Generac Power Systems MLG20 User manual

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone; 800-926-9768 • Fax: [phone] • www.m-p-llc.com Page 1 of 3 6/12
Mobile Lite Generator – MLG20 Specifications
Engine
Isuzu®4LE1NYGV-01 - naturally aspirated, diesel engine
oPrime – 32.1 hp @ 1800 rpm
o4 cylinder
o2.2 L displacement
oInterim Tier IV approved
Polyethylene fuel tank
o56 gal. capacity
o31 hr. run time – full load
o3 ½” fill port
Fuel consumption at prime:
o100% - 1.80 gph (6.81 Lph)
o75% - 1.35 gph (5.11 Lph)
o50% - 0.90 gph (3.41 Lph)
Cooling system capable of operating at 120°F ambient
Rubber vibration dampers isolate engine/generator from frame
Full flow oil filter, spin on type
Fuel filter with replaceable element
Dry type cartridge air filter
60 Hz engine/generator
ENGINE CONTROLS
Engraved aluminum punched and anodized control panel
Four position keyed switch – glow plugs (preheat, off, run, start)
Hour meter
Automatic low oil/high temperature shutdown system
GENERATOR
Marathon Electric®
oBrushless
o4 pole
oClass H insulation
Single phase output
oPrime - 19 kW / 19 kVA (79A @ 240V)
oStandby - 20 kW / 20 kVA (83A @ 240V)
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
ELECTRICAL SYSTEM AND CONTROLS
100A start limit breaker (assures no load condition exists before starting)
Convenience receptacles with individual breakers
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(2) 240V 30 Amp twistlock outlets (Nema L6-30R type)
o(2) 240V 50 Amp twistlock outlets (Non-Nema 6369)
720 CCA wet cell battery
20

MLG20 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone; 800-926-9768 • Fax: [phone] • www.m-p-llc.com Page 2 of 3
6/12
ENCLOSURE
Generac Mobile Power decals
Steel, 14-gauge, sound attenuated enclosure
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o70 dB(A) at 23 feet – prime power
Fully lockable enclosure
Stainless steel hinges, door latches and exterior hardware
Emergency stop switch located on front panel
License plate holder with light
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER
DOT approved tail, side, brake, and directional lights
oRecessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
Single wall polyethylene fenders
2” ball hitch
2200 lb. leaf spring axle
2000 lb. tongue jack with footplate
ST205/75R15 tubeless tires – 6 ply
48” track width
WEIGHTS & DIMENSIONS
Dry weight: 1455 lbs (660 kg)
Operating weight: 1853 lbs (841 kg)
105 x 68 x 56 in
(2.67 x 1.73 x 1.42 m)
WARRANTY
Engine and generator covered under OEM warranty – consult factory for details
CERTIFICATIONS
CSA certified

MLG20 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone; 800-926-9768 • Fax: [phone] • www.m-p-llc.com Page 3 of 3
6/12
MLG20 Options
ENGINE OPTIONS
Heated fuel filter
Lower radiator hose – engine heater
Oil drain valve kit
ELECTRICAL CONTROLS OPTIONS
720 CCA gel cell battery
685 CCA gel cell battery
Battery disconnect
Battery charger – 2A trickle
VOLTAGE OUTPUT OPTIONS
Alternative receptacle panel – consult factory for configurations
COOLANT OPTIONS
60/40 Coolant – cold weather applications
ENCLOSURE OPTIONS
Interior cabinet light
Level indicator
Tamper pack
Liquid containment / Quiet pack
Lift structure
FUEL TANK OPTIONS
56 gal. fuel tank
Tethered fuel tank cap
TRAILER OPTIONS
6 pin or 7 spade electrical connectors
Outrigger package
Tube and sleeve jack
Spare tire/wheel kit
HITCH OPTIONS
2.5” lunette ring
3” lunette ring
3” HD lunette ring
2 5/16” ball
Combination hitch – 2.5” lunette ring / 2” ball