Generac Power Systems Mobile Power MMG130 User manual

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 1of 5
06/12
Mobile Generator – MMG130 Specifications
ENGINE
•John Deere®PE4045HFG93 -
turbocharged, diesel engine
oPrime - 152 hp @ 1800 rpm
oStandby - 166 hp @ 1800
rpm
o4 cylinder
o4.5 L displacement
oInterim Tier IV emissions
•Steel, single wall fuel tank
o342 gal. capacity
o44 hr. run time – full load
oFuel tank built into skid of
generator set
•Fuel consumption at prime:
o100% - 7.4 gph (28.0 Lph)
o75% - 5.5 gph (20.8 Lph)
o50% - 3.7 gph (14.0 Lph)
•Cooling system capable of operating at 120°F ambient
•Low coolant shutdown
•Radiator and oil drains plumbed to exterior
•Rubber vibration dampers isolate engine/generator from frame
•Disposable air filter - paper element
•Air filter restriction indicator mounted on control panel
•60 Hz engine/generator
•Electronic isochronous governing
•Utilizes DOC / DPF exhaust filter
•Variable Geometry Turbocharger (VGT)
GENERATOR
•Marathon Electric®
oBrushless
o4 pole
oClass H insulation
•Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT
•3 selector switch modes:
oSingle phase – 120 / 240V Zig Zag
oThree phase – 120 / 208V Low Wye
oThree phase – 277 / 480V High Wye

MMG130 Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 2of 5
06/12
•96 kW / 96 kVA – standby, single phase
•90 kW / 90 kVA – prime, single phase
•107 kW / 134 kVA – standby, three phase
•98 kW / 122 kVA – prime, three phase
SYSTEM CONTROLS
•Microprocessor-based controller
oBacklit, 128x64 pixel resolution display
o-40°F to 185°F operating
temperature range
oThermostatically controlled LCD
heater
oSix LED indicators w/ lamp test
♦Alarm / Fault (Red)
♦Ready / Manual (Red)
♦Running (Green)
♦Warning (Yellow)
♦Ready / Auto (Green)
♦Supplying Load (Green)
•Push buttons for easy operation
oManual or Auto Start
oEngine Start or Stop
oAlarm Cancel & Fault Reset
oScrolling Arrows for Diagnostic Information
♦System kW output display
♦Line output & frequency display
♦Engine diagnostic display
•Oil pressure
•Engine temperature
•Fuel level
•Battery
♦System hours
•Running hours
•kW hours
•Time to service
oAlarm list – warnings / shutdowns are date & time stamped
♦Fuel level: warning – 15%; shutdown – 5%
♦Overspeed protection: shutdown – 115%
♦Oil pressure: warning – 25 psi; shutdown – 20 psi
♦Coolant temperature: warning – 220°F; shutdown – 230°F
♦Battery voltage: over – 15VDC; under – 11VDC
♦Generator over voltage: warning – 110%; shutdown – 111%
♦Generator under voltage: warning – 87%; shutdown – 86%
♦Generator over frequency: warning – 105%; shutdown – 110%
♦Generator under frequency: warning – 95%; shutdown – 90%
♦Over current shutdown

MMG130 Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 3of 5
06/12
ELECTRICAL CONTROLS
•Remote start / stop contacts located next to lug box
•Lockable control box door with diagnostics window
•Lockable lug box with safety switch
oTrips main breaker when lug door is opened
oDisables voltage regulator
•Cable entry guides to the lug box
oRestricts access of foreign objects
•Output ground connection lug inside lug box
•Convenience receptacles with individual breakers (restricted use in high wye mode)
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(3) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)
•Panel mounted rheostat for voltage adjustment - +/- 10%
•1000 CCA wet cell battery
ENCLOSURE
•Generac Mobile Power decals
•Aluminum, sound attenuated enclosure
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o68 dB(A) at 23 feet – prime power
•Fully lockable enclosure including doors and fuel fill
•Stainless steel hinges on doors
•Emergency stop switch located on outside of enclosure
•Central lifting point
•Multi-lingual operating/safety decals
•Document holder with operating manual including AC/DC wiring diagrams
TRAILER
•DOT approved tail, side, brake, and directional lights
oRecessed rear lights
•Transportation tie downs
•Safety chains with spring loaded safety hooks
•3” lunette ring hitch
•(2) 6000 lb. axles with surge brakes
•5000 lb. tongue jack with footplate
•7.50x16E-6-W tubeless tires – 10 ply
WEIGHTS & DIMENSIONS
Skid mounted
•Dry weight: 5444 lbs (2469 kg)
•Operating weight: 7929 lbs (3596 kg)
•144 x 50 x 77 in
(3.66 x 1.27 x 1.95 m)

MMG130 Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 4of 5
06/12
Trailer mounted
•Dry weight: 6840 lbs (3102 kg)
•Operating weight: 9325 lbs (4230 kg)
•210 x 86 x 93 in
(5.33 x 2.18 x 2.36 m)
WARRANTY
•Engine and generator covered under OEM warranty – consult factory for details.
CERTIFICATIONS
•CSA pending
MMG130 Options
ENGINE OPTIONS
♦In-line engine block heater (Kim Hotstart)
♦Fuel transfer pump
ELECTRICAL CONTROLS OPTIONS
♦Battery disconnect
♦Battery charger – 2A trickle
GENERATOR OPTIONS
♦Super Start Generator - motor starting applications
VOLTAGE OUTPUT OPTIONS
♦4 position phase switch
Single phase – 120 / 240V Zig Zag
Three phase – 120 / 208V Low Wye
Three phase – 277 / 480V High Wye
Three phase – 120 / 240V Delta
♦Dedicated voltage configurations
♦Buck Transformer kit - Provides 120V at GFCI outlets when in 277/480V
♦Cam locks
SYSTEM CONTROLS OPTIONS
♦Auxiliary strobe/audible indication for soft & hard alarm conditions
COOLANT OPTIONS
♦60/40 Coolant - cold weather applications

MMG130 Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 5of 5
06/12
ENCLOSURE OPTIONS
♦Fire extinguisher
♦Interior cabinet light
♦Control panel light
FUEL TANK OPTIONS
♦36 hr. single wall fuel tank
♦23 hr. double wall fuel tank
♦120% Containment
TRAILER OPTIONS
♦Tandem axle trailer w/ electric brakes
♦6 pin or 7 spade electrical connectors
♦Spare tire/wheel kit
HITCH OPTIONS
♦2 5/16” ball