Pioneer PD-117 User manual

ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2004
RRV2904
COMPACT DISC PLAYER
PD-217
T – ZZR MAR. 2004 Printed in Japan
PD-217
For details, refer to "Important symbols for good services" .
PD-117
Type
Model Power Requirement The voltage can be converted by the following method.
PD-117
PD-217 RFXJ
RFXJ
AC110-127V/ 220-240V
AC110-127V/ 220-240V
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
With the voltage selector
With the voltage selector

2
1234
1234
C
D
F
A
B
E
PD-217
SAFETY INFORMATION
This service manual is intended for qualified service technicians ; it is not meant for the casual do-
it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and
may void the warranty. If you are not qualified to perform the repair of this product properly and
safely, you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING !
THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1
BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR
CLASS 1.
A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE APPARATUS.
LASER DIODE CHARACTERISTICS
FOR DVD : MAXIMUM OUTPUT POWER : 5 mW
WAVELENGTH : 650 nm
FOR CD : MAXIMUM OUTPUT POWER : 7 mW
WAVELENGTH : 780 nm
Additional Laser Caution
* : Refer to page 23.
LABEL CHECK
REAR
(DRW2168)
1. Laser Interlock Mechanism
The position of the switch (S651) for detecting loading
state is detected by the system microprocessor, and
the design prevents laser diode oscillation when the switch (S651)
is not on CLMP terminal side (CLMP signal is OFF or high level).
Thus, the interlock will no longer function if the switch (S651)
is deliberatery set to CLMP terminal side. (low level)
The interlock also does not function in the test mode(
* ).
Laser diode oscillation will continue, if pin 33 of
CXA1782CQ (IC151) on the MOTHER BOARD ASSY
is connected to GND, or pin 26 of IC351 (LDON) is connected
to low level (ON), or else the terminals of Q151 are shorted
to each other (fault condition).
2. When the cover is opened, close viewing of the objective lens with
the naked eye will cause exposure to a Class 1 laser beam.

3
1234
1234
C
D
F
A
B
E
PD-217
[ Important symbols for good services ]
In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely.
When you find the procedures bearing any of the symbols, be sure to fulfill them:
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable.
In accordance with the procedures or instructions described in this manual, adjustments should be performed.
3. Cleaning
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning,
proper cleaning should be performed to restore their performances.
5. Lubricants, glues, and replacement parts
Appropriately applying grease or glue can maintain the product performances. But improper lubrication or applying
glue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply the
prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed
ones should be used.
4. Shipping mode and shipping screws
To protect the product from damages or failures that may be caused during transit, the shipping mode should be set or
the shipping screws should be installed before shipping out in accordance with this manual, if necessary.
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and
should keep the safety during servicing by following the safety instructions described in this manual.

4
1234
1234
C
D
F
A
B
E
PD-217
SAFETY INFORMATION ......................................................................................................................................2
1. SPECIFICATIONS .................................................................................................................................................5
2. EXPLODED VIEWS AND PARTS LIST ............................................................................................................... 6
2.1 PACKING SECTION ............................................................................................................................... 6
2.2 EXTERIOR (1/2)SECTION ............................................................................................................................. 8
2.3 EXTERIOR (2/2)SECTION.................................................................................................................................................................................................. 9
2.4 SINGLE MECHANISM SECTION ................................................................................................................... 10
3. SCHEMATIC DIAGRAM .................................................................................................................................................................................. ... 12
3.1 MOTHER, DISPLAY and SW BOARD ASSYS ........................................................................................... 12
3.2 WAVEFORMS MOTHER BOARD ASSY ..................................................................................................... 14
4. PCB CONNECTION DIAGAM ............................................................................................................................ 16
4.1 MECHA, DISPLAY, SW and HP BOARD ASSYS 16
.......................................................................................
4.2 MOTHER BOARD ASSY .................................................................................................................................................................................... 17
6.1 PREPARATIONS .............................................................................................................................................................................................................................................................................. 22
6.2 ADJUSTMENT .............................................................................................................................................................................................................................................................................. 23
5. PCB PARTS LIST ............................................................................................................................................... 19
6. ADJUSTMENT .................................................................................................................................................... 22
7. GENERAL INFORMATION ................................................................................................................................ 30
7.1 DISPLAY .................................................................................................................................................. 30
7.2 CLEANING ............................................................................................................................................ 31
7.3 BLOCK DIAGRAM .................................................................................................................................... 31
8. PANEL FACILITIES ............................................................................................................................................ 32
CONTENTS

5
1234
1234
C
D
F
A
B
E
PD-217
1. SPECIFICATIONS
Accessories
Remote Control Unit x 1
(CU-PD112) (PWW1158)
PD-217 Only
Output Cable x 1
(PDE1315 : L=1m)
AA/R6P Dry Cell Batteries
x 2
Operating instructions
(PRE1296)
Control Cable x 1
(PDE-319 : L=1m)
PD-117 Only
SPECIFICATIONS
Red
White
1. General
Type ........................................... Compact disc digital audio system
Power requirements
.................... 110 - 127/220 -240 V(switchable) ,50/60 Hz
Power consumption ................................................................. 12 W
Operating temperature ................................................ +5˚C - +35˚C
Weight ................................................................................... 3.1 kg
External dimensions
PD-217 ........................................ 420(W) X 101(H) X 267(D) mm
PD-117 ........................................ 420(W) X 101(H) X 263(D) mm
2. Audio section
Frequency response ................................................... 2 Hz - 20 kHz
S/N ratio .......................................................... 98 dB or more (EIAJ)
Dynamic range ................................................ 96 dB or more (EIAJ)
Harmonic distortion ........................................ 0.003% or less (EIAJ)
Output voltage ............................................................... 2.0 V (EIAJ)
Wow and flutter ............................................ Limit of measurement
(±0.001% W.PEAK) or less (EIAJ)
Channels .............................................................. 2-channel (stereo)
3. Output terminal
Audio line output jacks
CD•DECK SYNCHRO jack
Headphones jack (with volume control) (PD-217 Only)
Control input/output jacks (available with the PD-117 )
4. Accessories
Remote control unit(PD-217 Only) ............................................ 1
AA/R6P dry cell batteries(PD-217 Only) ................................... 2
Control cable(PD-117 Only) ...................................................... 1
Output cable ............................................................................. 1
Operating instructions ............................................................... 1
NOTE:
Specifications and design subject to possible modification without
notice, due to improvements.
OUTPUT
– LEVEL +
RANDOM
HI-LITE
1¡
4¢
783
123
456
789
10 >10
PROGRAM
Î
COMPACT DISC PLAYER
REMOTE CONTROL UNIT
PD-217 Only

6
1234
1234
C
D
F
A
B
E
PD-217
2. EXPLODED VIEWS AND PARTS LIST
2.1 PACKING
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to mark on product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
NOTES:
PD-117 Only
12
FRONT

7
1234
1234
C
D
F
A
B
E
PD-217
(1) PACKING PARTS LIST
• PACKING PARTS LIST
1 Styrol Protector R PHA1289
2 Styrol Protector L PHA1290
3 Packing Case
See Contrast table (2)
4 Packing Sheet Z23–007
(750 x 600 x 0.5)
5 Output Cable (L=1.0m) PDE1315
6 Operating Instructions PRE1296
(English/Spanish/Chinese)
NSP 7 Polyethylene Bag See Contrast table (2)
(340 ×230 ×0.03)
8 Caution 220V Label ARR1003
9 Remote Control Unit See Contrast table (2)
(CU–PD112)
10 Battery Cover
See Contrast table (2)
NSP 11 Dry Cell Batteries(AA/R6P) VEM1031
12 Control Cable (L=1.0m) See Contrast table (2)
Mark No. Description Part No.
(2) CONTRAST TABLE
PD-217/RFXJ and PD-117/RFXJ are constructed the same except for the following:
Part No.
Remarks
Mark PD-217/ PD-117/
RFXJ RFXJ
3 Packing Case PHG2370 PHG2369
NSP 7 Polyethylene Bag Z21–038 Not used
9 Remote Control Unit PWW1158 Not used
10 Battery Cover AZA7148 Not used
NSP 11 Dry Cell Batteries(AA/R6P) VEM1031 Not used
12 Control Cable (L=1.0m) Not used PDE-319
No. Symbol and Description

8
1234
1234
C
D
F
A
B
E
PD-217
2.2 EXTERIOR (1/2)
Mark No. Description Part No. Mark No. Description Part No.
1 MOTHER BOARD ASSY See Contrast table (2)
2 Strain Relief CM–22C
3 AC Power Cord PDG1075
4 Power Transformer PTT1238
5 Screw BBZ30P080FZK
6 Screw BBZ30P160FMC
NSP 7 PCB Spacer PNY-404
8 Screw PDZ30P050FMC
NSP 9 SINGLE MECHANISM ASSY PXA1593
10 Screw IBZ30P080FCC
11 Screw IBZ30P150FCC
12 Foot Assy AEC1531
NSP 13 Under Base PNA2177
14 Screw BBZ30P060FMC
15 Rear Base See Contrast table (2)
16 Binder (SKB–90BK) ZCA–SKB90BK
17 Caution Label DRW2168
NSP 18 HEADPHONE BOARD ASSY See Contrast table (2)
19 Headphone Knob See Contrast table (2)
(2) CONTRAST TABLE
PD-217/RFXJ and PD-117/RFXJ are constructed the same except for the following:
Part No.
Remarks
Mark PD-217/RFXJ PD-117/RFXJ
1 MOTHER BOARD ASSY PWM2139 PWM2136
15 Rear Base PNA2594 PNA2595
NSP 18 HEADPHONE BOARD ASSY PWZ2949 Not used
19 Headphone Knob PAC1707 Not used
No. Symbol and Description
(1) EXTERIOR PARTS LIST
EXTERIOR (1/2) PARTS LIST

9
1234
1234
C
D
F
A
B
E
PD-217
EXTERIOR (2/2) PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
2.3 EXTERIOR (2/2)
1 Bonnet PYY1182
2 Screw FBT40P080FZK
3 Screw BBZ30P080FZK
4 Tray Name Plate PNW2923
5 Screw IBZ30P080FCC
6 Display Window See Contrast table (2)
7 Name Plate PAM1776
8 Function Panel See Contrast table (2)
(2) CONTRAST TABLE
PD-217/RFXJ and PD-117/RFXJ are constructed the same except for the following:
Part No.
Remarks
Mark PD-217/RFXJ PD-117/RFXJ
6 Display Window PAM1849 PAM1856
8 Function Panel PNW2911 PNW2910
NSP 15 DISPLAY BOARD ASSY PWZ2937 PWZ2395
16 F ·F ·C/30V PDD1041 PDD1049
17 10 Key PAC1797 Not used
No. Symbol and Description
9 Mode Button PAC1796
10 Operate Button PAC1798
11 LED Lens PNW2019
12 Power Button PAC1708
NSP 13 SW BOARD ASSY PWZ2942
14 Screw PPZ30P100FMC
NSP 15 DISPLAY BOARD ASSY See Contrast table (2)
16 F ·F ·C/30V See Contrast table (2)
17 10 Key See Contrast table (2)

10
1234
1234
C
D
F
A
B
E
PD-217
2.4 SINGLE MECHANISM ASSY

11
1234
1234
C
D
F
A
B
E
PD-217
SINGLE MECHANISM ASSY PARTS LIST
1 Lever Switch (S601) DSK1003
2 Float Screw PBA1048
3 Rubber Belt PEB1193
4 Motor Pulley PNW3026
5 Tray Black V PNW2455
6 Float Base PNW2032
7 Drive Gear 2 PNW2369
8 Gear Pulley PNW2034
9 Clamper Base PNW2375
10 Clamp Cam PNW2364
11 D.C. Motor (0.75W, LOADING) PXM1010
12 Float Rubber B REB1287
13 Float Rubber G REB1288
14 Screw BPZ26P080FMC
15 Screw Z39-019
16 Screw BMZ26P040FMC
17 Pinion Gear PNW2055
NSP 18 D.C. Motor (CARRIAGE) PXM1027
19 D.C. Motor ASSY (SPINDLE) PEA1235
20 Carriage Base PNW2699
21 Disc Holder PNW1608
22 Screw JFZ20P030FNI
23 Screw JFZ17P025FZK
24 Gear 3 PNW2054
25 Gear 2 PNW2053
26 Washer WT12D032D025
27 PICK UP ASSY-S PEA1335
28 Guide Bar PLA1094
29 Gear 1 PNW2052
30 Gear Stopper PNB1303
31 Screw BBZ20P060FMC
32 FFC Holder PNW2734
33 Screw BPZ26P100FMC
34 Earth Lead Unit PDF1104
35 Screw BBZ26P060FMC
NSP 36 MECHANISM BOARD ASSY PWX1192
37 Clamp Magnet PMF1014
38 Yoke PNB1216
NSP 39 H Rubber PEB1249
40 Clamper S PNW1609
41 Loading Base PNW2376
42 D.C. Motor Assy (CARRIAGE) PEA1246
NSP 43 SERVO MECHANISM ASSY PXA1596
44 Binder Z09-056
45 Connector Assy (4P) RDE1043
46 Connector Assy (5P) PDE1239
47 PU Rack Spring ABH7077
48 Rack Holder PNW2056
49 16P F·F·C/30V PDD1185
Mark No. Description Parts No. Mark No. Description Parts No.

12
1234
1234
C
D
F
A
B
E
PD-217
53
18
19
16
33
223
3
4
7
5
6
8
23
-0.7V
1.8V
1.8V
0V
1.6V
1.6V
0V
1.6V
1.6V
0.2V
1.7V
1.7V
0V
0V
0V
5.0V
3.4V
5.0V
S801
A
PICK UP ASSY
PEA1335
SERVO MECHANISM ASSY
PXA1596
MECHANISM
BOARD
ASSY
PWX1192
SINGLE MECHANISM ASSY PXA1593
D801
SIGNAL ROUTE
: AUDIO SIGNAL
: AUDIO SIGNAL
: FOCUS SERVO LOOP
: TRACKING SERVO LOOP
: CARRIAGE SERVO LOOP
: SPINDLE DRIVE
: LOADING DRIVE
SPINDLE
MOTOR
ASSY
PEA1235
CARRIAGE
MOTOR
ASSY
PEA1246 CONNECTOR ASSY
RDE1043
PD-217 model Only PD-217 model Only
PD-217
PD-217
PD-117
PD-117
VCP1164
VCP1158
VCP1158
VCP1158
VCP1156
VCP1156
ABCD
DISPLAY BOARD ASSY
PWZ2937 : PD-217 TYPE
PWZ2935 : PD-117 TYPE
C
MOTHER BOARD ASSY
B
PWM2139 : PD-217 TYPE
PWM2136 : PD-117 TYPE
SW BOARD ASSY (PWZ2942)
D
3. SCHEMATIC DIAGRAM
3.1 MOTHER BOARD ASSY, DISPLAY BOARD ASSY and SW BOARD ASSY

13
5678
5678
C
D
F
A
B
E
PD-217
1.6V
1.6V 0V
0V
-9.2V
0V
-9.2V
0V
1.6V
1.6V
0V
HP BOARD ASSY
PWZ2949 : PD-217 TYPE Only
E
22/25
22/25
PD-217 TYPE
Only
AC POWER CORD
PDG1075
AC110-127V/220-240V
50/60Hz
POWER
TRANSFORMER
PTT1238
MTZJ5.1B/C
PIN No.
Volta-
ge(V)
PLAY
STOP
5.0
5.0
-23.2
-23.8
12345
-23.2 -23.2 -23.2
-23.7 -23.7 -23.8
678 9
-23.2
-23.8
-23.2
-23.8
-23.2
-23.8
-23.2
-23.8
10 11 12 13 14
-23.2
-23.8
-23.2
-23.8
4.9
0.2
15 16 17 18 19
-0.1
-0.1
-25.9
-26.4
-5.2
-5.2
20
PIN No.
Volta-
ge(V)
PLAY
STOP
21 22 23 24 25 26 27 28 29
4.9
4.9
-25.8 -26.2
30 31 32 33 34
4.9
4.8
4.0
2.5
35 36 37 38 39
4.9
4.9 1.3
1.0
40
4.8
4.9 2.9
4.0
2.3
0.1
0.0
0.1
0.0 1.3
1.0
PIN No.
Volta-
ge(V)
PLAY
STOP
41 42 43 44 45 46 47 48 49
1.0
1.2
50 51 52 53 54
4.9
1.2
4.9
4.9
55 56 57 58 59
4.9
4.9
0.1
0.1
60
4.9
4.9 4.9
2.3
2.3
2.2
2.2
0.1
0.1
4.9
4.9
1.3
1.0
1.3
1.0
5.0
5.0
1.2
1.0
-0.9
1.0
1.2
1.0
1.2
5.0
-1.0
4.9
6.8
4.9
61 62 63 64
0.1
0.1
0.1
0.1
0.1
0.1
0.1
0.1
DISPLAY BOARD ASSY
S701 : OPEN/CLOCE
S702 : STOP
S705 : RANDOM
S706 : HI-LITE SCAN
S708 : TIME
S710 : PROGRAM
S711 : DISPLAY OFF
S713 : REPEAT
S714 : EDIT
S715 : 5
S716 : 10
S717 : 1
S718 : 2
S719 : 3
S720 : 4
S721 : 6
S722 : 7
S723 : 8
S724 : 9
S725 : PLAY/PAUSE
S726 : TRACK
/MANUAL SEARCH REV
S727 : TRACK
/MANUAL SEARCH FWD
S728 : >10
SW BOARD ASSY
S801 : POWER STANDBY/ON
IC351(PD4835A)
1SS254
10
PD-217 model Only
PD-117 model Only
PD-217 model Only
B E
Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST"
: The power supply is shown with the marked box.

14
1234
1234
C
D
F
A
B
E
PD-217
TP1-Pin 1: PLAY MODE (RF)
500mV/div 500nsec/div
IC202-Pin 9: PLAY MODE (CADR)
0.2V/div 2sec/div
2
25
57
7
8
6
4
3
6'4'
TP1-Pin 1: TRACK SEARCH MODE
(RF)
500 mV/div 200 µsec/div
TP1-Pin 6: PLAY MODE (FOER)
100mV/div 10msec/div
TP1-Pin 2: PLAY MODE (TRER)
200mV/div 1msec/div
TP1-Pin 2: 50T - JUMP (*1) MODE
(TRER)
200mV/div 1msec/div
IC202-Pin 4: FOCUS-IN (*2) MODE
(FODR)
1V/div 200msec/div
IC202-Pin 4: PLAY MODE (FODR)
1V/div 1msec/div
IC202-Pin 3: PLAY MODE (TRDR)
500mV/div 1msec/div
IC202-Pin 3: 50T - JUMP (*1) MODE
(TRDR)
500mV/div 1msec/div
IC201-Pin 9: PLAY MODE (SPDR)
1V/div 50msec/div
IC201-Pin 9: TRACK SEARCH MODE
(SPDR)
2V/div 50msec/div
–VC –VC
–VC
–VC
–VC –GND
–GND
–GND
–GND
–GND
–GND
–GND
B
Waveforms (Mother Board Assy)
Note: The encircled numbers denote measuring point in the schematic diagram.
*1 50T-JUMP: After switching to the pause mode, press
the manual search key.
*2 FOCUS-IN: Press the play key without loading a disc.
3.2 WAVEFORMS MOTHER BOARD ASSY

15
1234
1234
C
D
F
A
B
E
PD-217
IC301-Pin 38 : PLAY MODE
(PCO)
2V/div 10 µsec/div
53
33
19
23
10
18
16
8IC202-Pin 9: TRACK SEARCH MODE
(CADR)
2V/div 200msec/div
IC301-Pin 86 : PLAY MODE (1kHz)
(LOUT 1)
1V/div 200msec/div
IC301-Pin 54 : PLAY MODE (1kHz)
(BCK)
2V/div 500nsec/div
IC301-Pin 50 : PLAY MODE (1kHz)
(LRCK)
2V/div 10 µsec/div
IC301-Pin 52 : PLAY MODE (1kHz)
(PCMD)
2V/div 500nsec/div
TRACK SEARCH MODE
Upper : TP1-Pin 1 (RF) 1V/div
Lower : IC151-Pin 23 (C.OUT)
2V/div 50 µsec/div
IC301-Pin 27 : PLAY MODE (MDP)
2V/div 2 µsec/div
–GND
–GND
–GND
–GND
–GND
–GND
–GND–GND
–GND

16
1234
1234
C
D
F
A
B
E
PD-217
CARRIAGE
MOTOR
M
SPINDLE
MOTOR
M
INSIDE
MECHANISM BOARD ASSY
A
HP BOARD ASSY
E
DISPLAY
BOARD ASSY
C
SW BOARD
ASSY
D
B
CN202
B
CN401
B
CN351
(PNP1239-C)
(PNP1386-A)
(PNP1386-A)
NOTE FOR PCB DIAGRAMS :
1. Part numbers in PCB diagrams match those in the schematic
diagrams.
2. A comparison between the main parts of PCB and schematic
diagrams is shown below.
3. The parts mounted on this PCB include all necessary parts for
several destinations.
For further information for respective destinations, be sure to
check with the schematic diagram.
4. View point of PCB diagrams.
Symbol In PCB
Diagrams
Symbol In Schematic
Diagrams Part Name
BCE
D
D
G
G
S
S
BCE
BCE
DGS
BCEBCE
BCE
Transistor
Transistor
with resistor
Field effect
transistor
Resistor array
3-terminal
regulator
Capacitor
Connector
P.C.Board Chip Part
SIDE A
SIDE B
AC D E
SIDE A
4. PCB CONNECTION DIAGRAM

17
1234
1234
C
D
F
A
B
E
PD-217
(PNP1424–B)
AC POWER CORD
VR151
VR152
Q391
Q452
Q454
Q404
Q403
Q453
Q451
Q405
IC406
IC405
IC31
IC401
IC34
Q341
Q151
Q152
IC202
IC21
Q321
VR153
VR154
VR155
VR156
BB
SIDE A
B
MOTHER BOARD ASSY
C
CN701
E
J501
A
CN610
To PICKUP ASSY
To LOADING MOTOR and CLAMP SW

18
1234
1234
C
D
F
A
B
E
PD-217
BB
SIDE B
BMOTHER BOARD ASSY
PNP1424–B
IC301
IC151
IC351

19
1234
1234
C
D
F
A
B
E
PD-217
5. PCB PARTS LIST
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
561
473
R50
1R0
5621
NOTES:
560
47k
0.5
1
RD1/4PU J
RD1/4PU J
RN2H K
RS1P K
56 x 10
1
47 x10
3
R50
1R0
561
473
5.62k RN1/4PC F562 x 10
1
5621
MOTHER BOARD ASSY PWM2139 PWM2136
NSP SUB BOARD ASSY PWX1400 PWX1398
NSP DISPLAY BOADR ASSY PWZ2937 PWZ2935
NSP SW BOARD ASSY PWZ2942 PWZ2942
NSP HP BOARD ASSY PWZ2949 Not used
NSP SINGLE MECHANISM ASSY PXA1593 PXA1593
NSP SERVO MECHANISM ASSY PXA1596 PXA1596
NSP MECHANISM BOARD ASSY PWX1192 PWX1192
LIST OF WHOLE PCB ASSEMBLIES
CONTRAST OF PCB ASSEMBLIES
MOTHER BOARD ASSY
PWM2139 and PWM2136 are constructed the same except for the following:
IC406 BA15218 Not used
D392- D394 Not used 1SS254
C470 CKCYF103Z50 Not used
C393 Not used CCCSL101J50
L391 Not used LAU1R0J
R391 Not used RD1/4PU244J
R392 Not used RD1/4PU102J
R470, R471 RD1/4PU470J Not used
R472, R473 RD1/4PU102J Not used
CN351 HLEM32S-1 HLEM30S-1
CN401 52147-0310 Not used
JA391, JA392 Not used RKN1004
Mark Remarks
Symbol and Description Part No.
PWM2139 PWM2136
Mark Symbol and Description Part No.
PD-217/RFXJ PD-117/RFXJ Remarks

20
1234
1234
C
D
F
A
B
E
PD-217
OTHERS
CN202 MT 4P CONNECTOR 173981-4
CN205 MT 5P CONNECTOR 173981-5
CN351 32P FFC CONNECTOR HLEM32S-1
JA401 2P JACK PKB1023
JA393 JACK PKN1005
X341 XTAL RES (16.9344 MHz) PSS1008
CN201 CONNECTOR 6P RKP-533
CN131 CONNECTOR SLW16S-1C7
X351 CERAMIC RESONATOR VSS1014
(4.19MHz)
CN401 3P JUMPER CONNECTOR 52147-0310
TERMINAL RKC–061
S5 VOLTAGE SELECTOR PSB1006
DISPLAY BOARD ASSY
SEMICONDUCTORS
D701–D707 1SS254
CAPACITOR
C701 CKCYF103Z50
SWITCHES
S701, S702, S705, S706, S708, S710 PSG1006
S711, S713–S728 PSG1006
OTHERS
CN702 4P JUMPER CONNECTOR 52147-0410
CN701 CONNECTOR HLEM32R-1
V701 FL INDICATOR TUBE PEL1085
REMOTE SENSOR SBX1976-51
SEMICONDUCTOR
D801 PCX1019
SWITCH
S801 PSG1006
OTHER
J801 2mm JUMPER WIRE D20PWY0405G
HP BOARD ASSY
RESISTOR
VR501 (5kΩ- B)PCS1003
COILS AND FILTERS
L501, L504, L505 (AXIAL INDUCTOR) LAU1R0J
CAPACITORS
C501, C502 CKCYF223Z50
C504 CKCYF473Z50
OTHERS
JA501 HP JACK RKN1002
J501 3P JUMPER WIRE D20PWY0310G
C
DSW BOARD ASSY
E
MOTHER BOARD ASSY
B
Mark No. Description Part No.
PARTS LIST FOR PD-217/RFXJ Mark No. Description Part No.
SEMICONDUCTORS
IC406 BA15218
IC151 CXA1782CQ
IC301 CXD2519Q
IC31, IC34 ICP-N10
IC201, IC202 LA6520
IC405 NJM4558D-D
IC351 PD4835A
IC21 PQ05RR12
Q151 2SA854S
Q391 2SC1740S
Q403, Q404 2SD2144S
Q152 DTA124ES
Q405 DTC124ES
Q341 2SK246
D341, D351, D352, D395–D397 1SS254
D54 MTZJ18B
D359 MTZJ5.1B
D218 MTZJ6.2B
D11–D14, D52 S5688G
COILS AND FILTERS
L351 (RADIAL INDUCTOR) LFA100J
L395, L396 (RADIAL INDUCTOR) LFA1R0J
CAPACITORS
C181 CCCCH100D50
C341, C342 CCCCH120J50
C383 CCCSL181J50
C315 CCCSL221J50
C481, C482 CCCSL390J50
C309 CEASR47M50
C171, C175, C301, C311–C314 CEAS101M10
C316, C302 CEAS101M10
C52 CEAS101M35
C26 CEAS102M16
C433, C434 CEAS220M25
C27, C131–C133, C431, C432 CEAS330M16
C25 CEAS332M16
C169, C170, C356 CEAS4R7M50
C351 CEAS471M6R3
C156, C161, C164, C168, C218 CGCYX103K25
C160 CGCYX333K25
C167 CGCYX472K25
C152, C307 CGCYX473K25
C157 CGCYX823K25
C163 CKCYB102K50
C176, C306, C441, C442 CKCYB152K50
C305 CKCYB222K50
C162 CKCYB332K50
C151 CKCYB682K50
C29, C159, C205, C210 CKCYF103Z50
C215, C219, C304, C310, C353 CKCYF103Z50
C357, C382, C470 CKCYF103Z50
C11, C13, C15, C16, C17 CKCYF103Z50
C153, C154, C155, C158 CQMBA104J50
RESISTORS
VR153, VR155 (10kΩ- B)VCP1156
VR151, VR152, VR154 (22kΩ- B)VCP1158
VR156 (220kΩ- B)VCP1164
Other Resistors RD1/4PU&&&J