Megamaster BakerBox Quick reference guide

ASSEMBLY & OPERATING INSTRUCTIONS
Important: Read these instructions for use carefully so as to familiarize yourself with the
appliance before putting it to your gas or charcoal grill. Keep these instructions for future reference
.
WARNING
To reduce the risk of fire, burn hazard or other injury, read the manual carefully and
completely before using your BakerBox.
WARNING
This BakerBox is not intended to be installed in or on recreational vehicles and/or boats.
dfWARNING
For outdoor use only.
www.megamaster.co.za
Manufactured in China· Distributed by Mega Group · PO Box 15, Woodlands, 0027, South Africa· Tel: [phone]
BakerBox
multi-purpose pizza oven
.

Table of Contents
Installation Final Check List
Operating Instructions
Care and Maintenance
Trouble Shooting
Warranty Information
9
10-11
11
12
13
Safety Instructions
Package Content List
Hardware Contents
Explode View
Part List
Assembly Instructions
2-3
4
4
5
6
7-9
2
Safety Instructions
Please read the following instructions carefully before attempting to assemble, operate or
install the product. Failure to follow these instructions may result in serious bodily injury
and/or property damage. If you have questions regarding the product please call customer
service at ([phone].
WARNING
This outdoor cooking appliance is not intended to be installed in or on boats and other
recreational vehicles.

3
Safety Instructions
1. Only use your BakerBox on a well ventilated outdoor grill with the lid fully opened at all
times.
2. Always wear heat resistant oven mitts or gloves for outdoor cooking when handling the
BakerBox.
3. Do not touch the BakerBox while the BakerBox is in operation or until the BakerBox has
cooled down after use.
4. Do not turn on or preheat BBQ before placing the BakerBox on the grill.
5. Children should not be left alone or unattended in an area where the BakerBox is being
used. Do not allow them to sit, stand or play in or around the BakerBox while the grill is
on or coals are hot.
6. Use only appropriate bake-ware or utensils while baking and cleaning your BakerBox. Do
not use plastic, silicone or glass.
7. Stones are fragile and can break if dropped. The BakerBox becomes extremely hot, do
not touch the stones or any other part of the BakerBox while it is in use.
8. To clean stones, heat the BakerBox for 15 minutes after food is cooked and scrape off any
remaining residue. Do not use any cleaning agents or other liquids to clean the stones.
9. Do not remove BakerBox from grill until it is completely cool. Allow at least 90 minutes
after turning off grill to remove. If using a charcoal grill additional cooling time may be
required. Do not use water or other solvents to aid in cooling the BakerBox after use.
10. Do not place gasoline, alcohol, wood products, charcoal or any other combustible
material(unless Megamaster approved)in the baking chamber.
11. The BakerBox must never be used indoors or for heating purposes.
12. Do not repair or replace any part of the BakerBox unless specifically recommended in this
manual.All other service should be referred to a qualified technician. This BakerBox is not
intended to be installed in or on recreational vehicles or boats.
13.Turn off grill controls and certain the BakerBox is cook before using any type of aerosol
cleaner on or around the BakerBox. Some cleaners produce toxic fumes or can ignite if
applied to a hot surface.

Package Content List
4
Hardware Contents
REF# QTY
8PCS
W5/32” -32 x2/5”mm
SpecificationDescription
Screw
A
Before beginning assembly, make sure all parts are present. Compare parts with package
contents list and diagram. If any part is missing or damaged, do not attempt to assemble
the product. Contact customer service for replacement parts.
EstimatedAssembly Time: 10 minutes.
Tools for required for assembly: Philips Screwdriver(not included) Philips
Screwdriver
1.Main lid and fire box assembly---
1piece 2.Top stone ---1 piece
3.Side stone ---2 pieces 4.Rear stone ---1 piece
5.Bottom stone---1 piece 6.Top stone support
bracket, front ---1piece
7.Top stone support bracket,
rear ---1piece 8. Stone support
bracket, side ---2 pieces

5
Exploded View
1
2
3
4
5
6
7
8
4
9
10 11 12
13
14
15
16
15
17
18 14
18
19
19
20

6
No. Part(Descreption) Warranty
coverage(year) QTY
1 Main lid 1 1
2 Temperature gauge 1 1
3 Temperature gauge seat 1 1
4 Main lid screw 1 2
5 Main lid left panel 1 1
6 Top stone support bracket,rear 1 1
7 Top stone 1 1
8 Main lid right panel 1 1
9 Top stone support bracket,front 1 1
10 Main lid handle seat,left 1 1
11 Logo 1 1
12 Main lid hand seat,right 1 1
13 Main lid handle 1 1
14 Stone support bracket,side 1 2
15 Side stone 1 2
16 Rear stone 1 1
17 Bottom stone 1 1
18 Main lid block screw 1 2
19 Hood buffer 1 2
20 Fire box assembly 1 1
Part List

2.Use 4 pieces screws(A), top stone front
support bracket (6),top stone rear support
bracket (7)to attach the top stone(2) to
main lid inside . As shown in Fig.2
3.Tight all the screws(A). As shown in Fig.3
1. Loosen and remove the screws which were
pre-assembled on the lid rear corner, so
firebox and main lid are separate .As shown in
Fig.1
Fig. 3
7
Assembly Instructions
Fig. 1
Fig. 2 62
7

4. Put bottom stone(5),side stones(3),rear
stone(4) inside firebox assembly. As shown
in Fig.4
8
Assembly Instructions
Fig. 4
Fig. 5
Fig. 6
3
34
5
5.Attach 2 pieces stone support brackets, side(8)
to fire box side panel left and right corner,
then tight the 4 screws(A).As shown in Fig.5
8
6.Assemble back the 2 screws which were
removed in step1.As shown in Fig.6

Note: The main lid block screw can hold
the main lid open as show in Fig.7
9
Assembly Instructions
Fig. 7
Installation Final Check List
Your BakerBox is ready to use!
1.Stones are tight and steady.
2.The main lid can be open as above Fig.7 shows. .

10
How to use your BakerBox
1.Open the main lid of gas grill or charcoal grill that will be used with the BakerBox.
2.Place BakerBox on the cooking grid, leave a 0.5’’(1.2cm) space between the front edge
of the BakerBox and the front edge of the cooking grid, at least 1’’(2.5cm) of space
between both side edges of the BakerBox and both side edges of the cooking grid.
3.With the gas grill or charcoal grill main lid completely open and proper spaces
surrounding the BakerBox, light your gas grill or charcoal grill as instructed by the gas
grill manufacturer.
4.Set all burners to high and preheat the BakerBox for 15 minutes.
5.Once the temperature crosses the pre-heat area and in the area of cooking. Please put
your pizza cake into the oven for cooking.
6. Rotate pizza as required to ensure even heat distribution.
Operating Instructions
Warning: Please read the following instructions carefully before attempt to
assemble, operate or install the product. The BakerBox becomes extremely hot and
can cause burning. Failure to comply with these instructions may result in serious
bodily injury.
Chart
Fits a 57cm Kettle Grill(Charcoal) Yes
Yes
Yes
Yes
5min.
8min.
10min.
Fits into a 50cm + Gas Grill
Accepts a 22cm Pizza
Accepts a 30cm Pizza
22cm Pizza Cook Time
30cm Pizza Cook Time
Assembly
Note: Remove all packaging, including straps, before using the BakerBox.

11
Ingredients Notes
Pizza dough Store bought or home made.
Pizza sauce Store bought or home made.
Cheese Fresh mozzarella is excellent or you can use your favorite cheese.
Herbs,spices and salt Use fresh basil or oregano and a nice sea salt.
Olive oil Use a good quality extra virgin olive oil for best flavor.
Toppings Use chopped/sliced vegetables, pre-cooked meats, etc. Get creative!
This is what is needed to create a gourmet pizza.
Care and Maintenance
Cleaning
1. Turn off the gas supply, and make sure all the knobs are in the “OFF” position.
2. Wait for the grill and BakerBox to cool.
3. Clean the exterior of the BakerBox with a wire brush. Use a metal scraper for stubborn
stains.
4. Wipe outer housing with a soft damp cloth only when completely cooled.
5. Clean clogged port with a straightened paper clip. Never use a wooden toothpick as it
may break off and clog the port.
Caution
1. Keep outdoor cooking gas appliance area clear and free from combustible materials,
gasoline and other flammable vapors and liquids.
2. Do not obstruct the flow of combustible and ventilation air.
3. Keep the ventilation openings of the cylinder enclosure free and clear from debris.
4. Never leave the BakerBox unattended during use.

Problem Solution
Can I close the lid of my grill
while using the BakerBox? We advise you to keep to lid of your grill in the fully opened position while using the BakerBox in order to protect you
and your grill. If you fully or partially close your grill lid while
using the BakerBox, it may cause components of your grill
to over-heat which may result in damage to your grill and/or
bodily injury should you touch the overheated components.
How do I clean the BakerBox? After baking your final pizza, you can clean the BakerBox
by letting the burners remain on high for approximately 15
minutes. Any residue should burn off and remains can be
scrapped off and pushed to the back of the oven by using a
long handled BBQ brush. Once the oven has cooled
completely, a damp cloth can be used to wipe off any char
left in the oven. The stone will remain blackened and/or
darkened which is natural. If this does not clean the stone
to your satisfaction, you can also remove the support
brackets and flip the base stone over and replace the
support brackets, This will give you a clean base stone to
use and the next time you use the BakerBox, any
remaining residue will burn off.
12
Trouble Shooting
Before calling for service
If the BakerBox does not function properly, use the following check list before contacting your
dealer for service. You may save the cost of a service call.
Preheating: It is necessary to preheat the BakerBox before cooking pizza, depending on the
type of food and the cooking temperature. The grill lid should be open during the preheating
time period.

This BakerBox has one (1) year limited warranty.
The warranty period is valid from the date of purchase. Please retain your proof of
purchase.
This is subject to correct assembly, use, storage and regular maintenance of the product.
It is the responsibility of the product owner to safely store and protect the BakerBox from
the elements.
This warranty does not cover the following:
-Rust
-Corrosion
-Discolouration
-Damage caused by improper use not according to instructions set out above
Please contact our customer service department for any further explanation at +27 12 802
1515
13
Warranty Information

FOR OUTDOOR USE ONLY
BakerBox
WARNING
Read and follow all Safety, Assembly, and Use & Care Instructions in
this guide before assembling and cooking with this BakerBox.
Failure to follow all instructions in this Use & Care Guide may lead to
fire or explosion, which could result in property damage, personal
injury or death.
14
www.megamaster.co.za
Manufactured in China· Distributed by Mega Group · PO Box 15, Woodlands, 0027, South Africa· Tel: [phone]