Pacific Micro Systems DM1210N User manual

DATA MULTIPLEXER
DM1210N
Operation and Installation Manual
©PacificMicroSystems

DM1210N©PacificMicroSystems
LIMITEDWARRANTY
PacificMicroSystemswarrantsitsproductstobefreefromdefectsinmaterialsand
workmanshipforaperiodofone yearfromdateofsaletotheoriginalowneror
fifteenmonthsfromdateofsalefromPacificMicroSystems.
Thiswarrantyprovidesfortherepairorreplacement(atouroption)ofanyparts
foundtobedefectiveinnormalandintendeduse,providedthatsuchdefectsarein
ouropinionduetofaultymaterialorworkmanship.
Thiswarrantydoesnotapplytoproductswhichhavebeenimproperlyinstalled,
subjectedtoextremesbeyondthelimitsofourspecifications,orwhichhavebeen
physicallydamaged.Nordoesitapplytoproductsfoundtobedefectivedueto
abuse,lightningoranyotherelectricaldischarge,saltorfreshwater,spray,or
improperorunauthorisedrepair.PacificMicroSystemswillpayshipping(method
tobeofourchoice)andinsurance forreturnofsaidproductprovidedthatthe
returnedproductproveddefectiveunderthetermsandconditionsofthiswarranty.
TheobligationofPacificMicroSystemsshallbelimitedtotherepairor
replacementonly.
InnoeventshallPacificMicroSystemsbeliableforanyspecial,collateral,
incidentalorconsequentialdamagesfor(1)breachofanyprovisionshereof,
including,withoutlimitation,provisionsregardingwarranties,guarantees,and/or
indemnities:or(2)anyclaimsbythepurchaserconcerningthegoodswithout
limitation,claimsoflossofgoodwill,lossofprofitorrevenues,lossofuse,costof
removal,installationorreinstallation,personalinjuryofanykindtothepurchaser
oranyoneelse.
Theforgoingwarrantyisinlieuofallotherwarranties,whetherexpressedor
implied,orarisingbylaw,custom,orconduct,including,withoutlimitation,
thewarrantiesofmerchantabilityand/orfitnessforanyparticularpurpose.
PacificMicroSystemspolicyisoneofcontinueddevelopment.Forthisreason,
PacificMicroSystemsreservestherighttochangespecificationswithoutnoticeand
withoutincurringanyobligationtosimilarlyalterproductspreviouslypurchased.
Copyright©1992/2007PacificMicroSystems.
Allrightsreserved.Nopartofthismanual,orsoftware(whetheron
diskorinhardware)suppliedbyPacificMicroSystemsmaybe
reproducedinanyformwithouttheexpresswrittenpermissionof
PacificMicroSystems.

DM1210N©PacificMicro Systems
Version1.01
1September2007
Contents
Page
OUTLINE: ...........................................................................................1
PARTSSUPPLIED: .............................................................................2
INSTALLATION:................................................................................2
DM1210NOPERATION:.....................................................................3
DMxxConfig.EXE(DM1210NCONFIGURATION):........................3
SPECIFICATIONS: .............................................................................4
CONNECTIONDETAILS ...................................................................5
SOFTWAREUPGRADES: ..................................................................8
Designedandmanufacturedby
PacificMicroSystems Telephone 6444759004
136CurtisStreet Facsimile 6444759084
POBox9285 Mobile 6425449061
Wellington6012 Email [e-mail]
NEWZEALAND Internet www.pacmicro.com

DM1210N©PacificMicroSystems
1
OUTLINE:
ThisDataMultiplexerDM1210NreceivesdatafromanumberofdifferentSatellite
Navigators,GPS's,Lorans,etccapableofsendingNMEA0182/3,FurunoCIF,JRC
format,Koden8805/8811,KaijoDenkiformatorSimradEK500depthformat.
ThesecanbeconvertedtoNMEA0183andtransferredtoanyotheroutput.The
datacanalsobeinputandoutputonanUTP10MegEthernetport.
Features:
1Ethernetport,10Mb,UDP.
12CurrentLoop,RS422orRS232asynchronousserialInputs.
10SerialOutputs.
10xCurrentLooporRS422asynchronousserialOutputs.
4ofthe10also haveRS232asynchronousserialOutputs.
Userselectablebaudratestoallowhighthruputofdata..
ConversionofNMEA0183,FurunoCIFtoNMEA0183orFurunoCIFserialdata.
FulltransfercapabilitiesbetweenallInputs&Outputsallowingflexibledata
combining.
FilteringofNMEA0183datathruanyinputoroutput,ieAll,GGA,VTG,ZDA
etc
NMEA0183orFurunoCIFsentencescanbegeneratedfromtriggeranddepth
pulseswithselectableNMEA0183depthsentenceie.SDDBT,SDDBSetc.Output
inMeters,FathomsorFeetdepthoutputwithselectablesoundvelocityfactors
between1450and1550m/s.
ConvertSimradITInetpositiontoTLLsentencefordisplayonplotter.
ConvertFurunoSonartargetdatatoTTMsentencefordisplayonplotter.
CapabilitytochangeNMEA0183talkersonanyoutputs.
GenerateslogpulsesfromNMEA0183sentenceVTGorVHWin100,200or400
PPNM.
GeneratesNMEA0183sentenceVTGorVHWfrom100,200or400PPNMinput.
AlarmoutputwhenpredefinedconditionsaremetieNoGPS,NoDGPSetc.
Galvanicisolationbetweeninputsupply,datainputsandoutputs.
RFIshieldedhousing.
StatusLEDsonallinputsandoutputs.
4xbinaryinputs/outputs

DM1210N©PacificMicroSystems
2
PARTSSUPPLIED:
1x DM1210NInterface.
INSTALLATION:
1. Runatwocorescreeneddatacablefromeachserialsourcetotherequired
serialinput..
2. Runatwocorescreeneddatacablefromeachoutputtothedata
destinations.
3. RunastandardUTPCat5patchcable(crossover)betweentheDM1210N
NetworkportandthenetworkportonthetargetPCorastraightthrucable
toahubthatthePCisalsopluggedinto.
4. Runthesupplycabletoasuitable1135vsupply.(Red/Black+volts,
Blackvolts).
Note:
TheDM1210NhasDCisolationbetweenitspowersupplyinputandground.This
makesitsuitableforinterfacingtoanycomputerinstallationandallisolated
groundequipment,withoutaffectingtheintegrityofthebatterypositive(+)or
negative()relativetoground.

DM1210N©PacificMicroSystems
3
DM1210NOPERATION:
1. The RXLED'sarenormallyoffandflashingonwhenreceivingserial
data.
2. Asdataisreceivedin1thru12theappropriateRXLEDwillflash.
3. Asdataistransmittedout1thru10theappropriateTXLEDwillflash.
DMxxConfig.EXE(DM1210NCONFIGURATION):
DuetotheextensivecapabilitiesavailableintheDM1210N,configurationis
accomplishedthoughtheConfigurationprogramDMxxConfig.exe.
ConnecttheDM1210NNetworkporttothePCnetworkportviaacrossovercable,
orstandardcableandnetworkhub,andlaunchtheprogramDMxxConfig.EXE.
ClickonthebuttonSearchforDM1210N’s.
AllDM1210N’sonthenetworkwillbelistedinthelistbox.
HighlighttheDM1210N(SerialNumberandIPAddress)oftheDM1210Nto
configure.
ClickontheGetConfigmenuitemtogettheselectedDM1210N’scurrent
configuration.
ChangetheconfigurationasrequiredusingtheOptionsandTransferMenuItems.
UpdatetheDM1210NbyclickingontheUpdateConfigMenuItem.

DM1210N©PacificMicroSystems
4
SPECIFICATIONS:
Serialdatacapabilities:
Inputs: 1thru12.RS232orCurrentLoop/RS422.
Outputs: 1thru10.CurrentLooporRS422.
Outputs: 7thru10.RS232.
Input/Output1:BaudRateupto115200.
Input/Output2thru10:BaudRateupto38400.
Input11,12:BaudRateupto38400.
SerialFormatsReceived:
NMEA0183,FurunoCIF.
SerialFormatTransmitted:
NMEA0183,CIF
TransmittedData:
NMEA0183: 4800,8databits,noparity,1stopbit.
CIF: 4800,7databits,evenparity,2stopbits
User: 50115200,58databits,None,Odd,Evenparity,1or2stopbits.
DigitalIn:
05v
DigitalOut:
Currentsink100mA,Externalsupplyrequired(50vmax).
PowerRequirements: 1135vdc@50200mA.
DCisolationbetweenpowersupplyinputandgroundisprovided.
Weight: 620grams.
Dimensions:170x150x40mm
Mounting:Tabletoporwallmounted
PacificMicroSystemshasapolicyofcontinueddevelopmentandthereforereserves
therighttochangespecificationswithoutnotice.

DM1210N©PacificMicroSystems
5
CONNECTIONDETAILS
J1 Description
1 +veDCIn(1136)
2 Ground
3 veDCIn(1136)
J2 Description
1 CurrentLoopInputRX1+(Signal)
2 CurrentLoopInputRX1 (Return)
3 CurrentLoopInputRX2+(Signal)
4 CurrentLoopInputRX2 (Return)
5 CurrentLoopInputRX3+(Signal)
6 CurrentLoopInputRX3 (Return)
J3 Description
1 CurrentLoopInputRX4+(Signal)
2 CurrentLoopInputRX4 (Return)
3 CurrentLoopInputRX5+(Signal)
4 CurrentLoopInputRX5 (Return)
5 CurrentLoopInputRX6+(Signal)
6 CurrentLoopInputRX6 (Return)
J4 Description
1 CurrentLoopInputRX7+(Signal)
2 CurrentLoopInputRX7 (Return)
3 CurrentLoopInputRX8+(Signal)
4 CurrentLoopInputRX8 (Return)
5 CurrentLoopInputRX9+(Signal)
6 CurrentLoopInputRX9 (Return)

DM1210N©PacificMicroSystems
6
CONNECTIONDETAILScont.
J5 Description
1 CurrentLoopInputRX10+(Signal)
2 CurrentLoopInputRX10 (Return)
3 CurrentLoopInputRX11+(Signal)
4 CurrentLoopInputRX11 (Return)
5 CurrentLoopInputRX12+(Signal)
6 CurrentLoopInputRX12 (Return)
J6 Description
1 Ground
2 Ground
3 Ground
4 Ground
5 Ground
6 Ground
J7 Description
1 RS422OutputTX1+
2 RS422OutputTX1 
3 Ground
4 Ground
5 RS422OutputTX2+
6 RS422OutputTX2 
J8 Description
1 RS422OutputTX3+
2 RS422OutputTX3 
3 Ground
4 Ground
5 RS422OutputTX4+
6 RS422OutputTX4 

DM1210N©PacificMicroSystems
7
CONNECTIONDETAILScont.
J9 Description
1 RS422OutputTX5+
2 RS422OutputTX5 
3 Ground
4 Ground
5 RS422OutputTX6+
6 RS422OutputTX6 
J10 Description
1 RS232OutputTX7
2 RS232OutputTX8
3 Ground
4 Ground
5 RS232OutputTX9
6 RS232OutputTX10
J11 Description
1 DigitalIn/Out1
2 DigitalIn/Out2
3 Ground
4 Ground
5 DigitalIn/Out3
6 DigitalIn/Out4
RS422DATAOUTPUTPOLARITY:
+5v
RS422TX+
 ov