Philips 32PFS5709/12 User manual

Published by YPC/SHC/SC 1439 Quality Printed in the Netherlands Subject to modification EN 3122 785 19618
2014-Sep-26
2014
©
TP Vision Netherlands B.V.
All rights reserved. Specifications are subject to change without notice. Trademarks are the
property of Koninklijke Philips Electronics N.V. or their respective owners.
TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust
earlier supplies accordingly.
PHILIPS and the PHILIPS’ ShieldEmblem are used under license from Koninklijke Philips Electronics N.V.
Colour Television Chassis
TPM14.2E
LA
Contents Page Contents Page
1Revision List 2
2Technical Specs Diversity and Connections 3
3Precautions Notes and Abbreviation List 10
4Mechanical Instructions 14
5Service Modes Error Codes and Fault Finding 52
6Alignments 60
7Circuit Descriptions 65
8IC Data Sheets 73
9Block Diagrams
Block diagram 5000/6000/7000 series 83
10 Circuit Diagrams and PWB Layouts Drawing PWB
A 715G6338 PSU 84 89-90
A 715G6353 PSU 91 95-96
A 715G6385 PSU 97 102-103
A 715G6161 PSU 104 106-107
A 715G6169 PSU 108 113-114
A 715G6405 PSU 115 120-121
A 715G6420 PSU 122 126-127
A 715G6432 PSU 128 129-130
A 715G6555 PSU 131 134-135
A 715G6661 PSU 136 139-140
A 715G6743 PSU 141 146-147
A 715G6940 PSU 148 153-154
A 380GLP30158SP0 PSU 155 156-157
B 715G6080 SSB 158 171-172
B 715G6388 SSB 173 187-188
B 715G6842 SSB 189 203-204
E 715G6316 Keyboard control panel 205 206
J 715G6737 IR/LED Panel 207 208
ALC 715G6484 Option Board 209 210
O 715G6935 Option Board 211 212
11 Styling Sheets
5700 series 32" 213
6500 series 32" 214
5700 series 40" 215
6600 series 40" 216
6710 series 40" 217
6400 series 40" 218
6800 series 40" 219
6909 series 40" 220
6500 series 42" 221
7109 series 42" 222
7170/7180 series 42" 223
7199 series 42" 224
7300/7500 series 42" 225
6659 series 47" 226
6689 series 47" 227
7170/7180 series 47" 228
7199 series 47" 229
7300/7500 series 47" 230
5700 series 48" 231
6400 series 48" 232
6600 series 48" 233
6700 series 48" 234
6909 series 48" 235
6800 series 50" 236
5700 series 55" 237
6400 series 55" 238
6500 series 55" 239
6900 series 55" 240
7170/7180 series 55" 241
7199 series 55" 242
7300/7500 series 55" 243
6800 series 58" 244
5909 series 65" 245
6600 series 65" 246
7500 series 65" 247

Revision List
EN 2 TPM14.2E LA1.
2014-Sep-26 back to
div. table
1. Revision List
Manual xxxx xxx xxxx.0
• First release.
Manual xxxx xxx xxxx.1
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-9 Cable dressing (47" 6500
series) and 4-12 Cable dressing (42" & 47" 7300/7500
series).
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 7: Updated figure 7-3 Power Architecture,table
7-1 Connector overview and added section 7.8 Ambilight.
•Chapter 10: Added circuit diagram 10.3 A 715G6385 PSU.
•Chapter 11: Added styling sheets 11.14 6659 series 47",
11.15 6689 series 47", 11.11 7170/7180 series 42" and
11.16 7170/7180 series 47".
Manual xxxx xxx xxxx.2
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-2 Cable dressing (32" 6500
series), 4-8 Cable dressing (42" 6500 series), 4-14 Cable
dressing (48" 6400 series), 4-16 Cable dressing (48" 6700
series), 4-21 Cable dressing (55" 6500 series) and 4-27
Cable dressing (65" 6600 series).
•Chapter 5: Updated tables 5-1 SAM mode overview and
5-2 Factory mode overview.
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 7: Updated figure 7-3 Power Architecture and
table 7-1 Connector overview.
•Chapter 10: Added circuit diagrams 10.4 A 715G6161
PSU, 10.5 A 715G6169 PSU, 10.6 A 715G6405 PSU, 10.8
A 715G6432 PSU, 10.8 A 715G6432 PSU and 10.19 ALC
715G6484 Option Board.
•Chapter 11: Added styling sheets 11.1 5700 series 32",
11.9 6500 series 42", 11.20 6400 series 48", 11.22 6700
series 48", 11.27 6500 series 55" and 11.34 6600 series
65".
Manual xxxx xxx xxxx.3
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-1 Cable dressing (32" 5700
series), 4-3 Cable dressing (40" 5700 series), 4-4 Cable
dressing (40" 6400 series), 4-12 Cable dressing (42" & 47"
7300/7500 series), 4-13 Cable dressing (48" 5700 series),
4-19 Cable dressing (55" 5700 series) and updated figure
4-27 Cable dressing (65" 6600 series) and sections 4.3
Assembly/Panel Removal ( for 32"/42"/47" 6500 series &
40" 6400 series & 40"/48" 6600/6700 series), 4.4
Assembly/Panel Removal ( for 42"/47"/55" 7100 series &
42"/47" 7300 series), 4.5 Assembly/Panel Removal ( for
55" 6500/6600 series), 4.6 Assembly/Panel Removal ( for
32"/48" 5700 series & 48"/55" 6400 series), 4.7
Assembly/Panel Removal ( for 40"/55" 5700 series) and
4.8 Assembly/Panel Removal ( for 42"/47"/55" 7199/7500
series & 55" 7300 series).
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 11: Added styling sheets 11.1 5700 series 32",
11.3 5700 series 40", 11.6 6400 series 40", 11.12 7199
series 42", 11.18 7300/7500 series 47", 11.19 5700 series
48", 11.25 5700 series 55", 11.29 7170/7180 series 55"
and updated styling sheet 11.17 7199 series 47".
Manual xxxx xxx xxxx.4
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-14 Cable dressing (48" 6400
series), 4-20 Cable dressing (55" 6400 series), 4-11 Cable
dressing (42" & 47" 7199 series), 4-23 Cable dressing (55"
7199 series), 4-24 Cable dressing (55" 7300/7500 series),
4-28 Cable dressing (65" 7500 series) and section 4.9
Assembly/Panel Removal ( for 65" 6600/7500 series).
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 11: Added styling sheets11.20 6400 series 48",
11.26 6400 series 55", 11.30 7199 series 55", 11.31
7300/7500 series 55" and 11.35 7500 series 65".
Manual xxxx xxx xxxx.5
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Updated figure 4-27 Cable dressing (65" 6600
series).
•Chapter 6: Updated table 6-3 Display code overview.
Manual xxxx xxx xxxx.6
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-6 Cable dressing (40" 6809
series), 4-18 Cable dressing (50" 6809 series), 4-25 Cable
dressing ( 58" 6809 series) and section 4.10
Assembly/Panel Removal ( for 40"/50"/58" 6809 series).
•Chapter 5: Updated table 5-2 Factory mode overview.
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 7: Updated figure 7-3 Power Architecture, table
7-1 Connector overview and added figure 7-4 Power
Architecture ( only for 58PUx6809).
•Chapter 8: Added IC data sheets 8.6 Diagram 10-16-1
System Power 1 B01, G5312QN1U (IC U103) and 8.7
Diagram 10-16-12 HDMI /Connector B12, SII9679CNUC
(IC U713).
•Chapter 10: Added circuit diagrams 10.9 A 715G6555
PSU, 10.10 A 715G6661 PSU, 10.16 B 715G6842
SSB,10.13 A 380GLP30158SP0 PSU and 10.18 J
715G6737 IR/LED Panel.
•Chapter 11: Added styling sheets 11.7 6800 series 40",
11.24 6800 series 50" and 11.32 6800 series 58".
Manual xxxx xxx xxxx.7
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figures 4-7 Cable dressing (40" 6900
series), 4-17 Cable dressing (48" 6900 series), 4-26 Cable
dressing ( 65" 5900 series) and sections 4.11
Assembly/Panel Removal ( for 40"/48"/55" 6909 series
),4.12 Assembly/Panel Removal (for 65" 5909 series).
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 7: Updated figure 7-3 Power Architecture, added
figures 7-7 Front-End Analogue block diagram[1], 7-9
Front-End DVB-T2 DTV block diagram[1] and 7-11
Front-End DVB-S2 block diagram and updated table 7-1
Connector overview.
•Chapter 10: Added circuit diagrams 10.11 A 715G6743
PSU, 10.12 A 715G6940 PSU and 10.20 O 715G6935
Option Board.
•Chapter 11: Added styling sheets 11.8 6909 series 40",
11.23 6909 series 48" and 11.33 5909 series 65".
Manual xxxx xxx xxxx.8
•Chapter 2: Updated table 2.1 Technical Specifications.
•Chapter 4: Added figure 4-22 Cable dressing (55" 6900
series) and updated section 4.11 Assembly/Panel
Removal ( for 40"/48"/55" 6909 series ).
•Chapter 6: Updated tables 6-2 White tone default settings
and 6-3 Display code overview.
•Chapter 7: Updated table 7-1 Connector overview.
•Chapter 11: Added styling sheet 11.28 6900 series 55".

Technical Specs, Diversity, and Connections EN 3TPM14.2E LA 2.
2014-Sep-26
back to
div. table
2. Technical Specs, Diversity, and Connections
Index of this chapter:
2.1 Technical Specifications
2.2 Directions for Use
2.3 Connections ( for 32"/40"/42"/47"/48"
6400/6500/6600/6710 series & 32"/40"/48"/55" 5700 series)
2.4 Connections ( for 42"/47"/55" 7000 series & 55" 6400/6500
series & 65" 6600/7500 series & 40"/50"/58" 6800 series &
40"/48"/55" 6900 series & 65"5900 series)
2.5 Chassis Overview
Notes:
• Figures can deviate due to the different set executions.
• Specifications are indicative (subject to change).
2.1 Technical Specifications
For on-line product support please use the links in back to div.
table 2-1. Here is product information available, as well as
getting started, user manuals, frequently asked questions and
software & drivers.
Table 2-1 Described Model Numbers and Diversity
CTN
24 9 10 11
Connection Overview
Mechanics
Block Diagram
Schematics
Styling Wire Dressing Rear Cover Removal SSB Removal Power Supply Power Supply 2 SSB E (Keyboard/Leading Edge) J (IR/LED panel) O (Option Board)
32PFS5709/12 2-1 4-1 4-37 4-38 9.1 10.4 -10.15 10.17 --11.1
32PFK5709/12 2-1 4-1 4-37 4-38 9.1 10.4 -10.15 10.17 --11.1
32PFK6509/12 2-1 4-2 4-29 4-30 9.1 10.4 -10.15 10.17 --11.2
40PFS5709/12 2-1 4-3 4-39 4-40 9.1 10.5 -10.15 10.17 --11.3
40PFK5709/12 2-1 4-3 4-39 4-40 9.1 10.5 -10.15 10.17 --11.3
40PFK6409/12 2-1 4-4 4-29 4-29 9.1 10.2 -10.15 10.17 --11.4
40PFS6409/12 2-1 4-4 4-29 4-29 9.1 10.2 -10.15 10.17 --11.4
40PFH6609/88 2-1 4-5 4-29 4-30 9.1 10.2 -10.15 10.17 --11.4
40PFK6609/12 2-1 4-5 4-29 4-30 9.1 10.2 -10.15 10.17 --11.4
40PFS6609/12 2-1 4-5 4-29 4-30 9.1 10.2 -10.15 10.17 --11.4
40PFK6719/12 2-1 4-5 4-29 4-30 9.1 10.2 -10.15 10.17 --11.5
40PFS6719/12 2-1 4-5 4-29 4-30 9.1 10.2 -10.15 10.17 --11.5
40PUK6809/12 2-9 4-6 4-47 4-48 9.1 10.10 -10.16 10.17 -10.19 11.7
40PUS6809/12 2-9 4-6 4-47 4-48 9.1 10.10 -10.16 10.17 -10.19 11.7
40PUS6809/60 2-9 4-6 4-47 4-48 9.1 10.10 -10.16 10.17 -10.19 11.7
40PFK6909/12 2-9 4-7 4-49 4-53 9.1 10.12 -10.14 10.17 -10.20 11.8
40PFS6909/12 2-9 4-7 4-49 4-53 9.1 10.12 -10.14 10.17 -10.20 11.8
40PFK6949/12 2-9 4-7 4-49 4-53 9.1 10.12 -10.14 10.17 -10.20 11.8
40PFK6959/12 2-9 4-7 4-49 4-53 9.1 10.12 -10.14 10.17 -10.20 11.8
40PFK6989/12 2-9 4-7 4-49 4-53 9.1 10.12 -10.14 10.17 -10.20 11.8
42PFK6549/12 2-1 4-8 4-29 4-30 9.1 10.5 -10.15 10.17 --11.9
42PFK6559/12 2-1 4-8 4-29 4-30 9.1 10.5 -10.15 10.17 --11.9
42PFK6589/12 2-1 4-8 4-29 4-30 9.1 10.5 -10.15 10.17 --11.9
42PFS7109/12 2-9 4-10 4-31 4-33 9.1 10.1 -10.14 10.17 --11.10
42PFK7109/12 2-9 4-10 4-31 4-33 9.1 10.1 -10.14 10.17 --11.10
42PFK7179/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.11
42PFK7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.11
42PFS7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.11
42PFK7199/12 2-9 4-11 4-31 4-33 9.1 10.3 -10.14 10.17 --11.12
42PFS7199/12 2-9 4-11 4-31 4-33 9.1 10.3 -10.14 10.17 --11.12
42PFS7309/60 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.13
42PFK7509/12 2-9 4-12 4-41 4-43 9.1 10.3 -10.14 10.17 --11.13
42PFS7509/12 2-9 4-12 4-41 4-43 9.1 10.3 -10.14 10.17 --11.13
47PFK6549/12 2-1 4-9 4-29 4-30 9.1 10.1 -10.15 10.17 --11.15
47PFK6559/12 2-1 4-9 4-29 4-30 9.1 10.1 -10.15 10.17 --11.14
47PFK6589/12 2-1 4-9 4-29 4-30 9.1 10.1 -10.15 10.17 --11.15
47PFK7109/12 2-9 4-10 4-31 4-33 9.1 10.1 -10.14 10.17 --11.10
47PFS7109/12 2-9 4-10 4-31 4-33 9.1 10.1 -10.14 10.17 --11.10
47PFK7179/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.16
47PFK7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.16
47PFS7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.16
47PFK7199/12 2-9 4-11 4-31 4-33 9.1 10.3 -10.14 10.17 --11.17
47PFS7199/12 2-9 4-11 4-31 4-33 9.1 10.3 -10.14 10.17 --11.17
47PFS7309/60 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 --11.18
47PFK7509/12 2-9 4-12 4-41 4-43 9.1 10.3 -10.14 10.17 --11.18
47PFS7509/12 2-9 4-12 4-41 4-43 9.1 10.3 -10.14 10.17 --11.18
48PFS5709/12 2-1 4-13 4-37 4-38 9.1 10.1 -10.15 10.17 --11.19
48PFK5709/12 2-1 4-13 4-37 4-38 9.1 10.1 -10.15 10.17 --11.19
48PFK6409/12 2-1 4-14 4-37 4-38 9.1 10.1 -10.15 10.17 --11.20
48PFS6409/12 2-1 4-14 4-37 4-38 9.1 10.1 -10.15 10.17 --11.20

Technical Specs, Diversity, and Connections
EN 4 TPM14.2E LA2.
2014-Sep-26 back to
div. table
2.2 Directions for Use
Directions for use can be downloaded from the following
websites:
http://www.philips.com/support
http://www.p4c.philips.com
48PFK6609/12 2-1 4-14 4-29 4-30 9.1 10.1 -10.15 10.17 - - 11.21
48PFS6609/12 2-1 4-14 4-29 4-30 9.1 10.1 -10.15 10.17 - - 11.21
48PFK6719/12 2-1 4-16 4-29 4-30 9.1 10.1 -10.15 10.17 -10.19 11.22
48PFS6719/12 2-1 4-16 4-29 4-30 9.1 10.1 -10.15 10.17 -10.19 11.22
48PFK6909/12 2-9 4-17 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.23
48PFS6909/12 2-9 4-17 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.23
48PFK6949/12 2-9 4-17 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.23
48PFK6959/12 2-9 4-17 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.23
48PFK6989/12 2-9 4-17 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.23
50PUK6809/12 2-9 4-18 4-47 4-48 9.1 10.9 -10.16 10.17 10.18 -11.24
50PUS6809/12 2-9 4-18 4-47 4-48 9.1 10.9 -10.16 10.17 10.18 -11.24
50PUS6809/60 2-9 4-18 4-47 4-48 9.1 10.9 -10.16 10.17 10.18 -11.24
55PFS5709/12 2-1 4-19 4-39 4-40 9.1 10.6 -10.15 10.17 - - 11.25
55PFK5709/12 2-1 4-19 4-39 4-40 9.1 10.6 -10.15 10.17 - - 11.25
55PFK6409/12 2-9 4-20 4-37 4-38 9.1 10.6 -10.14 10.17 - - 11.26
55PFS6409/12 2-9 4-20 4-37 4-38 9.1 10.6 -10.14 10.17 - - 11.26
55PFH6609/88 2-9 4-21 4-29 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK6549/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK6559/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK6589/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK6609/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFS6609/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK6909/12 2-9 4-22 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.28
55PFS6909/12 2-9 4-22 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.28
55PFK6949/12 2-9 4-22 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.28
55PFK6959/12 2-9 4-22 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.28
55PFK6989/12 2-9 4-22 4-49 4-53 9.1 10.11 -10.14 10.17 -10.20 11.28
55PFK7109/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFS7109/12 2-9 4-21 4-31 4-33 9.1 10.6 -10.14 10.17 - - 11.27
55PFK7179/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 - - 11.29
55PFK7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 - - 11.29
55PFS7189/12 2-9 4-12 4-31 4-33 9.1 10.3 -10.14 10.17 - - 11.29
55PFK7199/12 2-9 4-23 4-31 4-33 9.1 10.3 -10.14 10.17 - - 11.30
55PFS7199/12 2-9 4-23 4-31 4-33 9.1 10.3 -10.14 10.17 - - 11.30
55PFS7309/60 2-9 4-24 4-41 4-43 9.1 10.3 -10.14 10.17 - - 11.31
55PFK7509/12 2-9 4-24 4-41 4-43 9.1 10.3 -10.14 10.17 - - 11.31
55PFS7509/12 2-9 4-24 4-41 4-43 9.1 10.3 -10.14 10.17 - - 11.31
58PUK6809/12 2-9 4-25 4-47 4-48 9.1 10.13 -10.16 10.17 10.18 -11.32
58PUS6809/12 2-9 4-25 4-47 4-48 9.1 10.13 -10.16 10.17 10.18 -11.32
58PUS6809/60 2-9 4-25 4-47 4-48 9.1 10.13 -10.16 10.17 10.18 -11.32
65PFK5909/12 2-9 4-26 4-54 4-56 9.1 10.13 -10.14 10.17 - - 11.33
65PFS5909/12 2-9 4-26 4-54 4-56 9.1 10.13 -10.14 10.17 - - 11.33
65PFS6659/12 2-9 4-27 4-44 4-46 9.1 10.7 10.8 10.14 10.17 - - 11.34
65PFS7559/12 2-9 4-28 4-44 4-46 9.1 10.7 10.8 10.14 10.17 - - 11.35
CTN
24 9 10 11
Connection Overview
Mechanics
Block Diagram
Schematics
Styling Wire Dressing Rear Cover Removal SSB Removal Power Supply Power Supply 2 SSB E (Keyboard/Leading Edge) J (IR/LED panel) O (Option Board)

Technical Specs, Diversity, and Connections EN 5TPM14.2E LA 2.
2014-Sep-26
back to
div. table
2.3 Connections ( for 32"/40"/42"/47"/48" 6400/6500/6600/6710 series & 32"/40"/48"/55" 5700 series)
Figure 2-1 Connection overview
Note: The following connector colour abbreviations are used
(acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green,
Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
2.3.1 Side Connections
1 - Common Interface
68p-See figure 10-14-10 jk
2 - HDMI 3: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-2 HDMI (type A) connector
1 -D2+ Data channel j
2-Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5-Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8-Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
3 - HDMI 2: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-3 HDMI (type A) connector
1 -D2+ Data channel j
2 -Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5 -Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8 -Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
HDMI2 ARC
HDMI3ARC
USB 2
CI
NETWORK
TV ANTENNA
SERV.U
AUDIO IN
USB1 DVI
HDMI1
ARC
SCART
(RGB/CVBS)
(Optional)
R L
CVBS/Y PbPr
DIGITAL
AUDIO OUT
SAT
19610_001.eps
1
2
3
4
5
8
96
10
12
11 13
Side ConnectorsRear Connectors
7
10000_017_090121.eps
090428
19 1
182
10000_017_090121.eps
090428
19 1
182

Technical Specs, Diversity, and Connections
EN 6 TPM14.2E LA2.
2014-Sep-26 back to
div. table
4 - USB2 2.0
Figure 2-4 USB (type A)
1-+5V k
2 -Data (-) jk
3 -Data (+) jk
4 -Ground Gnd H
5 - Head phone (Output)
Bk -Head phone 80 - 600 W / 10 mW ot
2.3.2 Rear Connections
6 - Service / UART
1 -Ground Gnd H
2 -UART_TX Transmit k
3 -UART_RX Receive j
7 - HDMI 1: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-5 HDMI (type A) connector
1 -D2+ Data channel j
2-Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5-Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8-Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
8 - Audio - In: Left / Right, VGA
Gn -Audio L/R in 0.5 VRMS / 10 kjq
9 - USB1 2.0
Figure 2-6 USB (type A)
1-+5V k
2 -Data (-) jk
3 -Data (+) jk
4 -Ground Gnd H
10 - RJ45: Ethernet
Figure 2-7 Ethernet connector
1 -TD+ Transmit signal k
2 -TD- Transmit signal k
3 -RD+ Receive signal j
4 -CT Centre Tap: DC level fixation
5 -CT Centre Tap: DC level fixation
6 -RD- Receive signal j
7 -GND Gnd H
8 -GND Gnd H
11 - SAT - In
Signal input from an SAT.
12 - TV ANTENNA - In
Signal input from an antenna, cable or satellite.
13 - SCART: Video RGB/YC - In, CVBS - In/Out, Audio -
In/Out
Figure 2-8 SCART connector
1 -Audio R 0.5 VRMS / 1 kk
2 -Audio R 0.5 VRMS / 10 kj
3 -Audio L 0.5 VRMS / 1 kk
4 -Ground Audio Gnd H
5 -Ground Blue Gnd H
6 -Audio L 0.5 VRMS / 10 kj
7 -Video Blue/C-out 0.7 VPP / 75 jk
8 -Function Select 0 - 2 V: INT
4.5 - 7 V: EXT 16:9
9.5 - 12 V: EXT 4:3 j
9 -Ground Green Gnd H
10 -n.c.
11 -Video Green 0.7 VPP / 75 j
12 -n.c.
13 -Ground Red Gnd H
14 -Ground P50 Gnd H
15 -Video Red/C 0.7 VPP / 75 j
16 -Status/FBL 0 - 0.4 V: INT
1 - 3 V: EXT / 75 j
17 -Ground Video Gnd H
18 -Ground FBL Gnd H
19 -Video CVBS 1 VPP / 75 k
20 -Video CVBS/Y 1 VPP / 75 j
21 -Shield Gnd H
1 2 34
10000_022_090121.eps
090121
10000_017_090121.eps
090428
19 1
182
1 2 34
10000_022_090121.eps
090121
10000_025_090121.eps
120320
21
20
1
2
10000 001 090121 eps
090121

Technical Specs, Diversity, and Connections EN 7TPM14.2E LA 2.
2014-Sep-26
back to
div. table
2.4 Connections ( for 42"/47"/55" 7000 series & 55" 6400/6500 series & 65" 6600/7500series & 40"/50"/58" 6800
series & 40"/48"/55" 6900 series & 65"5900 series)
Figure 2-9 Connection overview
Note: The following connector colour abbreviations are used
(acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green,
Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
2.4.1 Side Connections
1 - Common Interface
68p-See figure 10-14-10 jk
2 - HDMI 4: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-10 HDMI (type A) connector
1 -D2+ Data channel j
2-Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5-Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8-Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
3 - HDMI 3: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-11 HDMI (type A) connector
1 -D2+ Data channel j
2 -Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5 -Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8 -Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
HDMI3ARC
HDMI4 ARC
USB 2
CI
NETWORK
TV ANTENNA
AUDIO IN
USB1
DVI
HDMI1
ARC HDMI2
ARC
SCART
(RGB/CVBS)
R L
CVBS/Y PbPr
DIGITAL
AUDIO OUT
SERV.U
SAT
19610_002.eps
1
2
3
4
5
7
86
9
11 1210 1314
Side ConnectorsRear Connectors
10000_017_090121.eps
090428
19 1
182
10000_017_090121.eps
090428
19 1
182

Technical Specs, Diversity, and Connections
EN 8 TPM14.2E LA2.
2014-Sep-26 back to
div. table
4 - USB2 2.0
Figure 2-12 USB (type A)
1-+5V k
2 -Data (-) jk
3 -Data (+) jk
4 -Ground Gnd H
5 - Head phone (Output)
Bk -Head phone 80 - 600 / 10 mW ot
2.4.2 Rear Connections
6 - SCART: Video RGB/YC - In, CVBS - In/Out, Audio -
In/Out
Figure 2-13 SCART connector
1 -Audio R 0.5 VRMS / 1 kk
2 -Audio R 0.5 VRMS / 10 kj
3 -Audio L 0.5 VRMS / 1 kk
4 -Ground Audio Gnd H
5 -Ground Blue Gnd H
6 -Audio L 0.5 VRMS / 10 kj
7 -Video Blue/C-out 0.7 VPP / 75 jk
8 -Function Select 0 - 2 V: INT
4.5 - 7 V: EXT 16:9
9.5 - 12 V: EXT 4:3 j
9 -Ground Green Gnd H
10 -n.c.
11 -Video Green 0.7 VPP / 75 j
12 -n.c.
13 -Ground Red Gnd H
14 -Ground P50 Gnd H
15 -Video Red/C 0.7 VPP / 75 j
16 -Status/FBL 0 - 0.4 V: INT
1 - 3 V: EXT / 75 j
17 -Ground Video Gnd H
18 -Ground FBL Gnd H
19 -Video CVBS 1 VPP / 75 k
20 -Video CVBS/Y 1 VPP / 75 j
21 -Shield Gnd H
7 - Audio - In: Left / Right, VGA
Gn -Audio L/R in 0.5 VRMS / 10 kjq
8 - Service / UART
1 -Ground Gnd H
2 -UART_TX Transmit k
3 -UART_RX Receive j
9 - RJ45: Ethernet
Figure 2-14 Ethernet connector
1 -TD+ Transmit signal k
2 -TD- Transmit signal k
3 -RD+ Receive signal j
4 -CT Centre Tap: DC level fixation
5 -CT Centre Tap: DC level fixation
6 -RD- Receive signal j
7 -GND Gnd H
8 -GND Gnd H
10 - TV ANTENNA - In
Signal input from an antenna, cable or satellite.
11 - SAT - In
Signal input from an SAT.
12 - USB1 2.0
Figure 2-15 USB (type A)
1-+5V k
2 -Data (-) jk
3 -Data (+) jk
4 -Ground Gnd H
13 - HDMI 1: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-16 HDMI (type A) connector
1 -D2+ Data channel j
2 -Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5 -Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8 -Shield Gnd H
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
14 - HDMI 2: Digital Video - In, Digital Audio with ARC -
In/Out
Figure 2-17 HDMI (type A) connector
1 -D2+ Data channel j
2 -Shield Gnd H
3 -D2- Data channel j
4 -D1+ Data channel j
5 -Shield Gnd H
6 -D1- Data channel j
7 -D0+ Data channel j
8 -Shield Gnd H
1 2 34
10000_022_090121.eps
090121
21
20
1
2
10000 001 090121 eps
090121
10000_025_090121.eps
120320
1 2 34
10000_022_090121.eps
090121
10000_017_090121.eps
090428
19 1
182
10000_017_090121.eps
090428
19 1
182

Technical Specs, Diversity, and Connections EN 9TPM14.2E LA 2.
2014-Sep-26
back to
div. table
9 -D0- Data channel j
10 -CLK+ Data channel j
11 -Shield Gnd H
12 -CLK- Data channel j
13 -Easylink/CEC Control channel jk
14 -ARC Audio Return Channel k
15 -DDC_SCL DDC clock j
16 -DDC_SDA DDC data jk
17 -Ground Gnd H
18 -+5V j
19 -HPD Hot Plug Detect j
20 -Ground Gnd H
2.5 Chassis Overview
Refer to 9. Block Diagrams for PWB/CBA locations.

Precautions, Notes, and Abbreviation List
EN 10 TPM14.2E LA3.
2014-Sep-26 back to
div. table
3. Precautions, Notes, and Abbreviation List
Index of this chapter:
3.1 Safety Instructions
3.2 Warnings
3.3 Notes
3.4 Abbreviation List
3.1 Safety Instructions
Safety regulations require the following during a repair:
• Connect the set to the Mains/AC Power via an isolation
transformer (> 800 VA).
• Replace safety components, indicated by the symbol h,
only by components identical to the original ones. Any
othercomponentsubstitution(other thanoriginaltype)may
increase risk of fire or electrical shock hazard.
Safety regulations require that after a repair, the set must be
returned in its original condition. Pay in particular attention to
the following points:
• Route the wire trees correctly and fix them with the
mounted cable clamps.
• Check the insulation of the Mains/AC Power lead for
external damage.
• Check the strain relief of the Mains/AC Power cord for
proper function.
• Check the electrical DC resistance between the Mains/AC
Power plug and the secondary side (only for sets that have
a Mains/AC Power isolated power supply):
1. Unplug the Mains/AC Power cord and connect a wire
between the two pins of the Mains/AC Power plug.
2. Set the Mains/AC Power switch to the “on” position
(keep the Mains/AC Power cord unplugged!).
3. Measure the resistance value between the pins of the
Mains/AC Power plug and the metal shielding of the
tuner or the aerial connection on the set. The reading
should be between 4.5 Mand 12 M.
4. Switch “off” the set, and remove the wire between the
two pins of the Mains/AC Power plug.
• Check the cabinet for defects, to prevent touching of any
inner parts by the customer.
3.2 Warnings
• All ICs and many other semiconductors are susceptible to
electrostatic discharges (ESD w). Careless handling
during repair can reduce life drastically. Make sure that,
duringrepair,youare connected withthesame potential as
the mass of the set by a wristband with resistance. Keep
components and tools also at this same potential.
• Be careful during measurements in the high voltage
section.
• Never replace modules or other components while the unit
is switched “on”.
• When you align the set, use plastic rather than metal tools.
This will prevent any short circuits and the danger of a
circuit becoming unstable.
3.3 Notes
3.3.1 General
• Measure the voltages and waveforms with regard to the
chassis (= tuner) ground (H), or hot ground (I), depending
onthetested areaofcircuitry. Thevoltagesand waveforms
shown in the diagrams are indicative. Measure them in the
Service Default Mode with a colour bar signal and stereo
sound (L: 3 kHz, R: 1 kHz unless stated otherwise) and
picture carrier at 475.25 MHz for PAL, or 61.25 MHz for
NTSC (channel 3).
• Where necessary, measure the waveforms and voltages
with (D) and without (E) aerial signal. Measure the
voltages in the power supply section both in normal
operation (G) and in stand-by (F). These values are
indicated by means of the appropriate symbols.
3.3.2 Schematic Notes
• All resistor values are in ohms, and the value multiplier is
often used to indicate the decimal point location (e.g. 2K2
indicates 2.2 k).
• Resistor values with no multiplier may be indicated with
either an “E” or an “R” (e.g. 220E or 220R indicates 220 ).
• All capacitor values are given in micro-farads (10-6),
nano-farads (n 10-9), or pico-farads (p 10-12).
• Capacitor values may also use the value multiplier as the
decimal point indication (e.g. 2p2 indicates 2.2 pF).
• An “asterisk” (*) indicates component usage varies. Refer
to the diversity tables for the correct values.
• The correct component values are listed on the Philips
Spare Parts Web Portal.
3.3.3 Spare Parts
For the latest spare part overview, consult your Philips Spare
Part web portal.
3.3.4 BGA (Ball Grid Array) ICs
Introduction
For more information on how to handle BGA devices, visit this
URL: http://www.atyourservice-magazine.com. Select
“Magazine”, then go to “Repair downloads”. Here you will find
Information on how to deal with BGA-ICs.
BGA Temperature Profiles
For BGA-ICs, you must use the correct temperature-profile.
Where applicable and available, this profile is added to the IC
Data Sheet information section in this manual.
3.3.5 Lead-free Soldering
Due to lead-free technology some rules have to be respected
by the workshop during a repair:
• Use only lead-free soldering tin. If lead-free solder paste is
required,pleasecontactthemanufacturerofyoursoldering
equipment. In general, use of solder paste within
workshopsshould be avoided becausepaste isnot easy to
store and to handle.
• Use only adequate solder tools applicable for lead-free
soldering tin. The solder tool must be able:
– To reach a solder-tip temperature of at least 400°C.
– To stabilize the adjusted temperature at the solder-tip.
– To exchange solder-tips for different applications.
• Adjust your solder tool so that a temperature of around
360°C - 380°C is reached and stabilized at the solder joint.
Heating time of the solder-joint should not exceed ~ 4 sec.
Avoid temperatures above 400°C, otherwise wear-out of
tips will increase drastically and flux-fluid will be destroyed.
To avoid wear-out of tips, switch “off” unused equipment or
reduce heat.
• Mix of lead-free soldering tin/parts with leaded soldering
tin/parts is possible but PHILIPS recommends strongly to
avoid mixed regimes. If this cannot be avoided, carefully
clear the solder-joint from old tin and re-solder with new tin.
3.3.6 Alternative BOM identification
It should be noted that on the European Service website,
“Alternative BOM” is referred to as “Design variant”.
The third digit in the serial number (example:
AG2B0335000001) indicates the number of the alternative
B.O.M. (Bill Of Materials) that has been used for producing the
specific TV set. In general, it is possible that the same TV
model on the market is produced with e.g. two different types
of displays, coming from two different suppliers. This will then

Precautions, Notes, and Abbreviation List EN 11TPM14.2E LA 3.
2014-Sep-26
back to
div. table
result in sets which have the same CTN (Commercial Type
Number; e.g. 28PW9515/12) but which have a different B.O.M.
number.
By looking at the third digit of the serial number, one can
identify which B.O.M. is used for the TV set he is working with.
If the third digit of the serial number contains the number “1”
(example: AG1B033500001), then the TV set has been
manufactured according to B.O.M. number 1. If the third digit is
a “2” (example: AG2B0335000001), then the set has been
produced according to B.O.M. no. 2. This is important for
ordering the correct spare parts!
For the third digit, the numbers 1...9 and the characters A...Z
can be used, so in total: 9 plus 26= 35 different B.O.M.s can be
indicated by the third digit of the serial number.
Identification: The bottom line of a type plate gives a 14-digit
serialnumber. Digits 1and 2 referto theproduction centre (e.g.
SN is Lysomice, RJ is Kobierzyce), digit 3 refers to the B.O.M.
code, digit 4 refers to the Service version change code, digits 5
and 6 refer to the production year, and digits 7 and 8 refer to
production week (in example below it is 2010 week 10 / 2010
week 17). The 6 last digits contain the serial number.
Figure 3-1 Serial number (example)
3.3.7 Board Level Repair (BLR) or Component Level Repair
(CLR)
If a board is defective, consult your repair procedure to decide
if the board has to be exchanged or if it should be repaired on
component level.
If your repair procedure says the board should be exchanged
completely, do not solder on the defective board. Otherwise, it
cannot be returned to the O.E.M. supplier for back charging!
3.3.8 Practical Service Precautions
•It makes sense to avoid exposure to electrical shock.
While some sources are expected to have a possible
dangerous impact, others of quite high potential are of
limited current and are sometimes held in less regard.
•Always respect voltages. While some may not be
dangerous in themselves, they can cause unexpected
reactions that are best avoided. Before reaching into a
poweredTV set, itisbest totest thehigh voltage insulation.
It is easy to do, and is a good service precaution.
3.4 Abbreviation List
0/6/12 SCART switch control signal on A/V
board. 0 = loop through (AUX to TV),
6 = play 16 : 9 format, 12 = play 4 : 3
format
AARA Automatic Aspect Ratio Adaptation:
algorithm that adapts aspect ratio to
remove horizontal black bars; keeps
the original aspect ratio
ACI Automatic Channel Installation:
algorithm that installs TV channels
directly from a cable network by
means of a predefined TXT page
ADC Analogue to Digital Converter
AFC Automatic Frequency Control: control
signal used to tune to the correct
frequency
AGC AutomaticGainControl: algorithmthat
controls the video input of the feature
box
AM Amplitude Modulation
AP Asia Pacific
AR Aspect Ratio: 4 by 3 or 16 by 9
ASF Auto Screen Fit: algorithm that adapts
aspectratio toremove horizontalblack
bars without discarding video
information
ATSC Advanced Television Systems
Committee, the digital TV standard in
the USA
ATV See Auto TV
Auto TV A hardware and software control
system that measures picture content,
and adapts image parameters in a
dynamic way
AV External Audio Video
AVC Audio Video Controller
AVIP Audio Video Input Processor
B/G Monochrome TV system. Sound
carrier distance is 5.5 MHz
BDS Business Display Solutions (iTV)
BLR Board-Level Repair
BTSC Broadcast Television Standard
Committee.MultiplexFMstereosound
system, originating from the USA and
used e.g. in LATAM and AP-NTSC
countries
B-TXT Blue TeleteXT
C Centre channel (audio)
CEC Consumer Electronics Control bus:
remote control bus on HDMI
connections
CL Constant Level: audio output to
connect with an external amplifier
CLR Component Level Repair
ComPair Computer aided rePair
CP Connected Planet / Copy Protection
CSM Customer Service Mode
CTI Color Transient Improvement:
manipulates steepness of chroma
transients
CVBS Composite Video Blanking and
Synchronization
DAC Digital to Analogue Converter
DBE Dynamic Bass Enhancement: extra
low frequency amplification
DCM Data Communication Module. Also
referred to as System Card or
Smartcard (for iTV).
DDC See “E-DDC”
D/K Monochrome TV system. Sound
carrier distance is 6.5 MHz
DFI Dynamic Frame Insertion
DFU Directions For Use: owner's manual
DMR Digital Media Reader: card reader
DMSD Digital Multi Standard Decoding
DNM Digital Natural Motion
10000_053_110228.eps
110228

Precautions, Notes, and Abbreviation List
EN 12 TPM14.2E LA3.
2014-Sep-26 back to
div. table
DNR Digital Noise Reduction: noise
reduction feature of the set
DRAM Dynamic RAM
DRM Digital Rights Management
DSP Digital Signal Processing
DST Dealer Service Tool: special remote
control designed for service
technicians
DTCP Digital Transmission Content
Protection; A protocol for protecting
digital audio/video content that is
traversing a high speed serial bus,
such as IEEE-1394
DVB-C Digital Video Broadcast - Cable
DVB-T Digital Video Broadcast - Terrestrial
DVD Digital Versatile Disc
DVI(-d) Digital Visual Interface (d= digital only)
E-DDC Enhanced Display Data Channel
(VESA standard for communication
channel and display). Using E-DDC,
the video source can read the EDID
information form the display.
EDID Extended Display Identification Data
(VESA standard)
EEPROM Electrically Erasable and
Programmable Read Only Memory
EMI Electro Magnetic Interference
EPG Electronic Program Guide
EPLD Erasable Programmable Logic Device
EU Europe
EXT EXTernal (source), entering the set by
SCART or by cinches (jacks)
FDS Full Dual Screen (same as FDW)
FDW Full Dual Window (same as FDS)
FLASH FLASH memory
FM Field Memory or Frequency
Modulation
FPGA Field-Programmable Gate Array
FTV Flat TeleVision
Gb/s Giga bits per second
G-TXT Green TeleteXT
H H_sync to the module
HD High Definition
HDD Hard Disk Drive
HDCP High-bandwidth Digital Content
Protection: A “key” encoded into the
HDMI/DVI signal that prevents video
datapiracy.Ifasource is HDCPcoded
and connected via HDMI/DVI without
the proper HDCP decoding, the
pictureisput into a “snow vision” mode
or changed to a low resolution. For
normal content distribution the source
and the display device must be
enabled for HDCP “software key”
decoding.
HDMI High Definition Multimedia Interface
HP HeadPhone
I Monochrome TV system. Sound
carrier distance is 6.0 MHz
I2C Inter IC bus
I2D Inter IC Data bus
I2S Inter IC Sound bus
IF Intermediate Frequency
IR Infra Red
IRQ Interrupt Request
ITU-656 The ITU Radio communication Sector
(ITU-R) is a standards body
subcommittee of the International
Telecommunication Union relating to
radio communication. ITU-656 (a.k.a.
SDI), is a digitized video format used
for broadcast grade video.
Uncompressed digital component or
digital composite signals can be used.
The SDI signal is self-synchronizing,
uses8bit or 10 bit datawords, and has
a maximum data rate of 270 Mbit/s,
with a minimum bandwidth of 135
MHz.
iTV Institutional TeleVision; TV sets for
hotels, hospitals etc.
LS Last Status; The settings last chosen
by the customer and read and stored
in RAM or in the NVM. They are called
at start-up of the set to configure it
according to the customer's
preferences
LATAM Latin America
LCD Liquid Crystal Display
LED Light Emitting Diode
L/L' Monochrome TV system. Sound
carrier distance is 6.5 MHz. L' is Band
I, L is all bands except for Band I
LPL LG.Philips LCD (supplier)
LS Loudspeaker
LVDS Low Voltage Differential Signalling
Mbps Mega bits per second
M/N Monochrome TV system. Sound
carrier distance is 4.5 MHz
MHEG Part of a set of international standards
related to the presentation of
multimedia information, standardised
by the Multimedia and Hypermedia
ExpertsGroup.It iscommonlyusedas
a language to describe interactive
television services
MIPS Microprocessor without Interlocked
Pipeline-Stages; A RISC-based
microprocessor
MOP Matrix Output Processor
MOSFET Metal Oxide Silicon Field Effect
Transistor, switching device
MPEG Motion Pictures Experts Group
MPIF Multi Platform InterFace
MUTE MUTE Line
MTV Mainstream TV: TV-mode with
Consumer TV features enabled (iTV)
NC Not Connected
NICAM Near Instantaneous Compounded
Audio Multiplexing. This is a digital
sound system, mainly used in Europe.
NTC Negative Temperature Coefficient,
non-linear resistor
NTSC National Television Standard
Committee. Color system mainly used
in North America and Japan. Color
carrier NTSC M/N= 3.579545 MHz,
NTSC 4.43= 4.433619 MHz (this is a
VCR norm, it is not transmitted off-air)
NVM Non-Volatile Memory: IC containing
TV related data such as alignments
O/C Open Circuit
OSD On Screen Display
OAD Over the Air Download. Method of
softwareupgradeviaRFtransmission.
Upgrade software is broadcasted in
TS with TV channels.
OTC On screen display Teletext and
Control; also called Artistic (SAA5800)
P50 Project 50: communication protocol
between TV and peripherals
PAL Phase Alternating Line. Color system
mainly used in West Europe (colour
carrier = 4.433619 MHz) and South
America (colour carrier
PAL M = 3.575612 MHz and
PAL N = 3.582056 MHz)
PCB Printed Circuit Board (same as “PWB”)
PCM Pulse Code Modulation

Precautions, Notes, and Abbreviation List EN 13TPM14.2E LA 3.
2014-Sep-26
back to
div. table
PDP Plasma Display Panel
PFC Power Factor Corrector (or
Pre-conditioner)
PIP Picture In Picture
PLL Phase Locked Loop. Used for e.g.
FST tuning systems. The customer
can give directly the desired frequency
POD Point Of Deployment: a removable
CAM module, implementing the CA
system for a host (e.g. a TV-set)
POR Power On Reset, signal to reset the uP
PSDL Power Supply for Direct view LED
backlight with 2D-dimming
PSL Power Supply with integrated LED
drivers
PSLS Power Supply with integrated LED
drivers with added Scanning
functionality
PTC Positive Temperature Coefficient,
non-linear resistor
PWB Printed Wiring Board (same as “PCB”)
PWM Pulse Width Modulation
QRC Quasi Resonant Converter
QTNR Quality Temporal Noise Reduction
QVCP Quality Video Composition Processor
RAM Random Access Memory
RGB Red, Green, and Blue. The primary
color signals for TV. By mixing levels
of R, G, and B, all colors (Y/C) are
reproduced.
RC Remote Control
RC5 / RC6 Signal protocol from the remote
control receiver
RESET RESET signal
ROM Read Only Memory
RSDS Reduced Swing Differential Signalling
data interface
R-TXT Red TeleteXT
SAM Service Alignment Mode
S/C Short Circuit
SCART Syndicat des Constructeurs
d'Appareils Radiorécepteurs et
Téléviseurs
SCL Serial Clock I2C
SCL-F CLock Signal on Fast I2C bus
SD Standard Definition
SDA Serial Data I2C
SDA-F DAta Signal on Fast I2C bus
SDI Serial Digital Interface, see “ITU-656”
SDRAM Synchronous DRAM
SECAM SEequence Couleur Avec Mémoire.
Colour system mainly used in France
and East Europe. Colour
carriers = 4.406250 MHz and
4.250000 MHz
SIF Sound Intermediate Frequency
SMPS Switched Mode Power Supply
SoC System on Chip
SOG Sync On Green
SOPS Self Oscillating Power Supply
SPI Serial Peripheral Interface bus; a
4-wire synchronous serial data link
standard
S/PDIF Sony Philips Digital InterFace
SRAM Static RAM
SRP Service Reference Protocol
SSB Small Signal Board
SSC Spread Spectrum Clocking, used to
reduce the effects of EMI
STB Set Top Box
STBY STand-BY
SVGA 800 × 600 (4:3)
SVHS Super Video Home System
SW Software
SWAN Spatial temporal Weighted Averaging
Noise reduction
SXGA 1280 × 1024
TFT Thin Film Transistor
THD Total Harmonic Distortion
TMDS Transmission Minimized Differential
Signalling
TS Transport Stream
TXT TeleteXT
TXT-DW Dual Window with TeleteXT
UI User Interface
uP Microprocessor
UXGA 1600 × 1200 (4:3)
V V-sync to the module
VESA Video Electronics Standards
Association
VGA 640 × 480 (4:3)
VL Variable Level out: processed audio
output toward external amplifier
VSB Vestigial Side Band; modulation
method
WYSIWYR What You See Is What You Record:
record selection that follows main
picture and sound
WXGA 1280 × 768 (15:9)
XTAL Quartz crystal
XGA 1024 × 768 (4:3)
Y Luminance signal
Y/C Luminance (Y) and Chrominance (C)
signal
YPbPr Component video. Luminance and
scaled color difference signals (B-Y
and R-Y)
YUV Component video

Mechanical Instructions
EN 14 TPM14.2E LA4.
2014-Sep-26 back to
div. table
4. Mechanical Instructions
Index of this chapter:
4.1 Cable Dressing
4.2 Service Positions
4.3 Assembly/Panel Removal ( for 32"/42"/47" 6500 series &
40" 6400 series & 40"/48" 6600/6700 series)
4.4 Assembly/Panel Removal ( for 42"/47"/55" 7100 series &
42"/47" 7300 series)
4.5 Assembly/Panel Removal ( for 55" 6500/6600 series)
4.6 Assembly/Panel Removal ( for 32"/48" 5700 series &
48"/55" 6400 series)
4.7 Assembly/Panel Removal ( for 40"/55" 5700 series)
4.8 Assembly/Panel Removal ( for 42"/47"/55" 7199/7500
series & 55" 7300 series)
4.9 Assembly/Panel Removal ( for 65" 6600/7500 series)
4.10 Assembly/Panel Removal ( for 40"/50"/58" 6809 series)
4.11 Assembly/Panel Removal ( for 40"/48"/55" 6909 series )
4.12 Assembly/Panel Removal (for 65" 5909 series)
4.13 Set Re-assembly
Notes:
• Figuresbelow can deviate slightly fromthe actual situation,
due to the different set executions.
4.1 Cable Dressing
Figure 4-1 Cable dressing (32" 5700 series)
19613_100.eps
CN9101
CN8501 CN700
CN401
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN602
ECN410
ECN401
ECN401
ECN4250
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
WW F 01
R LED BOARD
(1056)
J

Mechanical Instructions EN 15TPM14.2E LA 4.
2014-Sep-26
back to
div. table
Figure 4-2 Cable dressing (32" 6500 series)
Figure 4-3 Cable dressing (40" 5700 series)
19612_100.eps
CN9101
CN8501 CN700
CN602
CN4250
CN401
CN1404
CN410
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700 ECN1404
ECN410 ECN401
ECN401
ECN4250
EXA05
ECN602
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN 1
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)
19613_101.eps
CN9101
CN8501
CN700
CN401
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN602
ECN410
ECN401
ECN401
ECN4250
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J

Mechanical Instructions
EN 16 TPM14.2E LA4.
2014-Sep-26 back to
div. table
Figure 4-4 Cable dressing (40" 6400 series)
Figure 4-5 Cable dressing (40" 6609 series)
19613_102.eps
CN8101 CN9101
CN700
CN401
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN602
ECN410 ECN401
ECN401
ECN4250
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J
19610_100.eps
CN9101CN8101
CN700
CN401
CN1404
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN1404
ECN410
ECN401
ECN4250
EXA05
ECN602 ECN401
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)

Mechanical Instructions EN 17TPM14.2E LA 4.
2014-Sep-26
back to
div. table
Figure 4-6 Cable dressing (40" 6809 series)
Figure 4-7 Cable dressing (40" 6900 series)
19616_100.eps
CN9101
CN9301
CN700
CN602
CN4250
CN408
CN401
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700
ECN9101
ECN408
ECN4250
ECN602
ECN602
ECN401
ECN401
LOUDSPEAKER
(1184) LOUDSPEAKER
(1184)
KEYBOARD CONTROL
(1057)
E
CN 1
WIFI MODULE
WW F 01
IR LED BOARD
(1056)
J
19617_100.eps
ECN1404
CN9301
CN8101
CN700
CN409
CN408
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700
ECN409
ECN408
ECN4250
ECN602
ECN602
ECN401
LOUDSPEAKER
(1187)
LOUDSPEAKER
(1185)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
W
WF0
IR/LED BOARD
(1056)
J
CN401
CN602
CN4250
ECN401
OPTION BOARD
(1058)
O
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)
CN1404
XA04

Mechanical Instructions
EN 18 TPM14.2E LA4.
2014-Sep-26 back to
div. table
Figure 4-8 Cable dressing (42" 6500 series)
Figure 4-9 Cable dressing (47" 6500 series)
19612_101.eps
CN9301
CN8101
CN700
CN401
CN1404
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN1404
ECN410
ECN401
ECN401
ECN4250
ECN602
EXA05
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN 1
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)
19611_100.eps
CN401
CN602
CN4250
CN9301
CN8101
CN700 CN1404
CN410
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN1404
ECN410
ECN401
ECN401
ECN4250
ECN602
EXA05 ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN01
W FI MODULE
WW F 1
IR LED BOARD
(1056)
J
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)

Mechanical Instructions EN 19TPM14.2E LA 4.
2014-Sep-26
back to
div. table
Figure 4-10 Cable dressing (42" & 47" 7109/7170/7180 series)
Figure 4-11 Cable dressing (42" & 47" 7199 series)
19610_101.eps
CN9301
CN8101
CN700
CN602
CN4250
CN409CN408CN401
CN413
MAIN POWER SUPPLY
(1054)
ASSB
(1053)
B
ECN700
ECN409
ECN408
ECN401
ECN4250
ECN602
ECN4250
ECN413
ECN602
ECN401 ECN401
LOUDSPEAKER
(1186)
LOUDSPEAKER
(1185)
KEYBOARD CONTROL
(1057)
E
CN 1
RF4CE Modeul ASSY
(1076)
C2
WIFI MODULE
WW F 01
IR/LED BOARD
(1056)
J
AmbiLight
AL
(1062)
AmbiLight
AL
(1062)
CN1404
EXA04
ECN1404
19614_100.eps
CN409
CN408CN401
CN8102CN8101 CN9301
CN700 CN413
CN4250
CN602
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700
ECN409
ECN408
ECN413
ECN401
ECN401
ECN4250
ECN602
ECN602
LOUDSPEAKER
(1186)
LOUDSPEAKER
(1185)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODEUL
WW F 01
IR LED BOARD
(1056)
J
RF4CE Modeul ASSY
(1076)
C2
AmbiLight
AL
(1062)
AmbiLight
AL
(1062)
CN1404
ECN1404
EXA04

Mechanical Instructions
EN 20 TPM14.2E LA4.
2014-Sep-26 back to
div. table
Figure 4-12 Cable dressing (42" & 47" 7300/7500 series)
Figure 4-13 Cable dressing (48" 5700 series)
19611_101.eps
CN9301
CN8102
CN8101
CN700 CN1404 CN413
CN401
CN602
CN4250
CN409CN408
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700
ECN1404
ECN401
ECN602
ECN409
ECN408
ECN413
ECN4250 EXA04
EXA04
ECN401
ECN602
LOUDSPEAKER
(1186)
LOUDSPEAKER
(1185)
KEYBOARD CONTROL
(1057)
E
CN01
WIFI MODULE
WW F 01
R/LED BOARD
(1056)
J
AmbiLight
AL
(1063)
AmbiLight
AL
(1063)
AmbiLight
AL
(1063)
AmbiLight
AL
(1062)
AmbiLight
AL
(1063)
RF4CE Modeul ASSY
(1076)
C2
EXA04 EXA04
19613_103.eps
CN8101 CN9301
CN700
CN401
CN410
CN602
CN4250
MAIN POWER SUPPLY
(1054)
A
SSB
(1053)
B
ECN700
ECN410 ECN401
ECN401
ECN602
ECN4250
ECN602
LOUDSPEAKER
(1185)
LOUDSPEAKER
(1186)
KEYBOARD CONTROL
(1057)
E
CN 1
WIFI MODULE
WW F 01
R LED BOARD
(1056)
J