Raypak H7 504-2004 User manual

Catalog No.: 2000.364A Effective: 8-15-07 Replaces: 6-15-07
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor:
84% Thermal Efficiency at Full Rate
100% Factory Fire Tested
Maximum Outlet Water Temperature: 220°F
Minimum Acceptable Inlet Water Temperature: 120°F
Full Safety Diagnostics with History
Footprint: Less Than 5-1/2 ft2
Limited Twenty-Year Thermal Shock Warranty
Limited Ten-Year Heat Exchanger Warranty
Electronic Modulation, Constant Ratio 1.4:1 Turndown
TempTracker Mod Controller with LCD Display
Status Display Lights
Heat Exchanger
Bronze Headers
ASME H Stamped
160 PSIG Working Pressure
National Board Approved
Fin Tubing
Copper – Standard
Cupro Nickel – Option A-3
ASME Powder-Coated Tube Sheet
Silicone High Temp O-Rings
ASME Pressure Relief Valve
60 PSIG – Standard
PSIG – Optional
Temperature and Pressure Gauge,
Shipped Loose
Stainless Steel Evaporator Plate
Control
120V, 60Hz, 1Ø, Power Supply
120/24V 60Hz Transformer
Ignition Module
3-Try – Standard
Single-Try – Option C-6
Hot Surface Ignition (HSI)
Remote Flame Sensor
High Limit, Manual Reset, Fixed,
240ºF
On/Off Power Switch
Flow Switch
Blocked Vent Pressure Switch
Combustion Air Proving Switch
Pump Switch
Pump Time Delay
Diagnostics Panel
Modulating Temperature Control
Water Temperature Sensors (3)
Burner
Ultra-Low NOx: Less than 20 PPM
Gas Train
Fuel
Natural Gas
Propane
Zero Governor Regulator
Dual-Seat Combination Valve
Electronic Modulating Firing Mode
Construction
Indoor/Outdoor Construction
Front Controls Enclosed
PolyTuf Powder Coat Finish
Rear Connections (Water, Electrical,
Gas, Vent, Combustion Air)
Design Certified ANSI Z21.13/
CSA 4.9
Venting
Vent Termination Cap
Outdoor - Option D-11
Indoor, Horizontal – Option D-15
Indoor, Vertical (by others)
Combustion Air
In-Line Filter Kit – Option D-17
Air Intake Elbow – Option D-16
Extractor – Optional
By others
Not required
Temperature Controllers
B-36 Temp-Tracker Mod+ Digital
Controller, Up to 4 Boilers,
OA Reset
B-37 Temp-Tracker Mod+ Digital
Controller, Up to 10 Boilers,
OA Reset
B-38 Temp-Tracker Mod+ Digital
Controller, Up to 16 Boilers,
OA Reset
Y-241 Electronic Sequencer,
Up to 4 Boilers
Y-281 Electronic Sequencer,
Up to 8 Boilers
Options
A-13 Air Vent, Auto, 150 PSI
F-10 Low Water Cut-Off, Remote Probe
I-1 High Limit, Auto Reset, Adj.,
100-240°F
I-2 High Limit, Manual Reset, Adj.,
100-240°F
P- Pump: HP, 120V, 1∅, 60Hz
WaterHardness:
GPG
Cast Iron Bronze
Loose Mounted
P- Cold Water Start
P- Cold Water Run
S-1 Low Gas Pressure Switch,
Manual Reset
S-2 High Gas Pressure Switch,
Manual Reset
Regulatory Agency Requirements
MVB™ - Type H
Heating/Hot Water Supply Boilers
Models H7 504-2004

Catalog No.: 2000.364A Effective: 8-15-07 Replaces: 6-15-07
MVB™ – Type H
Models H7 504-2004 Model
Dimensions (in.)
MBTUH B D E F G H K M N P R V
Model
(H7-) Input Output Height NPT NPT Flue Ø C/A Ø
Ship
Weight
(Lbs.)
Foot-
print
(Ft2)Amps*
504 500 420 43 30 35 23-3/4 1 2 8 14-1/8 6 36 6 2 600 5.4 12
754 750 630 49 36 41 29-3/4 1 2 10 16 6 42 6 2 670 5.4 12
1104 1100 924 55 43 47 35-3/4 1-1/4 2-1/2 10 16 6 49 6 2 720 5.4 12
1504 1500 1260 61 50 53 41-3/4 1-1/4 2-1/2 12 18-1/8 8 53 6 2 780 5.4 12
2004 1999 1679 75 61 65 53-3/4 2 2-1/2 14 20-1/8 8 69 9 5 940 5.4 18
-Ratings shown are for elevations up to 4,500 feet. For installations at elevations
above 4,500 feet, please consult the factory for additional instructions.
-For direct vent applications, please contact the factory about relocating the pump.
* Current draw is for heater only.
(Supply breaker must have delayed trip.)
RATES OF FLOW AND PRESSURE DROPS
20°F ∆T 30°F ∆T 40°F ∆T* Maximum Flow Minimum Flow*
Model
(H7-) GPM ∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) ∆T (°F) GPM ∆P (ft.) ∆T (°F)
504 42 2.7 28 1.4 N/A N/A 100 11.3 8 25 1.1 34
754 63 6.0 42 2.9 32 1.7 100 13.8 13 32 1.7 40
1104 92 13.3 62 6.7 46 4.1 113 18.6 16 46 4.1 40
1504 N/A N/A 84 13.3 63 8.0 113 22.2 22 63 8.0 40
2004 N/A N/A 112 26.9 84 16.0 113 27.2 30 84 16.0 40
* Closed systems only
Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 [phone] Fax [phone] www.raypak.com
Raypak Canada Ltd. 2805 Slough St., Mississauga, Ontario, Canada L4T 1G2 [phone] Fax [phone] www.raypakcanada.com
CLEARANCES
Certified
Minimum Recomm. Service
Front 24” 24”
Rear 12” 24”
Right 1” --
Left 1” --
Top 0” 10”
Floor 0” --
Vent 1” --
PUMP HP
–
AMPS*
Water Hardness
Model
(H7-) Soft Medium Hard
504 1/4 - 6 1/4 - 6 3/4 - 11
754 1/4 - 6 1/2 - 7 3/4 - 11
1104 1/4 - 6 1/2 - 7 1 - 14
1504 1/2 - 7 1 - 14 1 - 14
2004 1 - 14 1-1/2 - 15 1-1/2 - 15
* Current draw is for pump only