Sears BBQ PRO 17757011-6 User manual

Use and Care Guide
22.5" Round Cart Charcoal Grill
With Base Shelf & Tile Table
Kmart Item No. 17757011-6
This Griil is for Outdoor Use Oniy
SAVE THESE INSTRUCTIONS!
• Read and follow all Safety, Assembly,
and Use and Care Instructions in this
Guide before assembling and cooking
with this grill.
• Failure to follow all instructions in this
Use and Care Guide may lead to fire or
explosion, which could result in property
damage, personal injury or death,
"Safety
, Parts
• Use and Care
- Assembly
Assembly Questions?
Call 1-86_561-0731
Tools needed for assembly:
Screwdriver (not provided)
Open end wrench (not provided)
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
See our extensive assortment of outdoor living products on-line at
www.sears.com and www. kmart.com

Tips and Features for safety and ease of use
\'_rif}' that all parts are included with your grill before beginning assembly by checking the Parts
List inside. If all parts are not included, please call our toll free number 1-866-56t-0731 tk_r part
USE DIAGRAM(S) PROVIDED FOR ASSEMBIX. Leave nuts half-tightened on the grill during:
assembly until unit is completely assembled, then finish tightening nuts.
SAFETY GU|DELINES
1. This grill is intended ti)r HOUSEHOLD OUTDOOR USE
ONLY. Do not attempt to use grill in enclosed areas or
under an overhead cover of any kind, incquding a tent or patio cover.
Your grill should never be used closer than 36 inches t¥om walls on the back and side(s) of gNll.
2. Place your grill outdoors on a fh'm, lewzl surfi,ce. Do not use this grill on a suflhcc that will burn
or melt, such as a plastic or artificial suN"ace or wood table° Keep grill away from wooden fences,
overhanging trees, or other flammable objects before adding and lighting charcoal
3, DO NOT USE GASOLINE, ALCOItOL OR KEROSENE IN THIS GRit.t,. Use only commercial
charcoal lighter fluid 'with charcoal bNquettes or pro-soaked charcoal bNquettcs. Prepare charcoal
according m the product's instructions. Do not exceed 3 Ibs of charcoal briquettes in tNs grill per use.
4. After lighting charcoal, do not leave gwill unatmnded.
5. Remember to keep children and pets away from lit grill at all times.
6_ N_ avoid harm to people, pets, or property, do not move the grill once the charc__N has been lit.
7. Once coals are lit, the grill and smTounding surtimcs become ve W hot. Use proper outdoor cooking
mitts, utensils and avoid skin contact with NI hot surfi_ces on grill.
8. lb extinguish dam-coal after cooMng, dowse coals with sand or spray with a fine mist of water.
9. After your grill has cooled, remove ashes t¥om the catcher and cover, and store the gNll when
not in use.
"WARNING! Combustion by°products produced when using this product contain chemicals known
to the State of Calitbmia to cause cancer, bbth det)cts, and other reproductive harm.
HARDWARE L!ST
i (SNs) 8 (4pcs)
I/4" x 2-1/2" leg Bolt 1/4:' Nut
2 (Spcs)
I/4" x 2" Bolt
I/4"x 1-3./'8' Bolt I0
5/16"Hex
4 (2pcs)
]/4" x778" Handle B01t I/4' Metal _&_her
5 (Sp<s)
I/4!' x 3N'B01t 12
1/4" Fi±_r Washer
5/32" x iVS" Damlmr [_lt 13 (2pcs)
5/16" Plashc '
7 (hx:)
5_3z D_dnt_cr Winged Nut
Customer Service-!-866-561-0731 Page !

PARTS L!ST
A: Lid (i) G: Back Shelf Support (2)
200423N .,00449N
N: Lid Vent Assembly (i)
220102N
B: Bottom Bowl (1)
C: Cooking Grid (1)
21032:_N
600306N
S: Base Shelf(i)
O: Axle (1)
300340N
P: Hook and Hanger
Accessories (i each)
300339N 300341N
D: Charcoal grid (1) K: Handle (1) Q: Grid Height Adjuster (2)
611)201N 2211018N 240100N
E: Support Leg (2) L: Wheel (2) R: Lid Bracket (1)
1
300334N 500200N 220002N
Fi Front SheiiSupport 12) M: Ash Catcher (1) S: Support Bracket-I (2) ///
300
300448N 230104N
Customer Service-l-866-561-0731
Page2

@
Customer Service-1-866-561-0731
Page 3

Remove all tlae parts from the carton
and lay them out on a smootlh, clean
surthce. Verify the presence of all Parts
by comparing 'to Hardware and Parts
Lists on previous pages. Do not throw
away' any of the packaging until you
locate all the parts.
STEP I: Attach lid vent assembly (N)
by inserting damper bolt (6)through lid
vent assembly (N), and lid (A). Inside of lid,
place I fiber washer (12), 1 winged nut (7)
m damper bolt (6)and tighten.
Attach handle (K) by inserting 2handle
bolts (4) through 2 metal washers (i 1), lid
bracket (R), 2 fiber washers (i 2), lid (A),
2 fiber washers (12) and into handle (M).
12
K
6
N
12
11 ° R
4
A
STEP 2: Position base shelf(J)between the
2 support legs (E). Fix base shelf (J) to the
2 support legs (E) with 8 leg bolts (3),
8 metal washers (I 1) and 8 hex nuts (9).
Only hand tigh*en bolts at this time.
Inset1 axle (O) through the bottom holes in
the suppo_ legs (E). Place wheel (L)
onto each end of axle: (O), through
2 plastic washers (I3) and screw the
hex locknuts (I 0) onto axle ends.
i3:
_, j
Customer Service*l-866-561-0731
Page4

STEP 3: Attach suppolX brackets (S)(T)
to support legs (E) by using 4 bolts (5).
Attach bottom bowl (B) to the support
brackets (S) (T) by using 4 bolts (5),
4fiber washers (i 2) and 4 winged nuts (8).
Attach 2 flont shelf supports (F)to iiont
support leg (E) with 4 leg blots. (i), 4 metal
washers (l 1) and 4 hex m_ts (9).
Attach 2 back shelf suppo_s (G) to back
support leg (E)with 4 leg blots (1), 4 metal
washers (1 I) and 4hex nuts (9).
of Grill
STEP 4:Attach shelf support (H) to
fl'ont shelf support (F) and back shelf
support (G) with 4 bolts (2). Put tile (i)
into shelf support (H).
Repeat stone procedure tbr the other
Place hook and hanser accessone_ (P)
into the holes of fronl shelf support (F).
Customer Service-l-866-561-0731
Page5

STEP 5: Slide ash catcher (M) under bowom
bow! (B) into slots provided,
Hook bottom of grid height adjusters (Q) onto
side of charcoal grid (D). Siide grid height
adjusters (Q)through the la_:geopenings
on the side of cooking grid (C),
Insert cooking grid/charcoal grid
assembly into bottom bowl (B). Place
top lid (A) on mp of bottom lid.
STEP 6: Fuily tighten all nuts and
screws at this time°
COOKING GRID
CHARCOAL GRID A SSEMBLY
Cu stome r Service- 1-866-561-0731
Page6

ORDER PARTS #
k
B
c
D
E
F
G
H
I
J
K
L
M
N
0
P
Q
1
1
1
I
2
2
2
2
2
1
1
2
I
I
I
l(each)
2
LID
BOTTOM BOWL
COOKING GRID
CHARCOAL GRID
SUPPORT LEG
FRONT SHELF SUPPORT
BACK SHELF SUPPORT
SHELF SUPPORT
TILE
BASE SHELF
200423N
210325N
600306N
61020IN
300334N
300448N
300449N
300450N
300451N
HANDLE 220018N
WHEEL 500200N
ASH CATCHER 230104N
LID VENT ASSEMBLY 220102N
AXLE 300340N
HOOK AND HANGER ACCESSORIES 30034 IN
GRID HEIGHT ADJUSTER 240100N
R 1 LID BRACKET
S 2 SUPPORT BRACKET-, 1 300452N
T 2 SUPPORT BRACKET-2 300453N
] _13 ! HARDWARE PACK
WARNING: To ensure flaatit:is safieto eat, t:5odmust be cooked
to the minimum internal temperatures listed in the table bei0w_ .
USDA* Safe Minimum Internal Temperatures
Figh .... 145°F
Pork 160 ° F
160 ° F
Steaks and Roasts of Beef, "Wal of Lamb 145 °F
Ground Beef_ Veal or Lamb 160 ° F
Whole Poultry (Turkey, Chicken, Duck, etc.)
Ground or Pieces Poultry ( Chicken Breast, etc.) 165 F
*United States Department of Agricutture
90 Day' Full Warranty
if this BBQ-Pro p_oduct fails due to a defect in mate:rial orwolkmanship within 90 days flom
the date of purchase, return it to any Sears or Kmart store or other BBQ-Pro outlet in the
United States with your proof of purchase f;arflee replacement.
This warranty gives you specific legal rights, and you may also have other rights which vary from
state to state.
Sears, Roebuck and Co., Hoffman Estates, iL 60! 79
For fiartherinformation, contact the manul_tcture:r,toll flee at 1-86&561-073 I
Customer Service-l-866-561-0731
Page7