Evo AGA Professional Series Instruction Manual

R
For Outdoor Use Only.
Do Not Use Indoors.
Wheeled Cart Model
Tabletop Model
by
10/2020 EINS 517893
LPRT 517892
AGA Professional Series Outdoor Gas Grills
For use in GB and IE
PLEASE READ THESE INSTRUCTIONS BEFORE USING THIS APPLIANCE
AND KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.
User Guide &
Installation Instructions
CAUTION: THIS UNIT IS HEAVY, PROPER EQUIPMENT AND ADEQUATE MANPOWER MUST BE USED IN MOVING THE
RANGE TO AVOID DAMAGE TO THE UNIT OR THE FLOOR.
REMEMBER, when replacing a part on this appliance, use only spare parts that you can be assured conform to the safety and
performance specication that we require.
DO NOT use reconditioned or copy parts that have not been clearly authorised by AGA.

II
Useful Information
It maybe useful to make a note of your AGA appliance Serial Number when it is being installed.
The serial number can be found on the right hand side of the control panel.
My AGA Details:
Model Nos: Professional Series Wheeled-Cart: AGA-10-0082-LP-CE
Professional Series Tabletop: AGA-10-0025-LP-CE
Serial No:
AGA Service No:
AGA Dealer or store
contact No:
Date of Installation:

III
1. General Warnings 1
2. Outdoor use advice 2
3. Safety Precautions 3
4. Grill Overview 4
5. Cook surface pre-seasoning 7
6. How to light your grill 9
7. Cooking Techniques 11
8. Cooking Techniques
Using the lid 13
9. Cooking Chart 14
10. Cleaning and Caring 16
11. Installation and Technical 17
12. Product Dimensions 18
13. Technical Information 20
14. Connection of LPG tank
to the grill 21
15. Fitting of cooking plate 22
16. Assembly / Disassembly 23
Contents

1
Grill is for outdoor use only. Grill should be operated in a well-ventilated space.
Never operate in an enclosed space, garage or building. Your grill is not intended to
be installed in or on recreational vehicles and/or boats.
Do not install or use grill within 36” (91.5 cm) of combustible materials from back
and sides of grill. Grill shall not be located under unprotected overhead (enclosed
carport, garage, porch, patio) made of combustible construction.
This symbol identies the most important safety
messaging in this manual. When you see this symbol,
be alert to the possibility of serious bodily injury if
the instructions are not followed. Be sure to read and
carefully follow all of the messages.
FOR YOUR SAFETY
If You Smell Gas:
1. Shut o gas to appliance.
2. Extinguish any open ame.
3. Remove grill cooking surface.
4. If odour continues, immediately call your gas
supplier or your re department.
FOR YOUR SAFETY
1. Do not store or use gasoline or other
ammable vapours and liquids in the vicinity
of this or any other appliance.
2. An LP Tank not connected for use shall not
be stored in the vicinity of this or any other
appliance.
It is the responsibility of the assembler/owner to
assemble, install and maintain gas grill. Do not
let children operate or play near your grill. Failure
to follow these instructions could result in serious
personal injury and/or property damage.
nWARNING
nWARNING
nWARNING
Some parts may contain sharp edges
as especially noted in this manual.
Wear protective gloves as necessary.
1. General Warnings

2
2. Outdoor use advice
Figure 1 - Enclosure with walls on all sides but
no overhead cover.
Figure 2 - Partial Enclosure with overhead cover and
no more than two walls.
Figure 3 - Partial Enclosure with overhead cover and
no more than two walls.
This appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas,
where gas leakage and products of combustion are rapidly dispersed by wind and natural convection.
Any enclosure in which the appliance is used shall comply with one of the following:
• An enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover. See
Figure 1.
• Within a partial enclosure that includes and overhead cover and no more than two walls. See Figure 2 & 3.
• Within a partial enclosure that includes an overhead cover and more than two, the following shall apply:
-At least 25% of the total wall area is completely open; and
-At least 30% of the remaining wall area is open and unrestricted. See Figure 4 & 5.
• In the case of balconies, at least 20% of the total side, back and front areas shall be and remain open and unrestricted.
The following diagrams provide a diagrammatic representation of outdoor areas. Rectangular areas have been used in these
gures - the same principles apply to any other shaped area.
Figure 4 - Open side at least 25% of total wall area.
30% or more in total of the remaining wall area is
open and unrestricted

3
3. Safety Precautions
• Installation of grill must conform with local codes.
• Do not install or use grill within 36” (92 cm) of
combustible materials from back and sides of grill.
Grill shall not be located under unprotected overhead
(enclosed carport, garage, porch, patio) made of
combustible construction.
• Grill must not have any obstructions in the venturi-
orifice air inlet area.
• Visually inspect hose before each use of grill. If there is
excessive abrasion or wear, or if the hose is cut, it must
be replaced prior to grill operation.
• Only use valve/hose/regulator that was supplied by Aga
with the purchase of your grill.
• Follow lighting and control instructions as described in
the Use & Care section of this manual.
• VERY IMPORTANT: Never attempt to place any
other cooking utensils (skillets, pots, pans) directly
on the burners. Only the Evo cooking grill surface is
to be placed over the burners. Only use grill with the
supplied grill cooking surface. Buildup of non-ignited
gas under other utensils is very dangerous.
• Grill cooking area should be kept clear and free
from combustible materials, gasoline and other
flammable vapours and liquids. Do not obstruct flow
of combustion and ventilation air. Keep ventilation
openings of LP gas tank enclosure free and clear from
debris. Visually check burner flames on regular basis.
• Grill is for outdoor use only. Grill should be operated
in a well-ventilated space. Never operate in enclosed
space, garage or building. Your grill is not intended to
be installed in or on recreational vehicles and/or boats.
• Valve/hose/regulator supplied with grill must be used.
Replacement valve/hose/regulator must be those
supplied by Aga.
• Carefully follow instructions in assembly manual for
attaching regulator to LP tank.
• Purging: Do not release liquid propane (LP) fuel
into atmosphere. This is a dangerous practice. If it is
necessary to remove fuel from LP gas tank, please call
local fire department for assistance.
Carefully follow instruction in assembly manual and
this booklet for proper assembly and gas leak testing of
your grill. Do not use grill until leak checked. If leak is
detected at anytime, it must be stopped and corrected
before using grill further.
Do not attempt to put other cooking utensils (skillets,
pots, pans) directly on the burners.
When grill is not in use, turn o both control knobs and
turn tank o.
nWARNING
nWARNING

4
1. Control panel with inner and outer burner control
knobs and electronic ignition. Right side of panel
contains serial number, certication number and
safety instructions. Left-side of panel contains lighting
and safety instructions.
2. Inner burner control knob for controlled temperature
across the center portion of grill cooking surface.
Inner burner controls cooking area to an 14”(35.5 cm)
radius from center.
3. Outer burner control knob for controlled temperature
across the outer portion of cooking surface. Outer
burner controls cooking area 19”(48 cm) radius from
center to outer edge.
4. Three triangular ame viewing portals located in the
burner skirt and above each leg position.
5. Serial number and safety information sticker.
6. Solid rubber wheels mounted on stainless steel axle
and nylon bearings provide durable transport for
your grill.
7. Grill surface is solid plate steel 3/16”(4.75mm) thick,
30” (762mm) in diameter.
8. Handles for removing your grill surface for burner
inspection, transportation, or long-term storage.
9. Drip pan constructed of easy to clean stainless steel
for containing food particles.
10. Burner lighting and ignition instruction sticker
located on left side of control panel.
3
2
1
8
9
9
4
10
6
7
5
4. Grill Overview
Front of Grill

5
11
13 12
11. Hood constructed of easy to clean stainless steel for
converting your grill into a patio oven, for roasting,
smoking, steaming or warming. The hood also protects
your cooking surface when not in use.
12. Vent for exhausting steam or vapors.
13. Handle for moving your hood onto the cooking surface,
and for moving your hood to the resting position.
14. Hood Hook support for resting hood on backside of
drip pan.
14
Top of Grill

6
19
17
15
16
18
21
20
15. Rear handle for lifting and pushing your grill into
position.
16. Stainless steel waste tray mounted to slide rails under
drip pan provides overow waste removal from drip
pan and convenient clean out.
17. Grill shown with hood resting from drip pan. When
hood is not in use, it is recommended to support
it from drip pan at the rear location. For complete
access to cook surface, remove hood from grill and
store separately.
18. Rear leg rubber foot provides support for positioning
grill on deck or patio surfaces.
19. Electronic ignition is battery operated. The ignitor
uses one AA type battery (installed in ignitor).
20. Burner lighting and ignition instruction sticker
located on left side of control panel.
21. Removable leg support on right side to access LP
tank for relling. No tools are required to remove leg
support. To remove, slide upward and push outward
over fasteners.
Back of Grill
Replacement of right leg support is necessary after
installing LP tank to provide structural stability to the
grill.
nWARNING

7
5. Cook surface pre-seasoning
Your Evo cooktop is preseasoned and ready to use, we
recommend you review this important information before
cooking your rst meal.
The Evo cooktop is one seamless piece of spun metal with
unique characteristics which may be visible until the patina
of the black-oil seasoning builds.
Your Evo grill is manufactured from a durable steel alloy. We
start the seasoning process before shipping but it takes at
least six to ten cooking and oiling (after cleaning) sessions to
create a hardwearing non stick base.
You may notice the seasoning has rubbed against the
packaging during transit. Simply oil the cooktop with a high
smoke point oil* before cooking to even out the seasoning.
*Oils that have high smoke points (200°C and higher) include avocado
oil, corn oil, canola oil, grapeseed oil, peanut oil, saower oil, sesame oil,
sunower oil and vegetable oil, rapeseed oil.
Cooking Unparalleled heat retention
and even heat distribution.
Seasoning
Pre-seasoned before
shipping, maintained by
applying cooking oil after
cleaning.
Cleaning Scrub cooktop with grill pad
and cooking oil to clean.
Oxidation Maintain seasoning to
prevent oxidation.
Marine Air
May corrode in salt air, must
maintain seasoning for
protection.
Durability
Can be easily reconditioned
even if not maintained
properly.
Healthy Little oil required.
IMPORTANT INFORMATION
Please read this rst.
The cook surface when properly maintained will provide
a lifetime of continual service. To give this cook surface its
non-stick properties, it must be routinely oiled to maintain its
seasoning. Very much like cast iron pan cooking, a seasoned
Evo cook surface is a traditional and healthy alternative to
plastic non-stick coated pans. Regular cleaning and care
for your Evo cook surface will keep your grill looking and
functioning its best.
The Evo Cook Surface is Pre-Seasoned and Ready For Use
• Similar to a cast iron pan, NEVER cook on a dry surface
ALWAYS apply a suitable cooking oil to the cook
surface prior to EVERY cooking session (Use corn oil,
vegetable or other high smoke point oil).
• ALWAYS properly clean the cook surface after every use
while the surface is still moderately hot. This will clean
and re-season the surface in preparation for the next
time you cook.
• NEVER use water, salt, soap or grill bricks to clean the
surface. ALWAYS use the supplied Evo Cleaning Kit,
including the grill pads and screens.