Philips FWM9000 User manual

all
TABLE OF CONTENTS Page
Technical specification ...........................................................1-15
Safety instruction......................................................................2-1
ESD protection.........................................................................2-2
Set Block diagram ........................................................... .......3-1
Set Wiring diagram............................................................. ....4-1
Disassembly diagram..........................................................5-1-2
Main & Amp board
Circuit diagram............................................................6-1..6-3
Layout diagram.................................................................6-4..6-7
board
Circuit diagram....................................................................7-1
Layout diagram.................................................................7-2..7-3
Mechanical Exploded view..... .......................................... .....10-1
©Copyright 2012 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without
the prior permission of Philips.
Published by LX 1 Service Audio Printed in The Netherlands Subject to modification
Version 1.
Seu Mini Hi-Fi System FWM9000/
Key & Display
board
Circuit diagram....................................................................8-1
Layout diagram........................................................................8-2
Tuner
board
Circuit diagram............................................................9-1...9-2
Layout diagram..................................................................9-3..9-5
Mcu & CD
0
215 3141 785 37540

1-2
Type /Versions:
Features
Board in used: Service policy
Main BOARD
display BOARD
* TIPS : C -- Component Lever Repair.
M -- Module Lever Repair
√
-- Used
Feature diffrence
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK
Type /Versions:
FWM9000
VERSION VARIATION
amp BOARD
key BOARD
(LATAM)
mic BOARD
mcu BOARD
FWM9000
/55
tuner BOARD
cd BOARD
/55
Location of PC Boards Technical Specification and Connection Facilities
C/M
C/M
C/M
C/M
C/M
C/M
3CD PART
Top key Board
(ARGENTINA)
x/77 x/78
x/77 x/78
(BRAZIL)
Switch Power BOARD M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
M M
C/M
C/M
Main Board
Tuner Board
Amp Board Switch power Board VFD Board
EQ Board
Light Board
Usb Board
Display Board
Ac cord Board
Power key Board

1 - 3
egaPnpotiprcseD.oN
1 GENERAL PART 1 - FRONT PANNEL SPECICFICATION 1
2 GENERAL PART 2 - BACK PANNEL SPECICFICATION 2
3 GENERAL PART 3 - GENERAL SPECICFICATION 3
4 GENERAL PART 4 - TECHNICAL SPECICFICATION 4
5 GENERAL PART 5 - AUDIO SIGNAL SPECICFICATION 5
6 GENERAL PART 6 - AUDIO SIGNAL SPECICFICATION 6
7 GENERAL PART 7 - CLOCK / TIMER SPECICFICATION 7
8 GENERAL PART 8 USB/SD-Card SPECICFICATION 8
9 GENERAL PART 9 - TUNER SPECICFICATION ( All ) 9
10 GENERAL PART 10 - CD / MP3 SPECICFICATION 10
11 GENERAL PART 11 - Ipod SPECICFICATION 11
12 GENERAL PART 12 - Microhone SPECICFICATION 12
13 GENERAL PART 12 - VERSION OVERVIEW SPECICFICATION 13
FWM9000 SH 190 content List

1 - 4
DEPICTION Pos Description Page
Units in Dealercarton
Weight ( inclusive packing )8.505KG
Weight ( exclusive packing & batery )26KG
CABINET
Diemensions with Boxes ( wxhxd ) 265mm X 382mm X 345mm
DATE : 11 A411 SH 190 - 1NAME : KT CHECK:
GENERAL PART 1 - FRONT PANNEL SPECICFICATION
Issued Date
12-Feb-09
Material : HIPS / ABS / POM / V2 / SAN
Finshing : Chrome Plate
Remarks :
Diemensions without Boxes ( wxhxd ) 1250mm X 340mm X 495 Units in Masstercarton
1 used into
Class No
2
3
Remark :
1
FWM9000 All Version
Ver

1 - 5
egaPnoitpircseDsoPNOITCIPED
Ver
1
2
3
10
GENERAL PART 1 - BACK PANNEL SPECICFICATION Issued Date
NAME :
10
Class No
FWM9000 All Version
SH 190
-
2
A4
CABINET
Diemensions with Boxes ( wxhxd )265mm X 382 mm X 345 mm
notracrelaeDnistinUgK62)yretab&gnikcapevisulcxe(thgieW
Diemensions without Boxes ( wxhxd ) 1250mm X 340mm X 495mm Finshing : Chrome Plate
notracretssaMnistinUgK5.8)gnikcapevisulcni(thgieW
Material :HIPS
10
DATE :
NAME :
10
KT CHECK:
SH 190
-
2
A4

1 - 6
31RPSIC,56006NE89/
8 11
SAFETY requirements CMEytefaSnoisreV
Page
CISPR 13
CLIMATIC requirements
ALL climates : + 5 Dregree till + 35 Degree
CISPR 13
99CCF56006LU73/
/79
FWM9000 All Version
3
2
A4
Issued Date
DATE :
NAME : Andy Lai
KT CHECK 10 10 SH 190 - 3
Class No GENERAL PART 1 - GENERAL SPECICFICATION
108-09-2011
Ver
Remarks
Tested according to General Test Instruction refer to PHILIPS standary ( UAN -D1591 )
Measured according to PHILIPS standary ( UAN - L1059 ) unless other wise stated
All not mentioned date, please refer to PHILIPS standary ( XUW - 0010 - JUNE 2001 ) NOITABORPPASKRAMERDEVIRED
Reliability : 3.0 % ( C 42 )
ECO Power mode(Without display): < 0.5W Ref. to CRS Ref. to CRS
Maximum :
< 0.5W
Quality : 0.8 % ( Major ) 2.0 % ( Mirror )
W052<TUPNI,A.MON,detarP8/1@
< 1W
( DEMO mode " OFF " ) , NOM. A, INPUT SRCotfeRSRCotfeRW1<:)yalpsidhtiw(ybdnatS
POWER CONSUMPTION / 12/ 05 / 55/77/78/98 /61 /93 / 37
Voltage Selection
Frequency
02055NE/31055NE56006NE21/
/05 EN 55013 / EN 55020
EN 60065
EN 60065
MODERATE climates : + N.A till N.A Degree
SWITCH POWER FOR AC100V TO 250V
96-301
/55 EN 60065,EN61000-3-2/EN61000-3-3
II
Version
PERFORMANCE CLASSES
POWER SUPPLY (SWITCHING MODE POWER SUPPLY)
MAINS ( A.C. )
RADIATION / IMMUNITY requirments ( EMC ) for 12 version only
XX X
III
XXX
I
CD-mp3Recorder ClockClass Tuner Supply + Amplifier USB
LIFETIME : 7 Years
GENERAL DESCRIPTION
MP3-USB Mini Hi FiSystem with Digital Tuner, 3CD/MP3
(2x350W+2x300W+2x150W) For FWM9000 Power Amplifier,VFD Display,Aux in ,Remote control
Subwoofer Boxes of 8 Ohm x 2

1 - 7
:
:
:
:
:
output power 1kHz
IS : YES
<4
dB
YES Hum ( Volume control from min. till max. – 20 dB) < 200 nW
Residual Noise ( Volume Minium ) < 60
3Bd04-tarecnereffiDlennahC
MAX nW
Standby Mode Indicator : FTD display Clock active
OUTPUT stage Protection : Yes Temperature : Yes. Shorcircuit : Yes
LoudSpeaker D.C. Protection : Yes.
INDICATORS
ECO Mode Indiicator : FTD turns off, ECO - Standby LED turn on
TECHNIAL DESCRIPTION
Total power 1500W, matching LOUDSPEAKER of 4 x 8 Ohm +2 x 4 Ohm. INPUT SOURCE, CD/MP TUNER USB AUX 3DSC ( Digital Sound Control ). IS
( Incredible Sound )
GENERAL PART
)zHk1ta(noitarapeSlennahCA/N:CAV ≥45
DSC : Rock, Pop, Jazz, Optimal
WOOX : N/A µW Signal / Noise ( unweighted ) ≥55
Subwoofer Out Hum( Volume minmun) dB
ELECTRICAL DATA (Main computer ) dB
A.N)thgiR/tfeL(tuOeniLnoitaludoM%08MAZHK5.76MFrenuT
INTERCONNECTS
Input Sensitity(±2 dB)rated ouput power at 1 kHz and 10kHz. Line Output Voltage ( *1 )
seYtuOrefoowbuS)53krT,1csiDoiduA(kcartBd0DC
A.NtuOlaixaoClatigiD73/rofVm009~Vm053:miLVm006:roN mhO23ta%2.0-/+V7.0enohpdaeH)53krT,1csiDoiduA(kcartBd0BSU
A.NtuOretsooB55/rofV5.2~V5.1:miLV2:roN
AUX
Subwoofer L/R : 8 Ohm x2 at 40HZ to 100HZ
Rear: L/R : 4 Ohms X2 at 200Hz to 16 KHz
Remarks
OUTPUT POWER ( * 1 )At THD = 10% (Measured with 20Hz-20KHz filter),(Per Channel measuremend )
L/R channel 300W ( Lim '-1dB )Power output ( RMS )
Power output ( RMS )
( *1 ) Measurement output power just connect 2 channel loads.
Tuner output ( Lim '-6dB )
Rated Impedance
FRONT:L/R : 8 Ohms X2 at 40Hz to 16 KHz
L/R Subwoofer channel 300W ( Lim '-1dB )Power output ( RMS ) )Bd1-'miL(W051lennahcraeRR/L)SMR(tuptuorewoP
SUB. Channel
Rear channel
Measurement output power only for AUX model and CD model of used audio analyzer equipment.
Ver
(*2) All speaker "R" channel "+ "connect to equipment " + "for measurement.
All speaker "L" channel "- "connect to equipment " + "for measurement (because all "L"channel output are reverse ).
GENERAL PART 1 - TECHNAICAL SPECICFICATION Issued DateClass No
08-09-2011
Electrical parameters are to be measuremend at specker terminals across 8 Ohm load ( pure resistor )
with rated input signal in AUX mode; DSC setting in Jazz mode with DBB OFF
IS off and OSM unless specified otherwise
40HZ-16KHZ(reference 1KHZ)
40HZ-125HZ(reference 63HZ)
200HZ-16KHZ(reference 1KHZ)
Main Channnel
3
input leven 1mv rms(lim:2.5mv rms)
Rs=600ohm Bd4±@esnopserycneuqerF:enohporciM
2
FWM9000 All Version
LOUDSPEAKER ( BOXES ) Please to package document of Speaker Box Assy
A4
1
DATE :
NAME : Andy Lai
KT CHECK 10 10 SH 190 - 4

1 - 8
0 0
60 Hz(SUB)
2 ) DBB ( Dynamic Bass Boot )
Set DSC to JAZZ(Flat) mode and switch off DBB,
Frequency
0
10 kHz(host computer)
0
02)BUS(zH06
POP TECHNO
1khz (host computer) 0 0 0
1 kHz(host computer) 0
01khz(host computer) 0 0 0
6 0
DBB 2
2020
DSC Modes with DBB 3 ON
JAZZ
OPTIMAL
2-0
OPTIMAL
1khz(SUB) 0 0 0
00 0
1 kHz(SUB) 0
2
2
Tabel 1b ( Tolerance ± 3dB )
16
10 kHz (host computer)
0 0
4
Tabel 1a ( Tolerance ± 3dB )
1K((SUB) 0
1khz(SUB) 0
Tabel 1b ( Tolerance ± 3dB )
0
60 Hz (SUB) 10 16
60 Hz (SUB) 4
0 0
0
POP TECHNO
JAZZ POP TECHNO
2-4
0
OPTIMAL
6
-410 kHz (host computer) 0
OPTIMAL
2
0
6
0
0
1 kHz (host computer) 0
2
0
4
16
0
13
0
DSC Modes with DBB 2 ON
4
AUDIO SIGNAL PROCESSING
MP3-USB Mini Hi Fi System with Digital Tuner , 3 CDC-MP3,(Main:2×350W+Rear:2×150W+SUB:2x300W) Universal Class D Power Amplifier
1 ) DSC ( Digital Sound Control )
Select AUX as input source with the following set conditions:
Inject sine wave 500mV at 1 KHz to L/R channels of AUX-IN socket.
Set DSC to JAZZ(Flat) mode and switch off DBB.
Frequency
Refence level for DSC's without DBB on=1W.
Refence level for DSC'S with DBB on=1.2V at the speaker terminal .
4
For FWM998 Subwoofer in put 500mW 60HZ @ 3R (Main computer )
Inject sine wave 500mV-2.4V to AUX-IN socket with frequencies indicated in Table 1.
60 Hz (SUB)
DSC Modes with DBB Off
JAZZ POP TECHNO
08-09-2011
GENERAL PART 1 - GENERAL SPECICFICATION
000
10K Hz(host computer)
Issued Date
10 kHz(host computer) 0 2
Tabel 1b ( Tolerance ± 3dB )
8 12
Frequency
DBB 3
Frequency DSC Modes with DBB 1 ON
0
2
8 8
DBB 1
0
1 Hz(SUB) 0
1 kHz (host computer) 0
Frequency DBB OFF
JAZZ
2
Reference level for the test is 500mW on the speaker terminals.
Tabel 2 of FWM998( Tolerance ± 3dB )
Select AUX as input source with the following set conditions :
Inject sine wave 500mV at 1kHz to L/R channels of AUX - IN socket.
000
A4
Class No
FWM9000 All Version
Ver
2
1
SH 190 - 5
KT CHECK
3
DATE :
NAME : Andy Lai 10 10

1 - 9
+2.0 dB- 1.0 dB -
2V - 0 -
2V -
Set DSC to JAZZ ( Flat ) mode and switch of DBB, OSM & INCREDIBLE SURROUND.
Adjust volume level to obtain 1W across 3 OHM load at L/R speaker output.
Inject sine wave 2V to AUX-IN socket withfrequency indicated in Table 3 (input level 600mV for /37,2V for /55 ).
4 ) DSC Mode ( Jazz , Rock, Techno and Optimal )
- 0.5 dB - + 3.0 dB -5 dB
Select AUX as input source.
Inject sine wave 2V at 1kHz to AUX-IN socket, two channel at a time (input level 600mV for /37,2V for /55 ).
LEFT RIGHT
OUTPUT LEVEL
NOSIFFOSI
10 kHz
Note : The above specs also apply to right channel.
1 kHz
AUDIO SIGNAL PROCESSING
MP3 - USB Mini Hi Fi System with Digital Tuner , 3 CDC-MP3, (Main:2×350W+SUB:2×300W+Rear:2x150W) Universal Class D Power Amplifier
FREQ INPUT LEVEL
3 ) IS ( Incredible Sound )
2V -
DBB 2
+ 3.5 dB 0 dB
The VEC modes are software controlled by switching the combination between DBB and DSC modes
as show in Table 4.
Set DSC to JAZZ ( Flat ) mode and switch of DBB, OSM & INCREDIBLE SURROUND.
Adjust volume level to obtain 1W across 3 OHM load at L/R speaker output.
- 15 dB
Table 3 ( Tolerence ± 3 dB )
LEFT RIGHT LEFT RIGHT
60 Hz
The 1W level will be used as 0 dB reference
Max ON
VEC MODE
Optimal
POP
Note : When these modes are activ DBB and DSC will not be displayed
DBB Level preset
DBB OFF
DBB 3
3BBDonhceT
Jazz
1 kHz 0+5
10 kHz -1
Inject sine wave 2V to AUX-IN socket withfrequency indicated in Table 5 (input level 600mV for /37,2V for /55 ).
5 ) MAX ( Maximum Sound )
Select AUX as input source.
Inject sine wave 2V at 1kHz to AUX-IN socket, one channel at a time (input level 600mV for /37,2V for /55 ).
10 10 SH 190 - 6
KT
3
108-09-2011
60 Hz -1
+7
FREQ Max OFF +19
GENERAL PART 1 - AUDIO SIGNAL SPECICFICATION ( 2 )
Class No
FWM9000 All Version
Ver Issued Date
A4
2
CHECK DATE :
NAME : Andy Lai

1 - 10
7-091HSiaLydnA:EMAN 10 10
CHECK DATE :
A4
KT
3
108-09-2011
Remark
CLOCK / TIMMER SPECICFICATION
Class No
FWM9000 All Version 2
Ver Issued Date
: Nom : 1 sec/day Limit : 2 sec/day
DFV :epyT yalpsiD
INDICATORS
BSUrorenuTroDC:edoMpuekaWremiT
.noisrevrehtorofsrh42,noisrev73/rofrh21:gnitteSemiTskrameR
gnitteStsaL:puekaWtaemuloV
No of Timer Settings : 1
Clock Accuracy
TECHNIAL DESCRIPTION
SOFTWARE IMPLEMENTED CLOCK / TIMER FUNCTION WITH 12MHZ QUARTZ OSCILLATOR.
GENERAL PART
remiTdnakcolC:gnitteSremiT