kozy heat SP-34-LE User manual

HUSSONG MANUFACTURING CO., INC.
INSTALLATION AND
OPERATION MANUAL
ͷDo not store or use gasoline or other
ammable vapors and liquids in the vicinity
of this or any other appliance.
ͷWHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
• If you cannot reach your gas supplier,
call the re department.
ͷInstallation and service must be performed
by a qualied installer, service agency or
the gas supplier.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
This appliance may be installed in
an aftermarket, permanently located,
manufactured home (USA only) or mobile
home, where not prohibited by local codes.
This appliance is only for use with the type
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certied kit is used.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
English and French installation manuals are available through your
local dealer. Visit our website www.kozyheat.com.
Les manuels d’installation en français et en anglais sont disponibles
chez votre détaillant local. Visitez www.kozyheat.com .
DANGER
HOT GLASS WILL
CAUSE BURNS
DO NOT TOUCH GLASS
UNTIL COOLED
NEVER ALLOW CHILDREN
TO TOUCH GLASS
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with this
appliance and shall be installed for the protection
of children and other at-risk individuals.
SP-34-LE
SP-34-MV
Models #SP-34-LE & #SP-34-MV
Direct Vent Gas Fireplaces
Hussong Mfg. Co., Inc.
SP-34-LE & SP-34-MV Report No: 19-553
Rev. 5, January 2020
Starting Serial Number: 20 83450 12

#SP-34 LE & MV R.5 January 2020 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces 3
Read this manual before installing or operating this appliance.
Please retain this owner’s manual for future reference.
Jim Hussong
President
Dudley Hussong
Board Chairman
Homeowner Reference Information
We recommend you record the following information:
Model Name: ____________________________________________
Serial Number: ___________________________________________
Dealership Purchased from: ________________________________
Date purchased/installed: __________________________________
Location of replace: ______________________________________
Dealer phone: ___________________________________________
Notes: ______________________________________________________________________________________________________________
____________________________________________________________________________________________________________________
____________________________________________________________________________________________________________________
____________________________________________________________________________________________________________________
CON GRAT ULAT ION S!
We welcome you as a new own of a Kozy Heat gas feplace. Kozy Heat products e
designed with supi components and matials, and assembled by ained crasmen who
take pride in the wk. To ense you eceive a quality product, the bn and valve assembly
e 100 pcent test-fed, and the complete feplace is thoughly inspected befe packaging.
O commitment to quality and custom satisfaction has emained the same f ov 40 yes.
Weoacompletelineofgasandwoodfeplaces,alongwithstylishaccessiestocomplement
any dec. Adding a feplace is one of the best ways to increase the value of yo home, and
we e proud to o a netwk of deals throughout the couny to help make yo expience
evything you imagine. We pride oselves in being dedicated not only to functionality and
eliability, but also custom safety. We o o continual suppt and guidance to help you
achieve the maximum benet and enjoyment om yo Kozy Heat gas feplace.

#SP-34 LE & MV R.5 January 2020 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces TABLE OF CONTENTS 5
TABLE OF CONTENTS
TABLE OF CONTENTS.....................................................................5
1.0 INTRODUCTION ......................................................................7
1.1 Appliance Certication ............................................................................. 7
1.2 California Proposition 65 Warning........................................................ 7
1.3 Requirements for the Commonwealth of Massachusetts............ 7
2.0 SPECIFICATIONS ..................................................................... 8
2.1 Heating Specications .............................................................................. 8
2.2 Electrical Specications ............................................................................ 8
2.3 Appliance Dimensions.............................................................................. 9
2.4 Safety Barrier Dimensions........................................................................ 10
3.0 FRAMING .................................................................................11
3.1 Appliance Placement Considerations ................................................. 11
3.2 Floor Support and Protection................................................................. 11
3.3 Stand-o Assembly and Installation.................................................... 12
3.4 Nailing Tabs Installation............................................................................ 12
3.5 Clearances to Combustibles ................................................................... 13
3.6 Wall Enclosure Rough Opening ............................................................. 14
3.7 Vent Termination Framing ....................................................................... 15
3.8 Outdoor Covered Fireplace Installation.............................................. 16
4.0 FACING AND FINISHING.........................................................18
4.1 Facing and Finishing Requirements..................................................... 18
4.2 Safety Barrier Installation......................................................................... 20
5.0 GAS LINE CONNECTION .........................................................21
5.1 Gas Conversion (sold separately).......................................................... 21
5.2 Gas Pressures................................................................................................ 21
5.3 Gas Line Installation................................................................................... 21
6.0 TERMINATION LOCATIONS .................................................... 22
6.1 Vertical Vent Cap Termination ................................................................ 22
6.2 Minimum Termination Clearances........................................................ 23
7.0 VENTING ..................................................................................24
7.1 Approved Vent Systems............................................................................ 24
7.2 Venting Requirements .............................................................................. 24
7.3 Use of Elbows ............................................................................................... 24
7.4 Restrictor Plate Assembly and Installation ........................................ 24
7.5 Vent Installation........................................................................................... 25
7.6 Class A Chimney/Masonry Chimney Conversion............................ 28
7.7 Coaxial to Co-Linear Chimney Conversion........................................ 29
7.8 #700-2 Series Direct Vent Termination Kit(s)..................................... 30
7.9 Vent Heat Shield Assembly Installation .............................................. 32
8.0 FIREPLACE SETUP...................................................................33
8.1 Glass Frame Assembly............................................................................... 33
8.2 #SP34-50A Log Set Installation.............................................................. 34
8.3 Control Board Removal and Installation............................................. 35
9.0 ELECTRICAL INFORMATION .................................................. 36
9.1 Electrical Specications ............................................................................ 36
9.2 Wiring Requirements................................................................................. 36
9.3 #SP-028 Optional Fan Kit.......................................................................... 39
10.0 OPERATING INSTRUCTIONS................................................40
10.1 Lighting Instructions (#SP-34-LE) ....................................................... 40
10.2 Lighting Instructions (#SP-34-MV) .................................................... 42
11.0 ADJUSTMENT........................................................................ 44
11.1 Gas Pressure Testing................................................................................ 44
11.2 Burner Flame Adjustments ................................................................... 46
12.0 TROUBLESHOOTING............................................................. 48
12.1 Electronic Ignition System .................................................................... 48
12.2 Continuous Pilot Ignition (Millivolt) System................................... 50
13.0 MAINTENANCE......................................................................52
13.1 Firebox.......................................................................................................... 52
13.2 Fan (optional)............................................................................................. 52
13.3 Vent System................................................................................................ 52
13.4 Glass Assembly.......................................................................................... 52
13.5 Burner and Pilot System ........................................................................ 53
14.0 REPLACEMENT PARTS LIST..................................................54
LIMITED LIFETIME WARRANTY ....................................................57