOOPRGHOVDQGJDV
FRQWUROV\VWHPVXQOHVVRWKHUZLVHQRWHG
WARNING
This unit is not for use with solid fuels.
Notice: 'XULQJLQLWLDO¿ULQJRIWKLVXQLWLWVSDLQWZLOOEDNHRXWDQG
VPRNHZLOORFFXU7RSUHYHQWWULJJHULQJRIVPRNHDODUPVYHQWLODWH
WKHURRPLQZKLFKWKHXQLWLVLQVWDOOHG
Notice:5HPRYHVFUHZLQYDOYHFRYHU6FUHZLVUHTXLUHGWRSUHYHQW
VKLSSLQJGDPDJH
$SSOLDQFHPXVWQRWEHFRQQHFWHGWRDFKLPQH\ÀXHWKDWLVVHUYLFLQJ
DVHSDUDWHVROLGIXHOEXUQLQJDSSOLDQFH
CAUTION
All vent runs must have a minimum VERTICAL rise of two
feet. See Venting Stove, page 11.
Installation in Residential Garages
*DVXWLOL]DWLRQHTXLSPHQWLQUHVLGHQWLDOJDUDJHVVKDOOEHLQVWDOOHG
VRWKDWDOOEXUQHUVDQGEXUQHULJQLWLRQGHYLFHVDUHORFDWHGQRWOHVV
WKDQPPDERYHWKHÀRRU
6XFKHTXLSPHQWVKDOOEHORFDWHGRUSURWHFWHGVRLWLVQRWVXEMHFW
WRSK\VLFDOGDPDJHE\DPRYLQJYHKLFOH
$SSOLDQFH&HUWL¿FDWLRQ
7KLVVWRYHLVGHVLJQFHUWL¿HGLQDFFRUGDQFHZLWK$PHULFDQ1DWLRQDO
6WDQGDUG&6$6WDQGDUG$16,=&6$DQGE\8QGHUZULWHUV
/DERUDWRULHVDVD'LUHFW9HQW*DV)LUHSODFH+HDWHUDQGVKDOOEH
LQVWDOOHGDFFRUGLQJWRWKHVHLQVWUXFWLRQV
&RQVXOW\RXUORFDOEXLOGLQJFRGHDJHQF\SULRUWRLQVWDOODWLRQWRHQVXUH
FRPSOLDQFHZLWKORFDOFRGHVLQFOXGLQJSHUPLWVDQGLQVSHFWLRQV
7KHVWRYHZKHQLQVWDOOHGZLWKEORZHUPXVWEHHOHFWULFDOO\JURXQGHG
LQDFFRUGDQFHZLWKORFDOFRGHVRULQDEVHQFHRIORFDOFRGHVZLWK
WKHNationalElectricCodeANSI/NFPA70RU&DQDGLDQ(OHFWULFFRGH
&6$&LIDQH[WHUQDOHOHFWULFDOVRXUFHLVXWLOL]HG
7KHVHPRGHOVPD\EHLQVWDOOHGLQDEHGURRPRUEHGVLWWLQJURRP
LQWKH86$DQG&DQDGD
4XDOL¿HG,QVWDOOLQJ$JHQF\
,QVWDOODWLRQDQGUHSODFHPHQWRIJDVSLSLQJJDVXWLOL]DWLRQHTXLSPHQW
RU DFFHVVRULHV DQG UHSDLU DQG VHUYLFLQJ RI HTXLSPHQW VKDOO EH
SHUIRUPHGRQO\E\DTXDOL¿HGDJHQF\7KHWHUP³TXDOL¿HGDJHQF\´
PHDQVDQ\LQGLYLGXDO¿UPFRUSRUDWLRQRUFRPSDQ\ZKLFKHLWKHULQ
SHUVRQRUWKURXJKDUHSUHVHQWDWLYHLVHQJDJHGLQDQGLVUHVSRQVLEOHIRU
DWKHLQVWDOODWLRQRUUHSODFHPHQWRIJDVSLSLQJRUEWKHFRQQHFWLRQ
LQVWDOODWLRQUHSDLURUVHUYLFLQJRIHTXLSPHQWZKRLVH[SHULHQFHGLQ
VXFKZRUNIDPLOLDUZLWKDOOSUHFDXWLRQVUHTXLUHGDQGKDVFRPSOLHG
ZLWKDOOWKHUHTXLUHPHQWVRIWKHDXWKRULW\KDYLQJMXULVGLFWLRQ
State of Massachusetts: 7KHLQVWDOODWLRQPXVWEHPDGH
E\DOLFHQVHGSOXPEHURUJDV¿WWHULQWKH&RPPRQZHDOWKRI
0DVVDFKXVHWWV
7KHLQVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHVRULQWKHDEVHQFHRI
ORFDOFRGHVZLWKWKHNational Fuel Gas Code ANSI Z223.1/NFPA
54* Natural Gas and Propane Installation Code, or CSA B149.1 in
Canada.*AvailablefromtheAmerican NationalStandardsInstitute,
Inc. 11 West 42nd St., New York, N.Y. 10036.
WARNING
ANY CHANGE TO THIS STOVE OR ITS CONTROLS CAN
BE DANGEROUS.
Improper installation or use of the stove can cause serious
LQMXU\RUGHDWKIURP¿UHEXUQVH[SORVLRQVRUFDUERQ
monoxide poisoning.
Any alteration of the original design, installed other than as
shown in these instructions or use with a type of gas not
shown on the rating plate is the responsibility of the person
and company making the change.
Important
$OOFRUUHVSRQGHQFHVKRXOGUHIHUWRFRPSOHWH0RGHO1XPEHU6HULDO
1XPEHUDQGW\SHRIJDV
High Altitude
:KHQLQVWDOOLQJ WKLV XQLWDWDQ HOHYDWLRQ DERYHIHHW LQ WKH
8QLWHG6WDWHVLWPD\EHQHFHVVDU\WRGHFUHDVHWKHLQSXWUDWLQJE\
FKDQJLQJWKHH[LVWLQJ EXUQHU RUL¿FH WRDVPDOOHUVL]H*HQHUDOO\
LQSXWVKRXOGEHUHGXFHGSHUFHQWIRUHDFKIHHWDERYHVHD
OHYHO+RZHYHULIWKHKHDWLQJYDOXHRIWKHJDVKDVEHHQUHGXFHG
WKLVJHQHUDOUXOHPD\QRWDSSO\&KHFNZLWKORFDOJDVXWLOLW\IRUSURSHU
RUL¿FHVL]HLGHQWL¿FDWLRQ
Canadian High Altitude
$OWLWXGHIHHWP
:KHQLQVWDOOLQJWKLVXQLWDWDQHOHYDWLRQDERYHIHHWLQ&DQDGD
FKHFNZLWKORFDODXWKRULWLHV
&RQVXOW\RXUORFDOJDVXWLOLW\IRUDVVLVWDQFHLQGHWHUPLQLQJWKHSURSHU
RUL¿FHIRUORFDWLRQ
Preparation
7KLVGLUHFWYHQWJDVVWRYHDQGLWVFRPSRQHQWVDUHWHVWHGDQGVDIH
ZKHQLQVWDOOHGLQDFFRUGDQFHZLWKWKLV,QVWDOODWLRQ0DQXDO5HSRUW
WR\RXUGHDOHUDQ\SDUWVGDPDJHGLQVKLSPHQWVSHFL¿FDOO\FKHFN
JODVVFRQGLWLRQ'RQRWLQVWDOOXQLWZLWKGDPDJHGLQFRPSOHWHRU
VXEVWLWXWH SDUWV 5HDG DOO LQVWUXFWLRQV EHIRUH VWDUWLQJ LQVWDOODWLRQ
DQGIROORZWKHVHLQVWUXFWLRQVFDUHIXOO\GXULQJLQVWDOODWLRQWRLQVXUH
PD[LPXPEHQH¿WDQGVDIHW\)DLOXUHWRIROORZWKHPZLOOYRLG\RXU
ZDUUDQW\DQGPD\SUHVHQWD¿UHKD]DUG
7KHZDUUDQW\ZLOOEH YRLGHGE\ DQGWKHZDUUDQWHUGLVFODLPVDQ\
UHVSRQVLELOLW\IRUWKHIROORZLQJDFWLRQV
 ,QVWDOODWLRQRIDQ\GDPDJHGVWRYHRUYHQWV\VWHPFRPSRQHQW
 0RGL¿FDWLRQRIWKHVWRYHRUGLUHFWYHQWV\VWHP
 ,QVWDOODWLRQRWKHUWKDQDVLQVWUXFWHGE\(PSLUH&RPIRUW6\VWHPV
,QF
 ,PSURSHUSRVLWLRQLQJRIWKHORJVRUJODVVGRRU
 ,QVWDOODWLRQDQGRUXVHRIDQ\FRPSRQHQWSDUWQRWPDQXIDFWXUHG
RUDSSURYHGE\PDQXIDFWXUHU
INTRODUCTION

30794-0-0812 Page 7
SPECIFICATIONS
Model DVP20CC DVP30CC
*DV7\SH 1DWXUDO*DV LP 1DWXUDO*DV LP
,QSXW%78+5.:+0D[ 19,500 26,500 26,500
,QSXW%78+5.:+0LQ 13,500 18,000 21,000
*DV,QOHW3LSH  
2UL¿FH PP 55 39 PP
*DV6XSSO\3UHVVXUH0D[ :&N3D :&N3D :&N3D :&N3D
*DV6XSSO\3UHVVXUH0LQ :&N3D :&N3D :&N3D :&N3D
*DV6XSSO\3UHVVXUH0DQLIROG :&N3D :&N3D :&N3D :&N3D
+HLJKW  
:LGWK  
'HSWK  
9HQWLQJ$FFHVVRULHV6SHFLDO9HQW.LWV6LPSVRQ'XUDYHQW&DQEHSXUFKDVHGIURP(PSLUH&RPIRUW6\VWHPV,QF
DVKHP
UHTXLUHV6'6'9$(%
9HUWLFDO'LUHFW9HQW.LWIRU'93&&/32QO\'9$%'9$%'9$$%'9$'&
46DVA-WT, 46DVA-HC, 46DVA-E90B)
DVK45LP +RUL]RQWDO'LUHFW9HQW'HJNLWIRU'93&&/32QO\6''9$(%6'7%DGDSWRU[
WR[6''9$'&6''9$:76''9$+6&+
DVK45NAT +RUL]RQWDO'LUHFW9HQW'HJNLWIRU'93&&1DW2QO\6''9$(%6''9$%6'-
46DVADC, SD46DVAWT, SD46DVAHC)
DVKVP45 9HUWLFDO'LUHFW9HQW'HJNLWIRU'93&&/3DQG1DWDQG'93&&1DW2QO\6''9$(%
SD46DVAE90B, SD46DVA12B, SD46DVA911B, SD46DVADC, SD46DVAWT, SD46DVAHC)
Accessories
TMV 0LOOLYROW:DOO7KHUPRVWDW5HHG6ZLWFK
FRBC %DWWHU\2SHUDWHG5HPRWH&RQWURO
FRBTC %DWWHU\2SHUDWHG5HPRWH&RQWUROZLWK7KHUPRVWDW
FREC (OHFWULF5HPRWH&RQWURO
FWS :DOO6ZLWFK
FRBTP 'D\3URJUDPPDEOH5HPRWH
TRW 5HPRWH:DOO7KHUPRVWDW
CIB3 $XWRPDWLF%ORZHU'93&&
CIB4 $XWRPDWLF%ORZHU'93&&
Stone Inlay Replaces Standard Grill Top - DVP30CC30 Models ONLY
CSI-8V 6WRQH,QOD\9HQHWLDQ*ROG
CSI-9A 6WRQH,QOD\$GREH)URVW
CSI-10M 6WRQH,QOD\3DWLQD0RFKD
CSI-11G 6WRQH,QOD\7HPSOH*UD\
CSI-12A 6WRQH,QOD\$PHULFDQ%HDXW\
&DVW,URQ6WRYH6LGH6KHOI.LW,QFOXGHV/HIW5LJKW
CSK-B 6LGH6KHOI.LW3RUFHODLQ%ODFN
CSK-F 6LGH6KHOI.LW0DWWH%ODFN
CSK-M 6LGH6KHOI.LW3RUFHODLQ0DKRJDQ\
CSK-S 6LGH6KHOI.LW3RUFHODLQ6DQG'93&&2QO\
CSK-W 6LGH6KHOI.LW0DWWH3HZWHU'93&&2QO\

30794-0-0812Page 8
&RQVXOWWKHFXUUHQW1DWLRQDO)XHO*DV&RGH$16,=&$1
&*$%RULQVWDOODWLRQFRGH
Note:1HYHUXVHSODVWLFSLSH&KHFNWRFRQ¿UPZKHWKHU\RXUORFDO
FRGHVDOORZFRSSHUWXELQJRUJDOYDQL]HG
Note:6LQFHVRPHPXQLFLSDOLWLHVKDYHDGGLWLRQDOORFDOFRGHVLWLV
DOZD\VEHVWWRFRQVXOW\RXUORFDODXWKRULW\DQGLQVWDOODWLRQFRGH
7KHXVHRIWKHIROORZLQJJDVFRQQHFWRUVLVUHFRPPHQGHG
² $16=$SSOLDQFH&RQQHFWRUVRI&RUUXJDWHG0HWDO7XELQJ
DQG)LWWLQJV
² $16=$VVHPEOHG)OH[LEOH$SSOLDQFH&RQQHFWRUVRI2WKHU
7KDQ$OO0HWDO&RQVWUXFWLRQ
7KHDERYHFRQQHFWRUVPD\EHXVHGLIDFFHSWDEOHE\WKHDXWKRULW\
KDYLQJMXULVGLFWLRQ7KHVWDWHRI0DVVDFKXVHWWVUHTXLUHVWKDWDÀH[LEOH
DSSOLDQFHFRQQHFWRUFDQQRWH[FHHGWKUHHIHHWLQOHQJWK
Figure 1
Installing a New Main Gas Cock
(DFKDSSOLDQFHVKRXOGKDYHLWVRZQPDQXDOJDVFRFN
$PDQXDOPDLQJDVFRFNVKRXOGEHORFDWHGLQWKHYLFLQLW\RIWKHXQLW
:KHUHQRQHH[LVWVRUZKHUHLWVVL]HRUORFDWLRQLVQRWDGHTXDWH
FRQWDFW\RXUORFDODXWKRUL]HGLQVWDOOHUIRULQVWDOODWLRQRUUHORFDWLRQ
&RPSRXQGVXVHGRQWKUHDGHGMRLQWVRIJDVSLSLQJVKDOOEHUHVLVWDQW
WRWKHDFWLRQRIOLTXH¿HGSHWUROHXPJDVHV7KHJDVOLQHVPXVWEH
FKHFNHGIRUOHDNVE\WKHLQVWDOOHU7KLVVKRXOGEHGRQHZLWKDVRDS
VROXWLRQZDWFKLQJIRUEXEEOHVRQDOOH[SRVHGFRQQHFWLRQVDQGLI
XQH[SRVHGDSUHVVXUHWHVWVKRXOGEHPDGH
1HYHUXVHDQH[SRVHGÀDPHWRFKHFNIRUOHDNV$SSOLDQFHPXVW
be disconnected from piping at inlet of control valve and pipe
capped or plugged for pressure test. Never pressure test with
DSSOLDQFHFRQQHFWHGFRQWUROYDOYHZLOOVXVWDLQGDPDJH
Note: 7KH JDV FRQWURO LV HTXLSSHG ZLWK D FDSWXUHG VFUHZ W\SH
SUHVVXUHWHVWSRLQWWKHUHIRUHLWLVQRWQHFHVVDU\WRSURYLGHD
WHVWSRLQWXSVWUHDPRIWKHFRQWURO
$JDVYDOYHDQGJURXQGMRLQWXQLRQVKRXOGEHLQVWDOOHGLQWKHJDV
OLQHXSVWUHDPRIWKHJDVFRQWUROWRDLGLQVHUYLFLQJ,WLVUHTXLUHGE\
WKH1DWLRQDO)XHO*DV&RGHWKDWDGULSOLQHEHLQVWDOOHGQHDUWKHJDV
LQOHW7KLVVKRXOGFRQVLVWRIDYHUWLFDOOHQJWKRISLSHWHHFRQQHFWHG
LQWRWKHJDVOLQHWKDWLVFDSSHGRQWKHERWWRPLQZKLFKFRQGHQVDWLRQ
DQGIRUHLJQSDUWLFOHVPD\FROOHFW
:KHQXVLQJFRSSHURUÀH[FRQQHFWRUXVHRQO\DSSURYHG¿WWLQJV
AlwaysprovideaunionVRWKDWJDVOLQHFDQEHHDVLO\GLVFRQQHFWHG
IRUEXUQHUVHUYLFLQJ
7KHDSSOLDQFHDQGLWVLQGLYLGXDOVKXWRIIYDOYHPXVWEHGLVFRQQHFWHG
IURPVXSSO\SLSLQJV\VWHPGXULQJDQ\SUHVVXUHWHVWLQJRIWKDWV\VWHP
DWWHVWSUHVVXUHVLQH[FHVVRISVLJN3D
7KHDSSOLDQFHPXVWEHLVRODWHGIURPWKHJDVVXSSO\SLSLQJV\VWHP
E\FORVLQJLWVLQGLYLGXDOPDQXDOVKXWRIIYDOYHGXULQJDQ\SUHVVXUH
WHVWLQJRIWKHJDVVXSSO\SLSLQJV\VWHPDWWHVWSUHVVXUHVHTXDOWR
RUOHVVWKDQSVLJN3D
CAUTION
If one of the procedures results in pressures in excess of 1/2
psig (14" w.c.) (3.5 kPa) on the stove gas valve, it will result
in a hazardous condition.
Checking Manifold Pressure
%RWK 3URSDQH DQG 1DWXUDO JDV YDOYHV KDYH D EXLOWLQ SUHVVXUH
UHJXODWRULQWKHJDVYDOYH1DWXUDOJDVPRGHOVZLOOKDYHDPDQLIROG
SUHVVXUHRIDSSUR[LPDWHO\ZFN3DIRUPD[LPXPLQSXWRU
ZFN3DIRUPLQLPXPLQSXWDWWKHYDOYHRXWOHWZLWKWKHLQOHW
SUHVVXUHWRWKHYDOYHIURPDPLQLPXPRIZFN3DIRUWKH
SXUSRVHRILQSXWDGMXVWPHQWWRDPD[LPXPRIZFN3D
3URSDQHJDVPRGHOVZLOOKDYHDPDQLIROGSUHVVXUHDSSUR[LPDWHO\
ZF N3D IRUPD[LPXPLQSXWRUZFN3D
IRUPLQLPXPLQSXWDWWKHYDOYHRXWOHWZLWKWKHLQOHWSUHVVXUHWRWKH
YDOYHIURPDPLQLPXPRIZFN3DIRUWKHSXUSRVHRI
LQSXWDGMXVWPHQWWRDPD[LPXPRIZFN3D
$ PP 137SOXJJHG WDSSLQJDFFHVVLEOH IRU WHVWJDXJH
FRQQHFWLRQLVORFDWHGRQWKHRXWOHWVLGHRIWKHJDVFRQWURO
GAS SUPPLY
Recommended Gas Pipe Diameter
Pipe Length Schedule 40 Pipe
Inside Diameter Tubing, Type L Outside Diameter
1DW L.P. 1DW L.P.
IHHW
PHWHUV
´
PP
´
PP
´
PP
´
PP
IHHW
PHWHUV
´
PP
´
PP
´
PP
´
PP
IHHW
PHWHUV
´
PP
´
PP
´
PP
´
PP
IHHW
PHWHUV
´
PP
´
PP
´
PP
´
PP
1/2 NPT
NIPPLE
1/2 NPT
NIPPLE

30794-0-0812 Page 9
,Q VHOHFWLQJ D ORFDWLRQ IRU LQVWDOODWLRQ LW LV QHFHVVDU\ WR SURYLGH
DGHTXDWHDFFHVVLELOLW\FOHDUDQFHVIRUVHUYLFLQJDQGSURSHURSHUD-
WLRQ
Locating and Venting the Direct Vent Stove
&OHDUDQFHV :KHQ IDFLQJ WKH IURQW RI WKH GLUHFW YHQW VWRYH WKH
PLQLPXP FOHDUDQFHV WR FRPEXVWLEOH FRQVWUXFWLRQ PDWHULDO DUH
WKHIROORZLQJ
7RSRIDSSOLDQFHFHLOLQJ PP
5HDU:DOO PP
6LGH:DOO PP
+HDWHU&RUQHUVDQJOHWR:DOO PP
)ORRU  PP
Installation on Rugs and Tile
7KLVDSSOLDQFHPXVWEHLQVWDOOHGRQDÀDWVROLGFRQWLQXRXVVXUIDFH
HJZRRGPHWDOFRQFUHWH7KLVPD\EHWKHÀRRURULWPD\EH
UDLVHGXSRQDSODWIRUPWRHQKDQFHLWVYLVXDOLPSDFW7KHFRQWLQX-
RXVVXUIDFHPD\EHFRYHUHGZLWKFDUSHWLQJYLQ\OZRRGÀRRULQJRU
RWKHUFRPEXVWLEOHPDWHULDO
6” (153mm)
TOSIDE WALL
6” (153mm) TO
COMBUSTIBLE
MATERIAL
36” (91cm) TOCEILING OR
HORIZONTAL PROJECTION
ABOVEAPPLIANCE
Figure 2
4” (102mm) HEATER CORNERS TOSIDE WALL
14” DVP30
(355mm)
4”
(102mm)
NOTE: HEATER INSTALLED AT 45° ANGLE INCORNER
10” DVP20
(254mm)
14” DVP30
(355mm)
10” DVP20
(254mm)
Figure 3
TOCOMBUSTIBLEMATERIAL
2” (51mm)
Figure 4
CLEARANCES

30794-0-0812Page 10
Special Vent Systems
7KHIROORZLQJYHQWV\VWHPVDUHDFFHSWDEOHIRUXVHZLWKWKH'93&&VWRYH
Simpson Duravent® GS
American Metal® 4" - 6 5/8"
Selkirk Direct-Temp® 4" - 6 5/8"
Security Secure Vent®
ICC Inc. Excel
American Metal®, Selkirk Direct-Temp®, Security Secure Vent®, and ICC Inc. Excel CAN NOT be used in side wall horizontal
vent installations in the state of Massachusetts.
CLEARANCES (cont.)
Figure 6
43 ½” DVP20
(1.10m)
90°ELBOW
24” PIPESECTION
(610mm)
47” DVP30
(1.193 m)

30794-0-0812 Page 11
VENTING STOVE
Venting Graph (Dimensions in Feet)
 'HWHUPLQHWKHKHLJKWRIWKHFHQWHURIWKHWHUPLQDWLRQ8VLQJWKLV
GLPHQVLRQRQWKH9HQWLQJ*UDSKORFDWHWKHSRLQWLWLQWHUVHFWV
ZLWKWKHVODQWHGJUDSKOLQHRUWKHULJKWHGJHRIWKHJUDSK
 )URPWKHSRLQWRIWKLVLQWHUVHFWLRQGUDZDYHUWLFDOOLQHWRWKH
ERWWRPRIWKHJUDSK
 $GMXVWWKHLQGLFDWHGPD[LPXPGLPHQVLRQIRUDGGLWLRQDOHOERZV
LIQHFHVVDU\
 3RVLWLRQWKHXQLWVRWKDWPD[LPXPKRUL]RQWDOUXQLVQRWH[FHHGHG
Venting Requirements
0LQLPXPYHUWLFDOULVHIURPDSSOLDQFHRXWOHWEHIRUHDQ\HOERZV 
LQFKHVPPIRU'93&&/31$7DQG'93&&1$7
DQGLQFKHVPPIRU'93&&/3
0D[LPXPYHUWLFDOULVHIURPDSSOLDQFHRXWOHW IHHWP
0D[LPXPYHUWLFDOULVHDQGKRUL]RQWDOUXQLVDFRPELQHGWRWDORI
IHHWP
0D[LPXPHOERZV WZRIRUWKHVHFRQGHOERZVXEWUDFWIHHW
IURPDKRUL]RQWDOUXQ
To Use the Vent Graph
EXAMPLE A:
,IWKHYHUWLFDOULVHIURPWKHDSSOLDQFHRXWOHWLVIHHWWKHKRUL]RQWDO
UXQWRWKHRXWHUZDOOÀDQJHRIWKHYHQWWHUPLQDWLRQPXVWQRWH[FHHG
IHHWZLWKRQHHOERZ
EXAMPLE B:
,IWKHYHUWLFDOULVHIURPWKHDSSOLDQFHRXWOHWLVIHHWWKHKRUL]RQWDO
UXQWRWKHRXWHUZDOOÀDQJHRIWKHYHQWWHUPLQDWLRQPXVWQRWH[FHHG
IHHWZLWKRQHHOERZ
SPECIALNOTE:)RUHDFKGHJUHHHOERZLQVWDOOHGLQWKHKRUL]RQWDO
UXQWKHOHQJWKRIWKHKRUL]RQWDOUXQ0867EHUHGXFHGE\LQFKHV
PP7KLVGRHVQRWDSSO\LIWKHGHJUHHHOERZVDUHLQVWDOOHG
RQWKHYHUWLFDOULVHRIWKHYHQWV\VWHP
Example:$FFRUGLQJWRWKHFKDUWWKHPD[LPXPKRUL]RQWDOUXQLV
IHHWDQGLIWZRGHJUHHHOERZVDUHUHTXLUHGLQWKHKRUL]RQWDOUXQ
LWPXVWEHUHGXFHGWRIHHW
7KH PD[LPXP QXPEHU RI  GHJUHH HOERZV SHUPLWWHG SHU VLGH
ZDOOLQVWDOODWLRQLVWZR7KHVHHOERZVFDQEHLQVWDOOHGLQHLWKHUWKH
YHUWLFDOULVHRUKRUL]RQWDOUXQ
7KH VKRUW VQRUNOH FDQ EH XVHG RQ '93&&/31$7 DQG
'93&&1$77KHWDOOVQRUNOHFDQEHXVHGRQ'93&&/3
VENTCAP
9” (229MM) TOSIDEWALL
Figure 6
SPECIAL VENTING NOTES:
DVP20CC NATFDQ EH YHQWHG KRUL]RQWDOO\ZLWKNLW'9.1$7
PD[LPXP
DVP20CC LP  FDQ EH YHQWHG KRUL]RQWDOO\ ZLWK NLW '9./3
PD[LPXP
DVP30CC-CANNOTEHYHQWHGKRUL]RQWDOO\VWUDLJKWRXWWKHEDFN
DVP30CC NATQHHGVDYHUWLFDOULVHRIIRRW
DVP30CC LPQHHGVDYHUWLFDOULVHRIIHHW
Note: $&R$[LDOWR&R/LQHDUDSSOLDQFHFRQQHFWRULVDSSURYHGIRU
LQVWDOODWLRQLQYHUWLFDOYHQWLQJDSSOLFDWLRQV2QHFDQEHSXUFKDVHG
WKURXJKD6LPSVRQ'HDOHUSDUWQXPEHU'9$*&/
Sidewall Venting
7KHPD[LPXPYHUWLFDODQGKRUL]RQWDOGLVWDQFHVDUHIHHWDQG
IHHWUHVSHFWLYHO\9HUWLFDOGLPHQVLRQVDUHEDVHGRQWRSRIVWRYHWR
FHQWHUOLQHRISLSH+RUL]RQWDOGLPHQVLRQVDUHEDVHGRQFHQWHUOLQH
RISLSHWRWHUPLQDWLRQ
CAUTION
7RWDOYHUWLFDOUXQ0867%(FRPSOHWHGEHIRUHVWDUWLQJKRUL]RQWDO
UXQHorizontal chimney run must slope upward (away from
stove) 1/4" per foot and vent termination must be level.
8QGHUQRFLUFXPVWDQFHVVKRXOGFRPEXVWLEOHPDWHULDOVLQFOXGLQJ
VLGLQJEHFORVHUWKDQIURPWKHWRSRIWKHSLSHRUFORVHU
WKDQRQWKHVLGHDQGERWWRP
Cutting the Hole
$IWHUWKHDSSOLDQFHKDVEHHQSRVLWLRQHGLQLWVSHUPDQHQWORFDWLRQ
WKHKROHWKURXJKWKHH[WHULRUZDOORIWKHKRXVHFDQEHFXW7KLVKROH
QHHGVWREHKLJK[ZLGHIRU[SLSHDQG[IRU
[SLSHZLWKLWVFHQWHUOLQHGHWHUPLQHGE\WKHDPRXQWRIYHUWLFDO
DULVHDQGKRUL]RQWDOUXQRIWKHWHUPLQDWLRQ:KHQORFDWLQJWKHKROH
LWPXVWEHQRWHGWKDWWKHERWWRPRIWKHFDSPXVWEHDERYHWKH
JURXQGOHYHODQGWRSRIWKHFDSPXVWEHQROHVVWKDQEHORZD
FRPEXVWLEOHSURMHFWLRQDQGQRFORVHUWKDQWRDQ\ZDOOUXQQLQJ
SDUDOOHOWRYHQWWHUPLQDWLRQ

30794-0-0812Page 12
VENTING STOVE (cont.)
Figure 7a - DVP20CC
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
VENTING MUST
TERMINATEIN
THIS AREA
VERTICAL RISE ABOVEFIREPLACE INFEET
24”
012345678910
11 12 13 14
36
37
38
39
40
HORIZONTAL RUN INFEET
29
30
31
33
32
33
34
35
26
27
28
Figure 7b - DVP30CC
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
VENTING MUST
TERMINATEIN
THIS AREA
VERTICAL RISE ABOVEFIREPLACE INFEET
28”
012345678910
11 12 13 14
36
37
38
39
40
HORIZONTAL RUN INFEET
29
30
31
33
32
33
34
35
26
27
28
LP
NAT

30794-0-0812 Page 13
7HUPLQDWLRQFOHDUDQFHIRUEXLOGLQJVZLWKFRPEXVWLEOHDQGQRQFRPEXVWLEOHH[WHULRUV
Vertical Sidewall Installations
Important!0LQLPXPFOHDUDQFHEHWZHHQYHQWSLSHVDQGFRPEXVWLEOH
PDWHULDOVLVRQHLQFKPPRQERWWRPDQGVLGHVDQGWKUHHLQFKHV
PPRQWRS
Important!:KHQ YHQW WHUPLQDWLRQH[LWVWKURXJK IRXQGDWLRQ OHVV
WKDQEHORZVLGLQJRXWFURSWKHYHQWSLSHPXVWÀXVKXSZLWKWKH
VLGLQJ'9$+&WHUPLQDWLRQFDSPXVWDOVREHXVHG
Information on Various Venting Routes and Components
Important:,WLVDOZD\VEHVWWRORFDWHWKHDSSOLDQFHLQVXFKDZD\
WKDWPLQLPL]HVWKHQXPEHURIRIIVHWVDQGKRUL]RQWDOYHQWOHQJWK
6LQFHLWLVYHU\LPSRUWDQWWKDWWKHYHQWLQJV\VWHPPDLQWDLQLWVEDODQFH
Figure 8
EHWZHHQWKHFRPEXVWLRQDLULQWDNHDQGWKHÀXHJDVH[KDXVWFHUWDLQ
OLPLWDWLRQV DV WR YHQW FRQ¿JXUDWLRQV DSSO\ DQG PXVW EH VWULFWO\
DGKHUHGWR
7KHJUDSKVKRZLQJWKHUHODWLRQVKLSEHWZHHQYHUWLFDODQGKRUL]RQWDO
VLGH ZDOO YHQWLQJ ZLOO KHOS WR GHWHUPLQH WKH YDULRXV YHQW OHQJWKV
DOORZDEOH
7KHKRUL]RQWDOYHQWUXQUHIHUVWRWKHWRWDOOHQJWKRIYHQWSLSHIURP
WKHYHQWHOERZRIWKHDSSOLDQFHWRWKHIDFHRIWKHRXWHUZDOO
TERMINATION CLEARANCES

30794-0-0812Page 14
Figure 9
$  &OHDUDQFHDERYHJUDGHYHUDQGDSRUFKGHFNRUEDOFRQ\
>LQFKHVPPPLQLPXP@
%  &OHDUDQFHWRZLQGRZRUGRRUWKDWPD\EHRSHQHG>LQFKHV
PP PLQLPXP IRU DSSOLDQFHV   %WXK
N:
&  &OHDUDQFHWRSHUPDQHQWO\FORVHGZLQGRZ>PLQLPXPLQFKHV
PP UHFRPPHQGHG WR SUHYHQW FRQGHQVDWLRQ RQ
ZLQGRZ@
'  9HUWLFDOFOHDUDQFHWRYHQWLODWHGVRI¿WORFDWHGDERYHWKHWHUPLQDO
ZLWKLQDKRUL]RQWDOGLVWDQFHRILQFKHVPPIURP
WKHWRSRIWKHWHUPLQDO
(  &OHDUDQFH WR XQYHQWLODWHG VRI¿W > LQFKHV PP
PLQLPXP@
)  &OHDUDQFH WR RXWVLGH FRUQHU > LQFKHV PP
PLQLPXP@
*  &OHDUDQFHWRLQVLGHFRUQHU>LQFKHVPPPLQLPXP@
+  1RWWREHLQVWDOOHGDERYHDPHWHUUHJXODWRUDVVHPEO\ZLWKLQ
 IHHW PP KRUL]RQWDOO\ IURP WKH FHQWHUOLQH RI WKH
UHJXODWRU
,  &OHDUDQFHWRVHUYLFHUHJXODWRUYHQWRXWOHW>IHHWP
PLQLPXP@
-  &OHDUDQFH WR QRQPHFKDQLFDO DLU VXSSO\ LQOHW WR EXLOGLQJ
RU WKH FRPEXVWLRQ DLU LQOHW WR DQ\ RWKHU DSSOLDQFH >
LQFKHVPPPLQLPXPIRUDSSOLDQFHV%WXK
N:
  LQFKHVPPPLQLPXPIRUDSSOLDQFHV!%WXK
N:@
.  &OHDUDQFHWRDPHFKDQLFDODLUVXSSO\LQOHW>IHHWP
PLQLPXP@
/  &OHDUDQFH DERYH SDYHG VLGHZDON RU D SDYHG GULYHZD\
ORFDWHGRQSXEOLFSURSHUW\>IHHWPPLQLPXP@
0  &OHDUDQFHXQGHUYHUDQGDSRUFKGHFNRUEDOFRQ\>LQFKHV
PPPLQLPXP@
  $YHQWVKDOOQRWWHUPLQDWHGLUHFWO\DERYHDVLGHZDONRUSDYHG
GULYHZD\ZKLFKLVORFDWHGEHWZHHQWZRVLQJOHIDPLO\GZHOOLQJV
DQGVHUYHVERWKGZHOOLQJV
  2QO\SHUPLWWHGLIYHUDQGDSRUFKGHFNRUEDOFRQ\LVIXOO\
RSHQRQDPLQLPXPRIVLGHVEHQHDWKWKHÀRRU
  $VVSHFL¿HGLQ&*$%,QVWDOODWLRQV&RGHVRU$16,=
Note: /RFDO &RGHV RU 5HJXODWLRQV PD\ UHTXLUH GLIIHUHQW
FOHDUDQFHV
VENT CLEARANCES

30794-0-0812 Page 15
Installing Vent Components
%HJLQWKHYHQWV\VWHPLQVWDOODWLRQE\LQVWDOOLQJWKH¿UVW6LPSVRQ
'XUDYHQWFRPSRQHQWDVWUDLJKWSLSHRQWKHWRSRIWKHDSSOLDQFHRU
URWDWHWKHYHQWHOERZWRWKHKRUL]RQWDOSRVLWLRQWKHQDGGKRUL]RQWDO
DQGYHUWLFDOSLSHOHQJWKVDQGWKHQDKRUL]RQWDORUYHUWLFDOWHUPLQDWLRQ
NLW(OERZVFDQEHDGGHGZKHUHQHFHVVDU\6HH3DJHVWKURXJK
IRUYHQWLQJUHTXLUHPHQWV
6LPSVRQ 'XUDYHQW YHQW V\VWHP FRPSRQHQWV ORFN LQWR SODFH E\
VOLGLQJWKHFRQFHQWULFSLSHVHFWLRQZLWKIRXUHTXDOO\VSDFHGLQWHULRU
EHDGVRQWRWKHDSSOLDQFHFROODURUSUHYLRXVO\LQVWDOOHGFRPSRQHQW
HQGZLWKIRXUHTXDOO\VSDFHGLQGHQWHGVHFWLRQV:KHQWKHLQWHUQDO
EHDGV RI HDFK VWDUWLQJ LQFK RXWHU SLSH OLQH XS URWDWH SLSH
VHFWLRQFORFNZLVHDSSUR[LPDWHO\LQFKHV7KHYHQWSLSHLV
QRZORFNHGWRJHWKHU
&RQWLQXH DGGLQJ FRPSRQHQWV SHU WKH SUHSODQQHG YHQW V\VWHP
FRQ¿JXUDWLRQ %H FHUWDLQ WKDW HDFK VXFFHHGLQJ YHQW FRPSRQHQW
LVVHFXUHO\¿WWHGDQGORFNHGLQWRWKHSUHFHGLQJFRPSRQHQWLQWKH
YHQWV\VWHP
Figure 10
Figure 11
VENT SYSTEM IDENTIFICATION
PART NAME "A" "B" "C"
3,3( PP PP PP
3,3( PP PP PP
3,3( PP PP PP
3,3( PP PP PP
3,3( PP PP PP
3,3( P PP P
(/%2: PP PP ---
(/%2: PP PP PP

30794-0-0812Page 16
Installing Support Brackets
$KRUL]RQWDOSLSHVXSSRUW0867%(XVHGIRUHDFKIHHWRIKRUL]RQWDO
UXQ7KHSLSHVXSSRUWVVKRXOGEHSODFHGDURXQGLQFKGLDPHWHU
SLSHDQGQDLOHGLQSODFHWRIUDPLQJPHPEHUV7KHUH0867%(D
LQFKFOHDUDQFHWRFRPEXVWLEOHVDERYHLQFKGLDPHWHUSLSHDQG
HOERZVDQGLQFKFOHDUDQFHRQERWKVLGHVDQGERWWRPRILQFK
WRFRPEXVWLEOHVRQDOOKRUL]RQWDOSLSHVHFWLRQVDQGHOERZV
9HUWLFDOUXQVRIWKLVYHQWV\VWHPVPXVWEHVXSSRUWHGHYHU\IHHW
DERYHWKHDSSOLDQFH ÀXH RXWOHWE\ZDOOEUDFNHWV DWWDFKHG WR WKH
LQFKYHQWSLSHDQGVHFXUHGZLWKQDLOVRUVFUHZVWRVWUXFWXUDO
IUDPLQJPHPEHUV
48”
(1219mm)
PIPESTRAP
MINIMUM 1” (25.4mm)
CLEARANCE TOCOMBUSTIBLE
CONSTRUCTION WITH
DOUBLE WALL VENT PIPE
STUD WALL
Figure 12
Installing Firestops
)LUHVWRSVDUHUHTXLUHGIRUVDIHW\ZKHQHYHUWKHYHQWV\VWHPSDVVHV
WKURXJKDQLQWHULRUZDOODQH[WHULRUZDOORUDFHLOLQJ7KHVH¿UHVWRSV
DFWDVD¿UHEUHDNKHDWVKLHOGDQGDVDPHDQVWRLQVXUHWKDWPLQLPXP
FOHDUDQFHVDUHPDLQWDLQHGWRWKHYHQWV\VWHP
+RUL]RQWDOUXQVLQWKHYHQWV\VWHPZKLFKSDVVWKURXJKHLWKHULQWHULRU
RUH[WHULRUZDOOVUHTXLUHWKHXVHRIZDOO¿UHVWRSVRQERWKVLGHVRI
WKHZDOOWKURXJKZKLFKWKHYHQWSDVVHV
3RVLWLRQWKH¿UHVWRSVRQERWKVLGHVRIWKHLQFK[LQFKKROHIRU
[SLSHDQG[KROHIRU[SLSHSUHYLRXVO\FXW
6HFXUH ZLWK QDLOV RU VFUHZV &RQWLQXH WKH YHQW UXQ WKURXJK WKH
¿UHVWRSV6HH)LJXUH
Figure 13
9HUWLFDOUXQVRIWKLVV\VWHPZKLFKSDVVWKURXJKFHLOLQJVUHTXLUHWKH
XVHRIRQHFHLOLQJ¿UHVWRSDWWKHKROHLQHDFKFHLOLQJWKURXJKZKLFK
WKHYHQWSDVVHV
3RVLWLRQDSOXPEEREGLUHFWO\RYHUWKHFHQWHURIWKHYHUWLFDOYHQW
FRPSRQHQWDQGPDUNWKHFHLOLQJWRHVWDEOLVKWKHFHQWHUSRLQWRIWKH
YHQW'ULOODKROHRUGULYHDQDLOWKURXJKWKLVFHQWHUSRLQWDQGFKHFN
WKH ÀRRU DERYH IRU DQ\ REVWUXFWLRQV VXFK DV ZLULQJ RU SOXPELQJ
UXQV5HSRVLWLRQWKHDSSOLDQFHDQGYHQWV\VWHPLIQHFHVVDU\WR
DFFRPPRGDWHFHLOLQJMRLVWVDQGRUREVWUXFWLRQV
&XWDLQFK[LQFKKROHWKURXJKWKHFHLOLQJXVLQJWKHFHQWHUSRLQW
SUHYLRXVO\PDUNHG)UDPHWKHKROHZLWKIUDPLQJOXPEHUWKHVDPH
VL]HDVWKHFHLOLQJMRLVWV6HH)LJXUH,IWKHDUHDDERYHWKHFHLOLQJ
LV127DQDWWLFSRVLWLRQDQGVHFXUHWKHFHLOLQJ¿UHVWRS'9$)6
RQWKHFHLOLQJVLGHRIWKHSUHYLRXVO\FXWDQGIUDPHGKROH6HH)LJXUH
,IWKHDUHDDERYHWKHFHLOLQJ,6DQDWWLFSRVLWLRQDQGVHFXUH
WKH¿UHVWRSRQWRSRIWKHSUHYLRXVO\IUDPHGKROH6HH)LJXUH
Note: 5HPRYHLQVXODWLRQIURPWKHIUDPHGDUHDLQWKHDWWLFEHIRUH
LQVWDOOLQJWKH¿UHVWRSDQGRUYHQWVWRSDQGRUYHQWSLSHV
Figure 14
FRAMING AND FINISHING

30794-0-0812 Page 17
Figure 15 Figure 16
$WWDFKDQGVHFXUHWKHWHUPLQDWLRQWRWKHODVWVHFWLRQRIKRUL]RQWDO
YHQWLQJE\VOLGLQJFDSRYHUWKHODVWVHFWLRQRIKRUL]RQWDOYHQWLQJWR
HQVXUHSURSHUORFDWLRQ
Note: 7HUPLQDWLRQFDSVKRXOGSDVVWKURXJKWKHZDOO¿UHVWRSIURP
WKHH[WHULRURIWKHEXLOGLQJ$GMXVWWKHWHUPLQDWLRQFDSWR
LWV¿QDOH[WHULRUSRVLWLRQRQWKHEXLOGLQJ
WARNING
Termination cap must be positioned so that the arrow is
pointing up.
8VLQJWKHWHUPLQDWLRQFDSLQWKHFHQWHURIWKHVTXDUHKROHDWWDFK
WKH WHUPLQDWLRQ FDS ZLWK WKH IRXU ZRRG VFUHZV SURYLGHG %HIRUH
DWWDFKPHQWRIWKHWHUPLQDWLRQUXQDEHDGRIVLOLFRQHVHDODQWUDWHG
DERYH)RQLWVRXWVLGHHGJHWRRVRDVWRPDNHDVHDOWRWKDW
H[WHULRUZDOO
NOTE:  :RRGVFUHZVFDQDQGVKRXOGEHUHSODFHGZLWKDSSURSULDWH
IDVWHQHUVIRUXVHRQVWXFFREULFNFRQFUHWHRURWKHUW\SHV
RIVLGLQJ
CAUTION
,IH[WHULRUZDOOVDUH¿QLVKHGZLWKVLGLQJYLQ\ODOXPLQXPHWF
it is necessary to install the vinyl siding shield (46DVA-VSS).
9LQ\OVLGLQJVKLHOG'9$966ZLOOEHLQVWDOOHGEHWZHHQWKHYHQW
WHUPLQDWLRQDQGWKHH[WHULRUZDOO6HH)LJXUH7KLVKRUL]RQWDO
YHQWWHUPLQDWLRQEROWVRQWRWKHÀDWSRUWLRQRIWKHYLQ\OVLGLQJVWDQGRII
VRDQDLUVSDFHZLOOH[LVWEHWZHHQWKHZDOODQGWKHWHUPLQDWLRQFDS Figure 17
HORIZONTAL TERMINATION
FRAMING AND FINISHING (continued)

30794-0-0812Page 18
Vertical Terminations
/RFDWHDQGPDUNWKHFHQWHUSRLQWRIWKHYHQWLQJSLSH8VLQJDQDLO
RQWKHXQGHUVLGHRIWKHURRIDQGGULYHWKLVQDLOWKURXJKWKLVFHQWHU
SRLQW0DNHWKHRXWOLQHRIWKHURRIKROHDURXQGWKLVFHQWHUSRLQW
Note: 6L]HRIWKHURRIKROHGLPHQVLRQVGHSHQGRQWKHSLWFKRI
WKHURRI7KHUHPXVWEHDLQFKFOHDUDQFHPPWRWKHYHUWLFDO
SLSHVHFWLRQV7KLVFOHDUDQFHLVWRDOOFRPEXVWLEOHPDWHULDO
&RYHUWKHRSHQLQJRIWKHYHQWSLSHDQGFXWDQGIUDPHWKHURRIKROH
8VHIUDPLQJOXPEHUWKHVDPHVL]HDVWKHURRIUDIWHUVDQGLQVWDOOWKH
IUDPHVHFXUHO\)ODVKLQJDQFKRUHGWRIUDPHPXVWZLWKVWDQGKLJK
ZLQGV7KHVWRUPFROODULVSODFHGRYHUWKLVMRLQWWRPDNHDZDWHUWLJKW
VHDO1RQKDUGHQLQJVHDODQWVKRXOGEHXVHGWRFRPSOHWHO\VHDOWKLV
ÀDVKLQJLQVWDOODWLRQ
Determining Minimum Vent Height Above the Roof.
WARNING
Major U.S. building codes specify minimum chimney and/or
vent height above the roof top. These minimum heights are
QHFHVVDU\LQWKHLQWHUHVWRIVDIHW\7KHVHVSHFL¿FDWLRQVDUH
summarized in Figure 18.
LOWEST DISCHARGE OPENING LISTED CAP
LISTED GAS VENT
H (MINIMUM)
MINIMUM HEIGHT FROM
ROOF TO LOWEST
DISCHARGE OPENING
12
X
ROOF PITCH IS X/12
ROOF PITCH H (MINIMUM
FEET METER
)/$772 1.0 0.30
72 1.25 0.36
29(572 1.5 0.46
29(572 2.0 0.61
29(572 2.5 0.76
29(572 3.25 0.99
29(572 4.0 1.22
29(572 5.0 1.52
29(572 6.0 1.83
29(572 7.0 2.13
29(572 7.5 2.27
29(572 8.0 2.44
Figure 18
Figure 19
1RWHWKDWIRUVWHHSURRISLWFKHVWKHYHQWKHLJKWPXVWEHLQFUHDVHG
,QKLJKZLQGFRQGLWLRQVQHDUE\ WUHHV DGMRLQLQJ URRI OLQHVVWHHS
SLWFKHGURRIVDQGRWKHUVLPLODUIDFWRUVFDQUHVXOWLQSRRUGUDIWRU
GRZQGUDIWLQJ,QWKHVHFDVHVLQFUHDVLQJWKHYHQWKHLJKWPD\VROYH
WKLVSUREOHP
:KHQWHUPLQDWLQJWKHYHQWFDSQHDUDQH[WHULRUZDOORURYHUKDQJ
PDLQWDLQPLQLPXPFOHDUDQFHVDVVKRZQLQFigure 19.
General Maintenance
&RQGXFW DQ LQVSHFWLRQ RI WKH YHQWLQJ V\VWHP VHPLDQQXDOO\
5HFRPPHQGHGDUHDVWRLQVSHFWDUHDVIROORZV
 &KHFN DUHDV RI WKH YHQWLQJ V\VWHP ZKLFK DUH H[SRVHG WR
WKH HOHPHQWV IRU FRUURVLRQ 7KHVH ZLOO DSSHDU DV UXVW VSRWV
RUVWUHDNVDQGLQH[WUHPHFDVHVKROHV7KHVHFRPSRQHQWV
VKRXOGLPPHGLDWHO\EHUHSODFHG
 5HPRYHWKHFDSDQGVKLQHDÀDVKOLJKWGRZQWKHYHQW5HPRYH
DQ\ELUGQHVWVRURWKHUIRUHLJQPDWHULDO
 &KHFNIRUHYLGHQFHRIH[FHVVLYHFRQGHQVDWHVXFKDVZDWHU
GURSOHWVIRUPLQJLQWKHLQQHUOLQHUDQGVXEVHTXHQWO\GULSSLQJ
RXWDWMRLQWV&RQWLQXHFRQGHQVDWHFDQFDXVHFRUURVLRQRIFDSV
SLSHDQG¿WWLQJV,WPD\EHFDXVHGE\KDYLQJH[FHVVLYHODWHUDO
UXQVWRRPDQ\HOERZVDQGH[WHULRUSRUWLRQVRIWKHV\VWHPEHLQJ
H[SRVHGWRFROGZHDWKHU
 ,QVSHFWMRLQWVWRYHULI\WKDWQRSLSHVHFWLRQVRU¿WWLQJVKDYHEHHQ
GLVWXUEHGDQGFRQVHTXHQWO\ORRVHQHG$OVRFKHFNPHFKDQLFDO
VXSSRUWVVXFKDVZDOOVWUDSVRUSOXPEHUVWDSHIRUULJLGLW\
9HQWLQJWHUPLQDOVKDOOQRWEHUHFHVVHGLQWRDZDOORUVLGLQJ
$UHPRYDEOHSDQHORURWKHUPHDQVPXVWEHSURYLGHGLQWKHHQFORVXUH
IRUYLVXDOLQVSHFWLRQRIWKHÀXHFRQQHFWLRQ
Installing the Vent System in a Chase
$ FKDVH LV D YHUWLFDO ER[ OLNH VWUXFWXUH EXLOW WR HQFORVH WKH JDV
DSSOLDQFHDQGRULWVYHQWV\VWHP9HUWLFDOYHQWUXQVRQWKHRXWVLGHRI
DEXLOGLQJPD\EHEXWDUHQRWUHTXLUHGWREHLQVWDOOHGLQVLGHDFKDVH
Figure 20
CAUTION
7UHDWPHQWRI¿UHVWRSVSDFHUVDQGFRQVWUXFWLRQRIWKHFKDVH
may vary with the type of building. These instructions are
not substitutes for the requirements of local building codes.
Therefore, your local building codes must be checked to
determine the requirements for these steps.
VERTICAL TERMINATION

30794-0-0812 Page 19
Installing Support Brackets
$KRUL]RQWDOSLSHVXSSRUW0867%(XVHGIRUHDFKIHHWRIKRUL]RQWDO
UXQ7KHSLSHVXSSRUWVVKRXOGEHSODFHGDURXQGLQFKGLDPHWHU
SLSHDQGQDLOHGLQSODFHWRIUDPLQJPHPEHUV7KHUH0867%(D
LQFKFOHDUDQFHWRFRPEXVWLEOHVDERYHLQFKGLDPHWHUSLSHDQG
HOERZVDQGLQFKFOHDUDQFHRQERWKVLGHVDQGERWWRPRILQFK
WRFRPEXVWLEOHVRQDOOKRUL]RQWDOSLSHVHFWLRQVDQGHOERZV
9HUWLFDOUXQVRIWKLVYHQWV\VWHPVPXVWEHVXSSRUWHGHYHU\IHHW
DERYHWKH DSSOLDQFHÀXH RXWOHW E\ZDOO EUDFNHWVDWWDFKHG WR WKH
LQFKYHQWSLSHDQGVHFXUHGZLWKQDLOVRUVFUHZVWRVWUXFWXUDO
IUDPLQJPHPEHUV
27’4”
(8.33 M)
MAXIMUM
LISTED CAP
LISTED GAS VENT
STORMCOLLAR
ROOF FLASHING
CEILING FIRESTOP
CEILING JOIST
Note::KHQLQVWDOOLQJWKLVYHQWV\VWHPLQDFKDVHLWLVDOZD\VJRRG
EXLOGLQJSUDFWLFHWRLQVXODWH WKH FKDVH DV\RXZRXOGWKHRXWVLGH
ZDOOVRI \RXU KRPH7KLVLVHVSHFLDOO\ LPSRUWDQWIRUFROG FOLPDWH
LQVWDOODWLRQV 8SRQ FRPSOHWLRQ RI EXLOGLQJ \RXU FKDVH IUDPLQJ
LQVWDOOWKHYHQWV\VWHPE\IROORZLQJWKHLQVWUXFWLRQVLQWKLVPDQXDO
5HPHPEHU WR EXLOG WKH FKDVH ODUJH HQRXJK VR WKDW PLQLPXP
FOHDUDQFHRIFRPEXVWLEOHPDWHULDOVLQFOXGLQJLQVXODWLRQWRWKHYHQW
V\VWHPDUHPDLQWDLQHG
Vertical Through the Roof Applications
<RXU*DV6WRYHKDVEHHQDSSURYHGIRU
D 9HUWLFDOLQVWDOODWLRQVXSWRIHHWRIYHQWUXQ
E 7ZR VHWV RI GHJUHH HOERZ RIIVHWV ZLWKLQ WKHVH YHUWLFDO
LQVWDOODWLRQV)URPWRDPD[LPXPRIIHHWDYHQWSLSHFDQEH
XVHGEHWZHHQHOERZV
F :DOOVWUDSVPXVWEHXVHGWRVXSSRUWRIIVHWSLSHHYHU\IHHW
7KLVDSSOLFDWLRQVZLOOUHTXLUHWKDW\RX¿UVWGHWHUPLQHWKHURRISLWFK
DQGXVHWKHDSSURSULDWHYHQWLQJFRPSRQHQWV
Reassembly and Resealing Vent-Air Intake System
$WWDFKYHQWSLSHWRDSSOLDQFHDLUGURSZLWKIRXUKH[KHDGVFUHZV
LQSRVLWLRQUHSODFHYHUWLFDODQGKRUL]RQWDOSLSHOHQJWKVHOERZVDQG
KRUL]RQWDORUYHUWLFDOWHUPLQDWLRQNLW
$OOYHQWV\VWHPFRPSRQHQWVORFNLQWRSODFHE\VOLGLQJWKHFRQFHQWULF
SLSH VHFWLRQ ZLWK IRXU  HTXDOO\ VSDFHG LQWHULRU EHDGV RQWR WKH
DSSOLDQFHFROODU RUSUHYLRXVO\ LQVWDOOHGFRPSRQHQW HQG ZLWKIRXU
HTXDOO\VSDFHGLQGHQWHGVHFWLRQV:KHQWKHLQWHUQDOEHDGVRIHDFK
VWDUWLQJLQFKRXWHUSLSHOLQHXSURWDWHSLSHVHFWLRQFORFNZLVH
DSSUR[LPDWHO\LQFKHV7KHYHQWSLSHLVQRZORFNHGWRJHWKHU
&RQWLQXHUHSODFLQJFRPSRQHQWVSHUWKHYHQWV\VWHPFRQ¿JXUDWLRQ
%HFHUWDLQWKDWHDFKVXFFHHGLQJYHQWFRPSRQHQWLVVHFXUHO\¿WWHG
DQGORFNHGLQWRWKHSUHFHGLQJFRPSRQHQWLQWKHYHQWV\VWHP
Figure 21
VERTICAL TERMINATION (continued)

30794-0-0812Page 20
LOG IDENTIFICATION
Log Photo (Front Views) Description Part Number
DVP20CC DVP30CC
REAR LOG 29790 29795
RIGHT LOG 29792 29797
LEFT LOG
'93&&VKRZQ 29791 29796
TOP BRANCH 29793 1$
TOP BRANCH 1$ 29798