Fiber Tronix FT-HHRX-1000-SC-MINI-V2 User manual

Manual
FT-HHRX-1000-SC-MINI-V2
CATV FTTH Receiver
User Manual

FT-HHRX-1000-SC-MINI-V2 Manual
2
Table of Contents
Preface ....................................................................................................................................... 3
Chapter 1 Overview.................................................................................................................... 3
Chapter 2 Features..................................................................................................................... 3
Chapter 3 Specications..........................................................................................................4-5
Chapter 4 Function Guide .......................................................................................................... 6
Chapter 5 Installation & Adjustment ........................................................................................... 6
5.1 Opening the cover .................................................................................................... 6
5.2 Apparatuses & Tools................................................................................................. 6
5.3 Installation ................................................................................................................ 7
Chapter 6 Cleaning & Maintenance............................................................................................ 8
Chapter 7 Customer Service/Warranty..................................................................................9-10

FT-HHRX-1000-SC-MINI-V2 Manual
3
Chapter 1 Overview
FT-HHRX-1000-SC-MINI-V2 is designed to receive FTTH 1310nm/1550nm analog TV or QAM
RF optical signal from Passive Optical Network (PON). With a built-in low-noise amplier and
AGC circuit, FT-HHRX-1000-SC-MINI-V2 outputs high quality CATV RF for TVs in the
residential premises.
Chapter 2 Features
• Compact plastic ame retarding housing
• High Linearity Photodiode for CATV RF
• 45 - 1000MHz (downstream) RF Output (45 - 1218MHz optional)
• Optical AGC range: -10dBm - 0dBm
• Optional MGC range: 0 - 15dB
• DC Power and optical input LED indicator
• 12V DC power adapter
Preface
This manual is designed for FT-HHRX-1000-SC-MINI-V2 CATV ber optic receiver with detailed
description of product feature, specication and installation. To install this receiver successfully
and use it safely, users must read the manual before installation, and perform the installation
and adjustment according to this manual. Otherwise, some practices may lead to property
damage or personal injury. Please contact North American Cable Equipment
if you have any questions.
Important User Information
• Caution: There are invisible laser beams from Optical output ports, which may
cause permanent injury to skin or eyes.
• UPS power supply and air condition environment are highly recommended for the stable
and long term optical receiver operation.

FT-HHRX-1000-SC-MINI-V2 Manual
4
RF and Optical Characteristics
Item Parameter
Input CATV Optical Wavelength 1260nm - 1650 nm (1550nm - 1560nm only on Request)
Working Optical Power -8dBm - +2dBm (Analog TV RF), -15dBm - +2dBm (DVB-C QAM RF)
Optical AGC Range 10dBm - 0dBm
Optical Connector SC/APC
Optical Return Loss 45 dB
RF Bandwidth 45 - 1000 MHz (1218MHz optional)
RF Connector American F
RF Output Impedance 75Ω
RF Output Level >76dBμV@-8dBm (No MGC)
MGC Range 0~15dB (Optional)
RF Flatness ± 1.0dB (45-1000MHz)
RF Return Loss >14 dB
CNR >46 dBc @ -6dBm (Analog TV RF)
CSO <-63 dBc @77ch NTSC (Analog TV RF)
CTB <-63 dBc @77ch NTSC (Analog TV RF)
MER >34 dB @ -12dBm (BER: <1.0E-9)
Power LED Green when DC power is ON
Optical Input LED Red (<-15dBm) Green (-15dBm - +2dBm)
Environment
Power Supply 12 V 0.5A (UL or CE approved)
Power Consumption <2W (not including power adapter)
Working Temperature 14 - 122ºF (-10 - +50ºC)
Board Dimension (L*W*H) 4.17 x 2.44 x 0.98" (106 x 62 x 25mm)
Weight (without power adapter) 0.44 lbs. (200g)
HDMI Output 1080p/60Hz, 720p/60Hz
Warranty 1 year - Can be extended to 3 years
Chapter 3 Specications

FT-HHRX-1000-SC-MINI-V2 Manual
55
FT-HHRX-1000-SC-MINI-V2 Optical Receiver Test Results in MER
Optical Rx Input Output RF Level MER(dB)
+2dBm 79dBμV 38.8
+1dBm 79dBμV 38.8
+0dBm 78dBμV 38.8
-1dBm 78dBμV 38.8
-2dBm 78dBμV 38.7
-3dBm 78dBμV 38.6
-4dBm 78dBμV 38.6
-5dBm 78dBμV 38.5
-6dBm 78dBμV 38.5
-7dBm 78dBμV 38.5
-8dBm 78dBμV 38.4
-9dBm 78dBμV 38.2
-10dBm 77dBμV 38.1
-11dBm 75dBμV 37.8
-12dBm 73dBμV 37.7
-13dBm 71dBμV 37.5
-14dBm 69dBμV 37.3
-15dBm 67dBμV 37.1
-16dBm 65dBμV 35.9
-17dBm 63dBμV 34.8
-18dBm 62dBμV 33.5
Test condition: 80ch DVB-C, 64QAM, Transmitter OMI 4.0%

FT-HHRX-1000-SC-MINI-V2 Manual
6
Chapter 4 Function Guide
1. Optical Input SC/APC connector
2. Optical connector to ONU (optional)
3. DC power adapter
4. LED for Power Supply
5. LED for Optical Input
6. RF Output port
7. MGC Port (optional)
1
2
3
4
5
6
7
LED Function
PWR Green LED ON when DC power is ON
OPT Green LED ON when optical input power ≥-15dBm
Chapter 5 Installation & Adjustment
5.1 Opening the cover
5.1.1 Inspect the package. If there is any damage, please contact
North American Cable Equipment.
5.1.2 After unpacking, check equipment and accessories according to the packing list.
Any question,please contact North American Cable Equipment.
5.1.3 If you think the equipment has been damaged, please do not power on the
device as it may cause more damage. Please contact North American
Cable Equipment.
5.2 Apparatuses & Tools
• An optical power meter
• A digital multimeter
• A standard ber test jumper (SC/APC)
• Waterless alcohol and nosocomial degrease cotton

FT-HHRX-1000-SC-MINI-V2 Manual
7
5.3 Installation
5.3.1 Receiver easily attaches to the wall using the mounting holes on the
rear of the device.
5.3.2 Check 12V voltage by digital multimeter in accordance with power requirement. .
Then plug in DC power adapter. FT-HHRX-1000-SC-MINI-V2 can be powered by
10-18V DC power adapter. When DC power is ON, the DC power LED shall
be Green.
5.3.3 Check the input power to FT-HHRX-1000-SC-MINI-V2 optical receiver
(higher than -15dBm@1550nm). Make sure that the ber connector to
FT-HHRX-1000-SC-MINI-V2 is SC/APC or the required connector.
The OPT LED will be Green when the input optical power is higher than -15dBm.
5.3.4 Connect FT-HHRX-1000-SC-MINI-V2 with coaxial cable to TV or DVB-C STB.
Two hole distance is
2.83” (72mm.)
Need 2 x M3-20mm screws

FT-HHRX-1000-SC-MINI-V2 Manual
8
Chapter 6 Cleaning & Maintenance
Each ber connector may be polluted by dust or dirt in the operation process, which can result in
increased optical link loss. If optical receive power and output level of the receiver decline, you
should clean and maintain ber active connector. The clean methods are recommended below:
a. Carefully screw o󰀨 ber active connector from the adapter and avoid the ber
active connector with laser to aim at any human body or eye.
b. Using a nosocomial degrease alcohol cotton patch, carefully cleanse the ber, allowing
1-2 minutes for connection to air dry.
c. Ensure connection is properly secured to avoid damage to the ber connector.
d. If optical power is still low after cleaning , it is recommended to clean the other end of the
ber optic cable. If optical power is still low after cleaning both ends, it is recommended to
use an OTDR to ensure there are no faults in the ber run.
Notice:
1. Avoid looking into any active ber optic connection, as damage to the eye may occur.
Unless you are able to see both ends of the ber cable, assume the connection is live2.
Assembly the ber adapter in a proper way with gentle action to prevent the china tube
inside the adapter from breaking up.

FT-HHRX-1000-SC-MINI-V2 Manual
9
Chapter 7 Customer Service
a. In the event that there is a failure with the equipment, please contact
North American Cable Equipment.
b. To avoid further damage, repairs should only be done by qualied individuals
Notice: Any unauthorized removal of the security seal will void the warranty
FIBERTRONIX 1-Year Limited Warranty
FIBERTRONIX. (the “Company”) warrants to the Original Purchaser that the item purchased is
free from defects in workmanship or material under normal use. This warranty starts on the date
of shipment of the hardware to the Original Purchaser.
During the warranty period, the Company agrees to repair or replace, at its sole option, without
charge to Original Purchaser, any defective component. To obtain service, the Original Purchas-
er must return the item to the Company properly packaged for shipping. All defective products
must be returned to the Company within thirty (30) days of failure. Products must be returned
with a description of the failure and Return Merchandise Authorization (RMA) number supplied
by the Company. To receive a RMA number and a return shipping address on where to deliver
the hardware, call 610-429-1821. The shipping, and insurance charges incurred in shipping to
the Company will be paid by Original Purchaser, and all risk for the hardware shall remain with
the Original Purchaser until such time as Company takes receipt of the hardware. Upon re-
ceipt, the Company will promptly repair or replace the defective unit, and then return said unit to
Original Purchaser, shipping prepaid. The Company may use reconditioned or like-new parts or
units, at its sole option, when repairing any hardware. Repaired products shall carry the same
amount of outstanding warranty as from original purchase. Any claim under the warranty must
include dated proof of purchase or invoice. In any event, the Company’s liability for defective
hardware is limited to repairing or replacing the hardware.
This warranty is contingent upon proper use of the hardware by Original Purchaser and does
not cover: if damage is due to Acts of God (including re, ood, earthquake, storm, hurricane or
other natural disaster), accident, unusual physical, electrical, or electromechanical stress, mod-
ications, neglect, misuse, operation with media not approved by the Company, tampering with
or altering of the hardware, riot, war, invasion, act of foreign enemies, hostilities (regardless of
whether war is declared), civil war, rebellion, revolution, insurrection, military or usurped power
or conscation, terrorist activities, nationalization, government sanction, blockage, embargo,
labor dispute, strike, lockout or interruption or failure of electricity, air conditioning, or humidity
control, Internet, network, or telephone service.

FT-HHRX-1000-SC-MINI-V2 Manual
10
The warranties given herein, together with any implied warranties covering the hardware,
including any warranties of merchantability or tness for a particular purpose, are limited in
duration to one year from the date of shipment to the Original Purchaser. Jurisdictions vary with
regard to the enforceability of warranty limitations, and you should check the laws of your local
jurisdiction to nd out whether the above limitation applies to you.
The Company shall not be liable to your for loss of data, loss of prots, lost savings, special,
incidental, consequential, indirect, or other similar damages arising from breach of warranty,
breach of contract, negligence, or other legal action even if the Company or its agent has been
advised of the possibility of such damages, or for any claim brought against your by another
party. Jurisdictions vary with regard to the enforceability of provisions excluding or limiting liabil-
ity for incidental or consequential damages. You should check the laws of your local jurisdiction
to nd out whether the above exclusion applies to you.
This warranty allocates risks of product failure between Original Purchaser and the Company.
The Company’s hardware pricing reects this allocation of risk and the limitations of liability
contained in this warranty. The warranty set forth above is in lieu of all other express warran-
ties, whether oral or written. The agents, employees, distributors, and dealers of the Company
are not authorized to make modication to this warranty, or additional warranties binding on
the Company. Accordingly, additional statements such as dealer advertising or presentations,
whether oral or written, do not constitute warranties by the Company and should not be relied
upon.
This warranty gives you specic legal rights. You may also have other rights which vary from
one jurisdiction to another.