Jenn-Air 730-0164 User manual

STAINLESS STEEL NATURAL GAS GRILL
MODEL NO.: 730-0164 ITEM NO: 5300
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

TABLE OF CONTENTS
SECTIONONE
Safety Instructions…………………………..
Placement of the Grill………………………..
SECTIONTWO
Side Burner, Side Shelf, & Spice Tray
Assembly……………………………………..
Side Burner Hose Quick-Connect…………
Side Shelf Handle & Battery Installation….
Braking System Operations……………….
Installation of Natural Gas Regulator……..
SECTION THREE
Gas Hook Up & Leak Testing……………….
Installer Final Check…………………………
SECTION FOUR
Operating Instructions………………………..
Lighting Instructions ………………………..
To Match Light the Grill……………………..
Lighting Illustrations…………………………
Using the Side Burner……………………….
Care and Maintenance of Side Burner……
Care and Maintenance of the Grill…………
Troubleshooting………………………………
SECTION FIVE
Exploded View…………………………….
Parts List………………………………….
SECTION SIX
Grilling Hints……………………………….
Grill Cooking Chart………………………
Grill Recipe Suggestions…………………
SECTION SEVEN
Limited Warranty………………………….
1-5
5
6
7
8
9
9
10
11
12
13
14
15
16
16
17
18
19
20
21
21-23
24-25
26
WARNING
To reduce the risk of fire, burn hazard or other
injury, read this Care and Use Manual carefully
and completely before using your grill.

SAFETY INSTRUCTIONS
WARNING
1. The grill and its individual shut-off valve must be disconnected from the gas supply piping
system during any pressure testing of that system at test pressure in excess of ½ psi. (3.5
kpa).
2. The grill must be isolated from the gas supply piping system by closing its individual
manual shut-off valve during any pressure testing of the gas supply piping system at test
pressure equal to or less ½ psi. (3.5 kpa).
WARNING
Never attempt to use damaged or obstructed equipment. See your local liquid propane dealer for
repair.
WARNING
Check all gas supply fittings for leaks before each use. Do not use the grill until all connections
have been checked and do not leak.
Do not smoke while leak testing.
Never leak test with an open flame.
WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIONS” section of this
manual.
CAUTION
When using the rotisserie burner, remove the
warming rack. High heat from the burner
may cause the warming rack to bend.
WARNING
The rotisserie motor is equipped with a plug and should
be plugged directly into a properly grounded receptacle.
DO NOT cut or remove the grounding prong from this
plug.
Keep the rotisserie motor electric cord away from the
heated surfaces of the grill. When not in use remove and
store the motor in a dry location
WARNING
1. Attach the coupling half (socket) to
the gas supply line in accordance
with NFPA54/ANSI Z223.1FUEL gas
code.
2. Prior to inserting the plug, test the
connection for leaks following the
leak test instructions on page 10.
After the leak test is completed, rinse
the connection with clean water to
remove any corrosive residue.
3. Do not use open flame to test for
leaks.
WARNING
Spiders and insects can nest inside the burners of
the grill and disrupt gas flow. This very dangerous
condition could cause a fire behind the valve panel,
thereby damaging the grill and making it unsafe for
operation.
Inspect the grill at least twice a year.
WARNING – Hazards or unsafe
practices which COULD result in severe
personal injury or death.
CAUTION – Hazards or unsafe practices
which COULD result in minor personal
injury.
WARNING
CAUTION
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
1

SAFETY INSTRUCTIONS
WARNING
When lighting, keep your face and hands
as far away from the grill as possible.
CAUTION
When using a match to light the grill make
sure to use the attached lighting rod.
CAUTION
Before cleaning, make sure the gas supply
and control knobs are in the “OFF” position
and the burners have cooled.
WARNING
WARNING
If you smell gas:
1. Shut off gas to the appliance.
Failure to properly place the burner over
the orifice could cause a fire to occur
behind and beneath the valve panel,
thereby damaging the grill and making it
unsafe to operate.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your
gas supplier or your fire department.
WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
WARNING
Do not leave the grill unattended while
cooking.
WARNING
Do not use the grill if the odor of gas is
present. Contact customer service at 1-
800-554-5799.
2

SAFETY INSTRUCTIONS
USING THE SIDE BURNER
Inspect the gas supply hose prior to turning on
the gas. If there is evidence of cuts, wear or
abrasion, it must be replaced prior to use. Do
not use the side burner if gas odor is present.
WARNING
Do not attempt to light the grill if gas odor is
present. Contact customer service at 1-800-
554-5799.
When lighting, keep your face and body as far
away from the burner as possible.
BEFORE LIGHTING
Inspect the gas supply hose prior to turning on the
gas. If there is evidence of cuts, wear, or abrasion,
it must be replaced prior to use.
Only the pressure regulator and hose assembly
supplied with the unit should be used. Never
substitute regulators for those supplied with the
grill. Contact customer service for proper
replacement.
Leak check the piping and regulator connections
with a soap and water solution before operating
the grill (See the “Leak Testing” instructions on
page 10).
Do not turn “ON” the gas supply at the natural gas
shut off valve unless the Quick-Connect gas hose
is properly connected to the side burner gas pipe
system and all burner valves are in the “OFF”
position.
WARNING
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
Keep a spray bottle of soapy water near the
gas supply valve and check the connections
before each use.
ROTISSERIE DRIVE MOTOR
To ensure continued protection against electric
shock:
Connect to properly grounded outlets only.
Keep extension cord connections dry and off
the ground.
Do not expose to rain.
Do not use indoors.
WARNING
If you smell gas:
1. Shut off gas to the grill.
2. Open the top cover or lid.
3. Extinguish any open flames.
4. If the odor continues, immediately call your
gas supplier or local fire department.
3