OW Lee CASUAL FIRESIDE 5110-2872O User manual

Model / Modèle
5110-2872O 5112-2872O 5120-2872O 5122-2872O
5110-3674BTO 5112-3674BTO 5120-3674BTO 5122-3674BTO
5110-4272O 5112-4272O 5120-4272O 5122-4272O
5110-4484BTO 5112-4484BTO 5120-4484BTO 5122-4484BTO
http://www.owlee.com/technical-information.aspx
T65O
DANGER
This gas appliance is designed as an “attended appliance”. Adults must be present when the unit is
operating/burning. DO NOT leave this unit operating/burning when unattended. If this product is left
operating/burning and unattended it may cause serious injury, death and or property damage.
CASUAL FIRESIDE
Installation and service must be performed by a qualified installer, service agency, or the gas supplier
FIRE OR EXPLOSION HAZARD
1. Shut off gas supply to the appliance.
If you smell a rotten egg odor immediately:
INSTALLER - Leave this manual with the
appliance.
CONSUMER – Retain this manual for
future reference.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
Failure to follow these instructions
could result in fire or explosion,
which could cause personal injury,
death or property damage,
3. If odor continues, leave the area immediately.
4. After leaving the area, call your gas supplier
or fire department.
2. Extinguish any open flame.
DANGER
Tested & Certified to
ANSI Z21.97-2017/CSA 2.41-2017
CGA 2.17-M91 (R2017)
The link below will take you to the Owners Manual and Operating Instructions in French where you can download a copy.
Sélectionnez le lien ci-dessous pour télécharger les instructions françaises.
A HIGHER STANDARD IN QUALITY AND APPEARANCE - SAFE AND BEAUTIFUL OUTDOOR
FIRE PIT FOR PROPANE AND NATURAL GAS (Requires Conversion Kit)
Report #14662-1G
WARNING
Improper installation, adjustment, alteration, service or maintenance of this gas appliance can cause
injury, death or property damage. Read the installation, operating and maintenance instructions
thoroughly before installing or servicing this gas appliance.
WARNING
To avoid risk of fire or explosion. Do Not store or use gasoline, or other flammable vapors and liquids, in
the vicinity of this or any other gas appliance. An LP-cylinder not connected for use shall not be stored in
the vicinity of this or any other gas appliance.
WARNING: FOR OUTDOOR USE ONLY
APPLIANCE BTU RATING
65,000 Propane / 65,000 Natural Gas
BUILDING CODE AND FIXED PIPING SUPPLY REQUIREMENTS: When an appliance is connected to a fixed gas piping supply
system, the installation must conform to local building codes, or in the absence of local building codes, to the National Fuel Gas
Code, ANSI Z223.1/NFPA 54, International Fuel Gas Code, Natural Gas and Propane Installation Code, CSA B149.1, or Propane
Storage and Handling Code, B149.2, as applicable.
READ THESE INSTRUCTIONS FULLY BEFORE INSTALLING THIS OUTDOOR FIRE PIT.
If the information in this manual is not followed exactly, a fire or explosion may result causing
personal injury, death or property damage.
V7-100120A

Table of Contents
Cover - Important Safety Information 1
Important Safety Information and
Minimum Clearances to Combustibles 2
Pre-Installation & Preparation Guidelines 3
Important Safety Information 4
Installation Information
Connecting the Gas to the Fire Pit 5
Propane Tank Information 6
Media Placement and Replacement Parts List
Certified Media List / Protective Screen Media Clearance 7
Gem, Mirrored, Crushed Glass and Lava Rock Installation 8
Rock Media Installation 9
Trouble Shooting Guide 10
Warranty Information 11
Operation Instructions
Lighting Instructions 12
Proposition 65 Public Warning 13
Conversion to a Different Gas Type 14
A.
B.
C.
D.
E.
Clearances to Combustible Construction:
Sidewalls: 60” (1.5 m) from center of unit (Figure 1)
Ceiling: 60” (1.5 m) from top of unit to ceiling or overhang
Flooring: 0” – Can be installed on deck, slab, floor, etc.
The dimensions shown in Figure 1 are MINIMUM
CLEARANCES to maintain when you install this Outdoor Fire
Pit. THERE MUST BE AT LEAST 60” of clearance from the
center of the unit to any combustible sidewalls, ceilings, or
material.
Figure 1
Page 2
CHECK STATE AND LOCAL BUILDING CODES TO DETERMINE IF THE OUTDOOR FIRE PIT IS PERMITTED IN
YOUR LOCALITY BEFORE INSTALLATION.
FOR OUTDOOR USE ONLY. THIS UNIT MUST BE INSTALLED AT LEAST 60” FROM CENTER OF BURNER TO ANY
COMBUSTIBLE WALLS, CEILINGS, OR MATERIAL.
WHEN SHUTTING OFF THE UNIT — BE SURE TO TURN THE CONTROL VALVE ON THE FIRE PIT TO THE FULLY OFF
POSITION ON THE FIRE PIT and CLOSE THE VALVE ON THE PROPANE TANK or NATURAL GAS SUPPLY LINE.
WARNING: CARBON MONOXIDE POISONING MAY LEAD TO DEATH. DO NOT MODIFY THIS OUTDOOR FIRE PIT
OR ITS CONTROLS, EXCEPT AS PROVIDED FOR IN THIS MANUAL.
IMPROPER INSTALLATION OR USE OF YOUR OUTDOOR FIRE PIT CAN CAUSE SERIOUS INJURY, DEATH, AND OR
PROPERTY DAMAGE FROM FIRE, BURNS, EXPLOSIONS OR CARBON MONOXIDE POISONING.
MINIMUM CLEARANCE TO COMBUSTIBLES
OUTDOOR FIRE PIT - TABLE OF CONTENTS
IMPORTANT SAFETY INFORMATION
READ THESE INSTRUCTIONS FULLY BEFORE INSTALLING THIS OUTDOOR FIRE PIT.
If not installed and used correctly per these instructions,
this product can cause serious injury, death, and or property damage and may void the warranty.
CAUTION: FIXED PIPING GAS SUPPLY INSTALLATION, AND REPAIRS MUST BE DONE BY
A CERTIFIED PROFESSIONAL TECHNICIAN or LICENSED PLUMBER.
Be sure you understand all safety precautions and warnings contained in this manual.
If you have any questions, please contact O.W. Lee at [phone]
NOTE
MINIMUM OF 60” (1.5 m) CLEARANCE ABOVE THE
OUTDOOR FIRE PIT IF INSTALLED UNDER CEILING OR
OVERHANG
60” (1.5 m)
CLEARANCE
FROM CENTER
TO ANY
COMBUSTIBLE
CONSTRUCTION
60” (1.5 m)
CLEARANCE
FROM CENTER
TO ANY
COMBUSTIBLE
CONSTRUCTION

O. SAFETY NOTE: Fire pits connected to a fixed piped gas line, require a second gas shut off valve. The valve must be kept in
the off position when the fire pit is not in use. The secondary valve shuts off the gas supply to the fire pit, and allows for
maintenance and repair.
Page 3
L. Propane Regulator Hose: Always inspect the condition of the propane regulator hose before each operation. Any signs of
excessive abrasion the hose MUST BE REPLACED. Contact your local dealer for replacement part #COM0589
M. Propane Regulator Hose (when used): The propane regulator hose is located inside the fire pit door panel. When
installed, make sure the hose is secured inside the unit and DOES NOT TOUCH THE BURNER PAN.
N. Note: The Use Of A Third Party Fire Pit Top, Media and or Components Will Void the LABTEST Certification
and O.W Lee Warranty.
I. If the Outdoor Fire Pit is connected to a fixed piping gas supply line, the supply line is required to have an on/off gas valve
installed before the fire pit and must be closed during any pressure testing of the system at test pressures equal to or less
than ½ psi (3.5kPa).
J. INSTALLER NOTE: This unit should be installed so that it can be removed at a later date for service.
K. GAS SUPPLY PLUMBING REQUIREMENTS
Apply only joint compounds that are resistant to all gasses on all male pipe fittings. Make sure to tighten every joint securely.
DO NOT use pipe joint compound to connect flare fittings.
F. Fixed Gas piping system must be sized to provide minimum inlet pressure at the maximum flow rate (BTU/hr). Undue
pressure loss will occur if the pipe is too small or the run is too long.
G. Casual Fireside Fire Pits are suitable for installation from 0 - 4,500 ft. elevation without modification.
H. If the Outdoor Fire Pit is connected to a fixed piping gas supply line, the supply line is required to have an on/off gas valve
installed before the fire pit and it must be closed during any pressure testing of the system at test pressures in excess of ½
psi (3.5kPa).
C. CHECK GAS TYPE (Natural Gas or Propane): The gas supply you intend to use may not be the same that your fire pit was
setup for or is stated on your outdoor rating plate. THIS FIRE PIT IS CONSTRUCTED FOR USE WITH PROPANE GAS. If
the gas supply is different, or you wish to change to Natural Gas, you MUST have the Fire Pit Converted (directions to
convert can be found on page 14) to the gas type you intend to use. Any gas type conversion should be performed
by a qualified, professional technician or licensed plumber. If you are unsure, contact your dealer for assistance.
D. DO NOT USE IF GAS PRESSURE IS LOWER THAN THE MINIMUM REQUIREMENT OR EXCEEDS THE MAXIMUM.
E. GAS PRESSURE REQUIREMENTS: FOR NATURAL GAS:
The minimum inlet gas supply pressure for purposes of input adjustment is 3.5 inches (127 mm) water column and maximum
inlet gas supply pressure is 10 inches (254 mm) water column.
FOR PROPANE: The minimum inlet gas supply pressure for purposes of input adjustment is 8 inches
(203 mm) water column and the maximum inlet gas supply pressure is 13 inches (330 mm) water column.
MANIFOLD PRESSURE REQUIREMENT: Liquid Propane 9.5 (241.3mm) / Natural Gas 2.5 (63.5mm) of pressure.
DO NOT INSTALL THIS UNIT IF MINIMUM PRESSURE IS NOT AVAILABLE OR IF MAXIMUM PRESSURE IS EXCEEDED.
IMPORTANT SAFETY INFORMATION
Pre-Installation & Preparation Guidelines
A. Before installing the Outdoor Fire Pit, check “Minimum Clearance to Combustibles” on page 2.
MINIMUM CLEARANCES must be maintained when you install this Outdoor Fire Pit. THERE MUST
BE AT LEAST 60” (1.5 m) from the center of the burner to any combustible sidewall, ceiling, or material.
B. The Outdoor Fire Pit is for outdoor use only. DO NOT install or use this appliance inside a building,
garage, or any other enclosed area or structure including recreational vehicles, boats & sheds. This unit must be
installed in such a manner that proper air ventilation is maintained without obstruction at all times, and during all
weather conditions.

S. Periodically make a visual check of the burner flame to make sure it has not considerably changed in height or coloration since
last being used. Any significant change in flame height or coloration is a sign that unit needs to be inspected and serviced or
cleaned as required in order to maintain proper safe operation.
T. Cleaning of appliance – Remove lava rock or glass pieces, clean burner with soap and water and dry thorough ly before lighting.
Clean lava rock or glass pieces with water and dry thoroughly before lighting. Remove any spider webs from inside the unit.
Page 4
P. Installation and repair should be done by a qualified service technician or licensed plumber. Open the door on the unit to
gain access for inspection.
Q. To reduce the risk of explosion, the appliance should be inspected before each use and at least annually by a qualified
service technician. More frequent cleaning maybe required as necessary. It is imperative that the control compartment, burner
and air passageways of the gas appliance are kept clean.
R. The burner must be replaced prior to the appliance being put into operation if it is evident that the burner is damaged.
Replacement burner #COM0568 manufactured by O.W. Lee Company, 1822 E. Francis Street, Ontario CA 91761
M. DO NOT store any combustible materials, gasoline, or any other flammable vapors/liquids within 60 inches of your Fire Pit.
Provide adequate clearance for servicing and operation.
N. WARNING: Clothing or other flammable materials should not be hung from the appliance or placed on or near the
appliance.
O. DO NOT use this appliance if any part of it has been under water. Call a qualified service technician to inspect the appliance
and to replace any part of the control system and any gas control part which has been under water before using.
J. WARNING:DO NOT BURN SOLID FUEL IN THIS FIRE PIT.
K. WARNING:"Improper installation, adjustment, alteration, service or maintenance can cause injury,death or property
damage. Read the installation, operation, and maintance instructions thoroughly before installing or servicing this
equipment"
L. DO NOT continue using your FIRE PIT if you smell a rotten egg odor or have headaches, nausea or dizziness.
G. WARNING: DO NOT throw trash, paper, plastics or any other flammable materials into your Fire Pit.
H. WARNING: DO NOT leave fire pit lit when unattended.
I. WARNING: DO NOT operate this Fire Pit in the rain.
D. WARNING: Every time you use your Fire Pit make sure that the area around the Fire Pit is clear of ALL flammable items
such as yard debris, wood, etc. and any flammable vapor producing or flammable liquid items such as gasoline, etc.
E. WARNING: HOT WHILE IN OPERATION AND FOR AT LEAST A HALF HOUR FOLLOWING OPERATION.
F. WARNING: Children must be carefully supervised when in the vicinity of this appliance. Serious injury or death may
IMPORTANT SAFETY INFORMATION
A. WARNING:YOUNG CHILDREN SHOULD ALWAYS BE CAREFULLY SUPERVISED WHEN THEY ARE IN THE AREA OF
THIS APPLIANCE and IT IS IN USE. SERIOUS INJURY OR DEATH MAY OCCUR
B. WARNING:DO NOT sit or place any part of the body or combustible materials including hair near the Fire Pit Flame.
C. WARNING: Children and adults should be alerted to the hazard of high surface temperatures and should stay away to
avoid burns or clothing ignition.

THE LP-GAS CYLINDER (Propane Tank) INFORMATION:
A
) Cylinder Size: Manchester Vertical Tank #11
11 Lbs. (4kg) Capacity: 2.6 Gallons (9.84 Liters).
B) Cylinder Size: Manchester Tank #20 20 Pound Horizontal Tank
20 Lbs. (9.07kg) Capacity: 4.6 Gallons (17.41 Liters).
BEFORE INSTALLATION, BE SURE THE LP-GAS CYLINDER/PROPANE TANKS VALVE IS CLOSED.
The LP-Gas Cylinder(s) to be used must be constructed and marked in accordance with the U.S. Department of
Transportation (D.O.T.) Specifications for LP-Gas Cylinders or the Standard for Cylinders, Spheres and Tubes for Transportation
of Dangerous Goods and Commission, CAN/CSA-B339 as applicable.
--Use cylinders approved for your area such as “Blue Rhino” or “AmeriGas” with this appliance. Other cylinders may be
acceptable for use with the appliance provided they can be mounted to the appliance using the cylinder retention devise provided.
(See illustration above.)
--The LP-Gas Cylinder to be used must be provided with a listed overfilling prevention device (OPD) and with a cylinder
connection device compatible with the connection for the appliance.
2.
Occasional Height Fire Pits Propane Tank Options:
CONNECTING AN LP-GAS CYLINDER/PROPANE TANK TO THE FIRE PIT
When connecting the regulator to the tank valve, make sure the coupling nut does not cross-thread on the tank valve.
Cross-threading the regulator nut to the tank valve may cause a leak.
Turn on the gas to the burner system and test for leaks with soapy water solution.
(Never use an open flame for testing). If a leak is found, re-connect the regulator coupling nut and tighten until no leaks are detected.
The hose and burner should be inspected before each use of the appliance.
The hose assembly must be replaced prior to the appliance being put into operation if there is evidence of excessive abrasion or wear,
or if the hose is damaged. The replacement hose must be specified by the manufacturer.
The LP-Gas Cylinders must be stored outdoors in a well-ventilated area out of the reach of children & at Least 60 inches away for
the fire pit. Disconnected cylinders must have threaded valve caps tightly installed and must not be stored in any building, garage,
or other enclosed area.
3. Make sure the appliance is NOT in use, and turn OFF the gas at the supply LP-Gas Cylinder Valve.
The LP-Gas Cylinder must be disconnected when the appliance is not in use.
Important WARNINGS and Safety Information (Pages 1, 2, 3, 4)
5.
6. The LP-Gas Cylinder must be standing on the designed bottom base of the cylinder for proper vapor withdrawal.
Page 5
B. Minimum Clearance to Combustibles (Page 2)
IMPORTANT
BEFORE PROCEEDING, CAREFULLY READ ALL OF THE IMPORTANT
SAFETY INFORMATION IN THIS OWNER'S MANUAL
A.
11 Pound Tank
1.
4.