maxwatt MX8000iS User manual

INVERTER GENERATOR OPERATOR’S MANUAL
MX8000iS

1
Using a generator indoors CAN KILL YOU IN MINUTES.
generator,
Generator exhaust fumes contains carbon monoxide.
This is a poison you cannot see or smell.
NEVER use inside a home or garage,
EVEN IF doors and windows are open.
Avoid other generator hazards. READ MANUAL BEFORE USE.
Only use OUTSIDE and far away
from windows, doors and vents.

TABLE OF CONTENTS
Introduction ....................................................................................1
Safety Information...........................................................................3
Generator Safety Warnings ..............................................................4
Know Your Generator.......................................................................7
Generator Preparation ...................................................................12
Starting the Generator ...................................................................16
Shutting Off the Generator.............................................................19
Maintenance .................................................................................20
Transportation & Storage...............................................................25
Troubleshooting Guide
Warranty Information
................................................................
.......................................................................
...26
27
2
KEY SPECIFICATIONS

DANGER: indicates a hazard, which, if not avoided, will result in death or serious injury.
WARNING: indicates a hazard, which, if not avoided, could result in death or serious injury.
CAUTION: indicates a hazard, which, if not avoided, might result in minor or moderate injury.
CAUTION: when used without the alert symbol, indicates a situation that could result in damage to
the machine.
SAFETY SYMBOLS
The purpose of following safety symbols is to attract your attention to possible dangers. The safety sym-
bols, and their explanations, deserve your careful attention and understanding. The safety warnings do not
by themselves eliminate any danger. The instructions or warnings they give are not substitutes for proper
accident prevention measures.
SAFETY INTRODUCTION
Safety is a combination of common sense, staying alert, and knowing how your tool works. This manual
contains important information regarding the generator’s potential safety concerns, as well as preparation,
operation, and maintenance instructions. Before operating this generator, be sure to read and observe all
warnings and instructions both on the generator labels and in this instruction manual. Failure to follow all
instructions listed below may result in personal injury.
NOTE: The following safety information is not meant to cover all possible conditions and situations that may
occur. We reserves the right to change this product and specifications at any time without prior notice.
SAVE THESE INSTRUCTIONS - Please keep this manual available to all users during the entire life of
the tool. Review it frequently to maximize safety for both yourself and others.
SAFETY INFORMATION
WARNING: Before operating the generator, make sure to read all safety warnings and all instruc-
tions. Failure to follow the warnings and instructions may result in electric shock, fire or serious injury.
3
WARNING!
HAZARDOUS KEEP NEW AND USED BATTERIES OUT OF REACH OF CHILDREN.
Never allow children to replace button batteries on any device. Swallowing or placing inside any
part of the body may lead to severe or fatal injuries in as little as 2 hours or less due to chemical burns
and potential perforation of the oesophagus.
If you suspect your child has swallowed a buton batery or placed inside any part of the body,
immediately call the POISONS INFORMATION CENTRE on 13 11 26 for prompt advice. If your child is
having any di culty breathing, contact 000.Dispose of used buton/ coin bateries immediately and
safely. A batery can s ll be dangerous even when it can no longer operate the device. Place s cky tape
around both sides of the batery and dispose of it immediately out of reach of children in an outside bin
or recycle safely.

WARNING: If this generator is used as a supply for a BUILDING’S WIRING SYSTEM, the generator
MUST be installed by a qualified electrician and connected to a transfer switch as a separately derived
system in accordance with all applicable laws and electrical codes and the National Electrical Code.
The generator shall be connected to a transfer switch that switches all conductors exclud-ing the
equipment grounding conductor. The frame of the generator shall be connected to an approved
grounding electrode.
• Do not operate near open flame, heat, or any other ignition source. Do not smoke near generator.
• Always operate on a firm, level surface.
• Always turn generator off before refueling. Allow generator to cool for at least 2 minutes before re-
moving fuel cap. Loosen cap slowly to relieve pressure in tank.
• Do not overfill fuel tank. may expand during operation. Do not fill to the top of the tank. Allow for
expansion. Always check for spilled fuel before operating.
• If fuel spills, move the generator at least 9M away from the spill and wipe clean any spilled fuel
before starting the engine.
• Empty fuel tank before storing or transporting the generator.
GENERATOR SAFETY WARNINGS
DANGER: CARBON MONOXIDE
Using a generator indoors CAN KILL YOU IN MINUTES. Generator exhaust fumes contains carbon monox-
ide (CO). This is a poison gas you cannot see or smell. If you can smell the generator exhaust, you are
breathing CO. But even if you cannot smell the exhaust fumes , you could be breathing CO.
NEVER use a generator inside homes, garages, crawl spaces, or other partia lly enclosed areas. Deadly
levels of carbon monoxide can build up in these areas. Using a fan or opening windows and doors does
NOT supply enough fresh air. ONLY use a generator OUTSIDE and far away from windows, doors, and
vents. These openings can pull in generator exhaust fumes.
Even if you use a generator correctly, CO may leak into the home. ALWAYS use a battery-powered or
battery-backup CO alarm in the home. If you start to feel sick, dizzy, or weak after the generator has
been running, move to fresh air RIGHT AWAY. See a doctor. You may have carbon monoxide poisoning.
WARNING:RISK OF EXPLOSION. HIGHLY FLAMMABLE: This generator may emit highly flam-
mable and explosive vapors, which can cause severe burns or even death, if ignited. A nearby
open flame can lead to explosion even if not directly in contact with .
4

GENERATOR SAFETY WARNINGS
OPERATING ENVIRONMENT
Using a generator indoors can kill you in minutes. Only use a generator OUTSIDE and far away from win-
dows, doors and vents.
Do not smoke near the generator.
Do not operate near open flame, heat, or flammable materials. This generator may emit highly flammable
and explosive vapors, which can cause severe burns or even death if ignited. A nearby open flame can
lead to an explosion even if it isn’t directly in contact with .
Do not expose the generator to rainy or wet conditions; doing so significantly increases the risk of electri-
cal shock. Never handle the generator, electronic devices, or any cord while standing in water, while bare-
foot, or when hands or feet are wet.
Always operate the generator on a dry, firm, level surface.
The generator should have at least 1.5 of clearance from buildings or other equipment during opera-
tion.
Do not allow children or non-qualified persons to operate the generator.
GENERATOR PREPARATION
1.Always ground the generator before using it to maximize safety (see “GROUND THE GENERATOR” section.）
2.Do not overfill fuel tank, as petrol may expand during operation. Do not fill to the very top of the tank.
Leave room for expansion. Always check for spilled fuel before operating.
3.If any part of the generator, electrical device or power cord is broken, damaged, or defective, make sure it is
repaired or replaced before operation. Service should only be performed by a qualified technician. Do not use
receptacles or cords that show signs of damage, such as broken or cracked insulation.
4.Use a ground fault circuit interrupter (GFCI) in highly conductive areas such as metal decking or steel work.
5.Extension cords with in-line GFCIs are recommended for these operations to maximize safety.
6.If connecting the generator to a building’s electrical system for standby power, you MUST consult a qualified
electrician and install a transfer switch. Such connections must comply with local electrical laws and codes.
Failure to comply can create a back-feed, which may result in serious injury or death to utility workers.
7.Never modify the generator in any way. Modifying or using the machine for any other purpose for which it is
not designed may result in serious injuries, machine damage and voiding of the warranty
WARNING: Do not let comfort or familiarity with the product replace strict adherence to product
safety rules. Failure to follow the safety instructions may result in serious personal injury.
5

GENERATOR SAFETY WARNINGS
GENERATOR OPERATION
Only use the generator for its intended purposes. Modifying or using the generator for operations for which
it was not designed may cause hazards and personal injury.
Do not touch bare wires or receptacles (outlets).
Do not exceed the wattage capacity of the generator by plugging in more electrical devices than the unit
can handle. This could damage the generator and/or connected electrical devices. Check the operating volt-
age and frequency requirements of all electrical devices prior to plugging them into the generator.
Allow generator to run for several minutes before connecting electrical devices. Do not start or stop en-
gine with electrical devices plugged in to the receptacles. Failure to do so could damage the generator and /
or connected electrical devices.
Do not turn ON electrical devices until after they are connected to the generator.
Generators vibrate in normal use. During and after the use of the generator, inspect both the generator as
well as extension and power supply cords for damage resulting from vibration.
Do not touch HOT PARTS. This generator produces heat when running. Temperatures near exhaust can
exceed 65ºC. Allow generator to cool down after use before touching engine or areas of the gen- erator
that become hot during use.
Turn off all connected electrical devices before stopping the generator.
Always turn generator off before refueling. Allow generator to cool for at least 2 minutes before removing
fuel cap. Loosen cap slowly to relieve pressure in tank.
Turn the engine switch to “OFF” position when the engine is not running.
Empty fuel tank before storing or transporting the generator. Do not store generator or near
furnaces, water heaters, or any other appliances that produce heat or have automatic ignitions. Store the
generator and fuel away from sparks, open flames, pilot lights, heat and other sources of ignition.
Always wash hands after handling generator.
CAUTION: Misuse of this generator can damage it or shorten its lifespan.
TO MAXIMIZE THE LIFESPAN OF YOUR GENERATOR:
We recommend running your generator at least once a month for 20 to 30 minutes. Start the generator
according to the instructions and plug a small load in to make sure the outlet is producing electricity.
6

KNOW YOUR GENERATOR
GENERATOR
7

KNOW YOUR GENERATOR
CONTROL PANEL
8