Sealey AP6350.V3 User manual

RACKING UNIT WITH 5 SHELVES
(350KG CAPACITY PER LEVEL)
MODEL NO: AP6350.V3 & AP6350GS.V3
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! Ensure Health & Safety, and local authority regulations are adhered to when assembling and using this rack.
9Locate rack in a suitable area where it will not be an obstruction.
9Keep the general area clean, uncluttered and ensure there is adequate lighting.
WARNING! Erect rack on a level and solid surface such as concrete.
9Keep children and unauthorised persons away from the storage area.
8DO NOT use the rack for any purpose other than that for which it is are designed.
8DO NOT site the rack out of doors.
8DO NOT get the rack wet or use in damp or wet locations or areas where there is condensation.
8DO NOT clean the shelf supports with any solvents which may damage the surface.
9Ensure that the rack is properly assembled before loading them with heavy items.
WARNING! Maximum load for each shelf is 350kg.
9Where possible the rack should be fixed to the wall with suitable fixings
9Place heavier items on the lower shelves.
9Heavier items should be evenly distributed across the shelves.
2. INTRODUCTION
Fully painted steel/galvanised frame with five MDF shelves (AP6350 painted/AP6350GS galvanised). 350kg capacity per level giving a maximum
capacity of 1750kg per rack. No nuts and bolts for easy assembly. Clips together in minutes. Two piece uprights allow use as a single bay rack, or
split in two separate shelf systems or workstations.
3. SPECIFICATION
Model No.......................... .............. AP6350.V3/AP6350GS.V3
Coating..................................... .................... .Paint/Galvanised
Height.................................. ........................................1800mm
Width.................................... .........................................900mm
Depth.............................................................................400mm
Weight............................................................................ 21kg
4. CONTENTSo
Carefully unpack the product and check the contents against the list below. Should any items be missing or damaged make immediate
contact with your Sealey stockist.
Original Language Version
© Jack Sealey Limited
Refer to
instructions
Wear protective
gloves
AP6350.V3, AP6350GS.V3 | Issue 1 16/11/18

5. a ASSEMBLY
5.1.
5.2.
5.3.
.
Original Language Version
© Jack Sealey Limited
Decide on height of
lowest shelf.
Use shelf to support
uprights ‘B’.
Refer to Step1B
below.
Build ends rst by joining B sections together refer to Step 2B
Use soft hammer/mallet
to tap down horizontal
supports.
Use screwdriver to bend
tabs down.
Joining pieces
AP6350.V3, AP6350GS.V3 | Issue 1 16/11/18
Step 1 Step 2
Step 1B
Step 2B

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be sorted, taken to
a recycling centre and disposed of in a manner which is compatible with the environment. When the product becomes completely
unserviceable and requires disposal, drain any fluids (if applicable) into approved containers and dispose of the product and fluids
according to local regulations.
Note: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior
notice.
Important: No Liability is accepted for incorrect use of this product.
Warranty: Guarantee is 12 months from purchase date, proof of which is required for any claim.
AP6350.V3, AP6350GS.V3 | Issue 1 16/11/18
Original Language Version
© Jack Sealey Limited
Step 3 Step 4
Fit shelves and last 2 C and E pieces. Fit last shelf.
Parts support is available for this product. Please log on to www.sealey.co.uk, email [e-mail] or telephone [phone]