Nexgrill The Classic 720-0083-04R Quick reference guide

ASSEMBLY & OPERATING INSTRUCTIONS
FOR OUTDOOR USE ONLY
Model: 720-0083-04R
T
M
Th
e
Gl
as
s
o
PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE
ABOUT ASSEMBLY OR GRILL OPERATION
DO NOT RETURN TO THE PLACE OF PURCHASE

FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, immediately call your gas supplier or your fire
department.
WARNING
Do not try to light this appliance without first reading the “LIGHTING
INSTRUCTIONS” section in this manual.
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity of
this or any other appliance..

MESSAGE TO OUR CONSUMERS
TABLE OF CONTENTS
Thank you for selecting our stainless steel gas grill.
Because this appliance contains features which may not found on other grill, we
recommend that you read this entire booklet before your first use. Keep it in handy
place as it has answers to questions that may occur during future use.
Read this booklet carefully and be sure your gas grill is properly assembled, installed and
maintained. Failure to follow these instructions could result in serious bodily injury and/or
property damage. This gas grill in intended for outdoor use only and is not intended to be
installed in or on recreational vehicles or boats.
NOTE TO INSTALLER: Leave these instructions with the consumer after installation.
NOTE TO CONSUMER: Retain for future reference.
SECTION ONE
Precautions …………………………….. 1
Placement of the grill ………...……..… 3
SECTION TWO
Assembly instructions …………….…... 4
SECTION THREE
Gas hook-up ………………………..….9
Installer final check list ……………….10
Leak testing ……….………….……....11
SECTION FOUR
Operation instructions ………….……..12
Grill lighting instruction …………..….. 13
Lighting illustration……..………….…..17
SECTION FIVE
Care and maintenance…………………19
Trouble shooting ………………....….... 20
SECTION SIX
Parts list ……………………………….. 22
Ordering parts …………………………. 24
SECTION SEVEN
Grill hints ………………………….…….24
Grill Cooking Chart ………………..…..25
Grill recipe suggestions …….……….. 28
SECTION EIGHT
Limited warranty ………………..……. 31

PRECAUTIONS
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, immediately call
your gas supplier or your fire
department.
WARNING
Do not try to light this appliance without
first reading the “LIGHTING
INSTRUCTIONS” section in this manual.
FOR YOUR SAFETY
1. Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance..
TESTED IN ACCORDANCE WITH ANSI
Z21.58 / CGA 1.6 STANDARD FOR
OUTDOOR COOKING GAS APPLIANCES.
THIS GRILL IS FOR OUTDOOR USE ONLY.
Check your local building codes for the
proper method of installation. In the
absence of local codes, this unit should be
installed in accordance with the National
Fuel Gas Code ANSI Z223.1/NFPA 54,
ANSI/NFPA 58 OR CGA B149.1 Natural
Gas and Propane Installation Code, and
the National Electrical Code, ANSI/NFPA
70, or the Canadian Electrical Code, CSA
C22.1.
CALIFORNIA PROPOSITION 65-WARNING
The burning of gas fuel generates some by-
products, which are on the list of
substances, which are known by the State
of California to cause cancer or
reproductive harm. California law requires
businesses to warn customers of potential
exposure to such substances. To minimize
exposure to these substances, always
operate this unit according to the use and
care manual, ensuring you provide good
ventilation when cooking with gas.
SAFETY PRACTICES TO AVOID PERSONAL
INJURY
When properly cared for, your stainless
steel grill will give safe, reliable service for
many years. However, extreme care must
be used since the grill produces intense
heat and that can increase accident
potential. When using this appliance basic
safety practices must be followed, including
he following:
Read this Care and Use Manual carefully
and completely before using your grill to
reduce the risk of fire, burn hazard or other
injury.
Do not repair or replace any part of the grill
unless specifically recommended in this
manual. All other service should be referred
to a qualified technician.
CHILDREN SHOULD NOT BE LEFT
ALONE OR UNATTENDED IN AN AREA
WHERE THE GRILL IS BEING USED.
NEVER ALLOW THEM TO SIT, STAND
OR PLAY ON OR AROUND THE GRILL
AT ANY TIME.
1

PRECAUTIONS
Moist or damp potholders on hot surfaces
may cause burns from steam. Do not use a
towel or bulky cloth in place or potholders.
Do not let potholders touch hot portions of
the grill rack.
Grease is flammable. Let hot grease cool
before attempting to handle it. Avoid letting
excess grease deposits collect in the
grease tray at the bottom of the grill’s
firebox. Clean often.
DO NOT USE ALUMINUM FOIL TO LINE
THE GRILL RACKS OR GRILL BOTTOM.
This can severely upset combustion air flow
or trap excessive heat in the control area.
For proper lighting and performance of the
burners keep the burner ports clean. It is
necessary to clean them periodically for
optimum performance. The burners will
only operate in one position and must be
mounted correctly for safe operation.
Clean the grill with caution. Avoid steam
burns; do not use a wet sponge or cloth to
clean the grill while it is hot. Some cleaners
produce noxious fumes or can ignite if
applied to a hot surface.
INSECT WARNING!!! Spiders and insects
can nest in the burners of this and any
other grill, and cause the gas to flow
improperly. This is a very dangerous
condition which can cause a fire to occur
behind the value panel, thereby damaging
the grill and making it unsafe to operate.
Inspect the grill twice a year.
Be sure all grill controls are turned off and
the grill is cool before using any type of
aerosol cleaner on or around the grill. The
chemical that produces the spraying action
could, in the presence of heat, ignite or
cause metal parts to corrode. 2
DO NOT STORE ITEMS OF INTEREST
TO CHILDREN AROUND OR BELOW
THE GRILL OR IN THE CART. NEVER
ALLOW CHILDREN TO CRAWL INSIDE
OF THE CART.
Never let clothing, pot holders or other
flammable materials come in contact with
or too close to any grate, burner or hot
surface until it has cooled. Fabric may
ignite and result in personal injury.
For personal safety, wear proper apparel.
Loose fitting garments or sleeves should
never be worn while using this appliance.
Some synthetic fabrics are highly
flammable and should not be worn while
cooking.
Only certain types of glass, heat-proof
glass ceramic, earthenware, or other
glazed utensils are suitable for grill use.
Theses types of materials may break with
sudden temperature changes. Use only on
low or medium heat settings according to
the manufacturer’s directions.
Do not heat unopened food containers as
a build-up of pressure may cause the
container to burst.
Use a covered hand when opening the
grill lid. Never lean over an open grill.
WHEN LIGHTING A BURNER, ALWAYS
PAY CLOSE ATTENTION TO WHAT
YOU ARE DOING. BE CERTAIN YOU
ARE TURNING THE IGNITER LABELED
FOR THE BURNER YOU INTEND ON
USING.
When using the grill, do not touch the grill
rack, burner grate or immediate
surroundings as these areas become
extremely hot and could cause burns. Use
only dry potholders.

PRECAUTIONS
Do not use the grill for cooking
excessively fatty meats or products which
promote flare-ups. Do not operate the grill
under unprotected combustible
construction. Use only in well ventilated
areas. Do not use in buildings, garages,
sheds, breezeways or other such
enclosed areas. THIS UNIT IS FOR
OUTDOOR USE ONLY.
Keep the area surrounding the grill free
from combustible materials, trash, or
combustible fluids and vapors such as
gasoline or charcoal lighter fluid. A
minimum of 24”(61cm) clearance away
from combustible material. Do not
obstruct the flow of combustion and
ventilation air. If the unit is stored indoors
ensure that it is cool. If propane is used,
the cylinder must be unhooked and the
propane cylinder stored outside in a well
ventilated area, out of the reach of
children.
DO NOT USE BRIQUETTES OF ANY
KIND IN THE GRILL.
This stainless steel grill is designed for
optimum performance without the use of
briquettes. Do not place briquettes on the
radiant as this will block off the area for the
grill burners to vent. Adding briquettes can
damage ignition components and knobs,
and void the warranty.
Keep the back of the cart free and clear
from debris. Keep any electrical supply
cord, or the rotisserie motor cord away
from the heated areas of the grill.
Never use the grill in extremely windy
conditions. If located in a consistently windy
area (oceanfront, mountaintop, etc.) a
windbreak will be required (see below).
Always adhere to the specified clearance.
NEVER USE A DENTED OR RUSTY
PROPANE TANK.
PLACEMENT OF THE GRILL
CLEARANCE
To Non-Combustible Construction
A minimum of 3”(7.6cm) clearance from the
back of the grill to non-combustible
construction is required for the lid to open
fully.
DO NOT INSTALL THIS UNIT INTO
COMBUSTIBLE ENCLOSURES!
LOCATION
When determining a suitable location take
into account concerns such as exposure to
wind, proximity to traffic paths and keeping
any gas supply lines as short as possible.
Locate the grill only in a well-ventilated area.
Never locate the grill in a building, garage,
breezeway, shed or other such enclosed
areas without an approved ventilation
system. During heavy use, the grill will
produce a lot of smoke. Lock the wheels
after the grill is placed in a suitable position
according to the sticker located beneath the
right door. Keep any electrical supply cord
and the fuel supply hose away from any
heated surfaces. Storage of an outdoor
gas cooking appliance indoor is permissible
only if the cylinder is disconnected and
removed from the appliance.
This outdoor cooking gas appliance shall
be used only outdoor and shall not be used
in a building, garage or any other enclosed
area. This appliance is not intended to be
installed on or on recreational vehicles
and/or boats 3

ASSEMBLE INSTRUCTIONS
•The screws used to attach the side burner and side shelf are already screwed into the two
side panels. Remove the screws and washers from the two side panels, align with the holes
in the side shelves, and then re-screw into the holes on the side panels of the grill. (see the
figure below)
•Repeat the above step to install the left side shelf on left side panel.
4
Th
e
Gl
a
s
s
o
T
M
T
M
Th
e
Gl
a
s
s
o

ASSEMBLE INSTRUCTIONS
•To assemble the side burner lid handle. Open the lid first, cut off the plastic tie tied in the
screw hole and install the handle in the lid as shown in figure below.
•The screws for the rotisserie bracket are already screwed into the left side of the grill
housing. Remove the screws and assemble the rotisserie motor bracket as shown in the
figure below. Assemble the rotisserie skewer as show in the figure below.
5
Th
e
Gl
a
s
s
o
T
M

ASSEMBLE INSTRUCTIONS
•Side Burner Valve Assembly
6
Take side burner valve and insert through side burner front panel. Then secure with
two (2) screws.
Insert burner venturi onto burner valve orifice and use two (2) screws to secure burner
to bracket as shown
Secure burner with “u” shape bracket with two (2) screws and attach ignition wire to
igniter
Install control knob onto valve stem and tighten nut with allen wrench; provided

ASSEMBLE INSTRUCTIONS
•Remove the screw from the side panel, then attach the lighting rod onto the side panel by
using the original screw.
7
Your gas grill is ready to use.
T
M
Th
e
Gl
as
s
o