Princess auto LMTDF-46L User manual

LMTDF-46L
User Manual

Table of Content / Innehllsfrteckning / Innholdsfortegnelse
English
Safety Instructions 4-7
Overview 8-9
Operation 10-14
Troubleshooting 15
Specifications 16
Other 17
Doc 18

English4
Safety instructions
Warning:
ÆTo reduce the risk of electric shock, do not
remove cover. No user serviceable parts inside.
Refer servicing to qualified service personnel.
ÆEnsure the equipment is not too close to heat
emitting appliances or placed in direct sunlight.
ÆDo not immerse the equipment in water or any
other liquids.
ÆRepairs to electrical appliances should only be
performed by qualified personnel.
ÆImproper repairs may place the user and/or
equipment at serious risk.
ÆThis equipment is intended for household use
only and should not be used for industrial or
commercial purposes.
ÆDo not operate this appliance after being
dropped or damaged in any way.
ÆIf the power adapter is damaged, it must
be replaced by the manufacturer or similarly
qualified persons in order to avoid a hazard.
ÆDo not use this equipment for anything other
than its intended use.
ÆDo not push objects into any openings as
damage to the equipment.
ÆRead the manual and safety instructions
carefully before you start riding the product.
ÆCheck for damage and loose parts before use.
ÆDo not modify any parts of the product. It may
damage the performance of the product and
highly increases the risk of injuries.
ÆThis appliance can be used by persons aged
above 12 years and persons with reduced
physical, sensory or mental capabilities or lack
of experience and knowledge if they have been
given supervision or instruction concerning use
of the appliance in a safe way and understand
the hazards involved.
ÆChildren shall not play with the appliance.
ÆCleaning and user maintenance shall not be
made by children without supervision.
Speed limit:
ÆThe maximum speed of the product is 25 km/h.
ÆWhen driving below the maximum speed, you
will more easily keep the balance.

5English
Safety instructions
Weight and height limit:
ÆMax. load: 120 kg
Battery and charging:
ÆConnect the power adapter to the product
before connecting it to a wall outlet to avoid
electric sparks.
ÆThe battery must be removed from the
appliance before it is scrapped.
ÆThe appliance must be disconnected from the
supply mains when removing the battery.
ÆThe battery is to be disposed of safely.
ÆDo not use any other charging devices but the
included power adapter to charge the product.
The longest distance depends on:
ÆTerrain: Riding on a smooth, flat ground
increases the total range.
ÆWeight: The weight of the driver affects the
distance.
ÆSurrounding temperature: Use or storage of
the product below or above the recommended
temperatures will reduce the distance.
ÆMaintenance: Reasonable charging and
maintenance of the battery can increase the
range.
ÆSpeed and driving style: Medium speed
increases the range. Frequent start, stop,
acceleration and deceleration will reduce the
distance.

English6
Safety instructions
Driving:
´Do not under any circumstances use the the
product if you are likely to lose control, collide,
fall or cause any other harm. Ensure that the
product is in good condition before you use it.
´Suggest wear helmet, knee and elbow pads etc
when use the product.
´The product is only for personal use, it is
prohibited to commercial use.
´Children shall not weigh less than 30 kg and if
they weigh below 45 kg the the product may
only be used under supervision from an adult
that is responsible for their safety.
´People with high blood pressure and/or heart
disease, people with lack of experience, old
people or people with disabilities and pregnant
women shall not use the product.
´Do not ride the product under the influence of
alcohol or drugs.
´Do not use the product to transport goods.
´Comply with local traffic laws when riding the
product.
´Ensure you keep a good view of the
surroundings.
´Suggest se sports clothes when riding the
product, it helps you handle steering and falling
better.
´Do not carry one or more people on the
product.
´Total weight of user and belongings shall not
exceed the maximum load of the product. This
may cause risk of injuries and damage to the
product.
ÆKeep the speed of the product at a controllable
level to ensure safety of the driver and others.
ÆIf driving the product and an accident occurs,
wait for the help to arrive for a reasonable and
lawful process.
ÆWhen driving the product with other drivers,
keep a certain distance between each other in
order to avoid a collision.
ÆPay attention to the position of you body centre
when steering. When the centre of gravity gets
offset or moves too fast you might fall off.
ÆDo not get distracted when driving the product.
ÆDo not answer the phone, listen to music, or

7English
Safety instructions
engage in any other activities.
ÆDo not push the driver to gain extra speed.
ÆDo not drive the product in dim light or dark
places to avoid an accident.
ÆAvoid driving on slippery surfaces. Such as ice,
snow and wet floors.
ÆAvoid driving on scattered objects, branches,
trash or a pebbles.
ÆAvoid driving in narrow spaces.
ÆDo not drive the product in places where driving
is not allowed. Obtain permission to use the
product in that certain place first.
ÆDo not start or stop the product suddenly.
ÆAvoid driving on a steep slope.
ÆDo not drive the product in environments
containing flammable gas, liquid, dust or fibre.
Don’t drive in rain or on wet
surfaces.
Don’t drive on gravel road or in a
high speed for a long time.

English8
Overview
Bike:
1. Throttle
2. Throttle lock
3. Dash board
4. Bell
5. Power/Mode button
6. Up button
7. Down button
8. Brake
9. Head light
10. Front wheel
11. Back wheel
12. Seat
13. Back light
14. Kick stand
15. Pedal
16. Chain wheel
17. Chain
18. Battery
19. Battery lock and key
20. Power button
1
3
2
4
7
6
8
8
5

9English
Overview
9
10 11
12
13
14
15
16 17
18
20
19

English10
Operation
Assemble the Bike
1. Install the handle bar.
´Insert front fender and make sure it is in place.
´Tighten the handle bar.
2. Install front wheel
´Use the Axle to fixed the front wheel
´Tighten the screw on one side of the axle.
´Tighten the Quick lock on another side of the axle.

11English
3. Install front fender
4. Install pedals
´Install the pedals in place by securely tightening with a 15mm
wrench.
Note: “L” and “R” are marked on the threaded fitting of the
pedals.
Left and right side is determined by sitting on the seat.
5. Install Front light
´Before assemble, prepare below parts:
´Loosen the screws on the front light.
´Put the lamp shade C and holder A into the front light and fixed
by screws.
Note: Do not fix the screws too tight.
Operation

English12
´Put the light with holder A on the front suspension bar, and
fixed with holder B. .
Note: Put the holder A outside and holder B inside.
´Tighten all the screws after fix the front light’s position.
´Connect front light’s wire and put the wires inside front light’s
rear space, finished.
6. Battery installation and remove
´The battery has been installed at begining.
´Rotate the key anticlockwise to unlock the battery and pull up
to remove it.
Operation

13English
Operation
Steer the bike:
1. Press the power button on the battery to turn on the
battery power.
2. Long press the M button to turn on the bike. The dash
board lights up ; Long press the M button again to turn off
the bike. The dash board will be off.
3. Rotate the throttle lightly to accelerate the vehicle and
rotate harder the speed goes faster.
Note: Be accelerate according to the proficiency to
assure safety, and accelerate gradually for initial use.
4. Throttle lock
Press down the throttle lock switch to lock the throttle,
the LCD shows Error 008.
´At this mode, the vehicle won’t accelerate when rotating
the throttle, you can ride the bike by pedal.
´At this mode, long press the button to move in fixed
speed 6KM/h even though loosen the accelerator, it
won’t decelerate until you brake.
5. Pedal assistant
This vehicle has pedal assistant. When you ride the pedal,
the motor will start work automatically to bring you faster
speed while pedaling.
When you stop riding, the motor will stop as well.
6. Pedal assistant level
Single press the and button to switch speed
between level 1, 2, 3, 4 and 5.
´Level 1: maximum speed is around 12km/h.
´Level 2: maximum speed is around 15 km/h.
´Level 3: maximum speed is around 17km/h.
´Level 4: maximum speed is around 21km/h.
´Level 5: maximum speed is around 25km/h.
7. Lightly hold the brake to decelerate, hold harder and the
deceleration more obvious.
Note: The left brake is for rear brake and the right one is
for front brake.
Note: Be brake in advance when the barriers are in the
front.
8. Mileage mode
Press the M button to show the different mileage mode:
´TRIP (cumulative mileage of this boot running)
´ODO (cumulative mileage of the bike’s record)
7. Light
Long press the button to turn on the front and rear
light.
Long press the button again to turn off the front and
rear light.

English14
Battery indicator:
´The Battery has 4 lights to indicate different battery level:
Indicate 4 lights The battery level is good.
Indicate 3 lights The battery level is at 71% - 85%.
Indicate 2 lights The battery level is at 50% - 70%.
Indicate 1 lights The battery level is low. Charge the
battery immediately.
Adjusting the brake:
1. Use the M5 hex wrench anti-clockwise to release the
plate screws on back wheel, adjust the length of exposed
tail, shorten for tighting and lengthen for loosing the
brake.
2. Lock the pressure plate screws by rotating clockwise.
Inflate the tires:
1. Remove the front and rear tire inflatable mouth cap.
2. Connect the pump to inflate and tight it to the inflatable
mouth.
Max inflate to 1.4bar
Normal inflate to 1.2bar
Note: We recommend a hand pump to avoid over
inflating the tires.
3. Replace the mouth cap when finish pumping.
Maintenance:
1. Wipe the exterior with a damp sponge.
Note: Do not use any abrasive cleaning or scouring
products. This may damage the surfaces.
2. Wipe the wheels with a damp sponge to remove any dirt.
Storage:
´Store the bike where it is not exposed to moisture, dust,
direct sunlight, extremely high or low temperatures.
´Store the bike out of reach from children.
Charge the product before storing for a long
time and charge it every 1 month to maintain
the battery.
Operation

15English
Troubleshooting
Problem Cause Solution
The bike is smelling
burned or is very hot.
The battery is damaged or overheated. Do not touch the battery. Bring the bike to a
service centre.
The battery is leaking. The battery is damaged or overheated. Do not touch the battery or the leakage. Bring the
bike to a service centre.
The bike is running slow
or sluggishly.
The battery is low, damaged or
overheated.
Do not touch the battery. Contact a service shop
on whether to charge the battery or bring the bike
to the service centre.
Code Error
002 Brake Error
003 Power Sensor Error (riding mark)
005 Cruise error
006 Low Battery Voltage
007 Motor Error
008 Throttle lock
Code Error
009 Controller Error
010 Communications Receiving Error
011 Communications Sending Error
012 BMS Communications Error
013 Light Error
021-030 Program Error
Error code description

English16
Specifications
Product name EVB 700
Power of motor 500 W
Battery type Lithium battery
Battery voltage 48 V
Battery capacity 10 Ah
Battery charging time 5 hours
Maximum distance Up to 45 km
Maximum speed Up to 25 km/h
Maximum climb angle 19°
Maximum weight 120 kg
Wheel size 20”
Storing temperature 0 - 40°C
Included in packaging - Bike
- Assembly tools
- Keys
- Charger
- User manual
Dimensions 1740 x 640 x 1100 mm
Weight 30 kg

17English
Other
Copyright:
This manual is the copyright of CI no 556520-4137. No part
of this manual may be revised, copied or transmitted in any
way without written permission from CI no 556520-4137.
Recycling:
This product’s packaging materials are recyclable
and can be reused. This product and the accessories
packed together are the applicable product to the
WEEE directive except batteries. Please dispose of
any materials in accordance with your local recycling
regulations. When discarding the unit, comply with
your local rules or regulations. Batteries should never
be thrown away or incinerated but disposed of in accordance
with your local regulations concerning chemical wastes.
Law and Safety:
The CE mark indicates that this product has been
manufactured according to current regulations
for electromagnetic fields, which means that it is safe
to use if used according to safety instructions. The product
is manufactured according to current regulations within the
EU legislation, limiting the use of hazardous substances in
electrical and electronic equipment.
Statement:
This manual does not provide any warranty or related
declarations. All information in this manual including the
product specification, pictures and literatures is just for
reference, CI no 556520-4137 reserves the rights to
update contents of this manual without further notice.