LEW ELECTRIC PUFP-CT-WC Seris User manual

!
!"#!$%&$'%()*+,*)(,-)&.//.&,0-(1",2*(
(
#0+(!.+&(-"34*+)5(!"#!$%&$4$'%6((!"#!$%&$47$'%6((!"#!$%&$24$'%6((!"#!$%&$
0'$'%6((!"#!$%&$-)$'%6((!"#!$%&$))$'%(6((!"#!$%&$4$89.$8")4$'%6((!"#!$%&$47$
89.$8")4$'%6(!"#!$%&$24$89.$8")46((!"#!$%&$0'$89.$8")4$'%(6(!"#!$%&$-)$
89.$8")4$'%6(!"#!$%&$))$89.$8")4$'%(
(
!
!+,0+(&0(,-)&.//.&,0-5(
1.!!To!ensure!compliance!with!local!electric!codes,!please!contact!your!local!
electrical!inspector!prior!to!installation!
2.!!Do!not!install!PUFP-CT-WC!prior!to!electrical!inspector!authorization.!
3.!Installation!should!only!be!done!by!a!licensed!and!bonded!electrical!contractor.!
4.!All!power!must!be!turned!off!at!its!source!prior!to!installation.!!Failure!to!do!so!
may!result!in!injury!or!death.!
5.!If!anytime!water!enters!into!the!PUFP-CT-WC,!turn!off!power!at!its!source!and!
have!the!unit!replaced!by!a!licensed!and!bonded!electrical!contractor.!
6.!!All!PUFP-CT-20A-2USB-WC!are!supplied!with!dust!covers!for!the!USB!ports.!!
These!dust!covers!must!remain!inside!the!USB!openings!UNLESS!the!port(s)!is!in!
use.!!Failure!to!do!so!will!void!any!ETL!listing.!!
7.!!All!PUFP-CT-WC!include!a!20!amp!cord/plug.!!Under!no!circumstances!should!the!
cord!be!cut!and!the!unit!hard!wired.!!This!will!void!any!ETL!listing!and!any!warranty!
provided!by!Lew!Electric.!!!
8.!!All!!-0-(1#%,(!"#!$%&$'%!series!must!be!connected!to!a!GFCI!circuit!breaker.!!
Failure!to!do!so!will!increase!the!risk!of!injury.!
!
(/*'(*/*%&+,%(.%%*!&)(-0(+*)!0-),4,/,&:(,#(&;*(.40<*(%0-2,&,0-)(.+*(
-0&(3*&=!
!
+*>",+*2(&00/)5(
-Construction!Adhesive,!Crimpling!Pliers/!Wire!Strippers,!Philips!Head!Screw!
Driver,!and!Drill.!
!
,-)&.//.&,0-(?!@AB(0CDE5(
1.!Prior!to!installation,!a!professional!granite!cutter!should!cut!a!4!1/16”!x!4!1/16”!
hole!in!the!desired!location!of!the!PUFP-CT.!
2.!Always!use!the!supplied!PUFP-WB!stamped!steel!box!
3.!The!tabs!on!the!side!of!the!PUFP-WB!box!must!be!attached!to!the!BOTTOM!of!the!
countertop.!!Please!note!that!the!PUFP-CT!will!not!work!if!the!tabs!are!mounted!on!
the!top!of!the!counter.!

4.!Apply!construction!adhesive!on!the!top!of!the!2!tabs!on!the!PUFP-WB!box!to!
secure!the!box!to!the!bottom!of!the!countertop!(alternately!wood!blocks!can!be!
secured!on!the!bottom!of!the!counter!so!that!you!can!install!the!box!using!1!½”!
wood!screws.!
5.!Please!note!that!the!tabs!can!be!moved!to!the!lower!set!of!holes!on!the!PUFP-WB!
box!to!accommodate!varying!depths!of!counter!top.!
6.!For!best!performance!it!is!preferred!to!mount!the!box!with!the!top!edge!sitting!
lower!in!the!hole,!which!leaves!more!room!for!the!inside!of!the!box!(see!video).!
!
,-)&.//.&,0-((?!@AB(&FGE(
1.!Place!the!PUFP-CT!cover!on!top!of!the!PUFP-WB!box!
2.!Remove!the!protective!film!from!the!PUFP-CT-WC!cover!and!press!the!open!tab!
on!the!PUFP-CT-WC!cover!exposing!the!two!mounting!screw!holes!inside!the!cover.!
3.!Line!up!the!two!screw!holes!with!the!PUFP-CT-WC!cover!and!the!PUFP-WB!box!
and!using!the!2!provided!screws,!secure!the!cover!to!the!box!(do!not!over!tighten!as!
this!may!interfere!with!the!opening!mechanism!of!the!box.)!
4.!To!close!the!cover,!press!and!hold!the!open!tab!while!pressing!down!on!the!cover!
until!you!hear!a!click!and!the!unit!is!locked!into!place.!
5.!Open!and!close!the!unit!several!times!to!make!sure!that!the!unit!is!opening!
properly!and!at!the!desired!speed.!!All!units!are!preset!to!the!optimal!functioning!
speed!at!the!factory!before!they!are!shipped.!
6.!!If!the!desired!opening!speed!has!not!been!achieved,!remove!the!remove!the!
PUFP-CT-WC!from!the!counter!and!turn!the!PUFP-CT-WC!cover!upside!down.!!
Locate!the!tension!screw!and!turn!the!screw!to!add!or!subtract!the!opening!speed.!!
!
!/"1(,-(%0+2(&0(.!!+0<*2(*/*%&+,%./(0"&/*&(
!
&+0"4/*();00&,-1(
(
SYMPTOM'
RESOLUTION'
Button&does&not&
work&
Make& sure& that& the& tabs& on& the& PUFP-WB& box& were& installed& underneath& the&
counter.&
&
&&
Turn&off&power&at&its&source,&take&the&PUFP-CT&out&of&the&box&and&make&sure&that&no&
excess&wires&are&interfering&with&the&opening&mechanism.&
&&
&
&&
Open&the&cover&by&pressing&button&and&make&sure&that&the&mounting&screws&are&not&
over&tightened&
&
&&
Turn&power&off&at&its&source.&&Place&the&cover&upside&down,&apply&a&small&amount&of&
WD-40&or&similar&lubricant&to&the&bottom&of&button&
Unit&pops&up&too&
slow&
Turn&off&power&at&its&source,&remove&the&PUFP-CT&from&the&counter&and&turn&the&
PUFP&upside&down.&
&&
Locate&the&tension&screw&and&turn&the&screw&to&add&or&subtract&opening&speed&
!
!