Lec+ CLGN700ST User manual

Gastronorm Refrigerators &
Freezers
CLGN700ST CUGN700ST CLGN1400ST CUGN1400ST
SKU’s 444449448 444449449 444449450 444449451
Glen Dimplex Professional Appliances
Stoney Lane, Prescot, Merseyside, L35 2XW
Tel: [phone]
www.lec-commercial.co.uk
Instruction Manual
Please read and
keep these
instructions
700 litre 1400 litre

INTRODUCTION
Please take a few moments to carefully read this manual. Correct maintenance and
operation of this machine will provide the best possible performance from your product.
TECHNICAL SPECIFICATIONS
Weight 134kg 138kg 198kg 208kg
Dimensions W x D x H 740 x 830 x 2010mm 740 x 830 x 2010mm 1480 x 830 x 2010mm 1480 x 830 x 2010mm
Gastro- norm 2/1 2/1 2/1 2/1
Net capacity 597 litre 597 litre 1325 litre 1325 litre
Gross capacity 700 litre 700 litre 1400 litre 1400 litre
Temperature range -2°C to 8°C -18°C to -22°C -2°C to 8°C -18°C to -22°C
Current 2.8A 2.8A 5.6A 5.6A
Power 650W 650W 1300W 1300W
Voltage 230V ~50Hz 230V ~50Hz 230V ~50Hz 230V ~50Hz
SKU Number 444449448 444449449 444449450 444449451
Model CLGN700ST CUGN700ST CLGN1400ST CUGN1400ST

INSTALLATION
Safety Tips:
• Position on a at, stable surface.
• A service agent/qualied technician should carry out installation and any repairs if
required. Do not remove any components or service panels on this product.
• Consult Local and National Standards to comply with the following:
• Health and Safety at Work Legislation
• BS EN Codes of Practice
• Fire Precautions
• IEE Wiring Regulations
• Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g. heaters, ice-cream makers
etc).
• DO NOT stand or support yourself on the base, shelves or doors.
• DO NOT allow oil or fat to come into contact with the plastic components or door seal.
Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in
the refrigerator.
• Always carry, store and handle the appliance in a vertical position and move by holding
the base of the appliance.
• Always switch off and disconnect the power supply to the unit before cleaning.
• Keep all packaging away from children. Dispose of the packaging in accordance with the
regulations of local authorities.
• If the power cord is damaged, it must be replaced by an agent or a recommended
qualied technician in order to avoid a hazard.
Electrical Wiring:
Appliances are supplied with a 3 pin, moulded, BS1363 plug and lead, with a 13 amp fuse
as standard. The plug is to be connected to a suitable mains socket. Appliances are wired
as follows:
Live wire (coloured brown) to terminal marked L
Neutral wire (coloured blue) to terminal marked N
Earth wire (coloured green/yellow) to terminal marked E
All appliances must be earthed, using a dedicated earthing circuit.
If in doubt consult a qualied electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any
emergency disconnection being required they must be readily accessible.
Pack Contents:
The following is included:
• Refrigerator or Freezer
• Shelves x 4 (Single) / x 8 (Double)
• Keys x 2
• Instruction manual
• Shelf guides x 8 (Single) / x 16 (Double)
We pride ourself on quality and service, ensuring that at the time of packaging the contents
are supplied fully functional and free of damage. Should you nd any damage as a result
of transit, please contact your dealer immediately.

Installation:
IMPORTANT: If the appliance has not been stored or moved in an upright position,
let it stand upright for approximately 12 hours before operation. If in doubt allow the
appliance to stand.
1. Remove the appliance from the packaging. Make sure that all protective plastic lm and
coatings are thoroughly removed from all surfaces.
2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for
ventilation. Increase this distance if the obstacle is a heat source.
3. Set the brakes on the castors to keep the appliance in position.
4. Before using the appliance for the rst time, clean the shelves and interior with soapy
water.
Removing the Compressor Safety Band:
The compressor is located on the top of the appliance, and sits on rubber washers. Under
normal operating conditions the compressor is allowed to vibrate. To avoid damage
through excessive motion during transit, a stainless steel safety band is placed over the
compressor and screwed into the top of the appliance. This safety band and the two
screws xing it to the appliance MUST BE REMOVED before the appliance is turned on.
Lock/Unlock the Doors:
A lock is tted to the doors to ensure foodstuffs are kept secure within your appliance.
Use the keys provided to lock/unlock the door.
Fitting the Shelves:
1. Place one set of shelf guides on either side of the cabinet at the desired height.
2. Slide the shelf into place.
3. Repeat for the remaining shelves.
Changing the Door Hinge:
The door can be changed from right hand-hinged to left hand-hinged, or vice versa.
1. Remove the top hinge pin, lift off the door, remove the bottom hinge pin.
2. Fit the bottom hinge pin on the desired side.
3. Place the door on the bottom hinge pin, t the top hinge pin.

USER GUIDE
Storing Food:
To get the best results from your appliance, follow these instructions:
• Only store foodstuffs in the appliance when it has reached the correct operating
temperature.
• Do not place uncovered hot food or liquid inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods of time.
Turn On:
1. Close the door(s) of the appliance.
2. Ensure the power switch is set to [O] and turn on at the socket.
3. Switch on the Power [I]. The current temperature within the appliance is displayed. The
set temperature is factory set and normally will not require adjustment.
Auto Defrost:
The appliance will automatically run a defrost cycle every six hours.
Note: The cycle starts from the time the appliance is initially powered up.
Manual Defrost:
1. Press and hold the DEFROST button for 5 seconds.
2. The defrost cycle will start immediately and the Defrost LED illuminates. The defrost will
last a maximum of 30 minutes.
Note: Starting a manual defrost also resets the automatic defrost timer. The next automatic
defrost will start six hours after the manual defrost has nished.
Cleaning, Care & Maintenance:
• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance frequently.
• Do not use abrasive cleaning agents. These can damage the surface nish.
• Clean the door seal with water only.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation
pan.
• Take care when cleaning the rear of the appliance. Sharp edges can cut.
• An agent or qualied technician must carry out repairs if required.
Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance.
We recommend that our agent or qualied technician clean the condenser.
Troubleshooting
If your appliance develops a fault, please check the following table before making a call to
your retailer.
Fault Probable Cause Action
The appliance is not working The unit is not switched on Check the unit is plugged in
correctly and switched on
Plug and lead are damaged Call your agent or qualied
Technician
Fuse in the plug has blown Replace the fuse
No power supply Check power supply
Internal wiring fault Call your agent or qualied
Technician

The appliance turns on, but
the temperature is too high/
low
Too much ice on the
evaporator
Defrost the appliance
Condenser blocked with dust Call your agent or qualied
Technician
Doors are not shut properly Check doors are shut and
seals are not damaged
Appliance is located near a
heat source or air ow to the
condenser is being interrupted
Move the refrigerator to a
more suitable location
Ambient temperature is too
high
Increase ventilation or move
appliance to a cooler position
Unsuitable foodstuffs are
being stored in the appliance
Remove any excessive
hot foodstuffs, remove any
foodstuffs preventing air ow
around the fan
Appliance is overloaded Reduce the amount of food
stored in the appliance
The appliance is leaking water The appliance is not properly
levelled
Level the appliance
The discharge outlet is
blocked
Clear the discharge outlet
Movement of water to the
drain is obstructed
Clear the oor of the
appliance
The evaporation pan is
damaged
Call your agent or qualied
Technician
The appliance is unusually
loud
Loose nut or screw Check and tighten all nuts and
screws
The appliance has not been
installed in a level or stable
position
Check installation position and
change if necessary
Disposal:
EU regulations require refrigeration product to be disposed of by specialist
companies who remove or recycle all gasses, metal and plastic components.
Consult your local waste collection authority regarding disposal of your
appliance. Local authorities are not obliged to dispose of commercial
refrigeration equipment but may be able to offer advice on how to dispose of
the equipment locally.

GUARANTEE
This refrigerator is guaranteed against defective materials or faulty workmanship, for a
period of 24 months on parts and labour.
This guarantee is given subject to the appliance being used in accordance with the
instructions supplied, and on the supply voltage marked on the rating label. The guarantee
is subject to fair wear and tear conditions.
The guarantee does not cover consequential damage arising out of any failure
acceptable under guarantee, nor does it cover damage resulting from misuse, accident or
unauthorised alterations to the appliance.
Proof of purchase will be required.
In any communication with the supplier or manufacturer, quote the model and serial
number marked on the appliance rating label.
This guarantee does not affect your statutory rights.
The products are intended for commercial use as detailed in these instructions.
The Company has a policy of continuous improvement in product quality and design. The
Company therefore reserves the right to change the specication at any time.
COMPLIANCE
Parts have undergone strict product testing in order to comply with regulatory standards
and specications set by international, independent, and federal authorities.
Products have been approved to carry the following symbol:

Customer helpline
For spares and after-sales service please contact
Lec on:
T: 0844 815 3755
F: 0844 815 3748
E: [email protected]
Glen Dimplex Professional Appliances
(A Division of Glen Dimplex Home Appliances)
Stoney Lane,
Prescot,
Merseyside L35 2XW
www.lec-commercial.co.uk
08.2011