PURSUIT S358 SPORT 2022 User manual

OWNER’S MANUAL
FEBRUARY 2022

CALIFORNIA
PROPOSITION 65 WARNING
WARNING: OPERATING, SERVICING AND MAINTAINING
A RECREATIONAL MARINE VESSEL CAN EXPOSE
YOU TO CHEMICALS INCLUDING ENGINE EXHAUST,
CARBON MONOXIDE, PHTHALATES, AND LEAD,
WHICH ARE KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. TO MINIMIZE EXPOSURE,
AVOID BREATHING EXHAUST, SERVICE YOUR VESSEL
IN A WELL-VENTILATED AREA AND WEAR GLOVES OR
WASH YOUR HANDS FREQUENTLY WHEN SERVICING
THIS VESSEL. FOR MORE INFORMATION GO TO
WWW.P65WARNINGS.CA.GOV/MARINE.
WARNING
!

Safety Information
S 358 SPORT
Your Owner’s Manual was written to include
safety instructions to ensure safe operation
and maintenance of your boat. Safety alert
symbols are used to alert potential personal
injury hazards.
DANGER
!
Indicates a hazardous situation which,
if not avoided, will result in death or
serious injury.
WARNING
!
Indicates a hazardous situation which,
if not avoided, could result in death or
serious injury.
CAUTION
!
Indicates a hazardous situation which,
if not avoided, could result in minor or
moderate injury.
NOTICE
!
Indicates a potentially hazardous situ-
ation which, if not avoided, may result
in property damage.
All instructions are viewed from the stern
looking toward the bow, with starboard (to
your right) and port (to your left). A glossary
of boating terms is included.
Your boat produces carbon monoxide (CO)
and uses flammable fuel. CO will cause
BRAIN DAMAGE or DEATH. Carbon mon-
oxide gas (CO) is colorless, odorless and
extremely dangerous.
Every precaution has been taken by Pursuit
Fishing Boats to reduce the risks associated
with death, possible injury and damage from
re or explosion. Your own precaution and
good maintenance procedures are necessary
in order to enjoy safe operation of your boat.
DANGER
!
Exposure to carbon monoxide will
cause death or serious injury. Avoid
direct and prolonged exposure to CO.
Gasoline and other fuels are extremely
ammable and highly explosive under
certain conditions.
• DO NOT smoke or allow open
ame or sparks nearby when
fueling.
• DO NOT block fuel vents.
• DO NOT store fuel in any
containers or compartments
which are not designated for
storing fuel.

Safety Information
S 358 SPORT
Operator Notes

Table of Contents
i
S 358 SPORT
Safety Label Locations
Interior ....................................................... 1
Exterior ....................................................... 2
Exterior ....................................................... 3
Hardtop....................................................... 4
Label Table ............................................ 5,15
General Information
Engine and General Specications .......... 17
Boat Information ....................................... 18
Warranty & Warranty Registration Cards . 19
Federal Boating Safety Act ...................... 19
Product Changes ..................................... 19
Transferring the Warranty ........................ 19
Responsibilities......................................... 20
Registration and Documentation .............. 20
Insurance.................................................. 20
Reporting Boating Accidents .................... 21
Education.................................................. 21
Required Equipment................................. 21
EPA Compliant Fuel System..................... 21
Propulsion Systems
1.1 General.............................................. 1-1
1.2 Saltwater Application ......................... 1-1
1.3 Engine Lubrication............................. 1-2
1.4 Engine Cooling System ..................... 1-2
1.5 Propellers .......................................... 1-2
1.6 Engine Instrumentation...................... 1-2
Helm Systems
2.1 General.............................................. 2-1
2.2 Helm Access...................................... 2-1
2.3 Engine Throttle and Shift Controls..... 2-1
2.4 Neutral Safety Switch ........................ 2-2
2.5 Engine Power Tilt and Trim................2-2
2.6 Engine Stop Switch ........................... 2-3
2.7 Automatic Fire Suppression System.. 2-3
2.8 Steering System ................................ 2-3
2.9 Trim Tabs ........................................... 2-4
2.10 Compass ......................................... 2-5
2.11 Bow Thruster ................................... 2-5
2.12 Spotlight (Optional).......................... 2-5
2.13 Control Systems Maintenance......... 2-5
Fuel Systems
3.1 General.............................................. 3-1
3.2 Fuel System....................................... 3-1
3.3 Diesel Generator Fuel System
(Optional) .................................... 3-3
3.4 Fueling Instructions .......................... 3-4
3.5 Fuel System Maintenance ............... 3-5
Electrical Systems
4.1 General.............................................. 4-1
4.2 DC System ........................................ 4-1
4.3 12-Volt DC Switches.......................... 4-5
4.4 AC System ........................................ 4-9
4.5 AC Main Distribution ......................... 4-9
4.6 Battery Charger Operation .............. 4-12
4.7 Shore Power Connection................. 4-13
4.8 Generator ........................................ 4-13
4.9 Electrical System Maintenance ....... 4-15
Plumbing Systems
5.1 Fresh Water System.......................... 5-1
5.2 Raw Water Washdown ...................... 5-5
5.3 Livewell.............................................. 5-6
5.4 Drainage............................................ 5-6
5.5 Plumbing System Maintenance......... 5-8
Ventilation Systems
6.1 Cabin Ventilation................................ 6-1
6.2 Carbon Monoxide and Proper
Ventilation ................................... 6-1

Table of Contents
ii S 358 SPORT
6.3 Bilge Compartment Ventilation .......... 6-1
6.4 Maintenance...................................... 6-1
Exterior Equipment
7.1 Forward Deck .................................... 7-1
7.2 Cockpit............................................... 7-3
7.3 Transom Tackle Storage ................... 7-5
7.4 Transom............................................. 7-6
7.5 Hardtop.............................................. 7-6
7.6 Tower (Dealer Installed)..................... 7-7
7.7 Sea Keeper 2 Gyro (Optional)........... 7-8
Interior Equipment
8.1 Companionway Door......................... 8-1
8.2 Main Cabin ........................................ 8-1
8.3 Carbon Monoxide Detector................ 8-1
8.4 Climate Control (Optional)................. 8-1
8.5 Head Compartment ........................... 8-2
Safety Equipment
9.1 General.............................................. 9-1
9.2 Engine Alarms ................................... 9-1
9.3 Neutral Safety Switch ........................ 9-1
9.4 Engine Stop Switch ........................... 9-1
9.5 Automatic Fire Extinguishing
System ........................................ 9-2
9.6 Carbon Monoxide Hazards................ 9-2
9.7 First Aid.............................................. 9-5
9.8 Required Safety Equipment............... 9-6
9.9 Additional Safety Equipment.............. 9-8
Operation
10.1 General.......................................... 10-1
10.2 Homeland Security Restrictions .... 10-1
10.3 Rules of the Road.......................... 10-2
10.4 Pre-Cruise Check .......................... 10-3
10.5 Operating your Boat ...................... 10-4
10.6 Fishing........................................... 10-6
10.7 Tower Operation (Optional
Equipment)................................ 10-6
10.8 Docking, Anchoring and Mooring... 10-7
10.9 Controls, Steering or Propulsion
System Failure ......................... 10-9
10.10 Collision ...................................... 10-9
10.11 Grounding, Towing and Rendering
Assistance ................................ 10-9
10.12 Flooding or Capsizing ............... 10-10
10.13 Transporting your Boat ............. 10-10
10.14 Man Overboard .........................10-10
10.15 Trash Disposal .......................... 10-11
Routine Maintenance
11.1 General ......................................... 11-1
11.2 Exterior Hull and Deck .................. 11-1
11.3 Seats, Upholstery, Canvas and
Enclosures ............................... 11-5
11.4 Cabin Interior ................................ 11-6
11.5 Bilge .............................................. 11-6
11.6 Generator ...................................... 11-7
Seasonal Maintenance
12.1 Storage and Lay-up....................... 12-1
12.2 Winterizing .................................... 12-2
12.3 Recommissioning ......................... 12-5
Appendices
Glossary of Terms....................................A-1
Maintenance Schedule............................B-1
Boating Accident Report......................... C-1
Float Plan ............................................... D-1
Troubleshooting Guide ............................E-1
Schematics..............................................F-1
Additional Information............................. G-1
Seakeeper 2 Gyro .................................. G-5
Aquatic Invasive Species........................ H-1

Safety Label Locations
1
S 358 SPORT
The following safety labels can be found on the Pursuit S 358 Sport. The numbers
correspond to the list in the table below. To obtain replacement labels refer to the part
number of the label in the table and contact your Pursuit dealer.
Interior
48

Safety Label Locations
2S 358 SPORT
Exterior
13,14,21,68,69
1,81
36
74
62
56
12,35
38,47
39
57
16
13,14
The numbers correspond to the
list in the table. To obtain
replacement labels refer to the
part number of the label and
contact your Pursuit dealer.
13
79,80

Safety Label Locations
3
S 358 SPORT
Exterior
8,10,16,38,49,60
11
9,43
67
54,55,67,70
67
67
67
67
61
41
67

Safety Label Locations
4S 358 SPORT
Hardtop
44

Safety Label Locations
5
S 358 SPORT
Label Table
Labels and Logos
LABEL, WARNING SUNSHADE STOWAGE
P/N: 5450054
7
8
TAG, OVERBOARD DISCHARGE YELLOW
P/N: 5450050
6
TAG, WARNING ETHANOL FUEL
P/N: 5450041
4
5
LABEL, WARNING CO HATCH
P/N: 5437750
LOGO: "P" SMALL PLATINUM
P/N: 5437700
3
LABEL, WASHDOWN/BAITWELL PICKUP
P/N: 5435220
P/N: 5346801
2
LABEL, CAUTION - HOT WATER HEATER
P/N: 5430190
1
LOGO: "P" 12V LED, LIGHTED

Safety Label Locations
6S 358 SPORT
Labels and Logos
LABEL, BOARDING DOOR WARNING
P/N: 5450551
16
15
LABEL, TRANSOM DOOR WARNING
P/N: 5450550
14
LABEL, "RAW WATER"
P/N: 5450270
13
LABEL, "FRESH WATER"
P/N: 5450260
12
LABEL, "110 VOLTS" RED ON WHITE
P/N: 5450170
11
LABEL, BOATMAN'S CHECKLIST
P/N: 5450120
10
LABEL, FUEL SYSTEM WARNING MYLAR
P/N: 5450060
9
LABEL, NOTICE DASH PANEL CLEANING
P/N: 5450055

Safety Label Locations
7
S 358 SPORT
Labels and Logos
23
24
PLATE, YACHT CERTIFICATION
OVER 26' ALL
LABEL, STORAGE AREA NOTICE
MYLAR 3"X1-1/8
LABEL, GELCOAT DAMAGE NOTICE MYLAR 3"
LONG
TAG, LEXAN "HEAD OVERBOARD
DISCHARGE"
P/N: 5450805
P/N: 5450800
P/N: 5450650
17
18
19
20
21
22
TAG, LEXAN "GENERATOR PICKUP"
LABEL, "FORWARD" MECHANICAL HATCH
P/N: 5450730
P/N: 5450720
P/N: 5450710
LABEL, FISH BOX VALVE STBD
P/N: 5450585
LABEL, FISH BOX VALVE PORT
P/N: 5450580

Safety Label Locations
8S 358 SPORT
Labels and Logos
TAG, LEXAN "FUEL SYS ENG WITHDRAWL
STBD"
TAG, LEXAN "FUEL SYS ENG WITHDRAWL
PORT"
TAG, LEXAN "FUEL SYS GENERATOR
WITHDRAWL"
TAG, LEXAN "FUEL SYSTEM GENERATOR
RETURN"
P/N: 5450840
TAG, LEXAN "TO DECK PUMPOUT"
P/N: 5450835
P/N: 5450830
P/N: 5450825
P/N: 5450815
TAG, LEXAN "BAITWELL PICKUP"
P/N: 5450845
P/N: 5450810
TAG, LEXAN "WASHDOWN PICKUP"
P/N: 5450820
32
31
30
29
28
27
26
25
TAG, LEXAN "AIR CONDITIONING PICKUP"

Safety Label Locations
9
S 358 SPORT
Labels and Logos
LABEL, NO SMOKING
LABEL, CAPACITY TOWER Y8
LABEL, SWIM LADDER WARNING
39
P/N: 5451750
40
LABEL, MANUAL DOOR OVERRIDE "UP"
P/N: 5451781
38
LABEL, WARNING PROPELLER, SWIM
PLATFORM
P/N: 5451180
37
P/N: 5451160
36
P/N: 5451130
35
P/N: 5451120
LABEL, HAZARDOUS VOLTAGE (WRAP
AROUND)
34
TAG, LEXAN, GREEN "WINTERIZED"
P/N: 5450855
33
TAG, LEXAN "FROM WASTE TANK"
P/N: 5450850

Safety Label Locations
10 S 358 SPORT
Labels and Logos
48
LABEL, WARNING CO CABIN
P/N: 5453680
47
LABEL, TRANSOM CO CALIFORNIA
P/N: 5453650
46
LABEL, "SLING" PS POLYESTER
P/N: 5453600
45
TAG, WARNING CA CODE PROP 65
P/N: 5453551
44
LABEL, WARNING HARDTOP
P/N: 5453160
43
P/N: 5452510
LABEL, WARNING "DO NOT RUN W/HELM
OPEN"
42
LABEL, "ESCAPE HATCH" WHITE/CLEAR
P/N: 5452020
41
LABEL, "FIRE EXTINGUISHER INSIDE"
P/N: 5452010

Safety Label Locations
11
S 358 SPORT
Labels and Logos
56
LABEL, FILL W/DIESEL ONLY
P/N: 5454580
55
LABEL, "TRASH OVERBOARD DISCHARGE"
P/N: 5454500
54
LABEL, "DISCHARGE OF OIL PROHIBITED"
P/N: 5454490
53
PLATE, CAPACITY DC 235 MY2017
P/N: 5454216
52
PLATE, CAPACITY C 238 MY2016
P/N: 5454215
51
P/N: 5454010
LABEL, KIT FOR FUSE BLOCK
50
LABEL, "NO STEP" 3"X8" RED/WHITE
P/N: 5453970
49
LABEL, WARNING CO HELM
P/N: 5453690

Safety Label Locations
12 S 358 SPORT
Labels and Logos
64
LABEL, WARNING "DO NOT DRILL"
P/N: 5455830
63
LABEL, WARNING AFT FACING SEAT
P/N: 5455780
62
LABEL, WARNING V - BERTH TABLE
P/N: 5455770
61
LABEL, WARNING HOT SURFACE - GRILL
P/N: 5455680
60
LABEL, NOTICE KEEP HATCHES CLOSED
P/N: 5455660
59
LABEL, NOTICE CONSISTENT TEMPERATURE
P/N: 5455650
58
LABEL, ENGINE FLUSHING SYSTEM
P/N: 5455602
57
LABEL, "NMMA" CERT SLVR/BLK 2IN CIRCLE
P/N: 5455250

Safety Label Locations
13
S 358 SPORT
Labels and Logos
72
LABEL, NOTICE WINDSHIELD CLEANING
P/N: 5456090
71
P/N: 5456081
LABEL, HOUSE BATTERY & BREAKER
LOCATION
70
LABEL, NOTICE BALL VALVE ACTUATOR
P/N: 5456080
69
LABEL, NOTICE ANCH RODE LEWMAR
P/N: 5455970
68
LABEL, WARNING WINDLASS LEWMAR
P/N: 5455960
67
LABEL, WARNING NO FLAMMABLE LIQUIDS
P/N: 5455950
66
LABEL, WARNING SUNPAD FILLER
P/N: 5455870
65
P/N: 5455840
LABEL, DANGER "DO NOT EXCEED 1000LB
CAP"

Safety Label Locations
14 S 358 SPORT
Labels and Logos
77
P/N: 5453601
LABEL, WARNING
"FALLING FROM HARDTOP"
76
P/N: 5454491
LABEL, WARNING "FALLING OVERBOARD"
75
LABEL, "TOWER CAPACITY"
P/N: 5453602
74
LABEL, WARNING "FALLING OVERBOARD"
P/N: 5450062
73
LABEL, CAUTION "SEAT ASSEMBLY"
P/N: 5450215