Mi-T-M MWT-0510-2MMD User manual

Water Trailer Manual 1
CAUTION
RISK OF INJURY! READ ENTIRE MANUAL BEFORE OPERATING!
THIS MANUAL IS AN IMPORTANT PART OF THE WATER TRAILER
AND MUST REMAIN WITH THIS UNIT!
WATER TRAILER
MWT-0510-2MHD
MWT-0510-2MMD
OPERATOR'S MANUAL
©Copyright 2010, Mi-T-M Corporation® 37-1103-020122

2 Water Trailer Manual
WARNING: This product can expose you to
chemicals including carbon monoxide, which is
known to the State of California to cause birth
defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov
WARNING
WARNING: This product can expose you to
chemicals including Lead, which is known to
the State of California to cause cancer and birth
defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov
WARNING
Table of Contents
INTRODUCTION .............................................................................................................3
WARNING ........................................................................................................................4
PREPARATION ................................................................................................................5
BEFORE TOWING WATER TRAILER ..........................................................................5
SAFETY PRECAUTIONS DURING USE......................................................................5
OPERATING INSTRUCTIONS ........................................................................................6
WATER FLOW .............................................................................................................6
FILLING THE TANK .....................................................................................................7
AFTER USE.................................................................................................................7
OPERATING INSTRUCTIONS FOR THE HARD SUCTION OPTION............................8
OPTION - HARD SUCTION.........................................................................................8
WATER FLOW: ............................................................................................................8
FILLING THE TANK: ..................................................................................................10
AFTER USE:..............................................................................................................10

Water Trailer Manual 3
IMPORTANT!
A "DANGER, WARNING or CAUTION" safety warning will used to designate and emphasize Safety Warn-
ings that must be followed when operating this Water Trailer. Accompanying the safety warnings are "Signal
Words" which designate the degree or level of hazard seriousness. The "Signal Words" used in this manual
are as follows:
DANGER: INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED, WILL
RESULT IN DEATH OR SERIOUS INJURY.
WARNING: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED,
COULD RESULT IN DEATH OR SERIOUS INJURY.
CAUTION: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED MAY
RESULT IN MINOR OR MODERATE INJURY OR DAMAGE TO THE WATER TRAILER.
The symbols set below are "Safety Alert Symbols". These symbols are used to call attention to items or
procedures that could be dangerous to you or other persons using this equipment.
ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ ALL
INSTRUCTIONS IN THIS MANUAL AND ANY INSTRUCTIONS SUPPLIED BY MANUFACTURERS OF
SUPPORTING EQUIPMENT BEFORE OPERATING THIS WATER TRAILER AND ESPECIALLY POINT
OUT THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE
OPERATOR.
INTRODUCTION
Congratulations on the purchase of your new Mi-T-M® Water Trailer! You can be assured your Mi-T-M®
Water Trailer was constructed with the highest level of precision and accuracy. Each component has been
rigorously tested by technicians to ensure the quality, endurance and performance of this Water Trailer.
The contents of this manual are based on the latest product information available at the time of publication.
The Manufacturer reserves the right to make changes in price, color, materials equipment, specications or
models at any time without notice.
Once the unit has been delivered, immediately write in the serial number of your unit in the space provided
below.
SERIAL NUMBER ________________________________
Inspect for signs of obvious or concealed freight damage. If damage does exist, le a claim with the trans-
portation company immediately. Be sure that all damaged parts are replaced an that the mechanical and
electrical problems are corrected prior to operation of the unit. If you require service, contact Mi-T-M®Cus-
tomer Service.
Mi-T-M®Corporation, 50 Mi-T-M Drive, Peosta, IA 52068
563-556-7484 / 800-553-9053 / Fax [phone]
Monday - Friday 8:00 a.m. - 5:00 p.m. CST
Please have the following information available for all service calls:
1. Model Number
2. Serial Number
3. Date and Place of Purchase

4 Water Trailer Manual
WARNING
THE FOLLOWING PAGES CONTAIN OPERATING
INSTRUCTIONS.
DO NOT ATTEMPT TO TOW YOUR WATER TRAILER
UNTIL YOU HAVE READ AND UNDERSTOOD ALL SAFETY
PRECAUTIONS AND INSTRUCTIONS LISTED IN THIS MANUAL.
INCORRECT OPERATION CAN CAUSE SERIOUS INJURY!!
DO NOT ALTER OR MODIFY THIS EQUIPMENT
IN ANY MANNER!

Water Trailer Manual 5
BEFORE TOWING WATER TRAILER
WARNING: DO NOT OPERATE TRAILER UNTIL THIS MANUAL HAS BEEN READ AND
UNDERSTOOD.
1. Thoroughly read and understand all instructions before operating this trailer.
2. Make sure that the trailer is properly attached to the tow vehicle, including lights, safety chains, hitch and
breakaway brake cable.
WARNING: RISK OF SERIOUS INJURY! ALWAYS ATTACH THE SAFETY CHAINS AND BREAKAWAY
CABLE TO THE TOW VEHICLE.
3. Check lug bolts for tightness and tires for wear.
4. Adjust hitch height as needed to assure that trailer is level when fully loaded.
WARNING: RISK OF DAMAGE AND INJURY! ALWAYS ASSURE THAT THE HITCH IS ATTACHED TO
THE PROPER SIZE BALL.
CAUTION: ALWAYS WEAR PROTECTIVE CLOTHING AND GLOVES WHEN WORKING WITH
CHEMICALS.
5. Wear safety goggles, chemical resistant apron and rubber gloves when handling chemicals.
6. Read and understand the chemical manufacturer's safety guidelines on handling, mixing and application.
SAFETY PRECAUTIONS DURING USE
• When possible, avoid operating the tow vehicle near ditches, embankments and holes.
• Reduce speed when turning, crossing slopes and on rough, slick or muddy surfaces.
• Do not permit others to ride.
• Operate tow vehicle smoothly - no jerky turns, starts or stops.
• Hitch only to the hitch points recommended by the tow vehicle manufacturer.
• When tow vehicle is idle, engage brakes and park lock securely.
• Tighten lug bolts before transporting the rst time and maintain proper torque.
• Check lights and wiring daily. Service and replace to maintain proper operation.
WARNING: RISK OF FALLING COULD CAUSE SERIOUS INJURY OR DEATH! DO NOT ALLOW
ANYONE TO RIDE ON TRAILER DURING OPERATION.
1. Reduce speed when crossing uneven or rough terrain .
2. Always turn off tow vehicle engine before making adjustments or repairs to an attached trailer.
PREPARATION

6 Water Trailer Manual
OPERATING INSTRUCTIONS
WATER FLOW
The Mi-T-M Water Trailer features an easy to use discharge manifold that allows the operator three methods
of controlling water ow. Water can be discharged through the spray nozzle valve (A), re hose valve (B), or
garden hose valve (C). (gure 1)
Turning the corresponding valve to the open or closed position will allow the ow of water through each
specic valve. If the spray nozzle bar on the back of the trailer is to be used, open spray nozzle valve (A) and
close valves (B) and (C).
Follow the same procedure for using the other valves.
When ready to spray, start the engine on the water pump. If this is the rst time using the pump, it may be
necessary to pour water in the top of the pump to prime it. Once the pump has water in it, it is self-priming.
Refer to the pump manual for additional instructions.
When using the re hose valve, (gure 2) quick couple the re hose (E) (gure 3) to the valve, open the re hose
valve (B) while closing the other two valves (A) and (C). The red spray nozzle (F) (gure 4) can be threaded to
the end of the re hose and adjusts from wide spray to straight stream by turning the body of the nozzle.
A
B
C
B
D E
F
Figure 1
Figure 2
Figure 3
Figure 4
WARNING: DO NOT DIRECT THE
SPRAY FROM THE FIRE HOSE OR
PRESSURE HOSE AT ELECTRICAL
CONNECTIONS, BOXES OR LINES.
ELECTRICAL SHOCK COULD CAUSE
SERIOUS BODILY INJURY OR DEATH.

Water Trailer Manual 7
OPERATING INSTRUCTIONS
FILLING THE TANK
To ll the tank through the anti-siphon ll (G) (gure 5), remove the tank lid (gure 6), couple the ll hose (D)
(gure 3) to the anti-siphon coupler and the other end of the hose to a re hydrant. Open the water source
and begin lling.
A re hydrant wrench is provided (H). (Figure 7)
AFTER USE
1. Inspect trailer for wear or damage.
2. Ensure that all fasteners and ttings are tight.
3. Flush tank and pump with fresh water if chemicals are used. Dispose of ush water using appropriate means.
G
Figure 5 Figure 6
Figure 7
H

8 Water Trailer Manual
OPERATING INSTRUCTIONS FOR THE HARD SUCTION OPTION
OPTION - HARD SUCTION
WATER FLOW:
The Hard Suction Option for the Mi-T-M Water Trailer features an easy to use discharge Manifold that allows
for four methods of controlling water ow (gure 8), and an easy to use inlet manifold allowing for two meth-
ods of supplying water (gure 9). Water can be discharged through the spray nozzle bar valve (M), re hose
valve (K), garden hose valve (N), or the tank valve (L). Water can be supplied by the tank valve (J) or from an
external body of water using valve (I).
N
K
M
L
I
J
Figure 8
Figure 9

Water Trailer Manual 9
OPERATING INSTRUCTIONS FOR THE HARD SUCTION OPTION
Refer to the pump manual for instructions on pump operation.
Turning the corresponding valve to the open or closed position will allow the ow of water through each
valve.
When using the Spray Bar, open valve (M) with valves (K), (L) and (N) closed (gure 10).
To use the re hose, quick couple the re hose (E) (gure 3) to valve (K), open valve (K) with valves (L), (M)
and (N) closed (gure 11).
To use a garden hose, attach the hose to valve (N), open valve (N) with valves (K), (L) and (M) closed (gure
12).
When using water from the tank, open valve (J) with valve (I) closed (gure 13).
When suctioning water from an external body of water, attach strainer (P) to the hard suction hose (O) (gure
14), attach hose (O) to valve (I), put the strainer (P) into the body of water and open valve (I) with valve (J)
closed (gure 15).
M
K
N
Figure 10 Figure 11
Figure 12 Figure 13
J

10 Water Trailer Manual
FILLING THE TANK:
To ll the tank through the anti-siphon (G) (gure 5), follow the instructions above in the trailer manual.
To ll the tank using an external body of water, attach the strainer (P) to the hard suction hose (O) (gure
14), attach hose (O) to valve (I), put the strainer (P) into the body of water, open valve (I) with valve (J) closed
(gure 15) and open valve (L) with valves (K), (M) and (N) closed (gure 16).
AFTER USE:
Follow instructions above in the trailer manual.
O
P
OPERATING INSTRUCTIONS FOR THE HARD SUCTION OPTION
I
Figure 14 Figure 15
L
Figure 16