Lexus LX570 2017 User manual

2017LX 570 Pre-Delivery Service Manual
Lexus Technician:
Before you perform Pre-Delivery Service (PDS) on this vehicle, be sure you:
• ReadandunderstandthisPDSManual
• ReadandunderstandallapplicablePDSTechnicalServiceInformationBulletins(TSIBs) & applicable
Repair Manual information for this vehicle
• ReadandunderstandthePDSPrecautionsintheTSIBs
• Attendthe“TechnicalIntroductiontoLexusCourseL005”attheLexusAreaOfce
When performing PDS on this vehicle:
• UsethePDSManualwhenperformingthisservice
• CheckTechnicalInformationSystem(TIS)foranyupdatedPDSTSIBsand applicable Repair Manual information
• VerifythattheVehicleIdenticationNumber(VIN)onrepairorderandvehiclematch
• Liftvehicleandperformundervehiclesafety/damageinspection
• Roadtestvehiclelongenoughtotesthotengineanddriveoverroughroad(Bottdots)totestforrattles/
squeaks
The following TSIBs are available on TIS:
BatteryMaintenanceforIn-StockVehicles&Pre-Delivery(Revised)
D/CCutFuseInstallationDuringPDS
EnformApps&DataServicesDownload&InstallationProcess
FloorMatInstallationDuringPDS
FrontLicensePlate&MountingBracketInstallation
InstallationofTowingWireHarnessConnectorDuringPDS
Long-TermVehicleStorageGuidelines
ParkingAssistMonitorSystemInitialization
TirePositioningBeforeNewVehicleDelivery
TirePressureWarningSystemInitialization
XMActivationConrmationDuringPDS
To obtain PDS material:
Manual
• DownloadfromTIS
CheckSheet
• DownloadandprintfromTIS
• Sheetistwo-sided;backsidehasproceduretips
OtherPDSTSIBs and applicable Repair Manual information
• DownloadfromTIS
Contact your District Service & Parts Manager if you have any questions.
MM/JBS201608
©2016Lexus,aDivisionofToyotaMotorSalesUSA,Inc.
TPWS Operation Verication
1. ConnectTechstreamtoDLC3.
2. Adjustalltires,includingthesparetire,tothestandardtireinationpressureasindicatedonthetireand
loadinginformationlabelonvehicle.
NOTE:
• Toadjusttirepressurecorrectlywhenoutsidetemperatureissignicantlycolderorwarmerthanshop
temperature,performaHealthCheckusingTechstreamandselectthe“CompensationTirePressure”
checkbox.CompensationpressureswillbedisplayedontheHealthCheckresultsscreen.
• Adjustthetirepressurewhenthetiresarecold.

2017MY
LX570
Pre-Delivery
Service Manual

INSPECTION DETAILS
 A.ENGINECOMPARTMENT........................................................ 1
 B.LOCKSANDLIGHTS................................................................ 5
 C.LEFTFRONT............................................................................. 11
 D.LEFTREAR............................................................................... 33
 E.CARGOAREA........................................................................... 41
 F. RIGHTREAR............................................................................. 43
 G.RIGHTFRONT.......................................................................... 44
 H.FRONTBUMPER...................................................................... 46
 I. UNDERVEHICLE(SAFETY/DAMAGE).................................... 47
 J. ROADTEST.............................................................................. 51
COMPLETION....................................................................................... 63
INDEX ................................................................................................... 65
I
TABLE OF CONTENTS
LX570

1Powersteeringuidreservoir............................................................................... 4
2Engineoilleveldipstick........................................................................................ 2
3Enginecoolantreservoir....................................................................................... 3
4Engineoilllercap................................................................................................ -
5Brakeuidreservoir.............................................................................................. 2
6Fusebox................................................................................................................-
7Washeruidtank.................................................................................................. 4
8Battery.................................................................................................................. 3
9Coolingfans........................................................................................................ 53
10Condenser.............................................................................................................-
  Radiator................................................................................................................. -
Page
NOTE:
Install protective fender covers prior to beginning the under-hood inspection.
11
II
TABLE OF CONTENTS
LX570

Engineswitch....................................................................................................... 8
Shiftlever............................................................................................................ 52
Meters................................................................................................................ 19
Multi-informationdisplay..................................................................................... 23
Parkingbrake..................................................................................................... 54
Turnsignallever................................................................................................... 9
Headlightswitch................................................................................................... 9
Windshieldwiperandwasherswitch(frontandrear)......................................... 17
Emergencyasherswitch................................................................................... 10
Fuelllerdooropener......................................................................................... 16
Hoodlockreleaselever....................................................................................... 2
Tiltandtelescopicsteeringcontrolswitch*......................................................... 23
Frontairconditioningsystem.............................................................................. 24
Audiosystem...................................................................................................... 25
Hands-freesystem............................................................................................. 26
Page
1
2
3
4
5
6
7
8
9
10
11
12
13
6
13
III
TABLE OF CONTENTS
LX570

Audioremotecontrolswitches............................................................................26
Talkswitch..........................................................................................................26
Telephoneswitches............................................................................................26
Metercontrolswitches........................................................................................23
Vehicle-to-vehicledistancebutton*.....................................................................58
LDA(LaneDepartureAlert)switch*....................................................................55
Cruisecontrolswitch*.........................................................................................58
Dynamicradarcruisecontrolswitch*.................................................................58
Paddleshiftswitches*............................................................................................-
Page
*Ifequipped
1
2
3
4
5
6
7
8
7
IV
TABLE OF CONTENTS
LX570

*Ifequipped
Insiderearviewmirror.........................................................................................31
Sunvisors...........................................................................................................31
Vanitymirrors......................................................................................................31
Personal/Interiorlights........................................................................................15
Moonroofswitches..............................................................................................31
“SOS”button*.....................................................................................................32
Garagedooropenerbuttons..............................................................................32
Page
1
2
3
4
5
6
7
V
TABLE OF CONTENTS
LX570

*Ifequipped
Outsiderearviewmirrorswitches........................................................................15
Windowlockswitch.............................................................................................14
Doorlockswitches..............................................................................................14
Powerwindowswitches.......................................................................................14
Drivingpositionmemorybuttons*........................................................................13
Automatichighbeamswitch................................................................................10
Headlightcleanerswitch*....................................................................................17
HUD(Head-updisplay)switches*.......................................................................16
Easyaccessmodeswitch...................................................................................57
“RSCAOFF”switch.............................................................................................60
Instrumentpanellightcontroldial........................................................................16
Odometer/Tripmeterandtripmeterresetbutton................................................16
Page
1
2
3
4
5
6
7
8
9
10
11
12
VI
TABLE OF CONTENTS
LX570

*Ifequipped
CrawlControlswitches/Multi-terrainselectmodeselectordial.......................... 59
VSCOFFswitch................................................................................................. 60
Centerdifferentiallock/unlockswitch................................................................. 56
Secondstartmodeswitch.................................................................................. 55
Four-wheeldrivecontrolswitch.......................................................................... 56
Heightselect/HeightcontrolOFFswitches......................................................... 57
Drivingmodeselectswitch................................................................................. 60
Frontseatheater/ventilatorswitches*................................................................ 30
Heatedsteeringwheelswitch*........................................................................... 28
Remotetouch........................................................................................................-
Page
1
2
3
4
5
6
7
8
9
10
VII
TABLE OF CONTENTS
LX570

Tirepressurewarningresetswitch..................................................................... 12
PCS(Pre-CollisionSystem)switch*................................................................... 11
Powerbackdoorswitch...................................................................................... 18
Powerbackdoormainswitch................................................................................ -
VIEWswitch....................................................................................................... 59
Intuitiveparkingassistswitch............................................................................. 28
Page
1
2
3
4
5
6
*Ifequipped
VIII
TABLE OF CONTENTS
LX570

INSPECTION DETAILS
LX570

WASHING VEHICLE
Afterwashingvehicle,makesurealladhesivewrappinglm
isremoved.
NOTE:
Handwashingisrecommended.
WATER LEAK TEST
Visuallyandbyhandcheckforwaterleaksinthevehicle
interiorfromeachofthefollowingareas(makesurethatthe
trimandoorcarpetarenotdamp):
a)Doorglassweatherstrips
b)Frontcowlsides
c)Aroundthewindshield
d)Aroundtheslidingroofarea
e)Aroundtherearwindows
PAINT FINISH (PAINT DEFECTS, DAMAGE)
Visuallyandbyhandinspectallbodypanels(doors,back
door,fenders,enginehood,roofpanel)forsurfacedamage
fromshipmentorforanyabnormalities(surfacerust,paint
aking,chips,dentsorscratches).
NOTE:
Carefullyinspectallpaintedsurfacesinawell-illuminated
area(800-luxilluminationisrecommended).
EXTERIOR PARTS FOR FIT
Visuallyandbyhandcheckthefollowingpartsforproper
installation,rust,t,misalignmentandlooseitems:
a)Frontandrearbumpers
b)Windowmoldings(front,sideandrear)
c)Lexusemblems(frontandrear)
d)Outsiderearviewmirrors
e)Headlights,turnsignallights,sidemarkerlights,fog 
 lightsandtaillightlenses
f)Doors,enginehoodandfuelllerdoor
g)Moonroof
h)Front/Reardoorpanelprotector
i)Outsidedoorhandle
j)Radiatorgrille
1
LX570
INSPECTION DETAILS - A. ENGINE COMPARTMENT

ENGINE HOOD RELEASE LEVER
Usetheenginehoodreleaselevertocheckthatthelatch
operatesproperly.Ensurethattheenginehoodopensand
closessmoothly.
BRAKE FLUID LEVEL
Visuallychecktheuidlevelthroughthereservoir.Ifthe
uidlevelislow,replenishthebrakeuidreservoirwith
FMVSSNo.116DOT3orSAEJ1703brakeuidandcheck
foruidleaks.Brakeuidlevelshouldbeatthe“MAX”line
(within0.2inches[5.0mm]below).
NOTE:
RefertotheRepair Manualforuidspecications.
ENGINE OIL LEVEL (ENGINE NOT
RUNNING)
a)Removetheengineoilleveldipstickandwipeitclean. 
 Reinsertthedipstickandpullitouttochecktheoillevel. 
 Thelevelshouldbebetweenthetwomarks.
1Low
2Normal
   Excessive
b)Checktheoilfordirtorimpurities.
NOTE:
Iftheoillevelislow,addspeciedengineoilandcheck 
foroilleaks.
3
2
LX570
INSPECTION DETAILS - A. ENGINE COMPARTMENT

1
2
ENGINE COOLANT LEVEL
Visuallycheckthecoolantlevelthroughthecoolant
reservoirtankwhentheengineiscool.Thecoolantlevelis
satisfactoryifthelevelisbetweenthe“FULL”and“LOW.”
1Reservoircap
2FULL
3LOW
Onlyuse“ToyotaSuperLongLifeCoolant.”
CAUTION:
Toavoidburningyourself,donotremovetheradiatorcap
whentheengineishot.
BATTERY TERMINAL TIGHTNESS AND
CHARGE
a)Checktheelectrolytelevel.Iftheelectrolytelevelislow, 
 checkthebatterycaseforleakage.
b)Checkthebatterycharge.Measuretheopen-circuit 
 batteryvoltagebetweentheterminals.Ifthevoltage 
 readingislessthan12.6volts,rechargethebattery.
NOTE:
Beforemeasuringthevoltage,turnofftheengineandall
electricalsystems.Wait60secondstoremovethesurface
charge.Iftheenginewasrunningbeforemeasuringthe
voltage,wait20minutesaftertheenginestopstoremove
thesurfacecharge.
c)Checkthatthebatteryterminalsareproperlyconnected 
 andthattheclampisrmlyinstalled.
   Terminals
   Hold-downclamp
3
LX570
INSPECTION DETAILS - A. ENGINE COMPARTMENT

WASHER FLUID LEVEL
Openthewashertankcapandvisuallycheckthewasher
uidlevelinthewashertank.Theuidlevelshouldbelled
within2inchesofthecap.
WIRING AND HOSES
a)Checkthehoses,hoseconnectorsandvariousclamps 
 fortightness.
b)Visuallyinspecttheconditionofallharnessconnectors 
 andterminalsforproperinstallationandtightness.
POWER STEERING FLUID LEVEL
Visuallycheckuidlevelthroughthereservoir.
1Full(whencold)
2Adduid(whencold)
3Full(whenhot)
 Adduid(whenhot)
Iftheuidtemperatureishigh(140-175°F/60-80°C),the
readingshouldbeinthe“hot”range.
Iftheuidtemperatureislow(50-85°F/10-30°C),the
readingshouldbeinthe“cold”range.
Ifuidlevelislow,replenishwithautomatictransmission
uidDEXRON®IIorIII.
4
4
LX570
INSPECTION DETAILS - A. ENGINE COMPARTMENT

WIRELESS REMOTE CONTROL
Inspectthevefunctionsofthesystem.
1Locksthedoors
2Unlocksthedoors
3Opensthewindowsandmoonroof
4Opens/Closespowerbackdoor
   Soundsthealarm
a)Lockingthedoors
  1. Closeallthedoors.
  2. Press ontheelectronickeytolockallthedoors 
   fromoutsidethevehicle.
NOTE:
   When ispressedtolockdoors,abeepwill 
 soundandallturnsignallightswillashonce. 
   However,ifanydoorisnotclosedsecurely,
   pressing willcausethebuzzertosound 
   continuouslyuntilalldoorsareproperlyclosed.
b)Unlockingthedoors
  1. Press ontheelectronickeyoncetounlockthe 
   driver’sdoor.
  2. Press onceagainwithin3secondstounlockthe
   otherdoors
NOTE:
   Theinteriorlightandouterfootlightswillturnonand
   alltheturnsignallightsashtwice,soundingtwo 
   beeps.
  3. Checkthatalldoorsautomaticallyre-lockafter60 
   secondsifanydoorisnotopened.
c)Openingthewindowsandmoonroof
  Pressandhold ontheelectronickeytoopen
  thewindowsandmoonroof.
NOTE:
  Abuzzersoundstoindicatethatthewindowsand
  moonroofareoperating.
c)Opening/closingthebackdoor
Pressandhold toopenorclosethebackdoor.
NOTE:
  Abuzzersoundstoindicatethebackdoorisopening.
d)Soundingthealarm
  1. Pressandhold tosoundthealarm.
2. Tostopthealarm,pressanybutton.
5
5
LX570
INSPECTION DETAILS - B. LOCKS AND LIGHTS

SMART ACCESS SYSTEM
a)Withelectronickeyinsidethevehicle,touchthelock 
 sensor(ontheupperpartoftheoutsidedoorhandle)and
 pushthebackdoorlockbutton.Checkthatthebuzzer
 soundsandthatthedoorsdonotlock.
b)Taketheelectronickeyoutofthevehicleandtouch 
 thelocksensoragain.Checkthatthedoorlocks.
NOTE:
  Recognitionsignalsforthelockoperationwilloperate 
  uptotwoconsecutivetimes.
c)Fromadistanceofatleast2.3ft.(0.7m),approachthe 
 vehicleandpullthedriverandpassengersidedoor 
 handles,andthebackdooropener.Checkthatthedoors 
 unlock.
NOTE:
  Thedoorscannotbeunlockedfor3secondsafterthey 
  werelocked.
THEFT DETERRENT SYSTEM
Withthedoorslocked,checkthatthesystemoperates
properly.
System Test:
a)Openthewindows.
b)Lockthedoorsbysmartaccesssystem,wireless  
 remotecontrolormechanicalkey.Besuretowaituntil 
 thesecuritylightonthecenterpanelstartsashing.
c)Unlockoneofthedoorsusingtheinsidedoorlock.The 
 systemshouldactivatethealarm(soundingofthehorn, 
 blinkingoftheheadlights,taillightsandemergency 
 asher,lightingupinteriorlight).
d)Cancelthesystembyunlockingdoorswiththesmart 
 accesssystem,wirelessremotecontrolormechanical 
 key.
IMMOBILIZER SYSTEM
a)Checkthatthesecurityindicatorlightasheswhenthe 
 engineswitchisOFF.
b)Checkthattheenginecanbestartedusingall  
 thekeys.
c)Checkthatthesecurityindicatorlightturnsoffwhen 
 startingtheengine.
6
LX570
INSPECTION DETAILS - B. LOCKS AND LIGHTS

OUTERFOOTLIGHT
DOOR LOCK SYSTEM AND ILLUMINATED
ENTRY SYSTEM
a)Checkthatalldoorsopenandclosesmoothlyusingthe 
 insideandoutsidedoorhandles.
b)Checkthatthedoorscannotbeopenedbyusingthe 
 insideandoutsidedoorhandleswhenthelockbuttonis 
 inthelockedposition(exceptfrontinsidedoorhandles).
c)Forfrontinsidedoorhandles:Checkthatthefrontdoors 
 canbeopenedbyusingtheinsidedoorhandleswhen 
 thelockbuttonisinthelockposition.
d)Checkexteriorkeylockcontrolsystemoperationby
 mechanicalkey(withdriver’sdoor).
1Locksalldoors
2Closesthewindowsandmoonroof(pushandhold)
3Unlocksthedoor(two-stepunlockfunction):
  1.Turnthekeyoncetounlockthedriver’sdoor.
2.Turnthekeyagaintounlockallthedoors.
4Opensthewindowsandmoonroof
e)Checkthattheouterfootlightilluminateswhenthe
 doorisopened.
7
LX570
INSPECTION DETAILS - B. LOCKS AND LIGHTS

POWER SUPPLY CHANGEOVER AND
ENGINE START/STOP
Checkforproperactivationoftheengineswitch.
Powersupplychangeover
a)Carrytheelectronickeyinthevehicleandapplythe 
 parkingbrake.
b)Withoutdepressingthebrakepedal,pressthe  
 engineswitchandchangethepowersupply.
   1.OFF
   2.Pressonce:ACCESSORYmode
   3.Presstwice:IGNITIONONmode
   4.Pressthreetimes:OFF
c)Ineachmode,checkthatthepowersupplyhaschanged
 properly.
NOTE:
Iftheengineswitchilluminatorblinks,seeRepair Manual.
Engine start/stop
a)Carrytheelectronickeyinthevehicleandapplythe 
 parkingbrake.
b)Checkthattheshiftleverisinthe“P”position.
c)Whiledepressingthebrakepedal,checkthattheengine
 switchindicatorturnsgreen.
d)Presstheengineswitch.
EXTERIOR LIGHTS
Walkaroundthevehicleandcheckthatthefollowinglights
illuminate:
a)Headlights
b)Parkinglightsanddaytimerunninglights
c)Sidemarkerlights
d)Foglights
e)Turnsignallights
f)Licenseplatelights
g)Taillightsandhigh-mountedstoplight
h)Back-uplights
HEADLIGHT AIM
Ifheadlightaimisnotcorrect,seeRepair Manualfor
headlightaimprocedure.
8
LX570
INSPECTION DETAILS - B. LOCKS AND LIGHTS

TURN SIGNAL, HEADLIGHT, HIGH BEAM,
AUTOMATIC HIGH BEAM*, FOG LIGHTS
AND EMERGENCY FLASHER INDICATOR
LIGHTS
a)Checkthattheturnsignalindicatorlightsonthe  
 instrumentpanelilluminatewhentheturnsignalleveris 
 movedupordown.
1Rightturn
2Movetheleverpartwayandreleasetosignalalane
   change(Right)
3Moveandholdtheleverpartwayandreleaseto
   signalalanechange(Left)
4Leftturn
b)Checkthattheheadlightortaillightindicatorilluminates 
 whentheheadlightswitchison.
1Turnoffthedaytimerunninglightsystem
2Thesidemarker,parking,tail,licenseplateand
instrumentpanellightsturnon
3Theheadlightsandalllightslistedaboveturnon.
4Theheadlights,daytimerunninglights,andalllights
   listedaboveturnonandoffautomatically(whenthe
   engineswitchisinIGNITIONONmode.)
*Ifequipped
NOTE:
 •Headlightsandtaillightsautomaticallyturnoff30
    secondsafteradoorisopenedandclosedif
    theengineswitchisturnedtotheACCESSORYor
    OFFmode.
   •Whenonlythetaillightsareon,thelights  
    automaticallyturnoffwiththedriver’sdooropened
    andtheengineswitchturnedtothe  
    ACCESSORYorOFFmode.
c)Checkoperationoftheautomaticlightcontrolfunction.
d)Checkthatthehighbeamindicatorlightilluminates 
 whenthehighbeamsareon.
   Withtheheadlightson,pushtheleverforwardto 
  turnonthehighbeams.Pullbacktocentertoturn 
   off.
   Pullthelevertowardyouandreleaseittoashthe
   highbeamsonce.
1
2
9
LX570
INSPECTION DETAILS - B. LOCKS AND LIGHTS