Polar Refrigeration CK490-A User manual

Model:
CK490-A/CK491-A/CK492-A
Stainless Steel Counter
Display Refrigerators
Instruction manual
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 1 2019/6/3 10:23

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g.
heaters, ice cream makers etc.)
• DO NOT stand or support yourself on the base, drawers or doors.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
• Polar recommend that this appliance is PAT tested on an
annual basis to ensure the product remains safe.
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 2 2019/6/3 10:23

3
AUAU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
Caution Risk of Fire
• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
CK490-A - POLAR 2 Door Counter Bar Refrigerator
CK491-A - POLAR 3 Door Counter Bar Refrigerator
CK492-A - POLAR 4 Door Counter Bar Refrigerator
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
• POLAR Refrigerator
• Shelf guides (4 per door)
• Shelves (2 per door)
• Instruction manual
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 3 2019/6/3 10:23

4
AU Telephone Helpline: 1300225960
Installation
Note: If the unit has not been
stored or moved in an upright
position, let it stand upright for
approximately 12 hours before
operation. If in doubt allow to
stand.
1. Remove the appliance from the packaging.
Make sure that all protective plastic film and
coatings are thoroughly removed from all
surfaces.
2. Maintain a distance of 20cm (7 inches)
between the unit and walls or other objects for
ventilation. NEVER LOCATE NEXT TO OR
NEAR A HEAT SOURCE.
Note: Before using the appliance
for the first time, clean the
shelves and interior with soapy
water.
3. Set the brakes on the castors to keep the
appliance in position
OR
Level the appliance by adjusting the screw
feet.
Fitting the Shelves & Floor Guards
1. Place one set of shelf guides on either side of
the cabinet at the desired height.
2. Slide the shelf into place.
3. Repeat for the remaining shelves.
4. Place the floor guards on the floor of the
cabinet, ensuring the flat side is clear of the
floor.
Note: This is vital for
ensuring correct drainage of
condensation.
Operation
Storing Food
To get the best results from your POLAR appliance,
follow these instructions:
• Only store foodstuffs in the appliance when it
has reached the correct operating temperature.
• Do not place uncovered hot food or liquid
inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods
of time.
Turn On
1. Close the doors/drawers of the appliance.
2. Ensure the power switch is set to [O] and turn
on at the socket.
3. Switch on the Power [I]. The current
temperature within the appliance is displayed.
Control Panel
Defrost LED
Compressor LED Up button
Down buttonFans enabled LED
Defrost button
SET button
To See the Setpoint
Push and immediately release the SET key. The
display will show the Setpoint value.
Changing the Setpoint
1. Push the SET key for more than 2 seconds to
change the Setpoint value.
2. The value of the set point will be displayed and
the COMPRESSOR LED starts blinking.
3. To change the Set value push and
buttons within 10 seconds.
4. To store the new Setpoint push the SET key or
wait 10 seconds.
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 4 2019/6/3 10:23

5
AUAU
Telephone Helpline: 1300225960
Manual Defrost
The appliance will automatically run a defrost cycle
every six hours.
Note: The cycle starts from the
time the appliance is initially
powered up.
To manually defrost the appliance:
1. Press and hold the “aux” button for more than
2 seconds.
2. The defrost cycle will start immediately and the
Defrost LED illuminates.
Note: Starting a manual defrost
also resets the automatic
defrost timer.
3. The next automatic defrost will start six hours
after the manual defrost has finished.
Cleaning, Care &
Maintenance
• Switch off and disconnect from the power
supply before cleaning.
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run
through the drain hole into the evaporation pan.
• Take care when cleaning the rear of the
appliance. Sharp edges can cut.
• A POLAR agent or qualified technician must
carry out repairs if required.
Cleaning the Condenser
Periodically cleaning the condenser can extend the
life of the appliance.
POLAR recommend that a POLAR agent or qualified
technician clean the condenser.
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline or your POLAR dealer.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance
turns on, but the
temperature is too
high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Clean condenser with hose attachment of
vacuum
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a heat
source or air flow to the condenser
is being interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or
blockages to the fan
Appliance is overloaded Reduce the amount of food stored in the
appliance
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 5 2019/6/3 10:23

6
AU Telephone Helpline: 1300225960
Fault Probable Cause Solution
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance
(if applicable)
The discharge outlet is blocked Clear the discharge outlet
Movement of water to the drain is
obstructed
Clear the floor of the appliance
(if applicable)
The water container is damaged Call POLAR agent or qualified Technician
The drip tray is overflowing Empty the drip tray (if applicable)
The appliance is
unusually loud
Loose nut/screw Check and tighten all nuts and screws
The appliance has not been installed
in a level or stable position
Check installation position and change if
necessary
Technical Specifications
Model Voltage Power Current Temp.
Range
Capacity
(litres)
Refrige-
rant
Dimensions
H x W x D (mm)
Weight
(Kg)
CK490-A 220-240V 50Hz 360W 1.8A 2°C to 6°C 366 R290 85g 1060 x 1505 x 600 120
CK491-A 220-240V 50Hz 360W 1.8A 2°C to 6°C 543 R290 85g 1060 x 2005 x 600 150
CK492-A 220-240V 50Hz 360W 1.8A 2°C to 6°C 720 R290 85g 1080 x 2505 x 600 180
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 6 2019/6/3 10:23

DECLARATION OF CONFORMITY
Equipment Type
Premium Bar Fridge 2 Door
Premium Bar Fridge 3 Door
Premium Bar Fridge 4 Door
Model
CK490-A
CK491-A
CK492-A
Legislation
Electrical Safety
Electromagnetic Compatibility
Standards
AS/NZS 60335.1:2011+A1:2012 +A2:2014 +A3:2015 +A4:2017
AS/NZS 60335.2.89:2010 +A1:2013+A2:2016
EN55014-1:2017
EN55014-2:2015
EN61000-3-2:2014
EN61000-3-3:2013
Producer Name
Polar
Producer Address
15 Badgally Road,
Campbelltown,
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Legislation and Standard(s).
Date
29th April 2019
Signature
Full Name
Ashley Hooper
Position
Technical & Quality Manager/ Responsible Supplier
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 7 2019/6/3 10:23

CK490-A_CK491-A_CK492-A_A5_v2_20190603
http://www.polar-refrigerator.com/
CK490-A_CK491-A_CK492-A_A5_v2_20190603.indb 8 2019/6/3 10:23