Philips DTM5096 User manual

DTM5096
Version 2.0
wk1505

USB Board
AUDIO IN
Board
Location of PC Boards
Main Board CD Board
BT Board
BT LED
Board
Key Board
1.Location of PC Boards & Versions Variation

M M+C
M M+C
M M+C
M M+C
M M+C
M M+C
M M+C
M M+C
M M+C
Location of PC Boards
Versiongs Variation
FM-ANT BoardSMPS Board
Tips:C--Component Level Repair
M--Module Level Rpair
CD Board
SMPS Board
Main Board
KEY Board
FM-ANT Board
AUIDO IN Board
BT LED Board
BT Board
USB Board
Type/Version
Board in used service Policy
DTM5096
/12
(EU)
/12
(APMEA)

项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
1 波段范围 Band coverage MHz
2 中心频率 Intermediate Frequency MHz
3 26dB有限噪声灵敏度 26dB quieting sensitivity dBuf 18 22 21 21
4 46dB有限噪声灵敏度 46dB sensitivity (Stereo) dBuf 46 49 46 46
5 中频抑制 I.F. rejection dB 65 60 60 61
6 镜像抑制 Image rejection dB 25 20 22 22
7 -3dB限制灵敏度 -3dB limiting PT. dBuV 17 23.5 21 21
8 调幅抑制比 AM supression Input dB 30 25 30 30
9 -3dB 自动频率控制范围 -3dB AFC holding range kHz\\\\
10 选择性 Adjacent channel selectivity dB 40 33 40 40
11 过载失真 Overall distortion %4745
12 最大有用输入信号 Large signal handling dBuV 116 108 108 108
13 中频啸叫 8X,9X,10X harmonics whistle dB 35 30 ＞35 ＞35
频率响应 Overall frequence response Hz 300 1.2 1.2
(1kHz ref) (1kHz ref) Hz 8K 22
10%失真输出功率
Output power At 10% THD 1KHz W40 32 30 30
1KHz W20161112
100Hz W70566061
16 失真度 %1 3 11
17 信噪比 S/N ratio dB 50 45 61 61
18 哼声调制信噪比 Modulation hum dB 55 45 50 55
19 放大器系数 Amplification reserve dB \\\\
21 立体声开 Stereo On pont dBuV 9.5 28 29 29
22 立体声关 Stereo Off pont dbuV / /
Channel separation
(400 / 1000 / 5000Hz)
声道分不平衡 Channel unbalance
(250 to 6300Hz) (250 to 6300Hz)
25 停震电压 V N/A N/A
Osc. stop voltage VN/A N/A
kHz/℃
Frequency drift vs. temp. kHz/℃
kHz/℃
27 选台灵敏度 Search tuning sensitivity dBuV 16 to 28 11 to 35 32/34/35 32/34/35
FM 电气指标及数据
MODEL： DTM5096
标准输出Ref.o/p： 500 mW 负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm 供电电压Supply： see version table 条件 Condition
40kHz dev
14 - 50us(For EUR)
See version table
-sh190
128KHz
90/98/106 MHz
100uV~4mV,75kHz dev
75kHz dev, ref o/p with
10% THD
10uV~1mV,22.5kHz dev
100uV~5mV,22.5kHzdev
1mV ,22.5kHz dev,
lower to upper range
+/-400KHz
- 75us (For USA)
FRONT R / L
67.5kHz dev Living sound on LIVING SOUND
Pilot dev : 6kHz
mV 2 6
Switching On -6dB
23 1mV ,40kHz dev
W/A FILTER dB 26/30/20 20/26/18
(400 / 1000 / 5000) 25/28/22 25/28/22
24 1mV ,22.5kHz dev dB 0 3 0.2 0.2
声道分离度
120V setting 96
230V setting 184
26
-10℃<--->10℃ N/A N/A
30℃<--->50℃ N/A N/A
10℃<--->30℃ N/A N/A
28 Vin >14.2mV,Step <= 50kHz Step
Other condition
选台准确度
a
rch tuning stop accuracy 0 +/- 1 N/A N/A
1mV ,22.5kHz dev
20
SUB - WOOFER
Distortion 1mV, 22.5kHz dev
1mV,75kHz dev
15
2.Technical Specification
频率漂移(温度)
FM Electrical Specification & Data
Vol. max. -20dB
噪声 (最大音量 - 20d
B
Hum 0.80.8

30 最大输出电平 Max output V
31 耗電量 (DC in ) Currnet consumption 67.5kHz
32 RDS 灵敏度 RDS sensitivity dBuV 28 35 N/A N/A
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
声道平衡 Channel balance dB 0 2 0.1 0.1
dB 0 2 N/A N/A
失真 THD (10KHz / 1KHz) % 2.0 / 1.0 3.0 / 1.5 0.5 0.5
% 2.0 / 1.0 3.0 / 1.5 1.0 1.0
100Hz % 2.0 / 1.0 3.0 / 1.5 0.57 0.57
串音 Crosstalk 1K dB 45 / 40 30 / 30 74 74
dB 45 / 40 30 / 30 N/A N/A
频率响应 300 to 20k
H
dB 0+/- 3 -1.7 -1.7
Frequency response 300 to 20KHz dB 0+/- 3 -1 -1
60 to 250Hz dB 0+/- 3 -2 -2
10%失真输出功率
Output power At 10% THD 1KHz W40 32 35.5 35
1KHz W20161111
100Hz W70566262
信噪比 SNR unwtd. dB \\\\
dB \\\\
信噪比 SNR wtd. DBA dBA 80 75 88 88
dBA 62 57 84 84
dBA 62 57 91 91
8 放大器系数 Amplification reserve dB \\\\
噪声 (最大音量 - 20dB) hum mV 1 3 0.6 0.6
mV 1 3 0.5 0.5
mV 1 3 0.5 0.5
最小音量(残余)噪声 Min volume (residual) noise mv 0.6 0.8 0.2 0.2
mv 0.6 0.8 0.2 0.2
mv 0.6 0.8 0.2 0.2
11 最大输出电平 Max output V
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
声道平衡 Channel balance dB 0 2 0.2 0.2
dB 0 2 N/A N/A
负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm
标准输出Ref.o/p： 500 mW
标准输出Ref.o/p： 500 mW 负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm
9
10
N/A
N/A
N/A29 87.5 to 108MHz S<= 60
t
ime of total tuning range
选台总时间 65.81to74 & 87.5to108MHz <= 100
1mV, 75kHz dev For reference only N/A
min. / max. vol. Refer to sh190
40kHz dev
1
5
条件 Condition
FRONT R / L
3
1LIVING SOUND
2
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
4
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
1 kHz 0 dB Living sound on LIVING SOUND
SUB - WOOFER
6
TNO 15 & TNO 49
(line out)
TNO 15 & TNO 49
(speaker out)
7
FRONT R / L
LIVING SOUND
SUB - WOOFER
TNO 35 (1 KHz -6dB)
FRONT R / L
LIVING SOUND
V
ol. max. -20dB to vol. Mi
n
SUB - WOOFER
FRONT R / L
LIVING SOUND
SUB - WOOFER
-20db / -0dB
供电电压Supply： see version table
音频Audio part (measured use Scan Disk USB driver,test signal copy from Audio Signal 1 disc - SBC429 data
For reference only
条件 Condition
FRONT R / L
LIVING SOUND
音频Audio part (measured with Audio Signal 1 disc - SBC429, 20 to 20k Hz filter)
USB 電氣指標及數據
USB Electrical Specification & Data
供电电压Supply： see version table
CD 电气指标及数据
CD Electrical Specification & Data

失真 THD (10KHz / 1KHz) % 2.0 / 1.0 3.0 / 1.5 0.8 0.8
% 2.0 / 1.0 3.0 / 1.5 1.2 1.2
100Hz % 2.0 / 1.0 3.0 / 1.5 0.9 0.9
dB 45 / 40 30 / 30 65 65
dB 45 / 40 30 / 30 N/A N/A
频率响应 dB 0+/- 3 33
Frequency response dB 0+/- 3 33
dB 0+/- 3 1.2 1.2
10%失真输出功率
Output power At 10% THD 1KHz W40 32 30 30
1KHz W20161111
100Hz W70566161
dB \\\\
dB \\\\
dBA 80 75 88 88
dBA 62 57 87 87
dBA 62 57 80 80
8 放大器系数 Amplification reserve dB \\\
mV 1 3 0.6 0.6
mV 1 3 0.6 0.6
mV 1 3 0.5 0.5
最小音量(残余)噪声 Min volume (residual) noise mv 0.6 0.8 0.2 0.2
mv 0.6 0.8 0.2 0.2
vol = 0 mute no active mv 0.6 0.8 0.1 0.1
11 最大输出电平 Max output V N/A N/A
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
1 输入灵敏度 Input sensitivity mV \ \ 500MV 505MV
声道不平衡 Channel unbalance dB 0 3 00
dB 0 3 N/A N/A
频率响应 dB 0+/- 3 -3 -3
Frequency response dB 0+/- 3 33
dB 0+/- 3 2.2 2.2
声道分离度 Channel separation dB 40 30 52 52
dB 40 30 N/A N/A
失真度 500mV THD (10KHz / 1KHz) % 0.2/1 1/3 0.16 0.17
% 0.2/1 1/3 0.18 0.19
100Hz % 0.2/1 1/3 0.19 0.19
W40 32 30 30
W20161010
W70566263
dB 80 75 88 88
dB 62 57 87 87
dB 62 57 80 80
噪声 (最大音量 - 20dB) Hum mV 1 3 0.6 0.6
4
2
6
7
5
信噪比 S/N wtd. DBA
标准输出Ref.o/p： 500 mW 负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm
10% THD output
power
500MV
10％失真输出
音频Audio part (Input 1KHZ 500mv ,test signal copy from Audio Signal 1 disc - SBC429 data)
10
9
5
3
o
sstalk 1K
2
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
4
FRONT R / L
LIVING SOUND
SUB - WOOFER
300 to 20KHz
300 to 20kHz
60 to 250Hz
串音
FRONT R / L
1 kHz 0 dB Living sound on LIVING SOUND
SUB - WOOFER
6
TNO 15 & TNO 49
(line out)
TNO 15 & TNO 49
(speaker out)
7
FRONT R / L
LIVING SOUND
SUB - WOOFER
V
ol. max. -20dB to vol. Mi
n
SUB - WOOFER
hum
噪声 (最大音量 - 20d
B
-20db / -0dB For reference only
TNO 35 (1 KHz -6dB)
FRONT R / L
LIVING SOUND
供电电压Supply： see version table
信噪比
N
R unwtd.
SNR wtd. DBA
信噪比
AUDIO IN 電氣指標及數據
AUDIO IN Electrical Specification & Data
FRONT R / L
LIVING SOUND
SUB - WOOFER
条件 Condition
FRONT R / L
LIVING SOUND
3
FRONT R / L
LIVING SOUND
SUB - WOOFER
300 to 20kHz
300 to 20KHz
60 to 250Hz FRONT R / L
LIVING SOUND
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L

mV 1 3 0.5 0.5
Min volume (residual) noise mV 1 3 0.5 0.5
最小音量(残余)噪声 mV 0.6 0.8 0.2 0.2
Min volume (residual) noise mV 0.6 0.8 0.2 0.2
mV 0.6 0.8 0.1 0.1
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
1 10％失真输出 mW 8 8.7 8.8
dB 0 + / - 3 00.1
dB 0 + / - 3 1.5 1.5
dB 0 + / - 3 0.8 0.9
dB 0 + / - 3 -2.2 -2.3
dB 0 + / - 3 0 0
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
声道平衡 Channel balance dB 0 2 0.2 0.2
dB 0 2 N/A N/A
失真 THD (10KHz / 1KHz) % 2.0 / 1.0 3.0 / 1.5 0.25 0.26
% 2.0 / 1.0 3.0 / 1.5 0.3 0.3
100Hz % 2.0 / 1.0 3.0 / 1.5 0.2 0.2
串音 Crosstalk 1K dB 45 / 40 30 / 30 73 75
dB 45 / 40 30 / 30 N/A N/A
频率响应 TN
O
200 to10KH
z
16KHz
=
dB 0+/- 3 33
Frequency response 200 to10KH
z
16KHz
=
dB 0+/- 3 2.2 2.2
40 to 150Hz dB 0+/- 3 1.2 1.2
10%失真输出功率
Output power At 10% THD 1KHz W40 32 32 32
1KHz W 20 16 10.6 10.6
125Hz W70566263
dB \ \ N/A N/A
dB \ \ N/A N/A
dBA 80 75 88 89
dBA 62 57 88 89
dBA 62 57 89 89
8 放大器系数 Amplification reserve dB \ \ N/A N/A
噪声 (最大音量 - 20dB) hum mV 1 3 0.5 0.5
mV 1 3 0.6 0.6
mV 1 3 0.5 0.5
mv 0.6 0.8 0.2 0.2
mv 0.6 0.8 0.1 0.1
mv 0.6 0.8 0.1 0.1
8
2电平比较 Level Matching
9
音频Audio part (test signal copy from Audio Signal 1 disc - SBC429 ) data setting will be TBC
I-PHONE / IPOD (I-PHONE 5)電氣指標及數據
I-PHONE 5 Electrical Specification & Data
信噪比 SNR wtd. DBA
10 Min volume (residual) noise
最小音量(残余)噪声
标准输出Ref.o/p： 500 mW 负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
SUB - WOOFER
条件 Condition
10% THD output power Headphone
impedance 32 ohm
耳机電氣指標及數據
Headphone Electrical Specification & Data
AUX 500MV ( 1 KHz )
CD 1K -6 db
USB 1K -6 db
FM 1K MOD: 67.5DEV
IPOD 4G / I-PHONE
1K 0db
供电电压Supply： see version table
条件 Condition
9
5
3
1FRONT R / L
LIVING SOUND
2
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
4
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
1 kHz 0 dB Living sound on LIVING SOUND
SUB - WOOFER
6
TNO 15 & TNO 49
(line out)
TNO 15 & TNO 49
(speaker out)
N
R unwtd.
信噪比
7
FRONT R / L
LIVING SOUND
SUB - WOOFER
TNO 35 (1 KHz -6dB)
FRONT R / L
LIVING SOUND
V
ol. max. -20dB to vol. Mi
n
SUB - WOOFER
FRONT R / L
LIVING SOUND
SUB - WOOFER

11 最大输出电平 Max output V N/A N/A
项目
内容 Description 单位 Unit 标准Nor 极限Limit 数据Data 数据Data
声道平衡 Channel balance dB 0 2 0.2 0.2
dB 0 2 N/A N/A
失真 THD (10KHz / 1KHz) % 2.0 / 1.0 3.0 / 1.5 0.5 0.5
% 2.0 / 1.0 3.0 / 1.5 0.2 0.2
100Hz % 2.0 / 1.0 3.0 / 1.5 0.6 0.6
串音 Crosstalk 1K dB 45 / 40 30 / 30 75 77
dB 45 / 40 30 / 30 N/A N/A
频率响应 TN
O
200 to10KH
z
16KHz
=
dB 0+/- 3 2.2 2.2
Frequency response 200 to10KH
z
16KHz
=
dB 0+/- 3 1.2 1.3
40 to 150Hz dB 0+/- 3 11
10%失真输出功率
Output power At 10% THD 1KHz W40 32 33 33
1KHz W20161111
125Hz W70566264
SNR unwtd. dB \ \ N/A N/A
dB \ \ N/A N/A
SNR wtd. DBA dBA 80 75 88 89
dBA 62 57 87 88
dBA 62 57 88 88
8 放大器系数 Amplification reserve dB \ \ N/A N/A
噪声 (最大音量 - 20dB) hum mV 1 3 0.5 0.5
mV 1 3 0.6 0.6
mV 1 3 0.6 0.6
最小音量(残余)噪声 mv 0.6 0.8 0.1 0.1
mv 0.6 0.8 0.2 0.2
mv 0.6 0.8 0.2 0.2
11 最大输出电平 Max output V N/A N/A
BT Electrical Specification & Data
BLUE TOOTH 電氣指標及數據
9
10
1
M
in volume (residual) noise
5
3
供电电压Supply： see version table
2
标准输出Ref.o/p： 500 mW 负载O/P imped : R/L , LS 6 ohm , Woofer 6 ohm
For reference only
-20db / -0dB
条件 Condition
FRONT R / L
音频Audio part (test signal copy from Audio Signal 1 disc -SBC429) data setting will be TBC
LIVING SOUND
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
LIVING SOUND
4
FRONT R / L
LIVING SOUND
SUB - WOOFER
FRONT R / L
1 kHz 0 dB Living sound on LIVING SOUND
SUB - WOOFER
6信噪比
TNO 15 & TNO 49
(line out)
TNO 15 & TNO 49
(speaker out)
LIVING SOUND
TNO 35 (1 KHz -6dB)
FRONT R / L
LIVING SOUND
SUB - WOOFER
For reference only
SUB - WOOFER
-20db / -0dB
7
FRONT R / L
V
ol. max. -20dB to vol. Mi
n
LIVING SOUND
SUB - WOOFER
信噪比
FRONT R / L

3.Safety instruction
1. General safety
Safety regulations require that during a repair:
. Connect the unit to the mains via an isolation transformer.
. Replace safety components indicated by the symbol ,
only by components identical to the original ones. Any
other component substitution (other than original type)
may increase risk of fire or electrical shock hazard.
Safety regulations require that after a repair, you must
return the unit in its original condition. Pay, in particular,
attention to the following points:
. Route the wires/cables correctly, and fix them with the
mounted cable clamps.
. Check the insulation of the mains lead for external
damage.
. Check the electrical DC resistance between the mains
plug and the secondary side:
1) Unplug the mains cord, and connect a wire between
the two pins of the mains plug.
2) Set the mains switch the “on” position (keep the
mains cord unplug).
3) Measure the resistance value between the mains
plug and the front panel, controls, and chassis
bottom.
4) Repair or correct unit when the resistance
measurement is less than 1M
¡
.
5) Verify this, before you return the unit to the
customer/user (ref. UL-standard no. 1492).
6) Switch the unit “off”, and remove the wire between
the two pins of the mains plug.
2.Laser safety
This unit employs a laser. Only qualified service personnel
may remove the cover, or attempt to service this device
(due to possible eye injury).
Laser device unit
Type :SemiconductorlaserGaAlAs
Wavelength : 650nm (DVD)
: 780nm (VCD/CD)
Output power : 7mW (DVD)
:10mW(DVD/CD)
Beam divergence: 60 degree
Note: Use of controls or adjustments or performance of
procedure other than those specified herein, may result in
hazardous radiation exposure. Avoid direct exposure to
beam.

Commutate
&Filter u1
x2
x1f(x1...xn)
AMP_30V/5A
6.5V/1.5A
3.5V/0.3A
-28V/0.3A
GND
AMP_GND
Power Ctrl&Standby
5.2V/2.1A

* MP3/WMA decoder
* CD DSP+RF Amp
* ESP
SPI
ANT
ANT
R
L
L/R PERSET-
EQ+VOLUNE
Power
Amplifier
STA326(30Wx2ch)
PERSET-
EQ+VOLUNE
Power
Amplifier
STA326(30W+70W)
DSP
CS48540
Switch+ADC
CE2631
DM
DP
L
R
C
SW
IR-Receiver
VFD Display
VFD20-1033
Touch Key x 10
GT1000A
USB Audio+
System CPU
OTK5250
16M SDRAM
VFD Driver
ET16315
SPI Flash
GD25Q80
32.768KHz
24MHZ
16.93MHZ

5.Set Wiring Diagram

6.DISMANTLING DIAGRAM
1)Dismantling of the top cabinet:
a.Remove 8 screws A&B as indicated to loosen the back cabinet
A
B

b.Remove 2 screws C as indicated to loosen the top cabinet
C

c.Remove 8 screws D,E&F as indicated to loosen the top cabinet
D
E
F

2)Dismantling the PCB board of the top :
a: Remove 3 screws G as indicated to loosen the BT board
b: Remove 4 screws H as indicated to loosen the Key board
c: Remove 2 screws I as indicated to loosen the BT-LED board
G
I
H

d: Remove 4 screws J as indicated to loosen the Main board
e: Remove 3 screws K as indicated to loosen the CD board
J
K

f: Remove 1 screws L as indicated to loosen the USB&AUDIO IN board
g: Remove 2 screws M as indicated to loosen the IR board
L
M

3)Dismantling of the bottom cabinet:
1.Remove 10 screws O&P as indicated to loosen the back cabinet
O
P

b: Remove 2 screws R as indicated to loosen the FM-ANT board
a: Remove 4 screws Q as indicated to loosen the SMPS board
2)Dismantling the PCB board of the Bottom :
R
Q