FMI (V)G42 Quick start guide

For more information, visit www.fmiproducts.com
SAVE THIS BOOK
This book is valuable. In addition to instructing you
on how to install and maintain your appliance, it also
contains information that will enable you to obtain re-
placement parts or accessory items when needed. Keep
it with your other important papers.
7KLV¿UHSODFHLVDSSURYHGIRUXVHDVDZRRGEXUQLQJ¿UH-
place or for use with a vented gas log approved to ANS
Z21.60 or Z21.84 standards or for use with a vent-free gas
log heater approved to ANS Z21.11.2 standard.
7KLVZRRGEXUQLQJ¿UHSODFHFRPSOLHVZLWK8/&$18/6
60VWDQGDUGDVD)$&725<%8,/7$33/,$1&(
)25&$1$'$7KHDXWKRULW\KDYLQJMXULVGLFWLRQVXFK
DVWKHPXQLFLSDOEXLOGLQJGHSDUWPHQW¿UHGHSDUWPHQW
etc.) should be contacted before installation to deter-
mine the need to obtain a permit.
,167$//(5/HDYHWKLVPDQXDOZLWKWKHDSSOLDQFH
&21680(55HWDLQWKLVPDQXDOIRUIXWXUHUHIHUHQFH
42" AND 50" WOOD BURNING
MASONRY FIREPLACE
OWNER’S OPERATION AND
INSTALLATION MANUAL
(V)G42/50
6PRRWK)DFHZLWK,QVXODWLRQ
(V)G42R/50R
6PRRWK)DFHZLWK,QVXODWLRQDQG
%RWWRP'RRU5DLO
(V)G42H/50H
6PRRWK)DFHZLWK,QVXODWLRQDQG
+HUULQJERQH5HIUDFWRU\
(V)G42HR/50HR
6PRRWK)DFHZLWK,QVXODWLRQ%RWWRP
'RRU5DLODQG+HUULQJERQH5HIUDFWRU\
PFS
®
USC
,&&(6(65

www.fmiproducts.com 109493-01R2
TABLE OF CONTENTS
Safety Information ............................................... 2
6SHFL¿FDWLRQV ...................................................... 3
)LUHSODFH,QVWDOODWLRQ............................................ 5
9HQWLQJ,QVWDOODWLRQ .............................................. 7
2SWLRQDO*DV/LQH,QVWDOODWLRQ.............................11
*ODVV'RRU,QVWDOODWLRQ ...................................... 12
2SHUDWLRQDQG0DLQWHQDQFH*XLGHOLQHV ............ 13
Technical Service............................................... 14
5HSODFHPHQW3DUWV............................................ 15
$FFHVVRULHV ....................................................... 16
SAFETY
:$51,1*,PSURSHULQVWDO-
ODWLRQ DGMXVWPHQW DOWHUDWLRQ
service or maintenance can
FDXVHLQMXU\SURSHUW\GDPDJHRU
ORVVRIOLIH5HIHUWRWKLVPDQXDO
for assistance or additional in-
IRUPDWLRQ &RQVXOW D TXDOL¿HG
installer or local distributor.
,03257$17&KHFNORFDOFRGHV
EHIRUHLQVWDOOLQJWKLV¿UHSODFH
%HIRUHEHJLQQLQJWKHLQVWDOODWLRQRIWKH¿UHSODFH
UHDGWKHVHLQVWUXFWLRQVWKURXJKFRPSOHWHO\
 7KLV)0,352'8&76//&¿UHSODFHDQGLWV
FRPSRQHQWVDUHVDIHZKHQLQVWDOOHGDFFRUG-
LQJWRWKLVLQVWDOODWLRQPDQXDO8QOHVV\RX
XVH )0, 352'8&76 //& FRPSRQHQWV
ZKLFKKDYHEHHQGHVLJQHGDQGWHVWHGIRU
WKH¿UHSODFHV\VWHP\RXPD\FDXVHD¿UH
hazard.
 7KH )0, 352'8&76 //& ZDUUDQW\ ZLOO
EHYRLGHGE\DQG)0,352'8&76//&
GLVFODLPVDQ\UHVSRQVLELOLW\IRUWKHIROORZLQJ
DFWLRQV
D0RGLILFDWLRQ RI WKH ILUHSODFH FRP-
SRQHQWV GRRUV DLU LQOHW V\VWHP DQG
damper control.
E8VHRIDQ\FRPSRQHQWSDUWQRWPDQXIDF-
WXUHGRUDSSURYHGE\)0,352'8&76
//&LQFRPELQDWLRQZLWKD)0,352'-
8&76//&¿UHSODFHV\VWHP
3URSHULQVWDOODWLRQLVWKHPRVWLPSRUWDQWVWHSLQ
HQVXULQJVDIHDQGFRQWLQXRXVRSHUDWLRQRIWKH
¿UHSODFH&RQVXOWWKHORFDOEXLOGLQJFRGHVDVWR
WKHSDUWLFXODUUHTXLUHPHQWVFRQFHUQHGZLWKWKH
LQVWDOODWLRQRIDOOIDFWRU\EXLOW¿UHSODFHV
:$51,1*'RQRWLQVWDOOD
¿UHSODFHLQVHUWLQWKLV¿UHER[XQ-
less the manufacturer's instruc-
WLRQVZLWKWKHLQVHUWVSHFL¿FDOO\
VWDWH WKLV ¿UHSODFH KDV EHHQ
tested for use with the insert.
7KLV¿UHSODFHLVQRWLQWHQGHGWR
be used as a substitute for a fur-
QDFHWRKHDWDQHQWLUHKRPH8VH
for supplemental heat only.
)25<2856$)(7<
 'RQRWVWRUHRUXVHJDVROLQH
RUDQ\RWKHUÀDPPDEOHYDSRUV
RUOLTXLGVLQWKHYLFLQLW\RIWKLV
or any other appliance.
 'XHWRKLJKWHPSHUDWXUHVWKH
appliance should be located
RXW RI WUDI¿F DQG DZD\ IURP
furniture and draperies.
 'RQRWSODFHFORWKLQJRURWKHU
ÀDPPDEOHPDWHULDOVRQRUQHDU
the appliance.
 1HYHU OHDYH FKLOGUHQ XQDW-
WHQGHGZKHQD¿UHLVEXUQLQJ
LQWKH¿UHSODFH
:$51,1*8VHVROLGZRRG
RUSURFHVVHGVROLGIXHO¿UHORJV
only. When processed wood
IXHO ¿UH ORJV DUH XVHG GR QRW
poke or stir the logs while they
DUHEXUQLQJ8VHRQO\¿UHORJV
that have been evaluated for
WKHDSSOLFDWLRQLQ¿UHSODFHDQG
UHIHU WR ¿UH ORJ ZDUQLQJV DQG
caution markings on packaging
prior to use.
 :$51,1* $OZD\V OHDYH
glass doors fully opened or
fully closed when operating
¿UHSODFH

www.fmiproducts.com
109493-01R 3
SPECIFICATIONS
02'(/6
10.5"
17"
0.625" 51"
30.5"
28.5"
21.25"
41.25"
23.5"
24.25"
3.5"
13"
1"
49"
8"
58"
30"
42"
51"
12"
9.5"
8.5"
67"
11"
GAS LINE
KNOCK OUTS
AIR KIT
KNOCK OUT
LEFT SIDE
OUTSIDE AIR
11/2" AIR SPACE
BACK AND SIDES
0" TO
BOTTOM
GAS LINE
KNOCKOUTS
12" EACH SIDE
COMBUSTIBLE
WALL BOARD
NO COMBUSTIBLE
MATERIAL ON FACE
MINIMUM 18" TO
PERPENDICULAR
SIDEWALL
HEARTH EXTENSION
66" X 20"
2" CHIMNEY AIRSPACE
CLEARANCE TO
COMBUSTIBLE MATERIAL
ROUND TOP TERMINATION
TERMINATION
SQUARE CHASE-TOP

www.fmiproducts.com 109493-01R4
SPECIFICATIONS
02'(/6
10.5"
17"
50"
23.5"
32.75"
3.5"
13"
9.5"
8.5"
2" CHIMNEY AIRSPACE
CLEARANCE TO
COMBUSTIBLE MATERIAL
TERMINATION
SQUARE CHASE-TOP
ROUND TOP TERMINATION
COMBUSTIBLE
WALL BOARD
NO COMBUSTIBLE
MATERIAL ON FACE
0" TO
BOTTOM
OUTSIDE AIR
11/2" AIR SPACE
BACK AND SIDES
GAS LINE
KNOCKOUTS
12" EACH SIDE
MINIMUM 18" TO
PERPENDICULAR
SIDEWALL
HEARTH EXTENSION
74" X 20"
0.625" 59"
38.5"
28.5"
21.25"
11"
1"
49"
8"
58"
30"
50"
59"
12"
67"
LEFT SIDE
GAS LINE
KNOCK OUTS
AIR KIT
KNOCK OUT

www.fmiproducts.com
109493-01R 5
FIREPLACE INSTALLATION
XSRQ D PHWDO RU ZRRG SDQHO H[WHQGLQJ
WKHIXOOZLGWKDQGGHSWKRIWKH¿UHSODFH
 6HW WKH ¿UHSODFH GLUHFWO\ LQ IURQW RI WKLV
RSHQLQJDQGVOLGHXQLWEDFNXQWLOQDLOLQJ
ÀDQJHVWRXFKVLGHIUDPLQJ
 &KHFNWKHOHYHORI¿UHSODFHDQGVKLPZLWK
VKHHWPHWDOLIQHFHVVDU\
 %HIRUH VHFXULQJ ILUHSODFH WR SUHSDUHG
IUDPLQJ WKH HPEHU SURWHFWRU SURYLGHG
PXVWEHSODFHGEHWZHHQKHDUWKH[WHQVLRQ
QRW VXSSOLHG DQG XQGHU ERWWRP IURQW
HGJHRI¿UHSODFHWRSURWHFWDJDLQVWJORZ-
LQJHPEHUVIDOOLQJWKURXJK,IWKH¿UHSODFH
LVWREHLQVWDOOHGRQDUDLVHGSODWIRUPD
=W\SH HPEHU SURWHFWRU QRW VXSSOLHG
PXVW EH IDEULFDWHG WR ¿W \RXU UHTXLUHG
platform height. The ember protector
VKRXOGH[WHQGXQGHUWKH¿UHSODFHDPLQL-
mum of 1 1/27KHHPEHUSURWHFWRUVKRXOG
EHPDGH RIJDOYDQL]HG VKHHWPHWDO 
JDXJHPLQLPXPWRSUHYHQWFRUURVLRQ
 8VLQJVFUHZVRUQDLOVVHFXUHWKH¿UHSODFH
WRWKHIUDPLQJWKURXJKÀDQJHVORFDWHGRQ
WKHVLGHVRIWKH¿UHSODFH
30.125"
58.125"
67.125"
51.25" (42")
59" (50")
92" (42" Models)
100" (50" Models)
65" (42" Models)
71" (50" Models)
Maintain 1
1
/
2
"
Clearance at Sides
and Back of Fireplace
1
1
/
2
" Clearance
Not Required at
Nailing Flanges
Figure 2 - Corner Installation
6(/(&7,1*/2&$7,21
7R GHWHUPLQH WKH VDIHVW DQG PRVW HI¿FLHQW
ORFDWLRQIRUWKH¿UHSODFH\RXPXVWWDNHLQWR
FRQVLGHUDWLRQWKHIROORZLQJJXLGHOLQHV
 7KHORFDWLRQPXVWDOORZIRUSURSHUFOHDU-
DQFHVVHH)LJXUHVDQG
 &RQVLGHU D ORFDWLRQ ZKHUH WKH ¿UHSODFH
ZLOOQRWEHDIIHFWHGE\GUDIWVDLUFRQGLWLRQ-
LQJGXFWVZLQGRZVRUGRRUV
 $ ORFDWLRQ WKDW DYRLGV WKH FXWWLQJ RI
MRLVWVRUURRIUDIWHUVZLOOPDNHLQVWDOODWLRQ
HDVLHU
 $Q RXWVLGH DLU NLW LV DYDLODEOH ZLWK WKLV
¿UHSODFH VHH Optional Outside Air Kit
SDJH
0,1,080&/($5$1&(72
&20%867,%/(6
%DFNDQGVLGHVRI¿UHSODFH 1/2" min.*
)URQWRI¿UHSODFH PLQ
Floor** 0" min.
3HUSHQGLFXODUZDOOWRRSHQLQJ 12" min.
7RSVSDFHUV PLQ
0DQWHOFOHDUDQFH VHHMantels
page 5
&KLPQH\RXWHUSLSHVXUIDFH PLQ
1RWUHTXLUHGDWQDLOLQJÀDQJHV
6HHVWHSRIFraming
:$51,1*'RQRWSDFNUH-
TXLUHGDLUVSDFHVZLWKLQVXODWLRQ
or other materials.
0LQLPXP0D[LPXP&KLPQH\+HLJKW
7KH PLQLPXP KHLJKW RI WKH FKLPQH\ PHD-
VXUHG IURP WKH EDVH RI WKH ¿UHSODFH WR WKH
ÀXHJDVRXWOHWRIWKHWHUPLQDWLRQLVIHHWIRU
VWUDLJKWÀXHRUDÀXHZLWKRQHHOERZVHW7KH
PD[LPXPGLVWDQFHEHWZHHQHOERZVLVIHHW
)RUV\VWHPVZLWKWZRHOERZVHWVWKHPLQLPXP
KHLJKWLVIHHW7KHPD[LPXPKHLJKWRIDQ\
V\VWHPLVIHHW7KLVPHDVXUHPHQWLQFOXGHV
WKH¿UHSODFHFKLPQH\VHFWLRQVDQGWKHKHLJKW
RIWKHWHUPLQDWLRQDVVHPEO\DWWKHOHYHORIWKH
ÀXHJDVRXWOHWVHH)LJXUHSDJH
)5$0,1*
 )UDPH RSHQLQJ IRU ¿UHSODFH XVLQJ WKH
GLPHQVLRQVVKRZQLQ)LJXUHVDQG
 ,I ¿UHSODFH LV WR EH LQVWDOOHG GLUHFWO\ RQ
FDUSHWLQJWLOHRWKHUWKDQFHUDPLFRUDQ\
FRPEXVWLEOH PDWHULDO RWKHU WKDQ ZRRG
ÀRRULQJ WKH ¿UHSODFH PXVW EH LQVWDOOHG

www.fmiproducts.com 109493-01R6
+($57+(;7(16,21
$KHDUWKH[WHQVLRQSURMHFWLQJDPLQLPXPRI
20" in front of and a minimum of 12" beyond
HDFKVLGHRIWKH¿UHSODFHRSHQLQJLVUHTXLUHG
WR SURWHFW FRPEXVWLEOH IORRU FRQVWUXFWLRQ
LQ IURQW RI WKH ¿UHSODFH )DEULFDWH D KHDUWK
H[WHQVLRQXVLQJDPDWHULDOZKLFKPHHWVWKH
IROORZLQJVSHFL¿FDWLRQV D OD\HURI QRQFRP-
EXVWLEOHLQRUJDQLFPDWHULDOKDYLQJDWKHUPDO
FRQGXFWLYLW\RI. %78,1)7+5)RU
OHVVDWWKLFN)RUH[DPSOHLIWKHPDWHULDO
VHOHFWHGKDVD.IDFWRURIVXFKDVJODVV
¿EHUWKHIROORZLQJIRUPXODZRXOGDSSO\
0.25[ WKLFNQHVVUHTXLUHG
 
7KHUPDOFRQGXFWLYLW\.RIPDWHULDOVFDQEH
REWDLQHGIURPWKHPDQXIDFWXUHURUVXSSOLHURI
WKHQRQFRPEXVWLEOHPDWHULDO,IWKHKHDUWKH[-
WHQVLRQLVWREHFRYHUHGXVHQRQFRPEXVWLEOH
PDWHULDO VXFK DV WLOH VODWH EULFN FRQFUHWH
PHWDO JODVV PDUEOH VWRQH HWF 3URYLGH D
PHDQVWRSUHYHQWWKHKHDUWKH[WHQVLRQIURP
VKLIWLQJDQGVHDO JDSEHWZHHQWKH ¿UHSODFH
IUDPHDQGKHDUWKH[WHQVLRQZLWKDQRQFRP-
EXVWLEOHPDWHULDOVHH)LJXUH
:$51,1*+HDUWKH[WHQVLRQ
is to be installed only as shown
LQ)LJXUH
FIREPLACE INSTALLATION
Figure 3 - Hearth Extension
Seal Gap
Fireplace Front
Ember Protector
Fireplace Front
5DLVHG+HDUWK
Fireplace Front
Elevated
Ember Protector
Ember Protector
Seal Gap
+HDUWK
([WHQVLRQ
0$17(/6
$ PDQWHO PD\ EH LQVWDOOHG LI GHVLUHG VHH
)LJXUH  :RRGZRUN VXFK DV ZRRG WULPV
PDQWHOV RU DQ\ RWKHU FRPEXVWLEOH PDWHULDO
SURMHFWLQJ IURP WKH IURQW IDFH PXVW QRW EH
SODFHG ZLWKLQ  RI WKH ¿UHSODFH RSHQLQJ
&RPEXVWLEOH PDWHULDOV DERYH  DQG SUR-
jecting more than 1 1/2 IURP WKH ¿UHSODFH
PXVW QRW EH SODFHG OHVV WKDQ  IURP WKH
WRSRSHQLQJRIWKH¿UHSODFH1)3$67'
6HF
0DQWHOV RU DQ\ RWKHU FRPEXVWLEOH PDWHULDO
DOVR PD\ FRPH XS WR WKH VLGH HGJH RI WKH
EODFNPHWDOIDFHRIWKH¿UHSODFHMXVWDVORQJ
DVWKHSURMHFWLRQIURPWKHIURQWIDFHIDOOZLWKLQ
WKHOLPLWVKRZQLQ)LJXUH
12 1/4" Ref.
15" Min.
12" Min.
11/20D[
3" Nom.
33°
&RPEXVWLEOH
Material
Safe
Zone for
Projection of
&RPEXVWLEOH
0DWHULDOV
Fireplace Opening
8SSHU
Section of
Fireplace
Figure 4 - Mantel Clearances to
Combustible Material
FIREBOX
SAFE ZONE
7RS9LHZRI)LUHSODFH
0D[
4.5"
Min. to
Perpendicular
6LGH:DOO
12"
7.75"
33°
&RPEXVWLEOH
0DWHULDO0XVW
Not Overlap
Front Face
6"
Ref.

www.fmiproducts.com
109493-01R 7
Figure 6 - Lineal Gain
/,1($/*$,1
3$5712 '(6&5,37,21 *$,1
Georgian Fireplace 66 1/2 "
'0
+7 Pipe Section 10 5/
"
'0
+7 Pipe Section 16 5/
"
'0
+7 Pipe Section 23 5/
"
'0
+7 Pipe Section 34 5/
"
'0
+7 Pipe Section 46 5/
"
5/7'
5/7+7 Round Termination 7 3/4
"
*
67/' 6TXDUH&KDVH7RS
ZLWK6OLS6HFWLRQ 7
" to 15 " *
7KHOLQHDOJDLQIRUWKHWHUPLQDWLRQVLVPHD-
VXUHGWRWKHÀXHJDVRXWOHWKHLJKW
+HPPHG
End
12 3/"
6WDLQOHVV
Inner Pipe
15" Galvanized
Outer Pipe
$66(0%/<$1',167$//$7,212)
'28%/(:$//&+,01(<6<67(0
(DFKGRXEOHZDOOFKLPQH\VHFWLRQFRQVLVWVRID
JDOYDQL]HGRXWHUSLSHDVWDLQOHVVVWHHOLQQHUÀXH
SLSHDQGDZLUHVSDFHU3LSHVHFWLRQVPXVWEH
DVVHPEOHGLQGHSHQGHQWO\DVFKLPQH\LVLQVWDOOHG
:KHQFRQQHFWLQJFKLPQH\GLUHFWO\WR¿UHSODFH
WKHLQQHUÀXHSLSHVHFWLRQPXVWEHLQVWDOOHG¿UVW
ZLWKODQFHGVLGHXS7KHRXWHUSLSHVHFWLRQFDQ
WKHQEHLQVWDOOHGRYHUWKHÀXHSLSHVHFWLRQZLWK
KHPPHGHQGXS3UHVVGRZQRQHDFKSLSHVHF-
WLRQXQWLOODQFHVVHFXUHO\HQJDJHKHPRQ¿UHSODFH
VWDUWHU7KHZLUHZLOODVVXUHWKHSURSHUVSDFLQJ
EHWZHHQLQQHUDQGRXWHUSLSHVHFWLRQV
&RQWLQXH WR DVVHPEOH FKLPQH\ VHFWLRQV DV
RXWOLQHGDERYHPDNLQJVXUHWKDWERWKLQQHUDQG
RXWHUSLSHVHFWLRQVDUHORFNHGWRJHWKHU:KHQ
LQVWDOOLQJ GRXEOH ZDOO VQDSORFN FKLPQH\ WR-
JHWKHULWLVLPSRUWDQWWRDVVXUHWKHMRLQWEHWZHHQ
FKLPQH\VHFWLRQVLVORFNHG&KHFNE\SXOOLQJ
FKLPQH\ XSZDUG DIWHU ORFNLQJ7KH FKLPQH\
ZLOOQRWFRPHDSDUWLISURSHUO\ORFNHG,WLVQRW
QHFHVVDU\WRDGGVFUHZVWRNHHSWKHFKLPQH\
WRJHWKHUH[FHSWLRQVHH)LJXUHSDJH
VENTING INSTALLATION
Figure 5 - Outside Air Kit
6HFXUHWR&ROODUVZLWK0HWDO7DSH
6FUHZVRU6WUDSV0LQ[VL]H
Air Inlet
/RFDWLRQ
0XVW$OORZ
)RU%XVKHV
RU6QRZ
9HQW+RRG
Required for
:DOO,QVWDOODWLRQ
Air Inlet
(\HEURZ
9HQWHG&UDZO6SDFH
&KHFN/RFDO&RGHV
%HIRUH,QVWDOOLQJLQD
9HQWHG&UDZO6SDFH
&+,01(<3,3(
7KH)0,352'8&76//&FKLPQH\V\VWHP
FRQVLVWVRIDQGVQDS
ORFN GRXEOHZDOO SLSH VHJPHQWV SODQQHG
IRU PD[LPXP DGDSWDELOLW\ WR LQGLYLGXDO VLWH
UHTXLUHPHQWV$FWXDO OHQJWKV JDLQHG DIWHU
¿WWLQJRYHUODSVPXVWEHWDNHQLQWRFRQVLGHU-
DWLRQOLQHDOJDLQDQGDUHJLYHQLQWKHOLQHDO
JDLQFKDUWVHH)LJXUH/LQHDO*DLQLVWKH
DFWXDOPHDVXUDEOHOHQJWKRIDSDUWDIWHUWZR
RUPRUHSDUWVDUHFRQQHFWHG)RU&DQDGD
XVHFKLPQH\SDUWVGHVLJQDWHG+7
 :$51,1* 7KH RSHQLQJ LQ
the collar around the chimney at
WKHWRSRIWKH¿UHSODFHPXVWQRW
be obstructed. Never use blown
LQVXODWLRQ WR ¿OO WKH FKLPQH\
enclosure.
237,21$/2876,'($,5.,7
02'(/$.$.)
7KH LQVWDOODWLRQ RI DQ RXWVLGH DLU NLW VKRXOG
be performed during the rough framing of
WKH¿UHSODFHGXHWRWKHQDWXUHRILWVORFDWLRQ
2XWVLGHFRPEXVWLRQDLULVDFFHVVHGWKURXJK
D YHQWHG FUDZO VSDFH $.) RU WKURXJK D
VLGHZDOO$.
 &$87,21 &RPEXVWLRQ DLU
inlet ducts shall not terminate
in attic space.

www.fmiproducts.com 109493-01R
VENTING INSTALLATION
Continued
86,1*(/%2:2))6(76('0
1. 7RDFKLHYHGHVLUHGRIIVHW\RXPD\LQVWDOO
FRPELQDWLRQVRIDQG
OHQJWKRIGRXEOHZDOOSLSHVHHRIIVHWFKDUW
DQG)LJXUH
OFFSET CHART (22-50 FT. SYSTEM HEIGHT)
Figure 7 - Typical Offset Terminations
Return
(OERZ
2IIVHW
(OERZ
Return
(OERZ
2IIVHW
(OERZ
0D[
0D[
0D[
0D[
0D[
0D[
Return
(OERZ
2IIVHW
(OERZ
2IIVHW
(OERZ
Return
(OERZ
A B &
2IIVHW
(OERZ
&HLOLQJ
Support Pipe
6'0
Return
(OERZ
Figure 8 - Ceiling Support Pipe
12S-12DM
2" Min.
6WUDSV
6WUDSV
6WUDSV
6WUDSV
'HWDLO$
5HWXUQ(OERZ
'HWDLO%
$QJOH)LUHVWRS
6HH'HWDLO$
6HH'HWDLO%
 &KLPQH\ ZHLJKW DERYH RIIVHW UHVWV RQ
UHWXUQ HOERZ 6WUDSV PXVW EH VHFXUHO\
QDLOHG WR UDIWHUV RU MRLVWV VHH )LJXUH 
GHWDLOVDDQGE
 0D[LPXPOHQJWKRISLSHEHWZHHQVXSSRUWV
UHWXUQHOERZRU6'0LVRIDQJOH
UXQ0D[LPXPRIWZRDQJOHUXQVHFWLRQV
SHUFKLPQH\V\VWHPVHH)LJXUH
 $OOSLSH FRQQHFWLRQVEHWZHHQ WKH RIIVHW
DQG UHWXUQ PXVW EH VHFXUHG ZLWK WZR
VFUHZVRQWKHRXWHUSLSHRQO\VHH)LJXUH
 SDJH  'R QRW SHQHWUDWH WKH LQQHU
VWDLQOHVV
2))6(7 5,6( &+,01(</(1*7+
A B 12" 18" 24"  48"
4 3/" 16 3/" (/%2:6(721/<
9 3/4" 25 1/2" 1
12 3/4" 30 3/4" 1
15" 34 3/4" 1
 40" 1 1
21 1/4" 46 1/4" 1
23 3/4" 49 1/4" 1 1
27 3/4" 56 3/4" 1
30" 60 3/4" 1 1
33" 66" 1 1
36" 71" 1 1
1/4" 75" 2
41 1/4"1/4" 1 1 1
45" 3/4" 2
46 3/4"1/2" 1 1 1
51" 97" 1 1
53 1/4" 101" 1 2
56 1/4" 106 1/4" 2
59 1/4" 111 1/2" 1 1 1
61 3/4" 115 1/2" 1 2
64 3/4" 120 3/4" 1 2
1/4" 127" 2 1
70" 130" 1 1 2
74 1/4" 137 1/2" 1 2 1
76 3/4" 141 1/2" 1 2 1
79 3/4" 146 3/4" 4

www.fmiproducts.com
109493-01R 9
VENTING INSTALLATION
Continued
Figure 9 - Elbow Offset
B
A
6FUHZV
),5(672363$&(56)6
)LUHVWRSVSDFHUVDUHUHTXLUHGDWHDFKSRLQW
ZKHUHWKHFKLPQH\SHQHWUDWHVDÀRRUVSDFH
7KHLU SXUSRVH LV WR HVWDEOLVK DQG PDLQWDLQ
WKHUHTXLUHGFOHDUDQFHEHWZHHQWKHFKLPQH\
DQGWKHFRPEXVWLEOHPDWHULDOV:KHQWKHSLSH
SDVVHVWKURXJKDIUDPHGRSHQLQJLQWRDOLYLQJ
VSDFHDERYHWKH¿UHVWRSPXVWEHSODFHGRQWR
FHLOLQJIURPEHORZDVVKRZQLQ)LJXUH
7KH\DOVRSURYLGHFRPSOHWHVHSDUDWLRQIURP
RQHÀRRUVSDFHWRDQRWKHURUDWWLFVSDFHDV
UHTXLUHGE\PRVWFRGHV:KHQWKHGRXEOHZDOO
SLSHSDVVHVWKURXJKDIUDPHGRSHQLQJLQWRDQ
DWWLFVSDFHWKH¿UHVWRSPXVWEHSODFHGLQWR
DQDWWLFÀRRUDVVKRZQLQ)LJXUH
Figure 10 - Firestop Spacer with Living
Space Above Ceiling
Figure 11 - Firestop Spacer with Attic
Space Above Ceiling
([LVWLQJ
&HLOLQJ
Frame
)LUHVWRS
Spacer
6FUHZVRU
6WDSOHV
0LQRI
)LUHVWRS
Spacer
6FUHZVRU6WDSOHV
0LQRI
3(1(75$7,1*522)
7RPDLQWDLQDFOHDUDQFHWRSLSHRQDURRIZLWK
DSLWFKDUHFWDQJXODURSHQLQJPXVWEHFXW
 'HWHUPLQHWKHFHQWHUSRLQWWKURXJKZKLFK
SLSHZLOOSHQHWUDWHURRI
 'HWHUPLQHWKHFHQWHUSRLQWRIWKHURRI3LWFK
LVWKHGLVWDQFHWKHURRIGURSVRYHUDJLYHQ
VSDQXVXDOO\$SLWFKPHDQVWKDW
WKHURRIGURSVIRUHDFKRQHPHDVXUH
KRUL]RQWDOO\GRZQIURPWKHURRIUDIWHUV
 8VHWKHURRIRSHQLQJFKDUW)LJXUHWR
determine the correct opening length and
ÀDVKLQJUHTXLUHG
 5HPRYH VKLQJOHV DURXQG WKH RSHQLQJ
PHDVXUHG&XWRXWWKLVVHFWLRQ
 $GG QH[W VHFWLRQV RI SLSH XQWLO WKH HQG
SHQHWUDWHVURRIOLQH&KHFNWRVHHWKDWWKH
SURSHUFOHDUDQFHVDUHPDLQWDLQHG([WHQG
FKLPQH\ E\ DGGLQJ VHFWLRQV RI GRXEOH
ZDOO SLSH XQWLO SLSH LV PLQLPXP RI 
DERYHWKHKLJKHVWSRLQWRIWKHURRIFXWRXW
7HUPLQDWLRQDQGFKLPQH\PXVWH[WHQGD
PLQLPXPRIDERYHWKHKLJKHVWSRLQW
ZKHUHLWSDVVHVWKURXJKWKHURRI
19.5" Min. 30" Min.
2" Min.
2" Min.
2" Min.
Opening "A"
3LWFK Slope Opening
$0D[
8VHG)ODVKLQJ
Model No.
Flat 0° 19.5" 9)'0
0-6/12 26.6° 22" 9)'0
6/12- 12/12 45.0° 27" 9)'0
([LVWLQJ
&HLOLQJ
Frame
Figure 12 - Roof Opening Measurements
)/$6+,1*,167$//$7,219)'0
259)'0
'HWHUPLQH ÀDVKLQJ WR EH XVHG ZLWK WKH URRI
RSHQLQJ FKDUW 6OLGH ÀDVKLQJ RYHU SLSH XQWLO
EDVH LV ÀDW DJDLQVW URRI 5HSODFH DV PDQ\
VKLQJOHV DV QHHGHG WR FRYHU H[SRVHG DUHD
DQGÀDVKLQJEDVH6HFXUHLQSRVLWLRQE\QDLOLQJ
WKURXJKVKLQJOHVVHH)LJXUHSDJH'2
1271$,/7+528*+)/$6+,1*&21(

www.fmiproducts.com 109493-01R10
VENTING INSTALLATION
Continued
Nail Only
Outer
Perimeter
RI)ODVKLQJ
Storm
&ROODU
)ODVKLQJ
&RQH
8QGHUODS
6KLQJOHV
at Bottom
Overlap
6KLQJOHV7RS
DQG6LGHV2QO\
Figure 13 - Flashing Installation
,QVWDOOLQJ)ODVKLQJRQD0HWDO5RRI
:KHQLQVWDOOLQJWKHÀDVKLQJRQDPHWDOURRI
LWLVUHTXLUHGWKDWSXWW\WDSHEHXVHGEHWZHHQ
WKHÀDVKLQJDQGWKHURRI7KHÀDVKLQJPXVWEH
VHFXUHGWRWKHURRIXVLQJ[VFUHZVDQG
WKHQVHDOHGZLWKURRIFRDWLQJWRSUHYHQWOHDN-
DJHWKURXJKWKHVFUHZKROHV$URRIFRDWLQJ
PXVWDOVREHDSSOLHGDURXQGWKHSHULPHWHURI
WKHÀDVKLQJWRSURYLGHDSURSHUVHDO
6WRUP&ROODU,QVWDOODWLRQ6&
3ODFHVWRUPFROODURYHUSLSHDQGVOLGHGRZQ
XQWLOLWLVVQXJDJDLQVWWKHRSHQHGJHRIWKH
ÀDVKLQJ VHH )LJXUH $SSO\ ZDWHUSURRI
FDXON DURXQG WKH SHULPHWHU RI WKH FROODU WR
SURYLGHDSURSHUVHDO
Figure 14 - Storm Collar
&KLPQH\
Pipe
:DWHUSURRI
&DXON
Storm
&ROODU )ODVKLQJ
7HUPLQDWLRQV6SDUN$UUHVWRU
7KH¿UHSODFHV\VWHPPXVWEHWHUPLQDWHGZLWK
WKHOLVWHGURXQGWRSRUFKDVHWHUPLQDWLRQV,Q
DQ\FDVHUHIHUWRWKHLQVWDOODWLRQLQVWUXFWLRQV
VXSSOLHGZLWKWKHWHUPLQDWLRQ
Secure
Termination
to Outer
3LSHZLWK
6FUHZV
57/'
/HYHORI
)OXH*DV
Outlet
6WDLQOHVV
Inner Flue
Pipe
:DWHUSURRI
&DXONLQJ
Storm
&ROODU
)ODVKLQJ
8QGHUODS
6KLQJOHV
Figure 15 - Termination
Overlap
6KLQJOHV7RSDQG6LGHV
RI)ODVKLQJ%DVH
&$87,21'RQRWVHDORSHQ-
LQJVRQWKHURRIWRSÀDVKLQJ)RO-
low the installation instructions
provided with the termination
being used.
&+$6(,167$//$7,216
,QVWUXFWLRQV IRU FKDVH LQVWDOODWLRQV DUH
LQFOXGHG ZLWK WKH FKDVH VW\OH WHUPLQDWLRQ
FKRVHQ ,Q D PXOWLSOH FKDVH LQVWDOODWLRQ EH
VXUHWRSURYLGHDGHTXDWHGLVWDQFHEHWZHHQ
WHUPLQDWLRQVWRSUHYHQWVPRNHVSLOODJHIURP
RQHWHUPLQDWLRQWRDQRWKHU7HUPLQDWLRQVEH
VHSDUDWHGDPLQLPXPRIFHQWHUWRFHQWHU
DQGVWDFNHGDWDPLQLPXPYHUWLFDOKHLJKWGLI-
IHUHQFHRIVHH)LJXUH
Note: If a decorative shroud is to be installed,
FRQWDFWWKHPDQXIDFWXUHUIRUVSHFL¿FDWLRQV
24" Min.
24" Min.

Min.
Typ.
Figure 16 - Multiple Chase Installation