Honeywell HW1000i - Portable Inverter Generator User manual

HW1000i
HW2000i
For product inquires or support, please visit www.honeywellgenerators.com or
call toll-free at 1-888-HWHELP1 (494-3571).
Owner’s Manual
Inverter Generator
Manual del Propietario
Si tiene preguntas acerca de los productos o requiere de asistencia, visite
www.honeywellgenerators.com o llame gratis al 1-888-HWHELP1 (494-3571).
Pour obtenir des renseignements sur les produits ou pour du soutien technique,
visitez notre site à l’adresse www.honeywellgenerators.com (en anglais seulement)
ou composez notre numéro sans frais 1-888-HWHELP1 (494-3571).
Guide D’Utilisation
Read and Save These Instructions
Lea y Conserve Estas Instrucciones - Lisez et Conservez les Présentes Instructions

Congratulations on owning a Honeywell inverter generator!
Please use the spaces provided below to record important information about your generator. You may be asked to pro-
vide this information should you require product service or support.
Identification information specific to your generator (model number and serial number) can be found on the generator
nameplate.
This manual contains important instructions for operating this generator. For your safety, and the
safety of others, read this manual thoroughly before operating the generator. Failure to properly follow
all instructions and precautions can cause you and others to be seriously hurt or killed.
FIGURE 1: Generator Nameplate Location
Date of Purchase:
Store/Dealer Purchased From:
Generator Model Number:
Generator Serial Number:
WARNING
Model Number: HW1000i
Power Output: 0.9kW
Frequency: 60Hz
AC Voltage: 120V Engine RPM: 5400
Duty Cycle: Continuous Fuel: Gasoline
Max. Ambient Temp.: 40oCInsulation Class: F
Serial Number:
Northshore Power Systems, LLC
Milwaukee, WI 53212 USA 245453
For electrical equipment only
For use in a weather protected area only
Pour materiel electrique seulement
Employez uniquement dans un emplacement a labri des intemperies
GROUNDED SYSTEM
p/n XXXXXXX
HW2000i HW1000i
Northshore Power Systems, LLC
4425 N. Port Washington Road
Suite 105
Milwaukee, WI 53212-1082 USA
1-888-HWHELP1 (494-3571)
www.honeywellgenerators.com
© 2010 Northshore Power Systems, LLC
The Honeywell Trademark is used under license
from Honeywell International Inc.
Honeywell International Inc. makes no representations
or warranties with respect to this product.
Manufactured exclusively for Northshore Power Systems.

PRODUCT REGISTRATION
To register your product, please complete the information below and mail to the address at the end of the form or register
online at www.honeywellgenerators.com. 18-digit serial number must be completed in order for warranty to be acti-
vated.
1 - PERSONAL INFORMATION
2 - PRODUCT INFORMATION
FIRST NAME
LAST NAME
CHECK HERE TO RECEIVE ANNUAL MAINTENANCE REMINDERS AND SPECIAL OFFERS FROM HONEYWELL
GENERATORS
CHECK HERE TO RECEIVE INFORMATION FROM OTHER COMPANIES VIA EMAIL, UNDERSTANDING YOUR
EMAIL ADDRESS MAY BE SHARED OR COMBINED WITH INFORMATION FROM OTHER SOURCES
DATE OF PURCHASE:
MM DD YYYY
//
*MODEL NUMBER:
*SERIAL NUMBER (18-digits):
PURCHASE LOCATION:
IN-STORE
ONLINE
STORE NAME:
PURCHASE PRICE: $___________.00
FEATURES INFLUENCING PRODUCT PURCHASE:
BRAND REPUTATION EASE OF USE
PORTABILITY SIZE / WEIGHT
POWER RATING STYLE/APPEARANCE
PRICE WARRANTY
HOW DID YOU BECOME AWARE OF THIS PRODUCT?
IN-STORE RADIO/TV
INTERNET STORE CIRCULAR
PRINT WORD OF MOUTH
OTHER BRANDS CONSIDERED WHEN SHOPPING
FOR THIS PRODUCT:
PRIMARY USE FOR PRODUCT:
TOOL POWER
RECREATION POWER
EMERGENCY POWER
PRIMARY LOCATION FOR PRODUCT USE:
HOME
WORK
TYPE OF WORK, IF PRODUCT BEING USED FOR
PROFESSION:
WHAT OTHER TYPE OF POWER EQUIPMENT ARE
YOU INTERESTED IN PURCHASING IN THE FUTURE?
WHO DECIDED TO PURCHASE THIS PRODUCT?
STREET ADDRESS
CITY, STATE, ZIP
COUNTRY
PHONE
EMAIL
*Found on nameplate of generator

3 - DEMOGRAPHIC INFORMATION
GENDER:
MALE
FEMALE
MARITAL STATUS:
MARRIED
SINGLE
DATE OF BIRTH:
MM DD YYYY
//
INCLUDING YOURSELF, HOW MANY PEOPLE LIVE IN
YOUR HOUSEHOLD:
NUMBER OF CHILDREN UNDER 18 LIVING IN YOUR
HOUSEHOLD:
PRIMARY RESIDENCE:
OWN
RENT
EDUCATION:
SOME HIGH SCHOOL
HIGH SCHOOL DIPLOMA
COLLEGE DEGREE
GRADUATE DEGREE
THANK YOU FOR REGISTERING YOUR PRODUCT. THE INFORMATION YOU PROVIDED MAY BE USED
FOR MARKETING PURPOSES IN ORDER TO OFFER YOU VARIOUS PRODUCT INFORMATION AND
OFFERS.
CHECK HERE IF YOU DO NOT WISH TO BE CONTACTED ABOUT SPECIAL OFFERS.
PLEASE RETURN THIS FORM TO THE FOLLOWING ADDRESS:
Northshore Power Systems, LLC
4425 N Port Washington Road
Suite 105
Milwaukee, WI 53212-1082
PLEASE MAIL THIS FORM IN A SEALED ENVELOPE. DO NOT STAPLE.
HOUSEHOLD INCOME:
LESS THAN $15,000 $100,000 - $124,999
$15,000 - $29,999 $125,000 - $149,999
$30,000 - $49,999 $150,000 - $174,999
$50,000 - $79,999 $175,000 - $199,999
$80,000 - $99,999 $200,000 OR OVER
PRIMARY METHOD OF PURCHASING HOUSEHOLD
ITEMS:
IN-STORE
ONLINE
TV
MAIL ORDER
TYPES OF CREDIT CARDS HELD BY HOUSEHOLD
MEMBERS:
VISA / MASTERCARD
DISCOVER
AMERICAN EXPRESS
GAS / RETAIL
OTHER
NONE
HOUSEHOLD INTERESTS:
HOME IMPROVEMENT
AUTOMOTIVE WORK
CAMPING
OTHER

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com i
CONTENTS
IMPORTANT SAFETY INSTRUCTIONS ............................................................................. 1
Safety Messages .........................................................................................................................................1
Location of Important Labels .......................................................................................................................3
GETTING STARTED ......................................................................................................... 5
Package Checklist .......................................................................................................................................5
Grounding the Generator .............................................................................................................................6
Using Generator for Back-up Power ............................................................................................................6
COMPONENTS ................................................................................................................. 7
Accessories .................................................................................................................................................7
Front and Back View ...................................................................................................................................8
OPERATION ................................................................................................................... 11
Generator Location ....................................................................................................................................11
Preparing for Operation .............................................................................................................................11
Starting Generator .....................................................................................................................................12
Connecting Appliances ..............................................................................................................................13
Stopping Generator ...................................................................................................................................13
Low Oil Protection .....................................................................................................................................14
Powering Appliances .................................................................................................................................14
MAINTENANCE .............................................................................................................. 17
Maintenance Schedule ..............................................................................................................................17
Engine Oil ..................................................................................................................................................18
Engine Fuel ...............................................................................................................................................21
Cleaning Spark Arrestor Screen ................................................................................................................23
Air Filter Maintenance ................................................................................................................................23
Spark Plug Service ....................................................................................................................................25
Transporting Generator .............................................................................................................................26
Storing Generator ......................................................................................................................................26
TROUBLESHOOTING .................................................................................................... 29
SPECIFICATIONS AND WIRING DIAGRAMS ............................................................... 31
WARRANTIES ................................................................................................................ 35
NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY .............................................35
NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY ...........................................36
INDEX .............................................................................................................................. 39
MAINTENANCE PARTS ................................................................................................. 41

THIS PAGE INTENTIONALLY LEFT BLANK
ii www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 1
SAVE THESE INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
NOTE:
Since there are many variations in the circumstances sur-
rounding the installation, operation, service, and mainte-
nance of this generator, we cannot possibly anticipate or
provide advice or safety messages to cover every situa-
tion.
Safety Messages
Signal Words
Safety messages are provided throughout this manual to
help prevent personal injury and equipment damage. All
safety messages are introduced by a signal word indicat-
ing the hazard level.
Hazard Symbols and Meanings
In addition to the signal words, the following symbols may
be used to draw your attention to specific types of haz-
ards.
ANYONE using or servicing this generator must read, understand, and follow all safety and operation instructions pro-
vided in the product manual. Failure to closely follow these instructions can result in circumstances leading to death,
serious injury, and property damage.
WARNING
Indicates an imminently hazard-
ous situation which, if not
avoided, will result in death or
serious injury to the operator or to
bystanders.
Indicates a potentially hazardous
situation which, if not avoided,
could result in death or serious
injury to the operator or to
bystanders.
Indicates a potentially hazardous
situation which, if not avoided,
may result in moderate or minor
injury to the operator or to
bystanders.
Indicates a situation which, if not
avoided, may result in damage to
the generator components.
DANGER
WARNING
CAUTION
NOTICE
Explosion Toxic f umes Fire
Chemical burn
Electrical shock
Hot surface
Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide. This is a poi-
son you cannot see or smell.
NEVER use inside a home
or garage, EVEN IF doors
and windows are open.
Only use OUTSIDE and
far away from windows,
doors, and vents.
+
DANGER

Safety Messages
2www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Safety Messages
Electric Shock Hazards
Fire and Burn Hazards
Medical and Life Support Uses
Generator Damage Hazards
Generators produce powerful voltage that can cause
death or great physical harm.
•NEVER touch bare wires or receptacles.
•NEVER use generator with electrical cords that are
worn, frayed, bare, or otherwise damaged.
•NEVER operate generator in rain or snow, or when
the generator is set on wet surface.
•Keep the generator out of reach of children, pets,
and untrained people.
When this generator is used to supply a building wir-
ing system the:
•Generator must be installed by a qualified electri-
cian and connected to transfer equipment as a
separately derived system in accordance with the
National Electrical Code, NFPA 70.
•Generator shall be connected through transfer
equipment that switches all conductors other than
the equipment grounding conductor.
•Frame of the generator shall be connected to an
approved grounding electrode.
Fuel and its vapors are extremely flammable and
explosive under certain conditions.
•Refuel generator only outdoors, in a well-ventilated
area.
•NEVER enclose the generator in any structure.
•Keep generator at least 6 feet (2 meters) away from
buildings, other equipment, and combustible mate-
rials during operation.
•NEVER fill fuel tank while the engine is running.
Turn generator OFF and allow to cool before filling
with fuel.
•NEVER smoke or allow flames or sparks near the
generator or where gasoline is stored.
•NEVER overfill the fuel tank (there should be no
fuel in the filler neck). After refueling, make sure the
tank cap is closed properly and securely.
•Be careful not to spill fuel when refueling. Spilled
fuel or fuel vapor may ignite. If any fuel is spilled, be
sure the area is dry before starting the engine.
•Avoid repeated or prolonged contact with skin or
breathing of vapor.
WARNING
WARNING
WARNING
The muffler becomes very hot during operation and
remains hot for a while after stopping the engine.
•NEVER touch hot surfaces and avoid hot gases.
•Let engine cool before storing the generator
indoors.
•In case of emergency, call 911 immediately.
•NEVER use this product to power life support
devices or life support appliances.
•NEVER use this product to power medical devices
or medical appliances.
•Inform your electricity provider immediately if you
or anyone in your household depends on electrical
equipment to live.
•Inform your electrical provider immediately if a loss
of power would cause you or anyone in your
household to experience a medical emergency.
NOTICE
Improper treatment or misuse of generator can cause per-
manent damage.
•NEVER modify generator in any way.
•NEVER tamper with governed speed. Generator sup-
plies correct rated frequency and voltage when run-
ning at governed speed.
•Damage to generator caused by misuse or modifi-
cation is not covered under warranty.
•Generators vibrate in normal use. During and after
the use of the generator, inspect the generator as
well as extension cords and power supply cords
connected to it for damage resulting from vibration.
Have damaged items repaired or replaced as nec-
essary. Do not use plugs or cords that show signs
of damage such as broken or cracked insulation or
damaged blades.
•For power outages, permanently installed station-
ary generators are better suited for providing
backup power to the home. Even a properly con-
nected portable generator can become overloaded.
This may result in overheating or stressing the gen-
erator components, possible leading to a generator
failure.
•This portable generator is not for use with gasoline
/ ethanol blends with over 15% ethanol.
WARNING
WARNING

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 3
Location of Important Labels
Location of Important Labels
Location of Important Labels
Your generator has several labels which provide important safety and maintenance information. Samples of these labels are
provided below. Should any of these labels become illegible or damaged, call 1-888-HWHELP1 (494-3571) for replacements.
FIGURE 2: HW1000i Model Label Locations
FIGURE 3: HW2000i Model Label Locations
PRODUCT LABEL PART NUMBER
A101589B
B102414A
1000 MAXIMUM
WATTS
900 RATED
WATTS
NEUTRAL FLOATING
NEUTRE FLOTTANT
D
B
A
C
AA
E
G
H
2100 MAXIMUM WATTS
2000 RATED WATTS
NEUTRAL FLOATING
NEUTRE FLOTTANT
D
A
B
C
E
H
G
F
p/n 101589B
Using a generator indoors
CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide.
This is a poison you cannot see or smell.
NEVER use inside
a home or garage,
EVEN IF doors and
windows are open.
Only use OUTSIDE
and far away from
windows, doors,
and vents.
Usar el generator en interiores
LO PUEDE MATAR EN MINUTOS.
El escape del generator contiene monóxido
de carbono. Este gas es un veneno que no
se puede ver ni oler.
NUNCA use el generador dentro del hogar
o el garaje, AÚN si las puertas y ventanas
están abiertas.
Solo uselo en EXTERIORES y lejos de
ventilaciones, puertas y ventanas abiertas.
L’utilisation d’une génératrice à l’intérieur
PEUT VOUS TUER EN QUELQUES MINUTES.
Les génératrices rejettent du monoxyde de
carbone, un gaz toxique invisible et inodore.
NE JAMAIS utiliser la génératrice à l’intérieur
d’une residence ou d’un garage MÊME SI les
portes et les fenêtres sont ouvertes.
Utiliser uniquement a L’EXTÉRIEUR et loin
des fenêtres, portes et évents.
DANGER
DANGER
PELIGRO
p/n 102414A
Clean Spark Arrestor
Every 6 Months or
100 Hours of Use
WARNING
Nettoyer le Pare-Étincelles
Tous Les 6 Mois ou
Après 100 Heures
AVERTISSEMENT

Location of Important Labels
4www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Location of Important Labels
C101591A
D101588B
E101605A (HW1000i Model)
101610A (HW2000i Model)
F102334A (HW2000i Model)
G
101596B* (HW1000i Model)
101597B* (HW2000i Model)
H101592A
TABLE 1. Safety Labels
p
/
n
:
1
0
1
5
9
1
A
p/n 101588B
Entrée d’air sur le bas de l’inverseur.
MAINTENEZ LA ZONE CLAIRE.
Air intake located on bottom of
inverter. DO NOT BLOCK.
El aire entra en el fondo de la
unidad. NO BLOQUEE.
CAUTION
ATTENTION
ATENCIÓN
OFF ON
CHOKE
p/n 101605A
ON OFF
CHOKE
p/n 101610A
Use regular
unleaded gasoline with a
minimum octane ratingof 87
Utilisez du carburant
ordinaire sans plomb avec
un taux d’octane minimum de 87
p/n 102334A
7
PULL RECOIL TO START.
TIREZ LE LANCEUR À RAPPEL
POUR DÉMARRER.
JALE LA CUERDA DE
REBOBINADO PARA ARRANCAR.
8
MOVE CHOKE TO OFF.
METTEZ L’ÉTRANGLEUR
EN POSITION OFF.
MUEVA EL CONTROL DE
AHOGO A APAGADO.
9
CHECK READY LIGHT ON.
ASSUREZ-VOUS QUE LE VOYANT
LUMINEUX EST ALLUMÉ.
ESPÉRESE HASTA QUE SE
ENCIENDA LA LUZ LISTA.
10
PLUG IN POWER CORDS.
BRANCHEZ LES CORDONS
D’ALIMENTATION.
CONECTE LOS CABLES.
FOR 24-HOUR STARTING INSTRUCTIONS
1-888-RECOIL-8 (732-6458)
p/n 101596B
UNPLUG POWER CORDS.
DÉBRANCHEZ LES
CORDONS D’ALIMENTATION.
DESENCHUFE LOS CABLES.
STOPPING INSTRUCTIONS INSTRUCTIONS D’ARRÊT INSTRUCTIONS PARA DETENER
MOVE ENGINE SWITCH TO STOP.
METTEZ LE COMMUTATEUR DU
MOTEUR EN POSITION D’ARRÊT.
MUEVA EL CONTROL DE MOTOR
A DETENER.
TURN FUEL VALVE OFF.
FERMEZ LE ROBINET DE
CARBURANT.
MUEVA EL RESPIRADERO
DE COMBUSTIBLE A
EJECUTAR.
6
TURN FUEL VENT ON.
OUVREZ LA MISE À
L’AIR LIBRE CARBURANT.
MUEVA EL RESPIRADERO
DE COMBUSTIBLE
A ENCENDIDO.
TURN FUEL VENT OFF.
FERMEZ LA MISE À
L’AIR LIBRE CARBURANT.
MUEVA LA VÁLVULA
DE COMBUSTIBLE A
APAGADO.
1
2
3
6
4
5
7
8
9
10
ALL USERS MUST READ AND UNDERSTAND OWNER’S MANUAL!
TOUS LES UTILISATEURS DOIVENT LIRE ET COMPRENDRE LE GUIDE D'UTILISATION!
TODOS LOS USUARIOS DEBEN LEER Y COMPRENDER EL MANUAL OPERACIÓN!
!
5
4
1
MOVE INVERTER OUTSIDE.
DÉPLACEZ L'ONDULATEUR
À L’EXTÉRIEUR.
MUEVA EL INVERSOR
HACIA AFUERA.
FILL FUEL TANK AND CHECK
OIL LEVEL.
REMOLIR LE RÉSERVOIR DE
CARBURANT ET VÉRIFIER LE
NIVEAU D’HUILE.
LLENE EL TANQUE DE GASOLINA
Y VERIFIQUE EL NIVEL DEL ACEITE.
2
TURN FUEL VALVE ON.
OUVREZ LE ROBINET
DE CARBURANT.
MUEVA LA VÁLVULA DE
COMBUSTIBLE A ENCENDIDO.
3
MOVE CHOKE TO ON.
METTEZ L’ÉTRANGLEUR
EN POSITION ON.
MUEVA EL CONTROL DE
AHOGO A ENCENDIDO.
MOVE ENGINE SWITCH TO RUN
AND EFFICIENCY MODE TO OFF.
METTEZ LE COMMUTATEUR
DU MOTEUR EN POSITION
RUN ET LE MODE D'EFFICACITÉ
EN POSITION OFF.
MUEVA EL CONTROL DE MOTOR
A EJECUTAR Y EL MODO DE
EFICACIA A APAGADO.
12 34
PULL RECOIL TO START.
TIREZ LE LANCEUR À
RAPPEL POUR DÉMARRER.
JALE LA CUERDA DE
REBOBINADO PARA
ARRANCAR.
MOVE CHOKE TO OFF.
METTEZ L’ÉTRANGLEUR
EN POSITION OFF.
MUEVA EL CONTROL DE
AHOGO A APAGADO.
CHECK READY LIGHT ON.
ASSUREZ-VOUS QUE LE
VOYANT LUMINEUX EST
ALLUMÉ.
ESPÉRESE HASTA QUE SE
ENCIENDA LA LUZ LISTA.
PLUG IN POWER CORDS.
BRANCHEZ LES CORDONS
D’ALIMENTATION.
CONECTE LOS CABLES.
p/n 101597B
UNPLUG POWER CORDS.
DÉBRANCHEZ LES CORDONS
D’ALIMENTATION.
DESENCHUFE LOS CABLES.
STOPPING INSTRUCTIONS INSTRUCTIONS D’ARRÊT INSTRUCTIONS PARA DETENER
MOVE ENGINE SWITCH TO STOP.
METTEZ LE COMMUTATEUR DU
MOTEUR EN POSITION D’ARRÊT.
MUEVA EL CONTROL DE MOTOR
A DETENER.
TURN FUEL VALVE OFF.
FERMEZ LA MISE À L’AIR
LIBRE CARBURANT.
MUEVA LA VÁLVULA DE
COMBUSTIBLE A APAGADO.
FOR 24-HOUR STARTING INSTRUCTIONS
1-888-RECOIL-8 (732-6458)
1
2
3
4
6
7
8
95
12 3
6
7
8
9
ALL USERS MUST READ AND UNDERSTAND OWNER’S MANUAL!
TOUS LES UTILISATEURS DOIVENT LIRE ET COMPRENDRE LE GUIDE D'UTILISATION!
TODOS LOS USUARIOS DEBEN LEER Y COMPRENDER EL MANUAL OPERACIÓN!
!
5
4
1
MOVE INVERTER OUTSIDE.
DÉPLACEZ L'ONDULATEUR
À L’EXTÉRIEUR.
MUEVA EL INVERSOR
HACIA AFUERA.
FILL FUEL TANK AND CHECK
OIL LEVEL.
REMOLIR LE RÉSERVOIR DE
CARBURANT ET VÉRIFIER LE
NIVEAU D’HUILE.
LLENE EL TANQUE DE GASOLINA
Y VERIFIQUE EL NIVEL DEL ACEITE.
2
TURN FUEL VALVE ON.
OUVREZ LE ROBINET
DE CARBURANT.
MUEVA LA VÁLVULA DE
COMBUSTIBLE A ENCENDIDO.
3
MOVE CHOKE TO ON.
METTEZ L’ÉTRANGLEUR
EN POSITION ON.
MUEVA EL CONTROL DE
AHOGO A ENCENDIDO.
MOVE ENGINE SWITCH TO RUN
AND EFFICIENCY MODE TO OFF.
METTEZ LE COMMUTATEUR
DU MOTEUR EN POSITION
RUN ET LE MODE D'EFFICACITÉ
EN POSITION OFF.
MUEVA EL CONTROL DE MOTOR
A EJECUTAR Y EL MODO DE
EFICACIA A APAGADO.
OFF
ON
FUEL
p/n 101592A
* The Smart Start instruction label is NOT intended to replace information provided in this Owner’s Manual. Thoroughly
read and understand all information provided in the Owner’s Manual before operating the generator. Failure to properly
follow all instructions and precautions can cause you and others to be seriously injured or killed.
WARNING

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 5
GETTING STARTED
Use the information in this section to prepare your generator for operation.
Package Checklist
1. Set carton on a rigid, flat surface.
2. Remove carton contents.
3. Remove and discard silica gel pack.
4. Verify all of the following items are included in the generator package:
Inverter Generator
Owner’s Manual
Oil Fill Container
Tool Kit
Oil Drain Pipe
Spark Plug Wrench
Screwdriver Handle
Screwdriver Universal Bit
5. Inspect for damage.
Carefully inspect generator for any damage that may have occurred during shipment. If loss or damage is noted after
opening, separate damaged materials and call 1-888-HWHELP1 (494-3571).
6. Remove the “No OIl Fill” tag from the generator. See “Adding Engine Oil” on page 18.
7. Record generator information.
Write down the identification information specific to your generator in the spaces provided on the inside cover of this
Owner’s Manual. This information is located on the generator nameplate (see illustration below).
ANYONE using this generator must read, understand, and follow all safety and operation instructions provided in the
product manual. Failure to closely follow these instructions can result in circumstances leading to death, serious injury,
and property damage.
Generator is heavy! Obtain assistance to lift the generator to avoid back or other bodily injury.
FIGURE 4: Generator Nameplate Location
WARNING
CAUTION
CAUTION!
OIL HAS BEEN DRAINED FOR SHIPPING
p/n102415A
FUEL ODORS MAY ALSO BE PRESENT
DUE TO FACTORY TESTING
Failure to fill engine with oil before starting
engine will result in permanent damage
and will void engine warranty.
(Please remove tag prior to operating)
Model Number: HW1000i
Power Output: 0.9kW
Frequency: 60Hz
AC Voltage: 120V Engine RPM: 5400
Duty Cycle: Continuous Fuel: Gasoline
Max. Ambient Temp.: 40oCInsulation Class: F
Serial Number:
Northshore Power Systems, LLC
Milwaukee, WI 53212 USA 245453
For electrical equipment only
For use in a weather protected area only
Pour materiel electrique seulement
Employez uniquement dans un emplacement a labri des intemperies
GROUNDED SYSTEM
p/n XXXXXXX

Grounding the Generator
6www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Grounding the Generator
Grounding the Generator
NOTE:
The generator is neutral floating which means the ground
terminal on the generator is not connected to the AC neu-
tral wire in the generator. If using a receptacle tester, it will
not show the same ground circuit condition as for a home
receptacle.
Generator Grounding
Special Requirements
There may be Federal or State Occupational Safety and
Health Administration (OSHA) regulations, local codes, or
ordinances that apply to the intended use of generator.
Consult a licensed electrician, electrical inspector, or the
local agency having jurisdiction.
•In some areas, generators are required to be regis-
tered with local utility companies.
•If generator is used at a construction site, there may
be additional regulations which must be observed.
Using Generator for Back-up Power
Generators produce powerful voltage that can cause
death or great physical harm.
• Before using generator, consult a licensed electrician,
electrical inspector, or local agency having jurisdiction
for local codes or ordinances that apply to the intended
use of generator.
FIGURE 5: Ground Terminal (HW2000i Model Illustrated)
Intended Use Connection to
Grounding Electrode
Equipment connected to
generator receptacles by a
cord and plug Not Required
All other uses
(such as direct connection
to a building’s electrical
system)
May Be Required;
Consult a
Licensed Electrician
Source: National Electrical Code 2008, Section 250.34
WARNING
2100 MAXIMUM WATTS
2000 RATED WATTS
NEUTRAL FLOATING
NEUTRE FLOTTANT
Improper connections of the generator to a building’s electri-
cal system can be deadly.
Electrical current from generator can feedback into
utility lines. Such feedback may electrocute utility
company workers or others who contact utility lines
during a power outage.
Electrical current can feedback into generator. When
utility power is restored, generator may explode,
burn, or cause fires in building's electrical system.
• Before connecting to a building’s electrical system, con-
sult a licensed electrician, electrical inspector, or local
agency having jurisdiction for local codes or ordinances
that apply to the intended use of generator.
DANGER

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 7
COMPONENTS
Use information provided in this section to become familiar with your generator’s components.
Accessories
The information below is provided for reference only. Refer to “OPERATION” on page 11 for instructions on
operating generator.
Generator is heavy! Obtain assistance to lift the generator to avoid back or other bodily injury.
FIGURE 6: Inverter Accessories
CAUTION
Oil Fill Container
Screwdriver Handle Screwdriver Universal Bit
Oil Drain Pipe
Spark Plug Wrench

Front and Back View
8www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Front and Back View
Front and Back View
HW1000i Model
A—Control Panel
1. Outlets
125VAC outlet(s) (NEMA 5-15R [HW1000i model] and NEMA
5-20R [HW2000i model]) to connect 120V appliances to gen-
erator for power.
2. Ground Terminal
Provides generator connections to a grounding electrode.
See “Grounding the Generator” on page 6.
3. Breakers
Protects circuits from damage caused by
overload or short-circuit by stopping flow of
electricity from generator to the appliance. If
there is no power at outlets, see “Trouble-
shooting” on page 29.
4. Overload Indicator Light
Illuminates red when the generator is overloaded. Turn the
generator off immediately and determine the reason for the
overload.
5. Output Indicator Light
Illuminates green when the generator is running under nor-
mal operating conditions.
6. Oil Alert Indicator Light
Illuminates red when low oil conditions are present and the
generator is running (or while recoil is pulled). The engine
will automatically stop to prevent generator damage.
NEUTRAL FLOATING
NEUTRE FLOTTANT
1000 MAXIMUM
WATTS
900 RATED
WATTS
A
B
C
2
4
7
8
6
1
5
3
D
G
E
F
H
I
Set Tripped

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 9
Front and Back View
Front and Back View
HW2000i Model
7. Engine Control Switch
Turns the engine ON or OFF.
8. Efficiency Mode Switch
When Efficiency Mode is ON, the engine speed will automati-
cally adjust based on the connected load, resulting in better
fuel consumption and less noise.
B—Top Maintenance Cover
Provides access to the engine spark plug.
C—Muffler
Provides outlet for engine exhaust.
D—Case Feet
Provides stability to the generator.
E—Recoil Starter Handle
Starts engine.
F—Back Maintenance Cover
Provides access to air filter, fuel filter, and oil fill cap.
G—Fuel Cap
Provides a secure seal on fuel tank. The HW1000i model has
a vented fuel cap.
H—Fuel Valve
Controls flow of fuel from fuel tank to carburetor.
I— Choke Control
Controls choke valve. Choke control must be in the ON posi-
tion when starting a cold engine.
2100 MAXIMUM WATTS
2000 RATED WATTS
NEUTRAL FLOATING
NEUTRE FLOTTANT
A
DE
B
C
2
8
47
6
1
5
3
G
F
H
I
Muffler reaches temperatures that can cause serious
burns if touched. NEVER touch hot surfaces.
WARNING

THIS PAGE INTENTIONALLY LEFT BLANK
10 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 11
OPERATION
Generator Location
When deciding on the location to place your generator,
keep in mind the following safety rules:
Preparing for Operation
Before starting generator, complete the following prepara-
tion tasks:
Be sure generator is placed outdoors in a well
ventilated area. Using a generator indoors CAN KILL
YOU IN MINUTES.
Check/add engine oil— IMPORTANT! BEFORE
STARTING GENERATOR, FILL WITH ENGINE OIL.
See page 18-21 for instructions on filling, checking,
and changing oil.
Check/add fuel—ADD FUEL. See page 22.
Check air filter—See “Air Filter Maintenance” on
page 23.
If required, connect ground terminal to a ground-
ing electrode—See “Grounding the Generator” on
page 6.
Check extension cords—be sure cords are:
In good condition.
Rated for outdoor use and match amperage and
voltage ratings of generator outlet.
Equipped with plugs that have a ground terminal.
Depressed areas such as construction foundations,
pools, or any low-lying areas, can cause carbon
monoxide to accumulate. Inhalation of carbon mon-
oxide can kill you in minutes.
• NEVER use generator inside homes, garages,
crawl spaces, sheds, or similar enclosed
spaces. Use generator only outdoors and far
away from windows, doors, and vents.
If generator is placed on an uneven or flexible sur-
face, generator could tilt or overturn, causing fuel to
spill from gas tank. Spilled fuel could ignite.
• Place generator on firm, level surface and avoid
loose sand or snow. If generator is tilted or
overturned, fuel spillage may result. Also, if
generator is overturned or sinks into a soft sur-
face, sand, dirt, or water may enter generator.
NEVER operate generator in rain or snow, or
when the generator is set on wet surface.
Keep generator at least 6 feet (2 meters) away
from buildings, other equipment, and combustible
materials during operation.
DANGER
+
WARNING
WARNING
WARNING
CARBON MONOXIDE
Generator exhaust contains high levels of carbon monoxide
(CO), a poisonous gas you cannot see or smell. If you can
smell the generator exhaust, you are breathing CO. But even
if you cannot smell the exhaust, you could be breathing CO.
• NEVER use a generator inside homes, garages, crawl-
spaces, or other partly enclosed areas. Deadly levels
of carbon monoxide can build up in these areas. Using
a fan or opening windows and doors does NOT supply
enough fresh air.
• ONLY use a generator outdoors and far away from
open windows, doors, and vents. These openings can
pull in generator exhaust.
Even when you use a generator correctly, CO may leak into
the home. ALWAYS use a battery-powered or battery-
backup CO alarm in the home.
If you start to feel sick, dizzy, or weak after the generator has
been running, move to fresh air RIGHT AWAY. See a doctor.
You could have carbon monoxide poisoning.
DANGER

Starting Generator
12 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Starting Generator
Starting Generator
1. Place the generator outside on a flat surface free of
debris to prevent blocking the air intake vents in the
bottom of the generator.
2. Turn the fuel valve to the ON position.
3. Fill the fuel tank and check oil is to appropriate level.
NOTE:
The generator starts more easily with a full fuel tank.
4. Move the choke to the ON position.
NOTE:
Place the choke in the OFF position when the HW1000i
has a warm engine.
5. Set the efficiency mode switch to the OFF position.
6. Press the engine control switch to the RUN position.
7. HW1000i Model Only: Turn the fuel cap vent to the
ON position.
8. While securing the generator with one hand, grip the
recoil starter handle and pull slowly until you feel
slight resistance. (HW2000i model illustrated)
9. Apply swift pulls to start the engine, carefully returning
the recoil starter handle to the original position.
Thoroughly read and understand all information
provided in this Owner’s Manual before operating
generator.
NOTICE
It is very important to maintain the proper level of engine oil
to keep the engine in good running condition.
• Check engine oil level prior to each use.
IMPORTANT! BEFORE STARTING GENERATOR, FILL
WITH ENGINE OIL.
Starting generator with appliances connected can cause
permanent damage to appliances.
• NEVER start generator with electrical appliances
plugged in and turned on.
• Do not move the generator while it is running.
FIGURE 7: Air Intake - DO NOT BLOCK
NOTICE
Blocking the air flow may cause damage to the generator.
FIGURE 8: Fuel Valve — ON Position
WARNING
OFF
ON
FUEL
p/n101592A ON
FIGURE 9: Efficiency Mode Switch
FIGURE 10: Engine Control Switch
FIGURE 11: Fuel Cap Vent — ON Position
FIGURE 12: Recoil Starter Handle
NOTICE
To prevent damage to the generator, do not allow the recoil
starter handle to snap back against the engine.
OFF
ON

HW1000i / HW2000i Inverter Generator Owner’s Manual www.honeywellgenerators.com 13
Connecting Appliances
Connecting Appliances
10. After the engine starts, let run for 2-5 seconds and
then slowly move the choke to the OFF position.
11. After starting, confirm the output ready indicator light
is green and stays on.
12. Allow the engine to run continuously and warm up
before connecting any appliance.
Connecting Appliances
1. Turn off and unplug all appliances to be plugged into
the generator.
2. Start the generator (see “Starting Generator” on
page 12).
3. Plug in and turn on appliances. Monitor the overload
indicator light. If the overload indicator illuminates lon-
ger than 4 seconds, STOP THE ENGINE IMMEDI-
ATELY. Do not restart generator until the reason for
the overload or appliance short circuit is corrected.
4. Set the efficiency mode switch to the ON position.
Stopping Generator
In an emergency:
Press the engine control switch to the STOP position.
In normal use:
1. Turn OFF any connected appliances and unplug any
connected power cords.
2. Allow the generator to run for 2-3 minutes.
3. Press the engine control switch to the STOP position.
4. Turn the fuel valve to the OFF position.
5. Turn the fuel cap vent to the OFF position (HW1000i
model only).
FIGURE 13: Output Ready Indicator Light (HW1000i Model)
FIGURE 14: Overload Indicator Light (HW1000i Model)
Substantial overloading that continuously lights the overload
indicator light may damage the generator. Marginal overload-
ing that temporarily lights the overload indicator light may
shorten the service life of the generator.
If appliance begins to operate abnormally, becomes slug-
gish, or stops suddenly, turn it OFF immediately. Disconnect
appliance and determine whether problem is appliance, or if
rated load capacity of generator has been exceeded.
FIGURE 15: Efficiency Mode Switch
CAUTION

Low Oil Protection
14 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner’s Manual
Low Oil Protection
Low Oil Protection
The oil alert system is designed to avoid engine damage
from insufficient oil in the crankcase. The oil alert system
will stop the engine automatically before the crankcase oil
gets below the safety line. The engine will not restart until
the required amount of engine oil is added.
NOTE:
Oil alert indicator light only illuminates while generator is
running or while recoil is pulled.
Powering Appliances
NOTE:
In this manual, the term “appliance” refers to any electri-
cal device that can be connected to generator for power.
• Plan carefully: Before using the generator to power
appliances, take time to add power ratings (wattage)
of each appliance and verify that total wattage does
not exceed rated output of generator. Power rating
information can usually be found on an appliance’s
product label, stamped inside, or on the back of the
appliance. See Table 2 for a listing of average appli-
ance wattage requirements.
• NEVER overload: Circuit breakers will stop the flow
of electricity between the generator and appliance if
the generator is overloaded. Check circuit breaker
for “tripped’ position. Reduce the load on the recep-
tacle(s) and reset the breaker.
• Pay attention to appliance operation: If appliance
begins to operate abnormally, becomes sluggish, or
stops suddenly, turn it OFF immediately. Disconnect
the appliance and determine whether the problem is
the appliance, or if rated load capacity of the gener-
ator has been exceeded.
• Use suitable extension cords: If using an exten-
sion cord to connect appliances to the generator,
use only UL-listed, three-prong extension cords. Be
sure the extension cord is the proper size (wire-
gauge) to handle the electrical load that will be
plugged into it.
FIGURE 16: Oil Alert Indicator Light (HW1000i Model)
NOTICE
NEVER start generator with electrical appliances plugged in
and turned on.
Faulty appliances and power cords can result in elec-
trical shock.
• Before attempting to power an appliance, be sure
generator has been properly grounded, and the
appliance and power cord are in good working order.
• NEVER use generator for any purpose other than its
intended use.
• NEVER parallel connect generators or lengthen the
exhaust pipe.
• NEVER connect generator directly to any household
receptacle using a power cord with male plugs at both
ends.
WARNING
Medical and Life Support Uses
•In case of emergency, call 911 immediately.
•NEVER use this product to power life support
devices or life support appliances.
•NEVER use this product to power medical devices
or medical appliances.
•Inform your electricity provider immediately if you
or anyone in your household depends on electrical
equipment to live.
•Inform your electrical provider immediately if a loss
of power would cause you or anyone in your
household to experience a medical emergency.
NEVER run power cords under carpet, rugs, or other materi-
als where heat might build up or cord damage may go unno-
ticed.
WARNING
CAUTION