Hamilton Beach D43012B - Commercial BrewStation Coffeemaker User manual

840160000
Coffeemaker
Cafetière
READ BEFORE USE
LIRE AVANT L’UTILISATION
English.......................................................................................... 2
USA: 1-800-851-8900
Visit hamiltonbeach.com for delicious recipes and to register your product online!
Français ............................................................................................ 13
Canada : 1-800-267-2826
Consulter hamiltonbeach.ca pour des recettes délicieuses et pour
enregistrer votre produit !
840160000 ENv03.qxd 4/5/07 8:49 AM Page 1

2
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety precautions should always be followed to
reduce the risk of fire, electric shock, and/or injury to persons, including the following:
1. Read all instructions.
2. Do not touch hot surfaces. Use handles
or knobs. Care must be taken, as burns
can occur from touching hot parts or
from spilled, hot liquid.
3. To protect against electric shock, do
not place cord, plug or BrewStation in
water or other liquid.
4. Close supervision is necessary when
any appliance is used by or near
children.
5. Unplug from outlet when either the
BrewStation or clock is not in use and
before cleaning. Allow to cool before
putting on or taking off parts and before
cleaning the appliance.
6. BrewStation must be operated on a flat
surface away from the edge of counter
to prevent accidental tipping.
7. Do not operate any appliance with a
damaged cord or plug, or after the
appliance malfunctions or is dropped or
damaged in any manner. Call our toll-
free customer service number for
information on examination, repair, or
adjustment.
8. The use of accessory attachments not
recommended by Hamilton Beach/
Proctor-Silex, Inc. may cause injuries.
9. Do not use outdoors.
10. Do not let cord hang over edge of table
or counter or touch hot surfaces,
including stove.
11. The coffee tank is designed for use with
this BrewStation. It must never be used
on a range top or in a microwave oven.
12. Do not place BrewStation on or near a
hot gas or electric burner or in a heated
oven.
840160000 ENv03.qxd 4/5/07 8:49 AM Page 2

3
Other Consumer Safety Information
This appliance is intended for household
use only.
This appliance has a polarized plug (one
blade is wider than the other). To reduce
the risk of electric shock, this plug is
intended to fit into a polarized outlet only
one way. If the plug does not fit fully into
the outlet, reverse the plug. If it still does
not fit, contact a qualified electrician. Do
not attempt to modify the plug in any way.
The length of the cord used on this appli-
ance was selected to reduce the hazards
of becoming tangled in, or tripping over a
longer cord. If a longer cord is necessary an
approved extension cord may be used. The
electrical rating of the extension cord must
be equal to or greater than the rating of the
BrewStation. Care must be taken to
arrange the extension cord so that it will
not drape over the countertop or tabletop
where it can be pulled on by children or
accidentally tripped over.
To avoid an electrical circuit overload, do
not use another high wattage appliance on
the same circuit with your BrewStation.
If the BrewStation overflows during brew-
ing, always allow unit to cool before
cleaning unit, coffee and grounds.
SAVE THESE INSTRUCTIONS!
13. To disconnect BrewStation, turn
controls to OFF, then remove plug
from wall outlet.
14. Scalding may occur if the cover is lifted
during the brewing cycle.
15. Warning: To reduce the risk of fire or
electric shock, do not remove the
bottom cover. No user serviceable parts
are inside. Repair should be done by
authorized service personnel only.
16. Do not use appliance for other than
intended use.
840160000 ENv03.qxd 4/5/07 8:49 AM Page 3

4
Parts and Features
Optional Accessories
To Order Call:
1-800-851-8900 (U.S.) • 1-800-267-2826 (Canada)
hbaccessories.com
D
ESCALER
Filter
Basket
Water Level
Guide
Coffee
Tank
Coffee
Level
Guide
Water Level
Guide
Coffee
Dispenser
Bar
Drip Tray
Water
Reservoir
Keep Hot
Plate
Permanent
Gold Tone
Filter
Water
Filter Lid
Water
Filter
Water Filter
Base
Coffee
Scoop
CleanCaf™
Cleaner
and Descaler
Coffee Tank
Screen
840160000 ENv03.qxd 4/5/07 8:49 AM Page 4

5
How to Make Coffee
1. To ensure best possible taste, before
first use, clean
the unit by
brewing at least
one complete
cycle using
water only (no
coffee).
2. For optional features only:
A.) If your model has a water filter,
follow steps list-
ed in “Optional
Features.” A
water filter is
not required to
make coffee in
the BrewStation.
B.) If your model has a clock, set
clock before first
use by pressing
Hand then M.
Follow the
instructions in
Optional
Features.
3. Fill coffee tank with desired amount
of cold water.
Holding coffee
tank level, use
Water Level
Guide on coffee
tank to ensure
correct amount
of water. Do not
exceed the
12 cup level.
4. Pour water from coffee tank into
water reservoir.
5. Place coffee tank on Keep Warm
Plate.
6. For each cup of coffee being made,
neatly place 3/4
tablespoon of
automatic drip
ground coffee
in a good quali-
ty cupcake
(basket) style
filter (8 to 12
cup size). A
permanent filter may also be used.
Do not get any grounds inside the
coffee tank.
7. Close lid; make sure it is fully closed.
8. Clock model: press Auto/ON/OFF
twice for coffee
now and light
will glow. When
button is
pressed only
once, the light
will blink slowly.
Press button
once more to
brew. To brew later, see “To Program
Automatic Brew” in “Optional
Features.”
Non-clock model: press ON/OFF
button once for
coffee now and
light will glow.
D
ESCALER
840160000 ENv03.qxd 4/5/07 8:49 AM Page 5

6
How to Make Coffee (cont.)
9. DO NOT open lid during and just
after brewing
to preserve the
coffee’s heat
and flavor. Do
not remove
coffee tank
while brewing
light is on or
coffee is hot.
10. To dispense coffee, press dispenser
with a cup.
Remove cup
when desired
amount has
been dispensed.
Coffee may be
dispensed dur-
ing and after
brewing. If
BrewStation overflows, allow the
unit, coffee and grounds to cool
before cleaning the unit, coffee or
grounds.
11. The BrewStation features a two-
hour automatic
shut off. To
turn off sooner,
press ON/OFF
button and
indicator light
will go out.
12. When finished, push ON/OFF
button to turn off, then unplug
BrewStation. Do not open cof-
feemaker until it has been turned off.
Always allow to cool before cleaning.
Never use coffee tank to pour or
carry hot coffee. Handle coffee tank
only when holding cold water for
filling water reservoir and to clean
tank after BrewStation has been
shut off and the coffee is cool.
NOTE: Care should be taken when
handling the coffee tank after brewing.
840160000 ENv03.qxd 4/5/07 8:49 AM Page 6

7
Optional Features
To Set Clock:
1. Plug in BrewStation. Numbers on the
clock will flash until you set time of
day or one minute elapses.
2. To set time of day, press Hbutton to
set current hour
with AM or PM
as indicated on
left of the clock.
3. Press Mbutton until you reach the
current time.
To Program Automatic Brew:
1. Make sure clock is set for correct
time of day.
2. Press Prog button and digits will
flash.
3. Press Hand Mbuttons until desired
brewing time is
reached.
4. Press Prog button to confirm setting.
Digits will stop
flashing and
return to set
time of day.
5. Push Auto/ON/OFF button once and
“PRO” will be shown in display and
the ON/OFF light will flash indicating
the brew cycle will begin at the set
time.
NOTE: If the Auto/ON/OFF button
is pushed twice, the ON/OFF light
will glow and brewing will begin
immediately. Simply press the
ON/OFF button once to turn off and
once more to set programming mode.
6. Follow steps 3-12 in “How to Make
Coffee.”
840160000 ENv03.qxd 4/5/07 8:49 AM Page 7

8
Optional Accessories
Water Filter
1. Before first use, soak water filter in
cold tap water
for 15 minutes.
Then rinse
under cold run-
ning tap water
for 15 seconds.
2. Insert filter in base. Snap lid onto
base.
3. Place filter and filter holder in reser-
voir.
4. Replace after 60 brew cycles of
coffee. Set your replacement month
by aligning the arrow with the month
you expect will represent 60 brew
cycles.
5. To replace, pull up on lid of filter
holder while holding filter base, turn
filter base to allow filter to drop out.
Permanent Filter
The Permanent Filter takes the place of
disposable paper filters. Simply place
the Permanent Filter in the filter bas-
ket. Rinse the Permanent Filter in hot
water before first use. Clean the
Permanent Filter under hot running
water and let dry. Permanent Filter can
be placed in top rack of automatic
dishwasher.
Cleaner and Descaler
Coffeemaker cleaner and descaler pre-
vents hard water deposits that affect
the coffeemaker’s performance and
removes coffee stains. Usage frequen-
cy depends on local water quality. Use
cleaner at least once a month.
BrewStations used in areas with hard
water may require weekly cleaning.
840160000 ENv03.qxd 4/5/07 8:49 AM Page 8

9
Cleaning Instructions
To maintain the performance of your
BrewStation, clean once a month.
Cleaning the BrewStation removes
mineral deposits that slow down brew
time and result in poor coffee taste.
BrewStations used in an area with hard
water require more frequent cleaning
(such as weekly).
To Clean Inside of BrewStation:
1. Remove water filter and water filter
holder (optional
feature).
2. Plug in BrewStation and set the
clock (on clock model).
3. Place empty coffee tank on Keep
Warm Plate.
Place filter bas-
ket on coffee
tank. Do not
add coffee into
filter basket.
4. Use any commercially-available
coffeemaker
cleaner and
descaler intend-
ed for home
use. Follow
package direc-
tions. After using
descaler, rinse
BrewStation
coffeemaker by brewing twice with
water only.
To order a cleaner, call:
1-800-851-8900 (U.S.)
01-800-71-16-100 (Mexico)
or online: hbaccessories.com
NOTE: Commercially-available
brands of descaler include
CleanCaf™or white vinegar.
5. To turn ON, press ON button and
light will glow.
After 20 sec-
onds turn OFF.
6. Wait 20 minutes to allow the
descaler to clean. Then turn ON
again. When the brew cycle is
finished, turn OFF. Wait for
BrewStation and water in coffee
tank to cool, then empty coffee
tank and rinse.
7. Pour one coffee tank of cold tap
water into the
reservoir. Place
coffee tank on
Keep Warm
Plate.
8. To turn ON, press Auto/ON/OFF
button twice for
clock model or
once for non-
clock model.
When the brew
cycle is finished,
allow
BrewStation to
cool and empty
coffee tank. Run 2-3 more cycles
with clean, cold water. Allow to cool
between cycles.
9. Turn OFF when complete.
10. Wash coffee tank and brew basket.
Your BrewStation is now ready to
brew coffee.
D
ESCALER
WARNING: Electronic Shock Hazard. Do not immerse coffeemaker, cord,
or plug in water or any other liquid.
840160000 ENv03.qxd 4/5/07 8:49 AM Page 9

10
To Clean Coffee Tank Filter:
1. Lift up on screen to remove it from
coffee tank.
Rinse screen
under stream of
water to flush
screen clean.
2. The screen snaps back into position
over the seal in
coffee tank.
To order replacment screens:
1-800-851-8900 (U.S.)
1-800-267-2826 (Canada)
or online: hbaccessories.com
To Clean Coffee Grounds or
Foreign Matter from Coffee Tank:
Over the sink, turn the coffee tank
upside-down then press lever and
flush with water for 30 seconds to
remove coffee grounds.
To Clean Coffee Tank, Drip Tray
and Filter Basket:
Coffee tank, drip tray, and filter basket
should be washed in hot, soapy water.
Drip tray and filter basket may be
washed on the top rack of the dish-
washer. Do not clean coffee tank in
dishwasher.
To Remove Coffee Stains from
Coffee Tank:
Follow the directions on any
commercially-available coffeemaker
cleaner and descaler intended for
home use.
Inside of
Coffee Tank
Cleaning Instructions (cont.)
Bottom of Coffee Tank
FLUSH
HERE PRESS
LEVER
HERE
840160000 ENv03.qxd 4/5/07 8:49 AM Page 10