Nevir NVR-CB4P User manual

NVR-CB4P
FULL SIZE COOKER WITH GAS CYLINDER
COMPARTMENT
COCINA GAS CON PORTABOMBONA
USER MANUAL
MANUAL DEL USUARIO
H10-20-180-603
GB
ES

GB
2
Dear Customer,
Thank you for relying on this product.
We aim to allow you to optimally and efficiently use this environment-
friendlyproductproducedinourmodernfacilitiesunderpreciseconditions
with respect to sense of quality in total.
We recommend that you read the user manual carefully and keep it
permanently before using the appliance so that it retains its original
features for a long time.
WARNING: This operating manual is prepared for
multiple models. Your appliance may not feature
some functions specified in the manual.
WARNING: The figures in the manual are schematic
and may not be in exact harmony with your product.
This product has been produced in modern environment-friendly
facilities without harmfully affecting the nature.
WARNING: Features marked with * are optional.
"Complies with AEEE Regulation"

3
Contents
Important warnings................................................................4
Electrical safety .....................................................................8
Gas safety...........................................................................10
Power connection................................................................13
Gas connection ...................................................................14
Appliance introduction.....................................................19
Technical specifications.......................................................20
Setting up the appliance......................................................22
Control Panel.......................................................................24
Appliance use......................................................................25
Maintenance and cleaning...................................................28
Troubleshooting...............................................................29
Handling rules .....................................................................30
Tips for saving energy .........................................................30
Disposal of waste product ...................................................31
Packing information.............................................................31

4
GB
IMPORTANT WARNINGS
1. Installation and repair should always be performed
by “AUTHORISED SERVICE” . Manufacturer shall not be
heldresponsibleforoperationsperformedbyunauthor-
ised persons.
2. Please read this operating instructions carefully.
Only by this way you can use the appliance safely and
in a correct manner.
3. The appliance should be used according to operat-
ing instructions.
4. Keep children below the age of 8 and pets away
when operating.
5. WARNING: Fire hazard; do not store the materials on
the cooking surface.
6. WARNING: The appliance and its accessible parts are
hot during operation.
7. Setting conditions of this appliance are specified
on the label. (Or on the data plate)
8. The accessible parts may be hot when the grate is
used. Small children should be kept away.
9. WARNING: This appliance is intended for cooking. It
should not be used for other purposes like heating a room.
10. Tocleantheappliance,donotusesteamcleaners.
11. NEVER try to put out the fire with water. Only shut
down the appliance circuit and then cover the flame
with a cover or a fire blanket.

5
12. Childrenunder8yearsofageshouldbekeptaway,
if they cannot be monitored continuously.
13. Touchingtheheatingelementsshouldbeavoided.
14. CAUTION: Cooking process should be supervised.
Cooking process shall always be supervised.
15. The appliance isnot suitable for use with an exter-
nal timer or a separate remote control system.
16. This appliance can be used by children over 8
years of age, people with physical, hearing or mental
challenges or people with lack of experience orknowl-
edge; as long as control is ensured or information is
provided regarding the dangers.
17. This appliance has been designed for household
use only.
18. Children should not play with the appliance.
Cleaning or user maintenance of the appliance shall
notbeperformedby children unlesstheyareolderthan
8 years and supervised by adults.
19. Keep the appliance and its power cord away from
children less than 8 years old.
20. Put curtains, tulles, paper or any flammable (ignit-
able) material away from the appliance beforestarting
to use the appliance. Do not put ignitable or flammable
materials on or in the appliance.
21. Keep the ventilation channels open.
22. Do not heat closed cans and glass jars. The pres-
sure may lead jars to explode.

6
GB
23. Do not use the appliance in states like medicat-
ed and/or under influence of alcohol which may affect
your ability of judgement.
24. Check that the appliance is off after each use.
25. Be careful when using alcohol in your foods. Alco-
hol will evaporate at high temperatures and may catch
fire to cause a fire if it comes in contact with hot sur-
faces.
26. Do not operate the appliance if it is broken orvis-
ibly damaged.
27. Do not touch the plug with wet hands. Do notpull
the cord to plug off, always hold the plug.
28. Do not place objects that are accessible to chil-
dren on the appliance.
29. The packaging materials are dangerous for chil-
dren.Keeppackagingmaterialsawayfromthereachof
children.
30. Theapplianceshould be disconnected during any
construction work in the house. After completing the
work, re-connecting the appliance should be done by
authorised service.
31. Do not place metal utensils such as knife, fork,
spoon on the surface of the appliance, since they will
get hot.
32. Toprevent overheating, the appliance should not
be installed behind of a decorative cover.

7
33. Turn off the appliance before removing the safe-
guards.Aftercleaning,installthesafeguardsaccording
to instructions.
34. Cable fixing point shall be protected.
35. WARNING: If the glass of the appliance is broken,
turn off any heating element immediately and disconnect
the appliance from power source, do not touch the surface
of the appliance and do not use the appliance.
36. User should not handle the appliance by them-
selves.
37. The user should be careful when cleaning the up-
per hobs of the appliance. It may cause personal inju-
ries.
38. Since the appliance is hot during cooking or right
after cooking, scalding may occur due to extreme tem-
perature and steam.
39. Usersmaycontacthotsurfacesandburnsmayoc-
cur if the appliance is forgotten to be turned off during
cooking.
40. If heavier loads are placed on the appliance, the
loads may overturn. It may cause personalinjuries.
41. Donotusethedoorand/orhandletocarryormove
the appliance.

8
GB
Electrical Safety
WARNING: This appliance might not require Electrical
connection¡ Check if your current model operates by gas
1. Plug the appliance in a grounded socket protected by a
fuse conforming to the values specified in the technical
specifications chart.
2. Have an authorized electrician set grounding equipment.
Our company will not be responsible for the dam- ages that
may occur due to using the appliance without grounding
according to local regulations.
3. WARNING: If the surface is cracked, turn off the appli ance to
avoid risk of electric shock.
4. Never wash the appliance by spraying or pouring
water on it. There is a risk of electrocution.
5. Do not touch the plug with wet hands. Do not pull the
cord to plug off, always hold the plug.
6. Unplug the appliance during installation, maintenance,
cleaning, and repair.
7. Make sure the plug of the appliance is inserted
firmly into wall socket to avoid sparks.
8. If the power supply cord (the cord with plug) is damaged,
this cord shall be replaced by the manufacturer or its service
agent or an equally qualified personnel to prevent a
hazardous situation.
9. Do not use cut or damaged cords or extension cords other
than the original cord.
10. Do not use steam cleaners for cleaning theappliance,
otherwise electric shock may occur.

9
11. Make sure that there is no liquid or humidity in
the outlet where the appliance plug is inserted.
12. The appliance should be installed in such a way
that the electrical installation can be completely dis-
connected. Disconnection from power supply shall be
provided with a switch or an integrated fuse installed
on fixed power supply according to building code.
13. The power supply cable should not touch the hot
parts of the appliance.
14. Unplug the appliance during installation, mainte-
nance, cleaning, and repair.
15. Theapplianceisequippedwitha type ‘’Y’’ cordcable.
16. The appliance circuit breaker switches should be
in the workplace accessible to the end user while the
appliance is in place.
17. Fixed connections shall be connected to a power
supply enabling omnipolar disconnection. For appli-
ances with over voltage category below III,disconnec-
tion device shall be connected to fixed power supply
according to wiring code.
18. Do not remove ignition switches from the appli-
ance. Otherwise, live electric cables can be accessed.
It may cause an electric shock.

10
GB
Gas Safety
1. This appliance is not connected to burning prod-
ucts evacuation apparatus. This appliance should be
connected and installed according to the installation
regulations in force. Conditions regarding ventilation
should be considered.
2. When a gas cooking appliance is used; humidity,
heat and burning products are generated in the room.
First, make sure the kitchen is well ventilated when op-
erating the appliance and maintain natural ventilation
openingsorinstallamechanicalventilationequipment.
3. After using the appliance heavily for en extended
period of time, additional ventilation may be required.
Forexampleopenawindoworadjustahigherspeedfor
mechanical ventilation, if any.
4. This appliance should be used only in well venti-
lated locations in accordance with the regulations in
force.Pleasereadthemanual beforeinstalling orusing
this appliance.
5. Before positioning the appliance, make sure local
network conditions (gas type and gas pressure) meets
appliance requirements.
6. The mechanism cannot be run for longer than 15
seconds. If the upper hob is not on after 15 seconds,
stop the mechanism and wait for at least one minute
before trying to ignite the upper hob again.

11
7. All kinds of operations to be performed on gas in-
stallation should be performed by authorised and com-
petent people.
8. For proper operation, hood, gas pipe and clamp
should be replaced periodically according tomanufac-
turer recommendations and when required.
9. Gas should burn well in gas appliances. Well burn-
ing gas can be understood from blue flame and contin-
uous burning. If gas does not burn sufficiently, carbon
monoxide (CO) can be generated. Carbon monoxide is
a colourless, odourless and very toxic gas; evensmall
amounts have lethal effect.
10. Ask your local gas supplies about the phone num-
bers for emergencies related to gas and the measures
to be taken upon gas odour is detected.

12
GB
What To Do When Gas Odor Is Detected
1. Do not use naked flame, and do not smoke.
2. Do not operate any electrical switch.
(For example: lamp switch ordoorbell)
3. Do not use telephone or mobile phone.
4. Open the doors and windows.
5. Close all valves on the appliances that utilise gas
and the gas counters.
6. Callfirebrigadefromatelephoneoutsidethehome.
7. Checkallhosesandtheirconnectionsagainstleaks.
If you still smell gas, leave the house and warn your
neighbours.
8. Donotenterintothehouseuntilauthoritiesclarify
it is safe.
Intended Use
1. This appliance is designed for domestic use. Com-
mercial use of the appliance is not permitted.
2. This appliance shouldonlybe used forcooking pur-
poses. It shall not be used for other purposes like heat-
ing a room.
3. Themanufacturerassumesnoresponsibilityforany
damage due to misuse or mishandling.
4. The operational life of the appliance you havepur-
chased is 10 years. This is the period for which the
spare parts required for the operation of this appliance
as defined is provided by the manufacturer.

13
Power Connection
WARNING: This appliance might not require Electrical
connection¡ Check if your current model just operates by gas
This appliance should beinstalled and connected correctly according to
the manufacturer's instructions and by the authorised service.
The electrical connections of the appliance should only be made with
(grounded) sockets with a grounding system that is laid in accordance
with the rules. Contact an authorised electrician if there is no suitable
socket for the grounded system where your appliance will be placed. The
manufacturerisabsolutelynotresponsibleforthedamagescausedbythe
ungrounded sockets connected to the appliance.
Your appliance should ground the plug; make sure the plug socket is
grounded. The plug should be placed within reach after installation.
Your appliance is manufactured in accordance with 220-240 V AC 50-
60 Hz. electrical supply. If your power network does not provide these
specifications, contact an electrician or an authorised service.
Do not allow the power cord of your appliance to contact hot parts ofthe
appliance. Keep it away from sharp edges and corners.

14
GB
Gas Connection
WARNING: Before starting any work related with gas
installation, turn off gas supply. Risk of explosion.
Check if the appliance settings are compatible with the local distribu-
tion conditions (gas type and gas pressure) before placing the appliance.
For LPG connection , attach the metal clamp
to the hose coming from the LPG cylinder.
Install one end of the hose by pushing itall
the way to the hose inlet record on the back
of the appliance by heating it in boiling
water. And tighten with a screwdriver by
bringing the clamp to the end of the hose.
The hose and gasket inlet record required
for connection is as follows.
For natural gas connection , place the gas-
ket in the nut at the end of the natural gas
connection hose. Turn the nut to attach the
hose to the main gas pipe. Check for gas
leakage and complete the connection.The
hose and gasket inlet record required for
connection is as follows.
WARNING: All kinds of work to be performed ongas
equipment and systems should be carried out by au-
thorised and qualified persons.
WARNING: Do not move a gas connected appliance.
Any force may cause gas leakage as it may loosen the
hose.
Main gas pipe
Gasket
Hose entry record
Metal clamp
LPG connection hose
Main gas pipe
Gasket
Nut
Natural gasconnection
hose

15
Figure 1 Figure 2 Figure 3
Conversion from Natural Gas to LPG or from LPG to Natu-
ral Gas
1. Switch off the gas and electricity of the appliance. If the applianceis
hot, wait for it to cool down.
2. Use a screwdriver with the tip as shown in figure 1 for injector
replacement.
3. Remove the burner cover and burner of the appliance as shown in
figure 2 and ensure that the injector is visible.
4. Removetheinjectorbyturningitasshowninfigure3withascrewdriver
and replace it with a new one.

16
GB
Gas Hose Crossing Path
Connect your appliance to the gas mains cock in the shortest way and
without any leakage. The correct connection shape is shown in the figure
below.
Ensure that the buttons on the control panel are closed and the gas
cylinder is open for sealing and gasket safety control.
WARNING: Never use any lighters, matches, lit cigarettes, or
similar flammable materials when checking for gas leakage.
Apply soap foam to the connection points. There will be foaming here if
there is a leak/leakage.
Ensure that the appliance is at the counter level when placing your
appliance in place.
Adjust the appliance to the counter level by adjusting the feet, if
necessary.
Useyourapplianceonaflatsurfaceandinawell-ventilatedenvironment.

17
LPG bottle sizes
WARNING: The LPG bottle to be used in this product
should comply with the table given below.
Country LPG Bottle Sizes
Spain
30 cm
Portugal
33.5 cm
Italy
31.5 cm
France
33 cm
Romania
30 cm
55 cm
52 cm
65 cm
52.5 cm
55 cm

18
GB
Room Ventilation
Air required for combustion is taken from the room air and gases
produced are returned directly to the room.
A good room ventilation is essential for the safe operation of your
appliance.
If there are no windows or doors to be used for room ventilation,
additional ventilation should be installed. However, if the room has a
door that opens directly to the outside, there is no need for additional
ventilation systems.
Room size
Ventilation opening
Less than 5 m³
min. 100 cm²
5 m³ to 10 m³
min. 50 cm²
Greater than 10 m³
is not necessary
In basement or cellar
min. 65 cm²
Flame Output Speed Setting
First pull out the buttons on the control panel to do this. Adjust by
turning the screw in the middle of the gas cocks with a small screwdriver,
as shown in the picture below. Use a screwdriver of appropriate size to
adjust the flow adjustment screw. Turn the screw clockwise. Reverse the
procedure to make the appropriate adjustment and reinsert the buttons.
A normal flame length in the low position should be 6-7 mm. Check if the
flame is on or off for the last check.

19
APPLIANCE INTRODUCTION
1
2
4 5
3
6 7
8 9
1. Upper hobs
2. Control panel
3. Cabinet door
4. Large burner
5. Middle burner
6. Small burner *
7. Wok burner *
8. Coffee adapter (coffee pot) *
9. Wok burner adapter *
10. Grate
10

20
GB
Technical Specification Tables
By gas type
upper hob
specifications
G30,28-30 mbar
G31,37 mbar
G30.50 mbar
G30.37 mbar
LPG
LPG
LPG
Wok burner
(3.5)
Injector
0.96
mm
0.76
mm
0.96
mm
Gas flow
254
g/h
254
g/h
254
g/h
Power
3.50
kW
3.50
kW
3.50
kW
Wok burner
(1.9)
Injector
0.68
mm
0.60
mm
0.65
mm
Gas flow
182
g/h
182
g/h
182
g/h
Power
1.90
kW
1.90
kW
1.90
kW
Large
burner
Injector
0.85
mm
0.75
mm
0.85
mm
Gas flow
211
g/h
211
g/h
211
g/h
Power
2.90
kW
2.90
kW
2.90
kW
Medium
burner
Injector
0.65
mm
0.60
mm
0.65
mm
Gas flow
124
g/h
124
g/h
124
g/h
Power
1.70
kW
1.70
kW
1.70
kW
Small
burner
Injector
0.50
mm
0.43
mm
0.50
mm
Gas flow
69
g/h
69
g/h
69
g/h
Power
0.95
kW
0.95
kW
0.95
kW
By gas type
upper hob
specifications
G20,20 mbar
G25,25 mbar
G20,25 mbar
Natural gas
Natural gas
Wok burner
(3.5)
Injector
1.40
mm
1.28
mm
Gas flow
0.333
m³/h
0.333
m³/h
Power
3.50
kW
3.50
kW
Wok burner
(1.9)
Injector
1.05
mm
1.05
mm
Gas flow
0.196
m³/h
0.196
m³/h
Power
1.90
kW
1.90
kW
Wok burner
(2.4)
Injector
1.15
mm
1.10
mm
Gas flow
0.243
m³/h
0.243
m³/h
Power
2.40
kW
2.40
kW
Large
burner
Injector
1.15
mm
1.10
mm
Gas flow
0.276
m³/h
0.276
m³/h
Power
2.90
kW
2.90
kW
Medium
burner
Injector
0.97
mm
0.92
mm
Gas flow
0.162
m³/h
0.162
m³/h
Power
1.70
kW
1.70
kW
Small
burner
Injector
0.72
mm
0.70
mm
Gas flow
0.96
m³/h
0.96
m³/h
Power
0.95
kW
0.95
kW
Supply voltage
220-240 V AC 50-60 Hz.