Raypak Power Vent Raytherm 2100 User manual

Catalog No.: 3500.24C Effective: 08-10-11 Replaces: 01-15-08
Job:
Engineer:
Contractor:
Prepared By:
Model: Indoor Date:
EFFICIENT
82% thermal efficiency – highest of any atmospheric
water heater available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum outlet temperature: 210°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby
and radiation losses associated with tank-type
water heaters are eliminated
LOW WATER OPERATING TEMPERATURE
Operates with water temperature as low as 105°F
without condensing
Heat Exchanger
ASME Inspected and Stamped
160 PSIG
National Board Approved
Headers
Bronze – Standard
Glass-lined Cast Iron – Option A-2
Fin Tubing
Copper – Standard
Cupro Nickel – Option A-3
ASME Steel Tube Sheet
Silicone O-Rings
125 PSIG ASME Pressure Relief Valve
Temperature and Pressure Gauge
Water Connections
Left Hand – Standard
Right Hand – Option A-6
Two-pass Flow Configuration
Controls
120V, 60Hz, 1 Ph Power Supply
120/24V Transformer
100% Pilot Shut-off/Lockout
Electronic, Intermittent Ignition (IID) Pilot
High Limit Control, Manual Reset – 200°F
High Limit Control, Auto Reset – 200°F
Models 3001-4001
On/Off Switch
Flow Switch
Economaster II Pump Time Delay
Gas Control Train
Manual Main Gas Shut-off Valve
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Firing Mode
On/Off (WH1)
2-stage Firing (WH3)
Motorized Modulation (WH2)
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.10.3
Construction
Front Controls
Stainless Steel Burners
Baked Enamel Paint
Built-in Draft Diverter
Draft Inducer – Optional
Motorized Draft Inducer –
Indoor – Option D-2
CSA Certified – AB 1953 & VLA 193
Low Lead Compliant
Water Heater Controller
Required on Model WH2 only
B-40 TempTracker MOD
Modulating Controller
Mounted
By Others
Temperature Controllers
B-2 Single-Stage Tankstat
(100-180°F), Loose
B-3 2-Stage Tankstat (100-180°F),
Loose
Y-241 Electronic Sequencer,
1-4 Stages
Y-281 Electronic Sequencer,
1-8 Stages
Additional Safety Controls
F-9 Low Water Cut-off Probe
I-3 High Limit Control, Auto Reset,
180°F
S-1 Low Gas Pressure Switch,
Manual
S-2 High Gas Pressure Switch,
Manual
Regulatory Agency Requirements
CSD-1 Safety Controls
Raytherm
®
- Type WH
Water Heaters
Commercial
Models 2100 - 4001
Proudly Made in the USA

Catalog No.: 3500.24C Effective: 08-10-11 Replaces: 01-15-08
Raytherm - Type WH
Models 2100-4100 Model
MODELS WH 2100
–
4001
MBTUH Width
Overall
Height
Gas
Conn.
Water
Conn.
Flue
Dia.
Model
No. Input Output A B G H K
Approx.
Shipping
Weight (lbs)
WH-2100 2100 1722 61 68-1/4 * 3 24 1400
WH-2500 2499 2049 70 68-1/4 * 3 26 1580
WH-3001 3000 2460 81-1/4 68-1/4 2 3 28 1750
WH-3500 3500 2870 92-1/2 68-1/4 2 3 30 1920
WH-4001 4000 3280 103-3/4 68-1/4 2 3 32 2100
* 1-1/2” or 2”, contingent on water heater type code requirements
NOTES: Dimensions are in inches.
Ratings are for elevations up to 2,000 feet. For elevations over 2,000 feet, reduce ratings
4% for every 1,000 feet above sea level.
HEATER RATES OF FLOW AND PRESSURE DROPS
20°F ΔT 30°F ΔT 40°F ΔT
Model
No. GPM ΔP (ft) GPM ΔP (ft) GPM ΔP (ft)
WH-2100 172 11.0 115 4.9 N/A N/A
WH-2500 N/A N/A 137 7.5 102 4.3
WH-3001 N/A N/A 164 11.2 123 6.5
WH-3500 N/A N/A 191 16.8 144 9.3
WH-4001 N/A N/A N/A N/A 164 12.8
Maximum acceptable flow through heat exchanger tubes is
200 GPM.
HEATER RECOVERY RATES (GPH)
Temperature Rise
Model
No. 20°F 30°F 40°F 50°F 60°F 80°F 100°F
WH-2100 10336 6890 5168 4134 3445 2584 2067
WH-2500 12300 8200 6150 4920 4100 3075 2460
WH-3001 14765 9844 7383 5906 4922 3691 2953
WH-3500 17227 11484 8613 6891 5742 4301 3445
WH-4001 19688 13125 9844 7875 6563 4922 3938
Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 [phone] Fax [phone] www.raypak.com
Electrical Rating
Models
W/Pump W/O
Pump
951276
pump*
11 Amps @
230VAC
2100-
4001
22 Amps @
110VAC
< 8 Amp
@
120VAC
* Pump requires separate
power supply