Heatilator A36R User manual
1
ners anal
nin n in
dels:
A36 A36H
A42 A42H
d rning irelae
D DAD H AA
N
mn in
n minnn
inin in.
i mn i
ni
n in.
nn
n
inin
inin n
in.
DO NOT
DISCARD
nin n i i
m i nn.
m ni
i -in in
niin i n
i in. ire is
i i i
in n.
D in nn .
A
the inrmatin in these instr
tins is nt lled eatl a
re ma reslt asing rert
damage ersnal inr r death.
n in m-
m n ii in iini
i n in.
n . in i i
n.
m i minimm n
mi i. i
m m .
A A
Ht sreen/mesh and glass drs ill ase brns.
N n/m ni
in n/m
in
in in m m
.
in n i
m.
High temeratres ma ignite lthing r ther
ammable materials.
in ni i n
mm mi .
H A
n/m
n
in in
n.
i 3 4 3 /1
ead this manal bere installing r erating this relae.
lease retain this ners manal r tre reerene.
Hmener eerene nrmatin
m /in
i m in n
i m n
mmnininn
inmin
isting abel nrmatin/atin
m inmin in i n n n in n m i
.
ngratlatins
rate irelae
del
erial
mber
i 3 4 3 /1
nin n in i nin
. i i
in i m in n iii.
n n n n
inin nin in i
n mn. i nin in n
nin.
i n mn in -
n. i i imn
mn n mn.
n i nin i i
n - nmn. -
m i mi
A .
D .
D .
. DA
WARNING: RISK OF
FIRE DAMAGE. REPLACE
GRATE WITH HEARTH & HOME
TECHNOLOGIES INC.
HA DD H HAH H H . D A A. AA AD
A H D. HAH H H . A D A AD H .
A A
AAD H
AA
:
H
2 . .
.
.
A
D .
AD A
11 0/60 H. A.
D . : D D
D DA A AA. D A
A H D
D H H D. D
A D A A H D
D . H A
DA A AA H A
AD DA H .
A H A HA D H A D
A . D H D
A A D A A.
A H AA A .
AA A A
A: HAH H H .
11 . AD . . AA A 2641.
3
aet Alert e:
N ni iin i i n i i in i in.
NN ni iin i i n i in i in.
N ni iin i i n i in min m in.
N: ni i i m m .
!
able ntents
nin
n 4
1 isting and de Arals 6
. in iin
. n-mi i
. mi i
ser ide
2 erating nstrtins
. i
. n
. in i
.
. in
. m
.
.
. i i (in)
. n i
. in mnn
.
. 10
3 aintenane and erie 11
. i 11
. imn nin/nin 11
. i 1
. n 1
. nin 1
4 rbleshting ide 13
nstaller ide
etting tarted 14
. i i m 14
. in n nin niin 15
. 15
. i 15
. in i imn 1
. n i 1
. i i m 1
. n i n mnn 1
6 raming learanes 18
. i in 1
. n 1
. i/n 0
. m i 0
nstallatin irelae 21
. in ni 1
. iin i 1
. i i 1
. i 1
. n i i i 3
8 himne Assembl 24
. imn imn 5
. in /n
. min imn in
. n imn i i
. nin iin i
. nin i nin i
. in
. m nin
. n in
. imn minin imn 30
hase nstallatins 31
. n 31
. n i imn 3
. n 3
. n minin 33
10 hrds 3
. iin i 35
. i n 35
11 inishing 3
. n-mi i 3
. mi i 3
. nin 3
. iniin i 3
. mi n 3
. i/n 40
12 Aessries 41
. /i iin 41
. nin n 41
13 eerene aterials 42
. i imnin 4
. i mnn 43
. imn mnn 44
. i 4
. n nmin 50
te: n ( n in ini n in nn.
i 3 4 3 /1
4
arrant
401-45 1--10 1
Hearth Hme ehnlgies n.
D AA
m ni n. n i n () n in n
n i in m n i .
AA A:
n iin n in i inin n n n in ni
in i inin iin in iin in
i m in mi n mni im mn. inin i m-
nn mn n i in mi mni in i n i
i i in i mnn. i n iin m i i
iin n ni in i nin ii i
i. mimm mn n i n i imi i . i n
i niin in n imiin i .
AA D:
n in n iin . n n m nin n
in n i n in i mn n innn
i / ii i i. n mmn n n 4 mn
in imn m inin n . n i
n mnn i in in .
m imi iim in i in 0 m innin n
in n 10 m innin n n in.
im i minimm i in mnn n nm in niin.
niin in n imiin n n .
i nin
n mi
niin
in n imiin
i
ni ni mnn
n
-in
n
i n n
5 1 in n
3 ni
imn n minin
10
1 n n
imi
iim
3 i n n
mn
n n i
n i n in n nin
1
mnn
3
0
i 3 4 3 /1
5
401-45 1--10
AA D:
i n n in n i ii. i
i i i n n i.
i n i n i i in min i iin inin.
n inin n i. inin i n i n n
n i i. iin i m i in n i
m n m m iin .
i in n n n nin n . n iin
n i n.
his arrant is id i:
in n -i in m nmin in in min
mi. -iin n inii n imi in in
in n iin nm ini.
in i n i mn nnin.
i n m in mnn m i i
n imi im imn nin inin.
A A:
n i m n iin n i n n n n
imi in n i imi mn i n ii . n n
n i i n inin nni m in in. m
n in imiin inin n
ni m imiin m n .
i n i ii i m i i m .
.
.
AA :
i n n in
n in ini nm . in in m n in ini n
i ini m . i i n n i n n n.
m in nm inin in mi m im
n n i n m i n i.
i mn nm n in n i.
in in n ii m i i i n i-
in .
in nin nin mmn in in ni. niin nm n m-
in i ni n i n.
m in m (1) i in minin in in n i inin
inin in inin n iin n iniiin ni i in () i
in in in n i iin (3) iin im nin (4) im -
in mi nin in i m i mnn in im/
in m i (5) ninmn niin in niin ni in
i nin iniin m- i nin i n
i n () n ii in in inin ()
inin mnn n i i in n mnn n i
n () miiin in n i n in iin
n/ () inin in i in.
n- nin mnn mnn i in nnin i in.
n -iin i m in i n in i in i in.
iin n i n n n in ii i . nm-
in i i i nm n in in in iin. ni-
in m in in in n niin ninmn niin inin n i in
.
i 3 4 3 /1
1 isting and de Arals
N: i i i n
i.nim
ininiinin.
NNoemni
iimnniiinnn
niiniiinin.
N:
inm
mi
in n in m
ni
i min
mnn
innnn
innmnnnm
ni
inmnnni
m inin mn in i
minnn n in m.
in iin inmin n i
inin.
. nmbstible aterials
i i i n ini n n m
n minin in
- - n
- i - i
- n -
- -
i in A 136 tandard
est ethd r ehair etals in a ertial be
rnae at 0
. mbstible aterials
i m i n in
mi
- - m
- n - i
n mi n ini n n m
n n-
i 3 4 3 /1
A. Aliane ertiatin
i m n n i in -
n i 1 n -10 n n-
i i n. inin n in in
ni n n.
i m in in in m -
in mn m. in i
iin in m
m.
i n n i i
in mnn i in i mn. -
in mnn m n in-
. nin n i i i i
i inin nin n i i in
im inin.
i i i m m
ni n.
2 erating nstrtins
NNNinnnninininin.i
ininininin.
ser ide
A
Ht glass ill ase brns.
D ni i i
in
in
in in m m .
in n i m.
High temeratres ma ignite lthing r ther ammable materials.
in ni i n mm mi .
H A
n in in n.
igre 2.1 eneral erating arts
A. r irelae
in m m in n i i mmn i i
n. in.
n n
in ..
i
(n n)
in ..
in
(n n)
in ..
(n n)
in ..
in ..
in ..
in ..
in ..
n
n
n
m
n
in ..
i i i
n
in ..
i 3 4 3 /1
m i
i n in n m
n n in . m ni
n ini . i i ni
nm.
-n ( in ..).
n m n iin.
m i n
.
n inin m i m
n n .
-m i
m i in -. i
nin n n m
mmn.
i m ini inin.
m i ni m
n i.
minimm i i i
min i n m
n m.
. tarting a ire
N:minm
iinm.
NNoemimi
innmmnii
.
N:
mmmi
in nn n i
iimiiinini
.
mmiimi
iiin.mimimini.
. easned d
n i imn
in . nin
m nin nn .
n i i i i n i
i mi nn n 0.
min n i i
n. i i i n i in
n n i. i n ii i
in i n nn .
n n n i i i
m i mi nn n i i n i
.
in .. m i.
Nnininii
inmiiinniiinii.
eooto
D. rate
i i in i -
i i i ni n . i
n im n i n in -
mn.
NNoeni
in.
in.
iiinn.
. iresreen
n i i n . i
n i in .
NNoeo
n i n n nin mi m in
.
nnm.
. le Damer
i .1 in n.
in n iin (n
) in in .
iin i n iin
in m ini .
NNoeton
miin.m
nimnm
inm.
. eratr
i i nin n i
n i ini.
i n im n i n in
mn. m iin n iin
nm n n i .
( minnn in 3..)
NNoeNni
.ni
mnin.
i 3 4 3 /1
igre 2.2 erating sitins ild Drs
NNoeoei
iini
n.
nnmmn
nin.
. tside Air tinal
i i i i m min i
. m ni
i . ( in 5..)
i .1 in n
in n n
i n in .
Noiin
niniinin.
iin.
NNoen
mnin.
in.
i . m.
H. lass Drs
4 in. (11 mm)
n i
1 in. (305 mm)
i i
(m
nin)
igre 2.3 lear ae
. ented as g ets as g ighters
in.
n i n in in
i . inin i i
in.
NNoeoto
Ninnn.
mmn.
mmnm.
. tinal mnents
in m i
n /ii
NN o e N inn
nmnnnm
nin.
. lear ae
n mi iin 4 in. (11 mm)
n . i .3.
NNNmiinn
.imminiin
nii.
n - i in n n -nii
n mn . m m
.
i 3 4 3 /1
10
. d el
Hardd s td
mn n n i
.
n nin 000 n
.
m n n .
nin 0 m n .
i m im n n
n ini.
i im n n
i ini.
i in
in m n i .
n n n n
im.
mi m n in
in n nn .
nn i n
in in m n
in mi imn in
min .
NNoe
Nnn.
nn n min
.
istre
i
in
i
n
tring d
n n
i i n n
i.
i n i iin
nn.
m i . n i in.
(15 mm) in im i.
( i) n
i i. in
n n i.
n n in
m in n. i in i n n
m.
easned d
i
i in. (15 mm)
i mi nn n 0
- - nin mn
- - in mn
N:ninimmninnin
niin.
NNeN
nn.
niinm.
ressed lid el irelgs
n m i i .
m ni n. mmn
i . mn-
iin n inin.
in m i m n imn in-
in n nin.
n i i nin.
n n iin
in mn n nin
n in min n in i .
i 3 4 3 /1
11
3 aintenane and erie
igre 3.1 himne erminatin a leaning
A. Dissal Ashes
reen: n m
: mn
NNoeninm
.
in m nin i i-in i.
nin n nn-
mi n n m
mi mi nin n i.
i i in i i
i in in
nin ni in
. himne nsetin/leaning
reen: i in in n
mmn i imn
: i imn
NNoeniim
.ni.
i 3.1 m/in minin .
reste rmatin and eed r emal
n i n i n
ni i min i mi
m . nn in -
i imn -nin .
i m n inin. n
ini i m n m .
NNoeimnnmnn
mimnmnn.
n n imn m n-
i n. mmn
mn imn n
inin n iin
inin ii.
imn in i
in in n min n
i .
n m i m
i imn .
i 3 4 3 /1
SCREW
imn
m 4
n i n .
i
in
35
minin
m
i .
344/34
n
minin
1. m 4 .
. m n.
3. m .
345/345
minin
35
minin
m m
n n n
i .
1. m ()
. i
1
. he ireb eratr
reen: m
: mn
D. nset rate
reen: m
: mn
n
in in 1-1/ in. (3 mm) m
n
n-
in n i n
m m ni n.
NNoen.
mininin
ninmi.
nin n nin i min in
. i i nm. i i
ii mn nin n .
n i
in ( mm) in i
i in
i .
. lass leaning
reen: i
: mn
n i nn-i mmi i
n
i i
- n
i
- n m
- mmi n (n i
)
N n m i . i
.
iiininmmin
iin
Nniii
i 3 4 3 /1
13
4 Troubleshooting Guide
Start Fire Problems Possible Cause Solution
Can’t get re started
Excessive smoke or spillage
Burns too slowly
Smolders, sizzles
Not enough kindling/paper or no
kindling/paper
Use dry kindling, more paper. Arrange kindling &
wood for air movement.
Damper closed/not fully open Open damper.
Not enough air for re to ignite Check for restricted cap/shroud.
Open air kit (if installed).
Check for ue blockage.
Pre-warm ue before starting re (refer to starting
re section).
Check for adequate vent height (refer to chimney
assembly section).
Open window below the replace towards the
wind.
Wood condition is too wet, too
large
Use dry, seasoned wood (refer to wood fuel
section).
Bed of coals not established
before adding wood
Start with paper & kindling to establish bed of
coals (refer to starting re section).
Flue blockage such as birds’
nests or leaves in termination
cap
Have chimney inspected for creosote and cleaned
by a certied chimney sweep.
Down draft or negative pressure
Competition with exhaust
devices
Do not use exhaust fans during start-up (refer to
negative pressure section).
Open window below the replace towards the
wind.
Fire burns too fast Extremely dry or soft wood Mix in hardwood.
Mix in less seasoned wood after re is established
(refer to wood fuel section).
No glass doors Add glass doors to slow down air ow.
Overdrafting Check for correct vent height; too much vertical
height creates overdrafting.
Check location of vent termination (refer to
chimney assembly section).
Heatilator • A36R & A42R • 28376 • Rev AO • 7/12
14
etting tarted
A. ial irelae stem
nstaller ide
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
n-mi
in minin
minimm n
n imn
iin
imn
( n
in ) i n
(in )
iin i
n i
(in )
n
imn (n n)
minin
(in )
imn n
i in
(in )
n (i n )
(in )
min
in iin i
(in )
n
n n i
(in )
n n n
(in 11)
i in
n im
(in 11)
nin
(in 11)
-i i
i m
i()
(in )
i
min i
(in )
mi min/
n - n
(in )
imn m
(in )
i inin i (n n)
m
inin m imn
i i i in (in )
m
(in )
N:
inniinin
ninn.
inimnn.
mmiinmn.
imn i i
(in )
i in
n.
m n
n .
(1.3m)
n .
i 3 4 3 /1
igre .1 ial irelae stem
15
i m imn i i-
. n n-
in .
in
n (in .)
n
min i imn n
n min in
in n-i n n i
niinin
mn i nin m
i
- iin
- i
-
minimi ni i
n i i i i in in iin
in in in n
n i min
in n imn
n n n i niinin n n n
in immi iini
i inin n
m i
iin n in
i i
i mn n i n in n m
mn inin i
NNotoi
niminmn.i
min.
N:mnin.mmn
ininmn.
D. egatie ressre. Design and nstallatin nsideratins
i in n n
. n i in
min iin m
imn.
niin in
nin ni
in n imn
inin min in
i in.
n m nin .
iin.
i iin.
min n niin i.
in ii n
i m n i.
N:iiniinin.
nin m i in n
nin n in.
n inn i iin in
i ii in iiin iin
inin inin n mi.
N: m ni m n
niiiimmn
m
nninmnniin
n
iinnin
niini
minimn
. Drat
i 3 4 3 /1
1
in in
in mmn
i in
in in i
i-
in
mmn in
mmn
n i
in im
mmn in
ni
in mmn
n
in
i i
in in
in in i
igre .2 emmended himne atins
. ating irelae himne
in n imn i -
mn.
n m i n
iin n. i m
i in iin n i-n .
n i . i minimi
in in.
minin m n
nn in n in.
inimi imn .
ni in i n iin
n i i.
in niin minin imn in
in n in .
N:ininmninin
niimmnninminm
im.nn
nn
nn
i 3 4 3 /1
1
innin inin in
n iin i i
iin min mi
i i m in mi
mm
ii i min
i i i n i
m in
m
1/-3/4 in. n -iin
i. n ni
. ls and lies eeded H. nset irelae and mnents
NNoeooom
imiin.Ninm
inmimnn.
.
m n mnn m in n
in m.
n m mnn n i in
.
n m in imn.
ead all the instrtins bere starting the
installatin. ll these instrtins arell
dring the installatin t ensre maimm saet
and benet.
. ial irelae stem
i m i
i/in //i i m
imn m n minin
nin
i 3 4 3 /1
1
6 raming learanes
n
m
ii
4 in.
(11 mm)
minimm
n
5/ in. (1 mm)
niin
3/4 in. (1 mm) min. i
m i
mi mi. 1/
in. (13 mm)
niin n.
te:
te: n iin
min imnin
n in
in
n (in
..)
n in
(in 11.. 11..)
i imnin
(in 13..)
n n i
in in
Note:mnimninnn
niniininini.
del AD H
in. 51 43 4 / 35 3/4 15 3/4 53 3
mm 15 10 10 0 400 134 54
in. 5 4 1/ 3 / 1 54 / 3
mm 144 145 1 45 134 54
3
4
1 in. (305 mm)
inimm m
nin n
ni .
igre 6.1 irelae atins raming dimensins shn
A. elet irelae atin
i 3 4 3 /1
1
. learanes
NNoemmiminimminmiiini
..Niiiininmi.
i 3 4 3 /1
(inin)
0 in.
n
i
nin
i
(iin)
()
(i)
(iin)
iin i
/n (
i n )
m
in
3/4 in. (1 mm)
i in
( niin n
i i 1/ in. 13 mm)
in. (51 mm)
minimm n
0 in.
in. (51 mm) min.
n
in. (51 mm) min.
i n
i n i
mi
4 in.
11 mm
(n n)
igre 6.2 learanes t mbstible aterials
te: imn i i n n i in n.
0
1 in.
305 mm
3/4 in.
4 mm
1 in.
305 mm
10 3/4 in.
3 mm
4 in.
10 mm
50 n
3 n
i n 1 in.
A
irelae
ening
tside
Dimensins
in. 3 4
mm 14 10
in. 4 4
mm 10 11
3
4
del
D. rame the irelae
i .4 i min in mi mi (4 m n).
i i n mi mi n in i ..
min m n.
in. (51 mm)
min. i
n
m imn.
n
n i i nnin.
i i n n i imnin m
n minimm n m.
A D
in. 43 3 41 1/
mm 10 54 1054 03
in. 4 3 41 1/
mm 145 54 1054 03
i i n i.
del
3
4
ini i in
i mmn.
igre 6.4 raming the irelae
. idealls/rrnds
n mi i m minimm 1 in. (305 mm) (m 4 in) m
nin.
mi n nn-mi mn n n m n i .3.
igre 6.3 antel eg r all retins Aetable n bth sides ening
i 3 4 3 /1
Other manuals for A36R
7
This manual suits for next models
3
Table of contents
Other Heatilator Indoor Fireplace manuals
Heatilator
Heatilator CB4236IR User manual
Heatilator
Heatilator NA36 Manual
Heatilator
Heatilator GNTC50 User manual
Heatilator
Heatilator I80 User instructions
Heatilator
Heatilator SILH20E-B User manual
Heatilator
Heatilator MHST36D Manual
Heatilator
Heatilator CALIBER NXT PLUS Manual
Heatilator
Heatilator Wood Burning Fireplace A36C User manual
Heatilator
Heatilator GNTC50 Owner's manual
Heatilator
Heatilator NNXT4236IF User manual
Heatilator
Heatilator GC421 Manual
Heatilator
Heatilator Gas Fireplace GDFL4136I User manual
Heatilator
Heatilator FL92 User manual
Heatilator
Heatilator G160 Manual
Heatilator
Heatilator B-Vent Gas Fireplace BCBV36 User manual
Heatilator
Heatilator Wood Burning Fireplace EL36 Series User manual
Heatilator
Heatilator BIR36-B User manual
Heatilator
Heatilator Birmingham BIR42 User manual
Heatilator
Heatilator CNXT4236 User manual
Heatilator
Heatilator CD4236IR-C User manual
Popular Indoor Fireplace manuals by other brands
RealFlame
RealFlame HEATSEEKER 700 Installation & operating manual
Heat & Glo
Heat & Glo LCOR-36TRB-IPI owner's manual
Quality Craft
Quality Craft MM190P-2628FCN instruction manual
Focal Point
Focal Point L30SE F500304 Installation & user's instructions
Focal Point
Focal Point BLENHEIM Installation & user's instructions
Heat & Glo
Heat & Glo Heat & Glo RED40 owner's manual
RealFlame
RealFlame 8500 instruction manual
Focal Point
Focal Point BLENHEIM STYLE Installation and user instructions
Vanguard
Vanguard BHDV34N(A) OWNER'S OPERATION AND INSTALLATION MANUAL
foc.us
foc.us Gigafocus 1500 Specific instructions
HAMPTON BAY
HAMPTON BAY H35-LP1 Owners & installation manual
Heat & Glo
Heat & Glo PIER-HVB-CE installation instructions
Heat & Glo
Heat & Glo Everest owner's manual
KAL-FIRE
KAL-FIRE Fairo 60 user manual
RealFlame
RealFlame T9650 LP Owners manualyamna
Classic Flame
Classic Flame 39EB500ARA installation guide
Quality Craft
Quality Craft M630-44FGO instruction manual
Procom
Procom PC32VFC OWNER'S OPERATION AND INSTALLATION MANUAL