Performance Tool W41044 User manual
Read these safety warnings before operation.
WARNING!
Failure to read, understand and follow these warnings may
result in loss of load, damage to unit, and/or failure of unit
resulting in personal injury or property damage.
WARNING!
Use this transmission adaptor only for the removal and instal-
lation of passenger car and light duty truck transmissions. Do
not overload beyond 300 lbs. Do not remove or install trans-
missions with transfer cases attached.
Jack must be in fully lowered positon to move load.
Always secure transmission in place with safety chain.
Use only with heavy frame service jack with removable saddle.
(See example on back page) Read, understand and follow all
warnings listed in jack instruction manual.
Vehicle must be properly supported before starting repair.
Refer to vehicle owner’s manual for proper jacking proce-
dures.
This unit is designed for use only on hard level surfaces capa-
ble of sustaining the load. Use of unit on other than hard level
surfaces can result in instablility and possible loss of load.
IMPORTANT SAFETY INFORMATION
1. Visual inspection must be made before each use of this unit, checking
for cracks, cracked welds and missing and/or damaged parts. Any
unit that appears to be damaged in any way must be removed from
service immediately.
2. BECAUSE OF THE POTENTIALHAZARDSASSOCIATED WITH THE
MISUSE OF EQUIPMENT OF THIS TYPE, NO MODIFICATIONS
SHALL BE MADE TO THE PRODUCT.
3. Keep adaptor well lubricated at all
points shown in drawing at right.
4. Replace worn or damaged parts
with Performance Tool replace-
ment parts. Be sure that only
qualified personnel perform
repairs.
CARE & MAINTENANCE
1
14
14
15
15 16 18
16
14
14
20
15 16
17
10
19
2
11
11
13A
21
12
3
4
5
6
7
8
9
13B
Oil Oil
Assembly Diagram
1
14
14
15
15 16 18
16
14
14
20
15 16
17
10
19
2
11
11
13A
21
12
3
4
5
6
7
8
9
13B
1. Install Threaded Bushing (3), into holes in Platform (1) using Large
Snap Rings (11) as shown.
2. Screw Adjustable Tilt Knob (2) through threaded bushing approximate-
ly half way.
3. Install 2 Lock Nuts (13A) approximately 3” from end of threaded shaft.
4. Install Non-Threaded Bushing (4) into holes in Pivot Frame (5) using
Large Snap Rings (11) as shown.
5. Slide Non-Threaded Bushing over onto threaded shaft and install
remaining Lock Nut (13B).
6. Connect Platform (1) to Pivot Frame (5) using Pivot Pin (6), Small Snap
Rings (12) and Spacers (21) as shown.
7. Bolt on Mounting Bracket Frames (7) and Mounting Brackets (8).
8. Install Chain Hook Assembly (9) and Safety Chain (10) as shown.
9. Install Assembled Adaptor onto Service Jack Saddle Frame securing
with Bolt (14) and Washer (20).
ASSEMBLY INSTRUCTIONS
1 Platform 1
2 Adjustable Tilt Knob 1
3 Threaded Bushing 1
4 Non-Threaded Bushing 1
5 Pivot Frame 1
6 Pivot Pin 1
7 Mounting Bracket Frame 2
8 Mounting Bracket 4
9 Chain Hook Assembly 1
10 Safety Chain 1
11 Large Snap Ring 4
12 Small Snap Ring 2
13 Lock Nut with Set Screw 3
14 M10 x 25 Bolt 7
15 M10 Washer 7
16 M10 Nut 7
17 M8 x 25 Bolt 1
18 M8 Washer 2
19 M8 Nut 1
20 Large Retaining Washer 1
21 Spacer 2
Part # Description Qty. Part # Description Qty.
Parts List
Example of
heavy frame
service jack
LIMITED WARRANTY
PERFORMANCE TOOL extends only the following warranties, and only to original retail purchasers. These warranties give spe-
cific legal rights. Except where prohibited by local law, the law of the State of Washington governs all warranties and all exclusions
and limitations of warranties and remedies. There may be other rights which vary from state to state.
PERFORMANCE TOOLwarrants the product to be free from defects in materials and workmanship under normal use and service.
A defective product may be returned for a free replacement within 90 days from the date of purchase, provided that product is
returned to place of purchase immediately after discovery of defect. After 90 days and up to 1 year from date of purchase,
PERFORMANCE TOOL will replace at no charge any parts which our examination shall disclose to be defective and under war-
ranty. These warranties shall be valid only when a sales receipt showing the date of purchase accompanies the defective
product or defective part(s) being returned.
These warranties exclude blades, bits, punches, dies, bulbs, fuses, and other consumables which must be replaced under
normal use and service. These warranties shall not apply to any product or part which is used for a purpose for which it is not
designed, or which has been repaired or altered in any way so as to affect adversely its performance or reliability, nor shall these
warranties apply to any product or part which has been subject to misuse, neglect, accident or wear and tear incident to
normal use and service.
PERFORMANCE TOOL does not authorize any other person to make any warranty or to assume any liability in connection
with its products.
Except for warranties of title and the limited express warranties set forth above, PERFORMANCE TOOL makes no express
or implied warranties of any kind with respect to its products. In particular, PERFORMANCE TOOL makes no implied
warranty of merchantability and no implied warranty of fitness for any particular purpose, except that for goods purchased
primarily for per-sonal, family or household use and not for commercial or business use, PERFORMANCE TOOL makes an
implied warranty of merchantability (and, if otherwise applicable, an implied warranty of fitness for a particular purpose), but
only for the particular qualities or characteristics, and for the duration, expressly warranted above. The laws on limitation of
implied warranties may differ from state to state, so the above limitations may not apply in all cases.
PERFORMANCE TOOL shall not be liable for consequential, incidental or special damages resulting from or in any
manner related to any product, or to the design, use, or any inability to use the product. The sole and exclusive remedy for a
defective product or part shall be the repair, or replacement thereof as provided above. The laws on limitation of remedies or on
consequen-tial, incidental or special damages may vary from state to state, so the above limitations may not apply in all cases.
Check out the collection of garage accessories we offer.
Table of contents
