Franklin 91017X User manual

www.franklinsports.com/91017X
ITEM NUMBER: 91017X 91017C1X
30IN (76.2CM)
PORTABLE BASKETBALL
--Small parts.
Not for children under 3 yrs.
Adult assembly required.
CHOKING HAZARD

ITEM#: 1
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
CUSTOMER SERVICE COMMITMENT
If possible, please include product part number and
parts description so we can best assist you.
[e-mail]
or
Visit our website at: www.franklinsports.com
Thank you for purchasing this Franklin®product! In the event that
the product you've purchased has missing or damaged parts, please contact us at:
Thank you for your continued support, and welcome to the #FranklinFamily!
WE'RE HERE FOR YOU!
PLEASE DO NOT RETURN THIS PRODUCT TO
THE STORE IT WAS PURCHASED FROM.
WE ARE COMMITTED TO FULFILLING ALL
REPLACEMENT PART NEEDS IMMEDIATELY.
91017X 91017C1X

2
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN
SERIOUS INJURY AND/OR PROPERTY DAMAGE AND WILL VOID WARRANTY.
Owner must ensure that all players know and follow these rules for safe operation of the system.
• 2 capable adults are recommended for this operation.
• Check base daily for leakage. Leaks will cause system to fall.
• Assemble the pole sections properly. Failure to do so could cause the pole sections to separate during play or transport.
SAFETY INSTRUCTIONS
To ensure safety, do not attempt to assemble this system without following the instructions carefully. Check entire box
and inside all packing material for parts and/or additional instruction material. Before beginning assembly, read the
instructions and identify parts using the hardware identifier and parts list in this document. Proper and complete assembly,
use, and supervision are essential for proper operation and to reduce the risk of accident or injury. A high probability of
serious injury exists if this system is not installed, maintained and operated properly.
Most injuries are caused by misuse and/or not following instructions. Use caution when using this system.
PARTS LIST
x1
Backboard
A
QTY
B
x1
Rim
B1
QTY
B2
x1
Bottom Pole
D
QTY
x1
Middle Pole with Warning Label
E
QTY
x1
Top Pole
F
QTY
x2
Support Arm
G
QTY
x2
Axle
H
QTY
x2
Y Bracket
I
QTY
x2
Wheel
J
QTY
x1
Plastic Nut
K
QTY
x1
Top Pole Cap
L
QTY
x1
Base Cap
M
QTY
x1
Triangle Nut
N
QTY
x10
Lock Nut M8
O
QTY
x18
Washer M8
P
QTY
Rep. Part: 92004X-R1 Rep. Part: 92004X-R2
PRE-INSTALLED
x1
Base
C
QTY
Adjustable Wrench
Tools Required (NOT INCLUDED)
13mm Wrench 14mm Wrench
91017X 91017C1X
x1
Bolt M8 x 65mm
5
QTY
x2
Bolt M8 x 20mm
1
QTY
x4
Bolt M8 x 35mm
2
QTY
x3
Bolt M8 x 55mm
3
QTY
x1
Bolt M8 x 60mm
4
QTY
x1
Ball
8
QTY
x2
Bolt M6 x 8mm
6
QTY
x2
Washer M6
7
QTY
x1
Pump& Needle
9
QTY

PARTS NOTE
Attach the Bottom
Pole (D) on the groove
on the Base (C); then
secure it by using the
Plastic Nut (K).
NOTE:
Make sure that the two
holes on the pole are
positioned on the
sides.
C x1
D x1
K x1
STEP 1
3
ASSEMBLY INSTRUCTIONS
1. Remove all components from the shipping
carton. Remove all protective wrap and layout
all components on the ground.
2. Ensure you have all components shown in the
parts list.
GENERAL NOTE
PARTS NOTE
STEP 2
Attach the Support
Arms (G) on the Base
(C) by using 2pcs of
Bolts M8x20mm (1)
through 2pcs of
Washers (P) and 2pcs
of Nuts (O).
NOTE:
Do not fully tighten
bolts during this step.
It will allow for easier
assembly if they are
tightened later.
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
C x1
D x1
G x2
O x2
P x2
1 x2
91017X 91017C1X

4
PARTS NOTESTEP 3 & 4
Attach the Support
Arms (G) to Bottom
Pole (D) by using 1pc
of Bolt M8x60mm (4)
through 2pcs of
Washers (P) and 1pc
of Nut (O).
Insert the Axles (H)
into Wheels (J) and
push them into the
grooves of the Base
(C).
PARTS NOTESTEP 5
Attach the Rim (B1) to
the front side of
Backboard (A) using
4pcs of Bolts
M8x35mm (2) through
the Rim (B1),
Backboard (A),
Y-Bracket (I), 8pcs of
Washers (P), and then
lock them with 4pcs of
Nuts (O).
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
C x1
D x1
G x2
O x2
P x2
H x2
J x2
4 x1
A x1
B x1
I x1
O x2
P x2
4 x1
PARTS NOTESTEP 6
Attach Net (B2) to Rim
(#B1) as shown.
B1 x1
B2 x1
FRONT SIDE
BACK SIDE
B1 B1
B1
B2 B2 B2
91017X 91017C1X

5
NOTE
STEP 7
Slide the Top Pole (F) through the Middle Pole (E) until it comes out from the top of the middle pole. Make sure there are two
holes on each side of the top pole protruding from the middle pole for backboard assembly.
Insert the Top Pole (F) up inside the Middle Pole (E). Insert the square Bolt M8x65mm (5) and lock it with the Triangle Nut (N).
NOTE:
1. Pole (F) comes packaged inside pole (E). Do not separate. Only need to slide pole (F) up through pole (E).
2. The square bolt M8x65mm (5) has a position fix point at the top of bolt. It helps secure the pole. Make sure this is well inserted
into the pole.
3. Check the warning label on the middle pole (E), and make sure it faces user/front and the triangle nut (N) is at the back.
4. The remaining holes in the Top Pole (F) are for height adjusting, including : 5.5ft (1.69m), 5.9ft (1.79m) and 6.4ft (1.95m).
PARTS
E x1
F x1
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
N x1
5 x1
91017X 91017C1X

6
PARTS NOTESTEP 8
Attach the Top Pole
(F) inside the
Y-Bracket (I) at the
joint using 2pcs of
Bolts M8x55mm (3)
and 4pcs of Washers
(P). Lock it with 2 pcs
of Nuts (O) and insert
the Cap (L) into the
Top Pole (F).
E x1
PARTS NOTESTEP 9
Attach the Y-Bracket
(I) on the backside of
Backboard (A) by
using 2pcs of Washers
M6 (7) and 2pcs of
Bolts M6X8mm (6).
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
F x1
O x2
P x2
3 x2
I x1
L x1
I x1
A x1
6 x2
7 x2
91017X 91017C1X

7
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
PARTS NOTESTEP 10
Insert the Middle Pole
(E) inside the Bottom
Pole (D) and secure by
using Bolt M8x55mm
(3), 2pcs of Washers
(P), and 1pc of Nut
(O).
NOTE:
Make sure all
hardware is fully
tightened before
moving or playing.
D x1
E x1
O x1
P x2
3 x1
91017X 91017C1X

8
NOTESTEP 11
Adjust backboard to lowest position.
While holding pole and lifting base, carefully lean
system forward until wheels touch ground.
While holding pole and base, roll system to desired
location.
Stand pole upright and set base flat on ground.
ALWAYS check to make sure system is stable in new
location.
Place base where it will be used. Unscrew and
remove base cap.
Pour sand while base is flat on the ground, and then
tip forward to allow even distrtibution.
Repeat the action until the base is full of sand.
Once full, replace base cap.
For safety reasons, we recommend that sand be used instead of water to fill the base. If a leak develops, water could run
out unnoticed, allowing the system to fall over, resulting in serious injuries, or property damage. If using water, check the
base carefully for leaks.If a leak is found, lay the system down on the ground and call customer service. Do not use,
stand up, or play on a leaking system.
ITEM#:
For replacement parts:
Visit: www.franklinsports.com/91017X
Email: [email protected]
Call: 1-800-225-8649
The system must only be moved by at least 2 adults that are capable of handling weight.DO NOT allow children to move unit.
a. Adjust the system to its lowest position and lock in place to prevent the height mechanism from adjusting.
b.Standing in front of the unit,pull the pole down until it is balanced on the 2 wheels.
c. Move the unit to the desired location and carefully lower the unit back down.
112lbs
(51kgs)
MOVING THE SYSTEM
CAUTION:
The system must only be moved when balanced on the wheels. Sliding the unit any other way may cause damage to the base and could
result in sand leakage and/or system tipping over.
91017X 91017C1X

YOU ARE NOW READY TO PLAY!
Failure to observe this warning may cause
property damage and/or serious injury.
This product is NOT designed to support a player hanging from any
component of this basketball system.
Rim height adjustments should be made by ADULTS ONLY.
Wear a mouth guard when playing to avoid dental injuries.
During play, do not wear jewelry (rings, watches, necklaces, etc.).
Objects may entangle in net.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow these rules for operation of the system.
• Only hang from the rim briefly to regain balance or avoid injuring others. Release the rim as safely as possible.
• During play, especially when performing dunk type activities, keep players face away from the backboard, rim and net. Serious injuries could
occur if teeth/face come in contact with backboard, rim, or net.
• Do not slide, climb, or play on base or pole.
• Completely fill base according to manufacturers instructions or the system will tip quickly causing serious personal injury.
• When adjusting height or moving system, keep hands and fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces, etc.) Objects may entangle in net.
• Surface beneath the base must be smooth and free of gravel or other objects. Punctures can cause leakage and could cause system to tip over.
• Keep water and organic materials away from pole. Pole can rust and fall.
• Once a month check pole and all metal parts for rust. Completely remove rust and repaint with exterior enamel. If rust has penetrated any
steel part, replace that part immediately.
• Check system before each use for proper ballast, loose hardware, instability, and signs of corrosion and repair before each use. Never play on
damaged equipment.
• Do not use system during windy or severe weather. System may tip over. Place system in an area protected from the wind or in an area away
from property that may be damaged if the system falls.
FRANKLIN SPORTS
1-800-225-8649
SWINGING ON THIS RIM
MAY CAUSE SERIOUS INJURY
OR DEATH.
DO NOT LEAVE UNIT IN VERTICAL
POSITION IF THE BASE IS NOT
PROPERLY FILLED WITH SAND.
Made In China
Franklin Sports Inc.
Stoughton, MA 02072