Raypak ECONOPAK WH-260 User manual

ECONOPAKTM
COMMERCIAL HOT WATER SYSTEM
FOR TODAY & TOMORROW
ECONOPAK Features
HOTEL / MOTEL
MULTI FAMILY
RESTAURANT
NURSING HOME
COMMERCIAL LAUNDRY
Proven Raypak Quality • Value • Serviceability • Efficiency
TYPE
WH
•All Non-ferrous Waterways
•Factory mounted and wired bronze pump
(Piping by others)
•High Efficiency - Up to 82% thermal efficiency
•Six models available:
90,000 to 399,000 BTU per Hour Input
•Super Fast Recovery - Consistent 140°F water
delivery, even during peak demand times
•Long Service Life (Four times longer than
average tank-type heaters)
•Compact - Fits in small equipment rooms
•Backed by a twenty-year limited warranty

ECONOPAKTM - COMMERCIAL HOT WATER SYSTEM
16
331/4
221/8
12
1
/2
5
18
31
/4
2
THERMOSTAT CONN
(ELECTRICAL CONN
ON OTHER SIDE) GAS
CONN
3/4 NPT PIPE
TO DRAIN
A
117
/8
6
INLET
OUTLET
31
/8
MIN
19
261/
41
/2
K
L
G
10-1/4
3-7/8
26-1/2
38
3-7/8
21-1/4 ELECTRICAL CONNECTION
13-1/4 GAS CONNECTION
PUMP
(OPTIONAL)
PUMP COVER
(OPTIONAL)
OUTDOOR
MODELS ONLY
(C)
INDOOR
DRAFT
J
K
A
G GAS
CONNECTION
40"
STACKLESS
OUTDOOR
TOP
INLET
OUTLET
H
WATER
CONN.
8-1/2"
26-1/2"
FER
GWD
LEDOM
EZIS
TUPNI
)HUTBM(
-NI
ROOD
-TUO
ROOD
YREVOCER
ΔF°001=T
**)HPG(
HTDIW
A
THGIEH
C
SAG
.NNOC
G
RETAW
.NNOC
HJ
EULF
.AID
KL
-TOOF
TNIRP
X
GNIPPIHS
THGIEW
)SBL(
SLAIRETAMELBITSUBMOCMORFECNARAELCMUMINIM
ROOLFTNORF
RAERTHGIR
EDISTFEL
EDISTHGIR
ROODNI
POT
ROODTUO
POTTNEV
1
09-HW 09 •0911-2/11-54/3574501
ELBITSUBMOCETONEES
661A/N6
531-HW 531 •23181-2/14/11-64/164/105531
ELBITSUBMOCETONEES
661A/N6
591-HW 591 •29181-2/14/11-74/164/105041
ELBITSUBMOCETONEES
661A/N6
2
062-HW 462 •• 2628/3228/7264/32/118/1117-35092
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
033-HW 433 •• 2334/3524/3364/32/114/3018- 2/165093
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
004-HW 993 •• 6934/1928/35612/112/1219-06504
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
TA N K
24 7/16 HEATER
LOWER UPPER
26 1/2
38 1/2
X
TA N K
24-7/16
HEATER
38 1/2
12
26-1/2
A
X
6-1/4
UPPER
LOWER
"RELIEF VALVE" LABEL
1" NPT COUPLING
8.00" DIAMETER
2" NPT
WATER
CONNECTION
3/4" NPT COUPLING "THERMOMETER" LABEL
MAGNESIUM ANODE
(.840 O.D. X 53")
(2 PLACES)
24 7/16"
DIAMETER
"SCALD DANGER" LABEL
INSULATION
STEEL TANK JACKET
NAMEPLATE/RATING
DECAL
ASME IDENTIFICATION
PLATE WITH
SERIAL NUMBER
(ASME CODE TANKS ONLY)
SERIAL NUMBER 55 5/8"
2" NPT
WATER
CONNECTIONS
3 5/8"
1 1/2" DIAMETER
(3 PLACES) DRAIN VALVE 3/4" NPT
"TO BOILER" LABEL
6 3/16"
13 3/16"
20 3/16"
"FROM BOILER"
LABEL
3/4" NPT COUPLING
"TANKSTAT" LABEL
EZISKNAT
)SNOLLAG( EPYT GNIPPIHS )SBL(THGIEW
08 EDOC552
08 EDOC-NON891
Drawing 1
MODELS WH-90, WH-135, WH-195
Drawing 1A-Footprint
Drawing 2 Drawing 2A-Footprint
MODELS WH-260, WH-330, WH-400
80-GALLON TANK
Tank must be ordered seperately
Raypak, Inc. reserves the right to make product changes or improvements at any time without notice.
Catalog No.: 3000.11H Effective: 03-01-08 Replaces: 06-01-02 Litho in U.S.A. ©1994-2008 Raypak, Inc.
Fig. 9287
Fig. 9286
RAYPAK,Inc.
2151 Eastman Avenue •Oxnard, CA 93030
805-278-5300 • Fax [phone] • www.raypak.com
* Installation on combustible floor requires optional shield. ** Based on manufacturer’s rating. Models available for use with either Natural Gas or Propane. A front clearance of at least 24 inches is recommended for ade-
quate service of burner tray and controls. Ratings shown are for elevations up to 2,000 feet. Ratings should be reduced at the rate of 4% for each 1,000 feet above sea level.
All dimensions are in inches.
All dimensions are in inches.
MODEL
MAXIMUM AND MINIMUM FLOW RATES HEATER RATE OF FLOW AND PRESSURE DROP
MAX. FLOW/MIN. ΔTMIN. FLOW/MAX. ΔT10°F (ΔT) 20°F (ΔT) 30°F (ΔT)
GPM (°F )ΔTΔP(FT) GPM (°F )ΔTΔP(FT) GPM ΔP(FT) GPM ΔP(FT) GPM ΔP(FT)
WH-90 22 7 12.5 6 25 0.95 15 6.0 7.4 1.5 N/A N/A
WH-135 33 7 10.0 9 25 0.75 22 4.6 11.1 1.2 N/A N/A
WH-195 44 7 11.5 12 26 0.85 32 6.0 16 1.6 N/A N/A
WH-260 45 10 9.4 20 22 1.90 45 9.4 22 2.2 N/A N/A
WH-330 45 12 9.6 20 27 1.90 N/A N/A 27 3.4 N/A N/A
WH-400 45 15 9.8 20 33 2.10 N/A N/A 33 5.2 22 2.3