Peak Performance PKC05MB Instruction Manual

TM
5,000,000 Rechargeable
Spotlight
Model No.: PKC05MB
Owner’s Manual
and Warranty Information
Read these instructions completely before using this product.
Retain this Owner’s Manual for future reference.

INTRODUCTION
Read and understand this Instruction Manual before using the Spotlight. Recharge and operate the Spotlight
only as described in this Instruction Manual.
FEATURES
1
2
3
5
4
Legend
1.LED Accessory Light
2. 110/120-volt AC Charging Adapter
3. LED Accessory Light ON/OFF Switch
4. Adjustable Stand
5. Spotlight ON/OFF Switch
SPOTLIGHT CHARGING
This Spotlight is shipped in a partially charged state. BEFORE first use, charge the
Spotlight battery using the 110/120-volt AC charging adapter for 24 hours. Failure to follow this
procedure may permanently damage the battery.
Charger Features
A standard two-prong 110/120-volt AC charging adapter is located on the back of the Spotlight behind
the protective cover for connection of an AC extension cord. The 110/120-volt AC charging adapter
allows charging from a household wall outlet (110/120-volt AC).
Charging Guidelines and Precautions
• Only use the charging adapter that is built in to this Spotlight. Use of any other chargers or adapters may
void any warranty, cause Spotlight damage, increase risk of fire and/or result in personal injury.
• Do not overheat or overcharge the battery.
110/120-Volt AC Charging
Never connect the 110/120-volt AC charging adapter to an ungrounded AC power supply.
Never connect the 110/120-volt AC charging adapter to any AC voltage other than
60 Hz - 110/120-volt AC supply.
Never turn the Spotlight on while charging, as this will damage the Spotlight and void any
warranty. Keep the Spotlight ON/OFF and LED accessory light ON/OFF switches in the OFF position
at all times during charging.
Charging performance may vary depending on local AC voltage.
Once the unit is discharged, future recharging will take 16 to 18 hours using the 110/120-
volt AC charging adapter to reach full charge.
Do not charge the battery for more than 24 hours using the 110/120-volt AC charging
adapter.
1. Make sure both the Spotlight ON/OFF switch and the LED accessory light ON/OFF switches are in the
OFF position.
2. Open the 110/120-volt AC charging adapter protective cover and connect the extension cord to the
110/120-volt AC charging adapter.
3. Plug the extension cord into an approved outlet.

Charging Tips
• Recharge the Spotlight as soon as possible once the Spotlight starts to dim and after each use.
• Disconnect the charging adapter cord and wait 5 minutes before use once charging is complete.
• Never leave the battery discharged or completely discharge the battery, as this will decrease battery life.
Recharge every 2 months in periods of non-use. Frequent charging will improve the performance of the
battery.
• Disconnect the power from the charging adapters and Spotlight when not in use.
SPOTLIGHT OPERATION
Do not operate the Spotlight when the extension cord is connected to the Spotlight.
• Be sure the Spotlight battery is completely charged. See SPOTLIGHT CHARGING on page 3.
• Before operating the Spotlight, disconnect the charging adapters. Disconnect the extension cord from the
power supply before disconnecting the extension cord from the Spotlight.
Spotlight:
1. Press the rocker switch to the ON “–” position to turn the Spotlight on.
2. To turn the Spotlight off, press the rocker switch to the OFF “O” position.
LED Accessory Light:
1. Press the LED accessory light ON/OFF switch to the ON “–” position to turn on the LED accessory light.
2. To turn off the LED accessory light, press the switch to the OFF “O” position.
Adjustable Stand:
1. Move the adjustable stand to allow the spotlight to stand at the desired position. The stand can be
moved to five different positions.
2. When not using the adjustable stand, fold the stand all the way back under the 110/120-volt AC charging
adapter protective cover.
CARE AND MAINTENANCE
Due to inherent self-discharge, lead-acid batteries should be charged at least every
2 months, especially in a warm environment. Leaving a battery in a discharged state, or if not
recharged every 2 months, may result in permanent battery damage.
• Read CHARGING GUIDELINES AND PRECAUTIONS on page 3 and CHARGING TIPS on page 4.
• Charge the Spotlight battery using the 110/120-volt AC charging adapter after every use.
• Charge the Spotlight every 2 months during periods of non-use.
• Unplug the unit and allow to cool before attempting to clean.
• Only use a soft cloth moistened with a mild solution of water and detergent on the outer surface of the
Spotlight when cleaning.

SPECIFICATIONS
1. Lumens 645
2. Run Time (primary halogen bulb) Up to 35 minutes in one full charge
3. Battery 6-volt, 5Ah rechargeable sealed lead-acid battery
(non-replaceable)
4. Main Bulb 6-volt 55W halogen bulb (non-replaceable)
5. LED 2 white LEDs (non-replaceable)
6. Initial Charge Time AC charger – 24 hours
7. Subsequent Charge Time AC charger – 16-18 hours
8. AC Charger Adapter Input 110/120-volt; output 6-volt 300 mA
PEAK HAND TOOLS