EXPERT GRILL BG2824BP User manual

1
VendorStockNO.:XG1609603400
ModelNO.:BG2824BP
CallCustomerServiceHotline
WARNING
ForOutdoorUseOnly(outsideanyenclosure)
WARNING
1.Improperinstallation,adjustment,alteration,
serviceormaintenancecancauseinjuryorproperty
damage.
2.Readthisinstructionmanualthoroughlybefore
installingorservicingthisequipment.
3.Failuretofollowtheseinstructionscouldresultin
fireorexplosion,whichcouldcauseproperty
damage,personalinjuryordeath.
4.Thisinstructionmanualcontainsimportant
informationnecessaryforproperassemblyandsafe
usethisappliance.
WARNING
1.Donotstoreorusegasolineorotherflammable
vaporsandliquidsinthevicinityofthisorany
otherappliance.
2.AnLPtanknotconnectedforuseshouldnotbe
storedinthevicinityofthisoranyother
appliance.
DANGER
Ifyousmellgas:
1.Shutoffgastotheappliance.
2.Extinguishanyopenflames.
3.Openthelid.
4.Iftheodorcontinues,keepawayfromthe
applianceandimmediatelycallyourgassupplier
orfiredepartment.
DANGER
Neveroperatethisapplianceunattended.
Savetheseinstructionsforfuturereference.
Ifyouareassemblingthisunitforsomeoneelse,
givethismanualtohimorhertoreadsavefor
futurereference.
DONOTRETURNYOURGRILLTOTHESTORE
Question,Problems,Missingparts?Beforerunningtoyourretailer,callourcustomerservicedepartmentat
1‐855‐CHANT‐US(1‐855‐242‐6887)from8:00amto5:00pmEasterntime,MondaythroughFriday.
OUTDOOR4BURNERGASGRILL
1‐855‐242‐6887

2
AlwaysreadandunderstandtheWARNINGSandINSTRUCTIONSthatarecontainedinthismanual
beforeattemptingtousethisgasbarbecuegrilltopreventpossiblebodilyinjuryorpropertydamage.
Alwayskeepthismanualforconvenientfuturereference.
Distributedby:
Wal‐MartStores,Inc.,
Bentonville, AR 72716
Manufacturer:
GuangdongChantGroupInc.
No.42XiaolanIndustrialRoadSouthZhongshan,Guangdong528415,China
Pleasecall1‐855‐CHANT‐US(1‐855‐242‐6887)foranyassistance
WARNING
1.Donotstoreorusegasolineorother
flammableliquidsorvaporsinthevicinityof
thisoranyotherappliance.

2.AnLPcylindernotconnectedforuseshould
notbestoredinthevicinityofthisoranyother
appliance.
DANGER

Ifyousmellgas:
1.Shutoffgastotheappliance
2.Extinguishanyopenflame
3.Openlid
4.Ifodorcontinues,keepawayfromthe
applianceandimmediatelycallyourgassupplier
oryourfiredepartment.

3
TABLEOFCONTENTS
Cover…………….…………………………………….………...….………….………….….…………………..……..1
Tableofcontents……………………………………….………...….………….………………………….…….…..3
SafetyInformation…………………………………….………...….………….….………….……………..……..4
ExplodedView……………….……………………………………………….......................……….………....6
Partslist….……………..…..….……...…...................……………....………………............................7
HardwareContents……………………………………………………………….………….……….….….....…..9
AssemblyInstructions……………………..……………….……………………………………………...….….10
OperationInstructions…………………………….……...……………………….…............................18
CareandMaintenance……………………………….………………………………………..………….……...25
Troubleshooting…………………………………………………………………..….…………………..………...27
Warranty………………………………………………………………………………………………………..………..29

4
SAFETYINFORMATION
Pleasereadandunderstandthisentiremanualbeforeattemptingtoassemble,operateorinstallthe
product.Ifyouhaveanyquestionsregardingtheproduct,pleasecallourcustomerserviceat
1‐855‐CHANT‐US(1‐855‐242‐6887)from8:00amto5:00pmEasterntime,MondaythroughFridayfor
assistance.

1.Theinstallationofthisappliancemustconformwithlocalcodesor,intheabsenceoflocalcodes,
witheithertheNationalFuelGasCode,ANSIZ223.1/NFPA54,orNaturalGasand
PropaneInstallationCode,CSA/CGA‐B149.1.
2.Thisgrillisintendedforuseoutdoorsandshouldnotbeusedinabuilding,garageoranyother
enclosedorcoveredarea.
3.Thisoutdoorgrillisnotintendedforinstallationinoronrecreationvehiclesand/orboats.
4.Aminimumclearanceof36inchesfromcombustibleconstructionstothesidesofthegrilland36
inchesfromthebackofthegrilltocombustibleconstructionsmustbemaintained.
Thisoutdoorcookinggasappliancemustnotbeplacedunderoverheadcombustibleconstruction.
5.Inspectthehosesbeforeeachuseforexcessiveabrasionorwear,orcutsthatmayaffectsafe
operationofthegrill.Ifthereisevidenceofexcessiveabrasionorwear,orthehoseiscut,itmustbe
replacedpriortothegrillbeingputintooperation.Thereplacementhoseassemblymustbethose
specifiedbythemanufacturer.
6.Keepyourgrillinanareaclearandfreefromcombustiblematerials,gasolineandotherflammable
vaporsandliquids.
7.Donottouchmetalpartsofgrilluntilithascompletelycooled(about45minutes)toavoidburns,
unlessyouarewearingprotectivegear(potholders,gloves,BBQmittens,etc…).
8.DONOTobstructtheflowofcombustionandventilationairtothisappliance.
9.Keeptheventilationopeningsofthetankenclosurefreeandclearfromdebris.
10.Checkallgasconnectionsforleakswithasoapywatersolutionandbrush.Neveruseanopenflame
tocheckforleaks.
11.Neverusecharcoalinthegrill.
12.Neverusethegrillinwindyareas.
13.Onlya20lb.LP‐gascylinderisallowed.Thecylindermustbe
constructedandmarkedinaccordancewiththeSpecificationsfor
LPGasCylindersoftheU.S.DepartmentofTransportation(D.O.T.)
ortheNationalStandardofCanada,CAN/CSA‐B339,Cylinders,
SpheresandTubesforTransportationofDangerousGoods;and
Commission.A20lb.LP‐Gascylinder’sdimensionsare:
14.Neverusethegrillwithoutthedriptrayinstalledandhung
undertheburnerbox.Withoutthedriptray,hotgreaseanddebriscouldleakdownwardandproduce
afirehazard.
15.Useonlythegaspressureregulatorsuppliedwiththisappliance.Thisregulatorissetforanoutlet
pressureof11.0wc



5
SAFETYINFORMATION
16.Thecylinderusedmustincludeacollartoprotectthecylindervalve.
17.DonotstoreaspareLP‐gascylinderunderornearthisappliance.
18.Neverfillthecylinderbeyond80percentfull.
19.Iftheinformationin“17”and“18”isnotfollowedexactly,afirecausingdeathorseriousinjury
mayoccur.
20.Theoutdoorcookinggasappliancemustbeisolatedfromthegassupplypipingsystembyclosing
itsindividualmanualshutoffvalveduringanypressuretestingofthegassupplysystemattest
pressuresequaltoorlessthan1/2psi(3.5KPa).
21.CALIFORNIAPROPOSITION65WARNING:
(a)Theburningofgascookingfuelgeneratessomebyproductswhichareonthelistofsubstances
knownbytheStateofCaliforniatocausecancer,reproductiveharm,orotherbirthdefects.Toreduce
exposuretothesesubstances,alwaysoperatethisunitaccordingtotheuseandcaremanual,ensuring
youprovidegoodventilationwhencookingwithgas.
(b)Handlingthebrassmaterialonthisproductexposesyoutolead,achemicalknowntotheState
ofCaliforniatocausecancerandbirthdefectsorotherreproductiveharm.Washhandsafterhandling.
(c)Thisproductcontainschemicals,includingleadandleadcompounds,knownbytheStateof
Californiatocausecancer,reproductiveharm,orotherbirthdefects.
(d)Washyourhandsafterusingthisproduct.
IMPORTANT:Weurgeyoutoreadthismanualcarefullyandfollowtherecommendationsenclosed.
Thiswillensureyoureceivethemostenjoyableandtrouble‐freeoperationofyournewgasgrill.We
alsoadviseyouretainthismanualforfuturereference.
WARNING:Yourgrillhasbeendesignedtooperateusingonlythegasspecifiedbythe
manufacturerontheratingplate.Donotattempttooperateyourgrillonothergases.
Failuretofollowthiswarningcouldleadtoafirehazardandbodilyharmandwillvoidyour
warranty.
WARNING:MakecertainyourLP(propane)tankisfilledbyareputablepropanedealer.An
incorrectlyfilledoranoverfilledLPtankcanbedangerous.Theoverfilledconditioncombinedwith
thewarmingoftheLPtank(ahotsummerday,tankleftinthesun,etc.)cancauseLPgastobe
releasedbythepressurereliefvalveonthetanksincethetemperatureincreasecausesthepropane
toexpand.LPgasreleasedfromthetankisflammableandcanbeexplosive.RefertoyourOwner’s
ManualformoreinformationconcerningfillingyourLPtank.

6
EXPLODEDVIEW

7
PARTSLIST
※：NOASSEMBLYREQUIRED
PARTDESCRIPTIONPARTNOQTY
1※LidAssembly2824BP011
2※LidAxis24110172
3LidHandleBezel52011762
4LidHandle52100441
5TemperatureGaugeBezel52081271
6TemperatureGauge24110161
7※LidSpacer21001584
8※FireboxAssembly52100471
9RightSideShelf 52100461
10DripTray52100541
11GreaseCup52100231
12RearBeam52100581
13RightBackLeg52065311
14RightDripTraySupport52100561
15HoseClipHook 23009611
16GasCylinderHook24092121
17Wheel21005302
18RightSideBeam52065321
19RightFrontLeg 52065301
20Axle24092111
21FrontPanel 52100572
22HardwarePack52100591
23LegEndCap24110242
24※MatchHolder24110231
25LeftFrontLeg52100521
26LeftSideBeam52069391
27LeftBackLeg52100521

8
PARTSLIST
※：NOASSEMBLYREQUIRED
PARTDESCRIPTIONPARTNOQTY
28LeftDripTraySupport52100551
29※Regulator&Hoseassembly52100381
30ControlKnob24106254
31※KnobBezel52100494
32※Manifold&GasValveAssembly52100271
33※ControlPanel52100511
34※BottleOpener50148381
35LeftSideShelf52100451
36※ThermalBaffle52100481
37※TubeBurnerIgnitionPin24110194
38※TubeBurner24110184
39※RPin23070014
40※TubeBurnerSupport52043734
41HeatTent 52100504
42CookingGrate24110212
43WarmingRack24110201
44TankBlockingWire24116621

9
HARDWARECONTENTS 
ASSEMBLYPREPARATION
Beforebeginningassemblyofproduct,makesureallpartsarepresent.Comparepartswithpackage
contentslistandhardwarecontentslist.Ifanypartismissingordamaged,donotattempttoassemble
theproduct.
NOTE:Somepartscomewithscrewspre‐installed.Loosenandtightenforfinalassembly.
EstimatedAssemblyTime:1hourbytwopeople

Toolsrequiredforassembly:
*PhillipsHeadScrewdriver1pc(notincluded);
*Wrench1pc(notincluded)
* Plier1pc(notincluded)
AAM6X16mmB
l
ac
k
Screw
BBM10FastenNut
CCM6Was
h
er

10
ASSEMBLYINSTRUCTIONS
IMPORTANT:ASSEMBLEONFLATANDSOFTSURFACETOAVOIDSCRATCHING.
6
X16mm Black Screw X 2
1. PutLeftBackLeg(27)andLeftFrontLeg(25)intoLegEndCaps(23)asshown.
2.AssembleLeftSideCartFrame.
2.1.Loosen6pcspre‐assembledM6X16mmScrewsfrom“X”positionandleavethescrewheads
protrudingapproximately5mm.
2.2.HangLeftSideBeam(26)andLeftDripTraySupport(28)with“L”markingtoLeftFrontLeg
(25)andLeftBackLeg(27),thenfastenthescrewson“X”position.
2.3.Take2pcsAAScrewsfromthehardwarepack,andfastenthescrewson“Y”position.
Note:Besurepart28and26areinstalledcorrectlyaspertheimageshown.
AAM6X16mmBlackScrewX 2

11
ASSEMBLYINSTRUCTIONS
6
X16mm Black Screw X 2
4.ThreadAxle(20)throughtheWheel(17),RightFrontLeg(19),RightBackLeg(13),
thenfastenBBnutasshown.
3.AssembleRightSideCartFrame.
3.1.Loosen6pcspre‐assembledM6X16mmScrewsfrom“X”position,andleavethescrewheads
protrudingapproximately5mm.
3.2.HangRightSideBeam(18)andRightDripTraySupport(14)with“R”markingtoRightFrontLeg
(19)andRightBackLeg(13),thenfastenthescrewson“X”position.
3.3.Take2pcsAAScrewsfromhardwarepack,andfastenthescrewson“Y”position.
Note:Besurepart14and18areinstalledcorrectlyaspertheimageshown.
M10防松螺母 X 1
BB M10 Fasten Nut
AAM6X16mmBlackScrewX2
BBM10FastenNut X1

12
ASSEMBLYINSTRUCTIONS
5.AttachRearBeam
5.1.Loosen4pcspre‐assembledM6X16mmScrewsfromLeftBackLeg(27)andRightBackLeg(13),
leavethescrewheadsprotrudingapproximately5mm.
5.2.HangRearBeam(12)ontoLeft&RightBackLegonthescrewsandhandtightenonlythescrews
onthispoint.
6.Assemblethefrontpanel
6.1.Loosen8pcspre‐assembledM6X16mmScrewsfromLeftFrontLeg(25)andRightFrontLeg(19),
leavethescrewheadsprotrudingapproximately5mm.
6.2.AttachFrontPanels(21)tothecartandfastenthescrewsasshown.Thenfullytightenallthe
screwsofrearbeamthistime.

13
ASSEMBLYINSTRUCTIONS 
6
X16mm Black Screw X 2
7.AttachDripTray(10)andGreaseCup(11)ontothecartasshown.
8.UsetwopeopletoliftandplacetheFireboxAssemblyontothecartandfasten4pcs
AAScrewsasshown.
A
A M6X16 mm Black Screw
AAM6X16mmBlackScrew X4

14
ASSEMBLYINSTRUCTIONS
10.AttachLeftSideShelfontofirebox.
10.1.Attach2pcsAAScrewsintotheuppertwoholesonleftsideoffirebox.Leavethescrewheads
protrudingapproximately5mm.
10.2.HangLeftSideShelfontothescrews,attachanother3pcsAAScrewsintothelowerthreeholes
andfullytightenall5pcsscrewstosecureleftsideshelftothegrill.
10.3.Attach1pcAAScrewand1pcCCM6Washerintotheholeonleftsideoffireboxandfastenthe
screw.
9.AssembleLidHandleandTemperatureGauge
9.1.AttachLidHandle(4)togetherwithLidHandleBezels(3)ontoLidAssemblyandfastenthe
screws.
9.2.AttachTemperatureGauge(6)togetherwithTe m peratureGaugeBezel(5)ontoLidAssembly
andfastenthescrews.
X 6
X 1
A
A M6X16 mm Black
AAM6X16mmBlackScrew
CCM6Washer

15
ASSEMBLYINSTRUCTIONS
11.RepeatStep10forRightSideShelf.
12.InsertHeatTent(41),CookingGrates(42).
X 6
X 1
A
A M6X16 mm Black
AAM6X16mmBlackScrew
CCM6Washer

16
ASSEMBLYINSTRUCTIONS
13.InsertWarmingRack(43)andControlKnobs(30).
14.AttachHoseClipHook
14.1.Loosen1pcpre‐assembledM6X16mmScrewfromRightFrontLegAssembly(19),andthen
attachHoseClipHook(15)andfastenthescrews.
14.2.PullouttheHoseClipHook(15)andsecurethehoseintothehook.

17
ASSEMBLYINSTRUCTIONS
16.Usethepre‐assemblednuttoinstalltheTankBlockingWire(44)asshown.
YourExpertGrillisnowassembled.









15.AttachGasCylinderHook(16)toRightFrontLeg(19)andRightBackLeg(13).
2
1
44
21
12
44

18
OPERATINGINSTRUCTIONS
LIQUIDPROPANEGASTANKINSTALLATION
GasgrillsthataresettooperatewithLiquidPropaneGascomewithahighcapacityhoseandregulatorassembly.
(Note:Onlyusethepressureregulatorandhoseassemblysuppliedwiththegrillorareplacement
pressureregulatorandhoseassemblyspecifiedbythemanufacturer).Thisassemblyisdesignedto
connectdirectlytoastandard20lb.L.P.Tank.L.P.tanksarenotincludedwiththegrill.L.P.tankscanbe
purchasedseparatelyatanindependentdealer.

ConnectingaLiquidPropaneGasTanktotheGrill:
1. Placea20Ib.tankintotheslotonrightsidebeam,thenputdowngascylinderhookontothetank.
SeeFig.1.
MakesurethetankvalveisintheOFFposition.
2.Checkthetankvalvetoensureithasproperexternalmatingthreadstofitthehoseand
regulatorassemblyprovided(Type1connectionperANSIZ21.58b‐2002).
3.Inspectthevalveconnectionportoftheregulatorassembly.Lookfordamageordebris.Remove
anydebris.Inspecthosefordamage.Neverusedamagedorpluggedequipment.
4.MakesureallburnerknobsareintheOFFposition.
5.Connectthehoseandregulatorassemblytothetankvalve（SeeFig.2）Handtightenthequick
couplingnutclockwisetoafullstop.DONOTuseawrenchtotightenbecauseitcoulddamagethe
quickcouplingnutandresultinahazardouscondition.


Fig. 2
Fig. 1
Before
Af
te
r

19
OPERATINGINSTRUCTIONS
6.Openthetankvalvefully(counterclockwise).Useasoapywatersolutiontocheckallconnectionsfor
leaksbeforeattemptingtolightyourgrill.See“LeakageTesting"onpage18.Ifaleakisfound,turnthe
TankValveoffanddonotuseyourgrilluntiltheleakisrepaired.

Gastankmustbeplacedontotheslotonrightsidebeamverticallyandbesurethecylinderhookis
placedcorrectlyontheleftsidecollarofthetank(seeFig.3a).Donotoperatethegrillifthegastank
istiltedorthehookisplacedincorrectly(seeFig.3b)
WARNING:TheTypeIconnectivecoupling(seeFig.4)suppliedwithyourgrillmustnotbe
replacedwithadifferenttypeofgrill/tankconnectionsystem.Removalwillresultinlossofwarranty,
gasleakage,fireandseverebodilyharm.
Fig. 4
Fig. 3a Fig. 3b

20
OPERATINGINSTRUCTIONS
DisconnectingALiquidPropaneGas(LP
Gas)TankFromYourGrill:
1.TurntheburnerknobsandLPgastank
valvetothefullOFFposition.(Turn
clockwisetoclose.)

2.Detachthehoseandregulator
assemblyfromtheLPgastankvalveby
turningthequickcouplingnut
counterclockwise.SeeFig.5.
CAUTION:Whentheapplianceisnotin
use,thegasmustbeturnedoffatthe
supplytank.

L.P.TANKINFORMATION
NeveruseadentedorrustedL.P.tankorcylinderwithadamagedvalve.
L.P.cylindersareequippedwithanO.P.D.(OverfillingPreventionDevice).Thedeviceshutsofftheflow
ofgastoacylinderafter80%capacityisreached.Thislimitsthepotentialforreleaseofgaswhenthe
cylinderisheated,avertingafireorpossibleinjury.
TheL.P.cylindermusthaveashut‐offvalveterminatinginanL.P.gassupplycylinderoutletspecified,
asapplicable,forconnectionNo.510inthestandardforcompressedgascylindervalveoutletandinlet
connectionANSI/CGA‐V‐1.Cylindersmustnotbestoredinabuilding,garage,oranyotherenclosed
area.(TheL.P.cylindermusthaveanoverfillprotectiondeviceandacollartoprotectthecylinder
valve.)
TheL.P.gassupplycylindermustbeconstructedandmarkedinaccordancewiththespecificationsfor
L.P.gascylindersoftheU.S.DepartmentofTransportation(DOT)ortheNationalStandardofCanada,
CAN/CAS‐B339,“Cylinders,SpheresandTubesfortheTransportationofDangerousGoodsand
Commission.”
L.P.TANKUSE
•WhenturningtheL.P.tankon,makesuretoopenthevalveSLOWLYtwo(2)completeturnsto
ensurepropergasflow.Mostgastanksnowcomeequippedwithaleakdetectormechanism
internaltothetank.Whengasisallowedtoescaperapidlyitshutsoffthegassupply.Openingthe
valverapidlymaysimulateagasleak,causingthesafetydevicetoactivate,andrestrictinggasflow
causinglowflames.Openingthevalveslowlywillensurethissafetyfeatureisnotfalselytriggered.
•Whennotinuse,gassupplycylindervalveistobeintheOFFposition.
•Thetanksupplysystemmustbestoreduprighttoallowforvaporwithdrawal.
•Theregulatorandhoseassemblymustbeinspectedbeforeeachuseofthegrill.Ifthereisexcessive
abrasionorwearorifthehoseiscut,itmustbereplacedpriortothegrillbeingusedagain.
Fig. 5