Gleamous DSK-45EP User manual

Instant Hot Water Heater
For proper operation and maintenance please
Read the instruction manual before installation.
www.gleamoushotwater.com.au
Instruction Manual
DSK - 45EP
Instant Hot Water Heater

88
240V~
50Hz
L
N
E
1
Thank you for your choice of our products.To enjoy the service of this unit,
Please read this manual carefully and follow the instruction rules.
I. Product Feartures
1. Energy-saving 4. Endless Hot warter
2. Supply hot water
on-demand
3. Easy operation 6. LED Temperature display
5. 240 volt 15amp
II. SCHEMATIC WIRING DIAGRAM FOR DSK-45EP
Residual current protective devices
Control PCB
Temperature indicator
Heating element
SCHEMATIC WIRING DIAGRAM FOR DSK-45EP
1
2
3
III．TECHNICAL PARAMETERS
DSK-45EP 240V~50Hz
3.3kW
IPX5 182×83×244mm
0KPa
Model Voltage Frequency Power Splash
proof Dimension
Rated
Pressure

2
IV. Part Designation and Installation Diagram
88
1
2
6
3
DSK-45EP
4
N L E
5
LEAKAGE
PROTEATION
SWITCH
1. Mains Pressure Cold Water Inlet
2. Adjustable Temperature Setting
3. Safety Cover
4. Hot Water Supply Outlet
5. 15 AMP power cable
6. Digital Temperature display
Fig2
￠8mm x 25mm
Expansion Bolt
Masonary Wall or
Plaster board
￠8mm x 25mm
Expansion Bolt
10cm
24cm
24cm
10
Fixing Holes for fixed water Heater
V. Installation procedure
1. The unit must only be installed by a licenced Electrical Contractor.
2. A earth leakage circuit breaker with 30mA is required to install for the
circuit controlling this unit.
3. The electric water heater should be wall-mounted installed. First
determine the right position for installation of the unit (See fig 2). Mark
& drill three holes(8mmx25), insert the expansion bolt on the top, keep
Fig1
Installation diagram
Installation diagram of DSK-45EP

3
VI. Operation Instructions:
1. Before you switch on the power for the first time , make sure the unit
has water flowing from the water outlet.
2. Switch on the power, the power indicator will light, the unit is on
standby. Regulate the temperature control knob on the cover of the unit
to your desired water temperature. Hot water will flow out in a few
seconds. Turning the water outlet valve off will automatically stop the
power and heating.
3. Water temperature regulation:
a. Changing the water flow by adjusting the water inlet valve will adjust
the temperature of outlet water.
b. When incoming (ambient temp) water temperature is very low,
regulate the outlet water temperature by adjusting both water inlet
valve and control knob.
4.
. This heater is not intended to be operated by children, or mentally
impaired personnel, unless under adult supervision and guidance.
6. Children are not allowed to play with the water unit.
7. When using water heater, the temperature of the heating tank will be
higher than 60℃, it will inhibit growth of Legionella bacteria.
To regulate the water temperature only by water inlet valve, turn the
control knob clockwise to the max.
5
6-8mm out of the wall. Mount the unit and determine the position of the
hole for the expansion bolt to fixed the unit, then drill the hole and
fasten the bolt.
4. The cold water supply to this unit must be portable & be within the
guidelines of the local authority. Before switching on the power, make
sure that all plumbing connection are completed, and the unit has water
flowing through the unit.
5. The unit must be properly earthed into 15amp power circuit .
6. The unit is only to be installed indoors and in a dry location
7. This heater should not be located where ambient air temp drops below 5℃
8. when connecting hoses to cold and hot
water inlets of the water unit.
DO NOT USE TEFLON TAPE

4
!VII. Precaution & Maintenance
1. The product uses separate 240V~, 50Hz power supply（15A above）
2. The maximum temperature of the hot water from the heater is 50℃.
3. When the unit is turned off and turned on again some care should be
taken as some extremely hot water will be in lines.
4. The water heater should be properly earthed by a qualified electrical
contractor.
5. The heater shall only be installed in a dry place where it is kept away
from water. Never adjust the unit with wet hands.
6. In the event of fault with the heater, contact an authorized electrical
contractor.
7. Clean the water heater with a soft cloth, Never wipe it with detergent
8. Clean the filter installed in the inlet pipe regularly to avoid blockages in
the pipeline.
9. DO NOT turn on the power switch if the water in the tank is frozen.
10. Damaged cable must be replaced by authorized electrical contractor.
11. The maximum water pressure for the unit is 0.6Mpa, and the minimum
is 0.05Mpa. If the range is exceeded, it will lead to the unit failing to
Trouble Cause Solution
No water output
Low flow rate
No heating
No hot water
Output temp. is low
No water supply
valves closed or pipeline restricted
Heating element damaged
Over-heating protector has acted
No power
Leakage circuit breaker cut off
Water flow rate is too high
Check the water supply
Contact your dealer for repair
Check the power is turned on
Circuit leakage,
contact your dealer for repair
decrease water flow rate
VIII. Trouble Shooting
Turn on the water source
/clean the filter

5
Tripping
Screen display E1
Screen display E2
Screen display E3
Power supply is short circuiting
or electric current leakage
Electric current Leakage
Temperature sensor is short circuit
Temperature sensor is open circuit
Cut off the power and
contact your Electrical
Contractor for repairs
Contact your dealer for repair
1
2
3
1 2
88
Electric water
heater
O-ring
1
3 Instruction manual
Expansion bolt
1
High-pressure
connecting pipe
IX Packing List:

6
Warranty details outlined:
The following items are specifically excluded from normal terms or warranty:
We will not incur any obligation or liability whatsoever under warranties for any damage
or harm which may arise directly or indirectly as a result of the water heater being
installed by others than a registered qualified plumber or being connected to a water or
power supply not in accordance with the regulation of the relevant electric, water and
health authorities.
Service costs by others are not covered by the warranty and are at the user's expense.
In the event of any claim being made under the warranty , it is the original purchaser's
responsibility to provide evidence of purchase and date of purchase.
The above warranties shall not apply to such water heater or part there of which in our
opinion has been subject to accident, alteration or any thermostat having fixed
temperature altered, abuse, misuse, has suffered any damage by flood, fire or act of
God or if any repairs have been made or attempted to be made by any person/s not
approved by us. The warranty shall not extend to any loss suffered by or resulting from
the non- operation of the water heater or part thereof.
Notwithstanding anything contained herein, the electric water heater shall continue
to be subject to any implied warranty provided by the trade practices Act 1974, if
and to the extent that the said Act is applicable and prevents the exclusions, restrictions
or modification of that warranty.
This warranty will apply Australia / New Zealand wide for parts only provided the water
heater or part is forwarded carriage paid both ways at owners risk to Gleamous Australia.
A nominal service charge may be made should the appliance be found to be in a normal
working condition.
P.O Box 611 Round Corner NSW 2158 Phone: [phone] Fax: [phone]
Gleamous Australia Pty Ltd
ABN: 150 208 745
Email: [e-mail] Web: www.gleamoushotwater.com.au
Damage as a result of transportation, removal or storage.
Damage due to connection to incorrect water supply.
Damage or faulty operation due to foreign matter in the water supply.
Damage or faulty operation due to the corrosive elements in the water supply.
Gleamous Australia - 2 YEAR WARRANTY*
We warrant parts for Two (2) years Domestic use and One (1) year for commercial use
from date of purchase, Gleamous (model GL5 / DSL / DSK) be free from defects in
material and workmanship under normal use and service. The obligation of Gleamous
Australia under this warranty is limited to repairing or exchanging any part of the water
heater which proves defective within the specified period and which our examination
shall disclose to our satisfaction to be defective.

www.gleamoushotwater.com.au