Gravely REAR PTO User manual

AGIRA/ELY
REAR PTO
OPERATORS MANUAL
FORM NO: 42163 (8-86) PART NO: 42158 PRINTED IN USA

Read this manual carefully
your rear PTO before using it.
and learn to operate and service
To keep
operated as d
the warranty,
i recte<i in this
NOTE
the rear
manual.
PTO must be maintained anci
AII- references to "left-side" r "right-side",
"back" are oiven froni the operatorts position.
ttf rontt'; antl
Use tLre serial nurnber to ensure prompt and correct. service
when orciering parts, requesting service, or making inquiries.
REAR PTO SSRIAi, IJUI.IBER
Look for this
precautions.
YOUR SAFETY IS
symbol to
It means
INVOLVED.
point out important
ATTEI.ITION ! BECOIUE
safety
ALERT !

.d',ft{VUUVlt .L
'9
Y
sNo I J)nuJ,st{ I dti-,ll{s
JSrT SJUVd Ot'lV SJUVd cg,l,vu,Lstl'IT r
g9vuoJ,s 'v
I3I'IVNgJNIV',{ 'e
c
.I
TVnOt{gu cNV IdOIJVI'IVJSNI
NOIJVUI{dO A.{VS UOJ SNOIJJNUJSNI
S.T,Ng,lNOJ

SECTIO}J 1
Tnstructions for Safe Operation
Improper use of this rear PTO can injure people anc.l c'lamage the
equipment, eeople using or servicing this rear PllO nust read ancl
f ollow the instructions in this rnanual. '
It is important to understanci that this manual ancl any other
Gravely instruction manuals do not cover every possible danger.
It is intpossible for Gravely to knovr all possible dangers in
operating and servicing the equipnent.
The purchaser must give these instructions to the people
operating and maintaining ttris rear PTO. These people nust use
eye and foot protection"
1.1 Preparation:
Read the Gravely tractor and tiller operatorIs :nanuals.
Be fanriliar with al-1 conlrols and fol1ow the safety
precaut ions outl ined in these manuals . I(now trow to STOP
the tractor and tiller quickly in an emergency.
Inspect and clear the vrork area (prior to tilling) of
rock s r glass 7 metal, bones r and any other foreign
objects that might be picked up and throvrn or tangled in
the ti11er. Stay alert for holes and other hidden
hazards.
1.
2.
3.
4.
5.
6.
7.
Do not wear loose
might get caught
Keep hands, feet,
parts.
fitting cJ.othing or accessories that
in r,roving parts or on the controls.
hair, clothing, etc., away fron moving
Keep bystanders and pets removed from the work area and
a safe distance away.
Do not allow children to operate the equipment, nor
alIow adults to operate it without their having
knowledge of safe operating practices.
Operate the tiller from the operatorrs position on the
seat of the Gravely.
Keep safety devices, interlocks, and shields in place at
all times.

.uf nlroAo 01 ro?cerl aq1 asnec ^dpru
1eq1 saTlTreTn6arrT raqlo pue rsaqcllp rsaloq roJ lraTp
ag '^dlages rno.d efnsur 01 q6noua Aofs spaads 1e TTT,I
. sopTsTf rq uo pue punor6 q6nor raAo dl,,aOls TITl s,{eaaTv .9
. roTrTl f arvroT uaql , uoT lou plpA.roJ
a6e6ua pup paads punor6 lsanof s I rolcefl oql lcatas .g
.eT11orq1 TTnJ 1e aur6ua
ung 'uoTlTsod 1:odsue:1 ur pasrer raTTTl daal ,ur6aq oJ .V
roJ ) alno.l P ueTd '(uoTlereda:d paqpaas
.paJeATlfnc aq 01 puno:6 aalasqo .E
'ToJluoc 6u1raa1s aseofcur of
sar f ossaccp 1q6r aru pe1sa66ns asn 'uollrsod 1dtlo,, uT oJd
daax 'raTTTl 6ut66e:p pTone 01 urerrel ur sdTp 6utsso:c
uaqn TnJafpc ag 'faTfTl 6ur1:odsupl? uaqn uorlnec asn .Z
.aur6ua 6u11:e1s ofoJaq
raITTl asTeu .^dcua6laua ue ur dllcrnb roTTTl aql dO,tS
01 /'loq Aoux . taTTT? ar{1 6ur6e6uasrp pup 6ur6e6ua tr1eJes
roJ sTpnueu s,:oleredo reTTTl pue lolcp.r? aql peag . T
:uor1e:adg e.T
'sTpcap uo palsTT suorlcnrlsuT lltorToJ .tT
' sTenueu s, role:ado OJd rea.r pue
,raTTTl ,ro1ce:1 aq? uT pa1carrp se luaudlnba aql daey
'uoTlTpuoc poo6 ur O,Id .real pue laTTTl aq? urelureN .ef
.6uT 1q6T I
elenbape lnoqlrA Irpp ralJe luaudrnba aql asn 1ou oO .ZI
'ourqceu aq1 6urneal STOTSt[ raTTTl ranoT pue
uor11sod,,J.{O,, aql ur O,ld aql 1nd pup aur6ua dO,lS s^ernle
--papualleun uar{A Suruunr luaudrnba aq? aleaT .raAai.I . TT
'luaudrnba eq1 6ut1:e1ser aroJaq
pa:reda: aq lsnu a6euep ,{uv 'a6euep roJ 6urlcadsul
5-f6'l-q raTTTl .raAoT pue ruor1lsod,.d"{Ou aql uT OJd aql
lnd 'eutbua eq+ dOJS ,1ce[qo ubra:oy e 6ur1rr1s ]alJV .07
trol-dtt au16ua aql do,rs pue raTrTl aql ;lt;:,r#t"3$i::lA .6
aou sT raTTTl aqr uaq/,r ""r;n""1f,i"r:?l #tt"J."Jrjo"u'i".Xl .8

7. I?hen tilling loose ground (we11 established loamy garden
soil), increase ground speed to cover more ground in
less time and stil1 do a good job.
B. Do not back up with tiller down. Raise ti1ler to
transport position before backing up or turning sharply.
9. Do not stop or start suddenly when going up or dovrnhill.
10. Avoid steep hillside operation which could cause the
tractor to overturn. Reduce speed when turning so there
is no danger of the tractor overturning.
11. A1ways l"ook behind you when backing up.
3

'uoT?Tsod
uNOr aq1 uT 1nd ST TOf luoc O,ld aql AloJaq ||.{JOu sT AuT6ua
oql arns ag 'ssacord uorleTrelsuT aq1 asfaAaf ,aAouol oJ 6.2
'xoq urPqc aq1 pup aurefJ .rolcerl eq1 01 lalcprq
aql lcauuoc qcTqA lToq "g/E pue lToq "z/I eql ualqbrJ g.z
'1Toq aq? uo 1nu
IcoT P 1nd '1al3erq aq1 q6norql lToq aql apTTs pup lToq aql
uo raqse/q lpTJ o1'r1 lnd 'apTslno aql urofJ auerJ to13ef1 aq4
q6norqt lsnF ?T apTfs pue lToq "Z/T oq1 uo roqsen leTJ p ?nd L.Z
'lnu lcoT pue
lToq e q1T^l lJeqs aq1 01 l}eqs aAr.rp Tes.laArun aq1 urElau g. z
'1}eqs oATrp TesranTun aql Jo a{o^ aql uT
atoq aql LIIT^I subrTe lJpqs aql ur aToq aql 1eq1 os lJeqs aq1
a1elou 'faurelaf 6urrpaq aTxe aq1 uT l}eqs aq1 oluo l}eqs
aATrp Tesraarun ag+ 6urprn6 atTqA dn xoq uTpqJ ar{1 6urng S. Z
'uorlrsod ld1u ar{l 01 xoq ureqJ aq1 uo fa{cprq aq4 aAoW V.C,
. uor qr sod s J.|IO u
aq1 ur To.rluoc OId aq1 uoTlTsoda: 01 a.rns eg '1srsse TITA
(llo aur6ua) uorlrsod uNO,, aql ur O;,d oq1 6ur11n6 .ace1d
ur sl3oT 1T TTlun lJpqs o,Id uorssTrusupfl ar{1 uo qlloJ
pue 1ceq xoq rea6 aql apTTs pue rpTToc 6ur1co1 oql aseaTag
'4Jeqs O;d uorssrursuer? aq1 oluo 1T 6urprls aTTqA uollrsod
ur qT pToq pue xoq uTeqr aq1 uo reTToc 6ut1co1 aql sse:deq t.Z
'uorlrsod
,,NOu aq1 ur Torluoc OJd or{1 1nd pue ,,J,EOu eut6uo oq1 urn6, Z. Z
'asear6 qlTA slJpr{s asaql leoJ '1Jeqs
O;d aql pue rauTelor 6ulreeq aTxe oql uT lJeqs aql ueaT3 I'2,
Tenouau pue uorfeTTPfsuI
Z NOI.IJSS

SECTION 3
Iulaintenance
3. I Apply grease to the shaft bearings in the axle bearing
retainer after every B hours of use. Apply multi-purpose
grease to Lhe grease fitting until it comes out qround the
sha ft .
3.2 Check tire oil level in the chain box after every 40 hours of
use. Flold the gear box in a vertical position. Remove the
lower plug (see Figure l). Fi11 with sAE 30I/J-40 oil until
it is level with the ho1e. Replace the plug.
I - Pipe Plug
2 - Vent Plug
FIGURE 1
l
d

'xoq uTeqc ael Jo do1 aq1 le 6n1d paluaA aqf Jo
1no unr lou saop TTo ?eq1 os pauorlrsod aceld .f,rp B ur arols t.t
'reTfoc 6ur>1co1 aq1 TTO
' reTToc 6ur 1co1 aq1 1e saul lds lJeqs O,ld aql pue seur 1ds
aloF fpsraaTun rear aq1 uo asear6 Jo UITTJ e 1nd pup ueaTC Z. V
'.rolcefl aq1 urofJ ?alcprq o$d
fBaf pup lJeqs aATfp r{1TA,tlqurasse xoq uTeqc o.ld.rpaf oAouau T.?
e6Er-o$
? NOI.IJSS
t
I
I'
I

SECTION 5
Illustrated Parts ancl Parts List
\ft
nJ. \
\€
b-n
W
"(')
//
YJ I-
N-'g;\', \\$
\\
=-\

'9 'oN ura?I Jo xTs pue vv-l.v '6c-gz
t9Z-ZZ sraqurnN ulalf sapnTJur 09TZV 'oN ?red 'gV 'oN urall :g,lON
uTeq3 aATrq ,dlqruessg
?uo.rd '6u1snop
Taols pH bS 0S' adTa '6nTd
palua^ '6nTd
00.Zx9T-glE xaH ,1Tog
09'ZxgT-g/E xag ,lTog
oceu lsnfq;, '6urreag
lJeqs
8/e 'TTeg
qlaal tT qolTd g/9 '1a1co:dg
lJBI{S
I9# prPH gZ9'xAgt' J;nrpoog ,XaX
0g'xgLg'Tx00g't aTpoaN,6utreeg
raTToU'uTeqJ
laIsPg
feog '6u1snog
6ururelag ,6rTU
zTE'x 9ZT'2,x009'T TTO 'rees
lJeqs
6u1ure1ag ,6rTU
fauuJ,rauTelog
6ur:dg
fpTToJ
deug '6tTU
(reo6) aar:g 'lJeqs
!Z-V/T lcoT '1nN
00.ZXOZ-V/I xap, ,1fog
aer6eq 06 aqnT '6uTllTJ
00. Tx EI-7,/I xe1p- ,1Tog
lalsp0
000'TxBAE' fxeOO'I azuolg,6ur:eag
faurelag aTxV,ztlqruessg
009'xOgZ' ZxOgZ' I TTPg r6ur:eag
6uru1e1ag ,6rTU
aTxV TTO , TBoS
lJBI{S O0'I 6uru1e1ag '6rTU
lsnrq[ aTpaaN '6ut:eag
lsnfq; burreeg ,oceg
luToC-O :1edag '1TX
9I-B/E IcoT 'lnN
O,ld -reag ,1e1ce:g
tr-z/T rcor '1nN
€90'x092'Tx009' lpTJ,:aqse6
lJeqs
00.ZxtT-Z/T xag ,lTog
NOIJdIUJSgC
UV
I
T
T
9
T
v
T
e
z
T
z
v
T
T
T
v
v
T
T
T
T
T
t
T
7,
z
T
z
T
z
T
T
I
z
T
z
v
T
L
T
I
t
T
T
'I'.l0
09TZV
6V687
088 g 0r
8968r
OETOST
'ET08 I
?968 T
966 Tt
ev99vT
€968 T
99687
L8 LIEV
OE68 I
1968 T
89687
B?687
0968r
T968 T
7,L687
29687
966IV
66 L9E
00898
I089E
TT6B T
v9v6IV
??008I
T,EOTTV
ETIOBT
OEOS I
LL6ET
TTB 'E62087
ZTBS I
TTOBI
LB6VI
9ZZTT
O'E6T
099V2
?0099 ?
LO LOV
1099t?
68 €0Zr
B 0t0?
T8 I08 T
'oN ,luvd
9V
vv
E'
zt
T?
0?
6g
BT
LE
9g
9g
NE
€t
zt.
TT
OE
6Z
8Z
LZ
9Z
9Z
v7,
E7,
cu
IZ
07,
6T
8I
LT.
9I
9T
?I
EI
ZT
TI
OI
6
8
L
9
E
v
€
z
T
'oN
i,{gIr

6.1
SECTION 6
Set-Up Instructions
Axle Bearing Retainer Assembly (refer to the illustration):
1. Clean the transmission drain plug and adjacent area.
2. Drain transmission oil into a clean container.
3. Raise and block the right drive wheel. Remove the tire-
wheel assembly.
4. Remove the nut and flat washer on the axle. Remove the
wheel hub with a puller.
5. Remove the axle key and the bolts attaching the rear
hitch to the axle bearing retainer.
6. Remove the four boLts holding the axle bearing retainer
and slide from the axle.
7. Clean all gasket residue from the end of the axle
housing.
8. Wipe the axle clean and apply a film of grease. tr^Iipe a
film of grease on the axl-e gasket and stick it on the
end of the axle housing with the four holes aligned.
9. Apply grease to the seals in the new axle bearing
retainer. Carefully slide the nevr axle bearing retainer
assembly into place over the axle and secure with the
L/2" bolts which vrere removed.
10. Fasten the rear hitch to the nevr axle bearing retainer
casting with the two new L/ZxL bolts coated rrith locking
compound. It may be necessary to loosen the bolts in
the rear hitch arm that hold the rear hit,ch to align the
new bolts in the axle bearing retainer.
11. Put the key in the axler slide the wheel hub on the
axler followed by a flat washer. Retain with a lock
nut.
L2. Replace the tire-wheel assembly. _
I3. Put oil in the transmission. Use the drained oi1 only
if it is clean.
o

OL
'xoq uTeqc aq? Jo apTs .rea.r aq? oluT lJpqs aq+ apTIS .t
'1nu looT pup lToq ZxV/t e qlTA arncas .ubr1e saToq
aql lpr{l os elod fes.ralrun aq1 oluT lJeqs ar{l apTfS .Z
'asooT lToq aq1 eAeaT 'Jnu IOoT pue ?Toq g/E e
qlTr xoq uTpqc aql Jo apTs .rpar aql o? lalcprq aql lTos . r
: (uorlerlsnTfr aql 01 :eJar) 6fquassv xog uTeq3 Z. g
'?JBqs aql ?e s:paddB 1T TTlun
6uT qlT g asea:6 aqA le 6ur : eaq lJ er-is aql of asea:6 dlddV . EI
.aaoo.r6 aq? ur
slpas 1T leql eJns eleur pup lJeqs aqf uo 6ur:6ururpla.r
aq1 lnd 'lJer-{s aql oluo ace.r lsnrqf pue ,6uT.rpaq lsnJq1
'acer f sn.rql p aopTd '.raurplaf 6ur:eaq aTxp aq? Jo .reef
aql oluT ?Jpr-{s aql l.rasur '1Jpqs paurlds aq1 oluo acer
lsnJq1 f aqloup pue 6ur:eaq ?snrql e , acp.r ?snlql E apT TS ' tf

SECTION 7
LIMITED FIVE.YEAR WARRANTY
3.
This Limited Five-Year Warranly is issued by Gravely
lnternational, lnc., only to the original purchaser. lf
Gravely equipment is leased by Gravely, this Warranly
shall extend also lo the original lessee as il such
lessee were the original purchaser.
Gravely warrants that all new equipment manu-
laclured by Gravely ("Gravely Products") shall be free
of defects in malerial and workmanship for the term
described in paragraph 4, below. Except as hereinafler
provided, lhis Warranty does nol cover any engine,
tires or battery lorming a part of the Gravely Product.
Engine arrd tires are covered by and subject to
separate wa(anlies of the manufacturers thereof.
ln the event that any Gravely Product warranted
hereurrder shall be def ective or tail lo conform with this
Warranty, Gravely shall, subject 10 the provrsions
hereof, pay for, or provide labor and materials for, the
repair or replacemenl of such defective Gravely
Product.
This Warranty is for live years (60 months) from
purchase date for Gravely Products used exclusively
lor personal, family or household purposes, and two
years (24 months) for products used for other
purposes (commercial use), excluding rental firms.
Gravely products used for rental purposes will bs
warranted for g0 days. Repair of Gravely Products
after the second year (24 months lrom date ol
purchase) shall be subjecl to a $50.00 deductible lor
each repair. (After two years, Gravely agrees to repair
or replace delective Gravely Products used ex-
clusively lor personal, family or household purposes
only to the extenl that the cost of such warranly
covered repair or replacemenl exceeds $50.00.)
Batteries are warranted by Gravely for a period of
lwelve (12) months only. lf a battery shall fail wilhin
twelve (12) months of purchase, the replacemenl cosl
thereof shall be prorated over a lwelve-month term
based upon the nurnber of months since purchase,
To obtain Warranly Service on a Gravely Product
(including any battery or olher component not manu-
lactuted by Gravely), use this procedure:
a. Notily the Gravely dealer from whom you pur-
chased the equipment.
b. ll you have moved and it is nol convenient to notity
the selling dealer, notify the nearest Gravely
dealer. You should supply this dealer with a copy
of the bill of sale as prool of the date of purchase.
c. Make arrangements lo have the equipment de-
livered to the dealer (refer to paragraph 6 a.,
below).
d. ll you have any questions concerning the Gravely
Limited Warranty, they should be referred to:
Gravely lnternational, lnc.
One Gravely Lane
Clemmons, NC 27012
Attn: Customer Service Department
e. Warranty service on Gravely Products must be
performed by an authorized Gravely dealer.
6. This Warranty does not cover the following:
a. Transporlation lo the Gravely dealership. (ll the
Gravely dealer provides transportatjon, he will
charge for such service.)
b. t Normal mainlenance services and normal re-
placement of items such as spark plugs, belts, oil,
oil filters, air fillers, and mower, plow or cultivator
blades, gauge wheels, skids and olher wear items.
c. Any Gravely Product which has been allered or
modified in any way.
d. Any repair or replacement occasioneC by cus-
tomer neglect or lack of proper maintenance (The
purchaser is responsible lor making sure that
Gravely Products are operated and servjced as
drrected in the applicable manual or servtce
inslruction. Incorrect use or maintenance willvoid
this Warranty.)
e. Any repair occasioned by the use ot any
altachmenl not approved by Gravely. (The use cl
any such unapproved attachment will void this
Warranty.)
7, GRAVELY MAKES NO OTHER EXPRESS OR
IMPLIED WARRANTIES, OR WARRANTIES AS TO
THE MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, ALI- WARRANTIES ARE
LIMITED IN DURATION TO THE TERMS SET OUT IN
PARAGBAPH 4, ABOVE. GRAVELY SHALL HAVE NO
LIABILITY FOR INCIDENTAL OR CONSEOUENIIAL
DAMAGES RESULTING FROM THE BREACH OF
ANY WARRANTY, INCLUDING, BUT NOT LIT/ITED
TO, LIABILITY FOR INCONVENIENCE, BENTAL OR
PURCHASE OF REPLACEMi:NT EOUIPMENT. OR
FOR LOSS OF PROFITS OR OTI-IER COI.4[/ERCIAL
LOSS.
B. Some states do not allow limrtations on how long an
implied warranty lasts, so the above statement may not.
apply to you. Some stales do not allow the exclusion-
or limitation of incidental or consequential damages,
so the above limitalion or exclusion may not apply lo
you.
L This Warranty gives you specific legal rights, and you
may have other rights which !,ary lrom state to state.
10. A Gravely product registration card is supplied with
each Gravely Product. Please complete the card and
relurn it to Gravely at the address listed on the card.
The equipment registration card will be used by
Gravely for:
a. Becording date of purchase.
b. Notification of owners in compliance with the
Consumer Product Safety Act, should any notifi-
cation be necessary.
The return of such card is necessary for your warranty
to be effective.
1 l. This Warranty is not subject lo change or modification
by anyone, including Gravely dealers and no Gravely
dealer is authorized to make any represenlations or
promises on Gravely's behalf.
AGHAVELY
One Gravely Lane, Clemmons, NC 27012
5.
1'1