Sierra KLD4005SA User manual

Item # 9180
Model # KLD4005SA, KLD4005SB
Keep and check the manual before assembling the appliances
OZ CYLINDER FIRE PIT
DANGER
If you smell gas:
1. Shut off gas to the appliance.
3. If odor continues, keep
away from the appliance and
immediately call your gas
WARNING
Do not store or use gasoline
liquids in the vicinity of this or
any other appliance.
An LP-cylinder not connected
for use shall not be stored in
the vicinity of this or any other
appliance.
WARNING
For outdoor use only.
WARNING
DANGERCARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Neveruse this appliance in an enclosed space
such as a camper, tent, caror home.
CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
Improper installation,
adjustment, alteration, service
or maintenance can cause injury
or property damage. Read the
owner’s manual thoroughly
before installing or servicing this
result causing property damage,
personal injury or loss of life.

SAFETY INFORMATION
DANGER indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury. • EXPLOSION - FIRE HAZARD
• Keep solid combustibles, such as building materials,
paper or cardboard, a safe distance away from the
fire pit as recommended by the instructions.
• Provide adequate clearances around air openings
into the combustion chamber.
• Never use the fire pit in spaces which do or may
contain volatile or airborne combustibles, or products
such as gasoline, solvents, paint thinner, dust particles
or unknown chemicals.
• During operation, this product can be a source of
ignition. Keep fire pit area clear and free from
combustible materials, gasoline, paint thinner, cleaning
solvents and other flammable vapors and liquids. Do
not use fire pit in areas with high dust content.
Minimum fire pit clearances from combustible
materials: six (6) feet from the sides & eight (8) feet
from the rear, 6 feet from ceiling.
• CARBON MONOXIDE HAZARD
• This fire pit is a combustion appliance. All combustion
appliances produce carbon monoxide (CO) during the
combustion process. This product is designed to produce
extremely minute, non-hazardous amounts of CO if used
and maintained in accordance with all warnings and
instructions. Do not block air flow into or out of the fire pit.
• Carbon Monoxide (CO) poisoning produces flu-like
symptoms, watery eyes, headaches, dizziness, fatigue
and possibly death. You can't see it and you can't
smell it. It's an invisible killer. If these symptoms are
present during operation of this product get fresh air
immediately!
• For outdoor use only.
• Never use inside house, or other unventilated or
enclosed areas.
• This fire pit consumes air (oxygen). Do not use in
unventilated or enclosed areas to avoid endangering
your life.
The equipment has been tested to comply with ans Z 21.97-2010.
CGA Cr 97-003 external gas furnace.
There are no local gas standards in the national gas regulations. burning Z223. .1 This manual
contains important information about the fire pit assembly, operation and maintenance E. Regulations commonly
safety information is provided on the previous pages and is included in the entire contingent owned equipment
manual.
Save this manual for future reference and learn from new users use manual.
Read the label product, as safety precautions must be taken.
These are mechanical equipment or propane Precautions must be taken where applicable.
Store and cover unit when not in use.
To avoid personal injury or material damage, follow the danger symbols.
This manual contains a wide range of recommendations. Pay attention to these preventive measures prior to use.
CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
Combustible materials should not be within 48 in.
from sides and 96 in. from of the unit.
DANGERDANGER
DANGER
WARMING: if the information in this manual is not followed
exactly, a fire or explosion may result causing property damage,
personal injury, or loss of life.
Min. Clearance
48 in. (121.92 cm)
Min. Clearance
48 in. (121.92 cm)
Min. Clearance
48 in. (121.92 cm)
Min. Clearance
48 in. (121.92 cm)
1-877-387-3639 | Page 2

•EXPLOSION - FIRE HAZARD
• • Never store propane near high heat, open flames,
pilot lights, direct sunlight, other ignition sources or
where temperatures exceed 120 degrees F (49°C).
••Propane vapors are heavier than air and can
accumulate in low places. If you smell gas, leave the
area immediately.
• • Never install or remove propane cylinder while fire pit
is lighted, near flame, pilot lights, other ignition sources
or while fire pit is hot to touch.
••This fire pit is red hot during use and can ignite
flammables too close to the burner. Keep flammables
at least 4 feet from sides & 4 feet from rear, 8 feet
from ceiling. Keep gasoline and other flammable liquids
and vapors well away from fire pit.
••Store the propane cylinder outdoors in a well ventilated
space out of reach of children. Never store the propane
cylinder in an enclosed area (house, garage, etc.). If
fire pit is to be stored indoors, disconnect the propane
cylinder for outdoor storage.
We cannot foresee every use which may be made of
our fire pit.
Check with your local fire safety authority if you have
questions about fire pit use.
Other standards govern the use of fuel gases and heat
producing products for specific uses. Your local
authorities can advise you about these.
If no local codes exist, follow National Fuel Gas Code,
ANS Z223.1. In Canada, installation must conform to
local codes. If no local codes exist, follow the current
National standards of CANADA CAN/CGA-B 149.2.
WARNING indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
CARBON MONOXIDE HAZARD
This appliance can produce
carbon monoxide which has
no odor. Using it in an enclosed
space can kill you. Never use this
appliance in an enclosed space
such as a camper, tent or home.
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or
death. Read the installation, operation and
maintenance instructions thoroughly before installing
or servicing this equipment.
California Proposition 65
Combustion by-products produced when using
this product contain chemicals known to the State
of California to cause cancer, birth defects, and
other reproductive harm.
•This product is fueled by propane gas. Propane gas
is invisible, odorless, and flammable. An odorant is
normally added to help detect leaks and can be
described as a “rotten egg” smell. The odorant can
fade over time so leaking gas is not always
detectable by smell alone.
•Propane gas is heavier than air and leaking propane
will sink to the lowest level possible. It can ignite by
ignition sources including matches, lighters, sparks or
open flames of any kind many feet away from the
original leak. Use only propane gas set up for vapor
withdrawal.
•Store or use propane gas in compliance with local
ordinances and codes or with ANS/NFPA 58. Turn off
propane when not in use.
BURN HAZARD
Solid fuels shall not be burned in this appliance.
• Never leave fire pit unattended when hot or in use.
•Keep out of reach of children.
Certain materials or items, when stored under the
fire pit, will be subjected to radiant heat and could
be hazardous.
• Alert children and adults to the hazards of high
surface temperatures. Stay away from these
surfaces to avoid burning skin or igniting clothing.
• Carefully supervise young children when in the
vicinity of the fire pit.
• Do not hang clothing or any other flammable
materials from the fire pit, or place on or near the
fire pit.
• Replace any guard or protective device removed for
servicing the appliance prior to placing back in service.
• Installation and repair should be done by a qualified
service person. The fire pit should be inspected before
use and annually by a qualified service person. More
frequent cleaning may be required as necessary. It is
imperative that the control compartment, burners, and
circulating air passageway of the appliance be kept
clean.
CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
WARNING
WARNING DANGER
WARMING
WARMING: For outdoor use only
WARMING
WARMING
WARNING
DANGER
WARNING
WARNING
WARNING
WARNING
1-877-387-3639 | Page 3
SAFETY INFORMATION

17
18
19
10
7
6
3
2
1
54
11
12
13
14
15
16
9
8
PACKAGE AND HARDWARE CONTENTS
PART DESCRIPTION QUANTITY
1 Glass 1
2 Ignition needle 1
3 Thermoucouple 1
4 Gas collecting hood 1
Burner 1
6
5
Body 1
7 corrugated pipe 1
8 Connector 1
9 Base 1
10 Regulator hose 1
11 Valve 1
12 Panel 1
13 Control knob 1
14 Igniter 1
15 Door 1
16 Lock 1
17 Lava Rocks (2.6 lbs.) 1 Box
18 Protective Cover 1
19 AA Battery 1
Before beginning assembly of product, make sure all arts are present, and check the manual carefully. The product is
pre-assembled before leaving the factory .
1-877-387-3639 | Page 4

SAFETY INFORMATION
Please read and understand this entire manual before attempting to assemble, operate or install this appliance.
If you have any questions regarding the product, please call customer service 1-877-387-3639, 8 a.m. – 4 p.m., EST,
Monday – Friday. This appliance has been tested to and complies with the ANSI Z21.97-2017/CSA 2.41-2017, Outdoor
Decorative Gas Appliances CGA CR 97-003 Outdoor Gas Fireplaces. The installation must conform to local codes or in
the absence of local codes, to the National Fuel Gas Code. ANSI Z223.1. This manual contains important information
pages and is also located throughout this manual. Keep this manual for future reference and to educate new users of this
appliance. This manual should be read in conjunction with the labeling on the appliance. Safety precautions are essential
when any mechanical or propane fueled equipment is involved. These precautions are necessary when using, storing,
and servicing. Using this appliance with the respect and caution demanded will reduce the possibilities of personal injury
or property damage. The following symbols shown below are used extensively throughout this manual. Always heed
these precautions, as they are essential when using any mechanical or propane fueled equipment.
DANGER:
DANGER indicatesan imminently hazardous
situation which, if not avoided, will result in death
or seriousinjury.
DANGER:
Failure to complywiththe precautions and
in death, seriousbodily injury and propertyloss
asphyxiation, and/or carbon monoxide poisoning.
Only persons who can understand and follow the
DANGER:
FOR YOUR SAFETY:
If you smell gas:
1. Shut off gas to the appliance.
3. If odor continues, keep away from the appliance
department.
Solid fuels shall not be burned with this appliance.
CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
1-877-387-3639 | Page 5

Step 1. Put the lava rocks into the re pan.
(The weight of lava rocks is 1.2kg)
Step 2A. Leave adequate space around
the Ignition Screen for ventilation.
Step 2B. DO NOT block or cover the Ignition
Screen with the lava rocks.
ASSEMBLY INSTRUCTIONS
Step 3. Place wind guard on the re pit. Step 4. Install Battery to Igniter. Remove the rubber
cap on the electronic igniter (A) by unscrewing and
slide battery (B) into the battery slot. Make sure the
positive side of the battery faces outwards.
Screw the electronic igniter cap (A) over the battery tightly.
A
B
ignition screen
A
B
1-877-387-3639 | Page 6

ASSEMBLY INSTRUCTIONS
Step 6A.
Install Cylinder. Put the cylinder into bottom base.
Step 6B.
Close the door. Fire pit assembly is now complete.
B
A
Step 5
(A) Connect hose and regulator to cylinder.
(B) Turn the cylinder valve clockwise to close the gas supply
on the gas cylinder. Screw the regulator coupling clockwise
by hand only. Make sure it is fastened.
Standard 20 lb. tank
Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance. A
cylinder must be stored outdoors in a well-ventilated area out of reach of children. A disconnected cylinder must have
all dust caps tightly installed and must no be stored in a building, garage or any other enclosed area. The maximum inlet
gas supply pressure: 250 PSI. The minimum inlet gas supply pressure: 5 PSI.
The pressure regulator and hose supplied with the appliance must be used. The installation must
conform with local codes or in the absence of local codes, with national fuel gas code,
ANSI Z223.1/NFPA54, NFPA58, natural gas and propane Installation Code, CSA B1491.1,
or propane storage and handling code, B149.2.
A dented, rusted or damaged propane cylinder may be hazardous and should be checked by your
cylinder supplier. Never use a propane cylinder with a damaged valve connection.
LP gas cylinders of the U.S. Department of Transportation (DOT) or the standard for cylinders,
spheres and tubes for transportation of dangerous goods and commission, CAN/CSA-B339.
The cylinder must have a connection device compatible with the connection for the appliance.
The cylinder used must include a collar to protect the cylinder valve.
Never connect an unregulated propane cylinder to the appliance.
1-877-387-3639 | Page 7

ASSEMBLY INSTRUCTIONS
Step 7
Perform Leak Test
Regulator/Cylinder Connection
Hose/Regulator Connection
WARNING
Perform all tests outdoors.
NEVER leak test when smoking.
have beenleak tested and do not leak.
((I) Make 2-3 oz. of leak test solution (one part liquid dishwashing
detergent and three parts water).
(III) Apply several drops of solution where hose attaches to regulator.
(IV) Apply several drops of solution where regulator connects to cylinder.
(V) Turn cylinder valve ON.
If bubbles appear at any connection, there is a leak.
(I) Turn cylinder valve OFF.
(II) If leak is at hose/regulator connection: tighten connection and
perform another leak test. If bubbles continue appearing, the hose
should be returned to the place of purchase.
(III) If leak is at regulator/cylinder valve connection: disconnect,
reconnect, and perform another leak test. If you continue to see bubbles
after several attempts, cylinder valve is defective and should be returned
to cylinder place of purchase.
If NO bubbles appear at any connection, the connections are secure.
NOTE: Whenever gas connections are loosened or removed, you must
perform a complete leak test.
• Do not store a spare LP-gas cylinder under or nearthis
appliance.
•
• Place the dust cap on the cylinder valve outlet whenever the
cylinder is not in use. Only install the type of dust cap on the
cylinder valve that is provided with the cylinder valve. Other
type of caps or plugs may result in leakage of propane.
CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
1-877-387-3639 | Page 8

DANGER
CARBON MONOXIDE HAZARD
For outdoor use only. Never use inside house, or
consumesair(oxygen). Donot use in an unventilated
or enclosed areasto avoid endangering your life.
pit
WARNING:
VERY HOT WHILE IN OPERATION
use. Failure to comply with these instructions may
result in seriousbodily injury.
For a safe heating experience, perform these checks before each use.
Before Operating:
1. Familiarize yourself with owner’s manual to understand all precautions.
2. All components are properly assembled, intact and operable.
3. No alterations have been made.
4. All gas connections are secure and do not leak.
5. Do not operate if wind is 10 mph or above.
7. Fire pit is outdoors (outside any enclosure).
8. There is adequate fresh air ventilation. Do not use this appliance if any part has been under water. Immediately call a
9. Fire pit is away from gasoline or other ammable liquids or vapors.
has been under water.
10. Fire pit is away from windows, air intake openings, sprinklers and other water sources.
11. Combustible material should not be within 96 in. from sides and top of the unit.
12. Fire pit is on a hard and level surface.
13. There are no signs of spiders or insects.
14. All burner passages are clear.
15. All air circulation passages are clear.
16. Children and adults should be alerted to the hazards of high surface temperature and should stay away to avoid
burns or clothing ignition.
pit.
21. More frequent cleaning may be required as necessary. It is imperative that control compartment, burner and
After Operation:
1. Gas control is in OFF position.
2. Gas tank valve is OFF.
3. Gas line has been disconnected.
4. After each use, replace cap on gas tank.
Keep children away during assembly, as this item contains small parts which can be swallowed by children.
Do not use indoors or inside any enclosure.
Retain the assembly instructions for future reference.
Installer – Please leave these instructions with the owner.
CAUTION
OPERATION INSTRUCTIONS
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
1-877-387-3639 | Page 9

OPERATION INSTRUCTIONS
Caution: Do not attempt to operate until you have read and understand all Safety Information in this manual
and all assembly is complete and leak checks have been performed.
Before Turning Gas Supply On:
enclosed area.
3. Ensure that there is no obstruction to air ventilation. Be sure all gas connections are tight and there are no leaks.
4. Be sure the cylinder cover is clear of debris. Be sure any component removed during assembly or servicing is replaced
and fastened prior to starting.
Before Lighting:
2. Inspect the hose assembly for evidence of excessive abrasion, cuts, or wear. Suspected areas should be leak
manufacturer. The burner must be replaced prior to the appliance being put into operation if it is evident that the burner
Lighting:
1. Make sure the control knob is in the “OFF” position (Figure A).
2. Fully open LP cylinder valve.
Note: For initial start or after any cylinder change, hold Control Knob IN for 2 minutes to purge air from gas lines
before proceeding.
3. Push in gas control knob, turn counterclockwise to “HIGH” (Figure B), and press the RED Ignitor button to light the
re pit. If needed, keep the control knob depressed and continue pressing the RED Ignitor botton until the re pit
pit
lights (you should hear a clicking sound).
“LOW” (Figure C).
Note: If burner fails to remain lit, all valves should be closed and a waiting period of at least 5 minutes should
pass before attempting to light.
WARNING
FOR YOUR SAFETY
Be careful when attempting to manually ignite this
than 10 seconds before igniting the gas will cause
Re-lighting:
1. Turn control knob to “OFF”.
2. Repeat the “Lighting” steps on prior page.
Turn off:
1. To extinguish burner depress control knob and continue
to turn it clockwise to “OFF”.
2. Turn cylinder valve clockwise to “OFF” and disconnect
WARNING
FOR YOUR SAFETY
Fire pit will be hot after use. Handle with
extreme care.
Figure A Figure B Figure C
1-877-387-3639 | Page 10

CARE & MAINTENANCE
you perform the following maintenance activities
To enjoy years of performance from your re pit, make sure
on a regular basis:
Keepexterior surfaces clean.
or corrosive cleaning agents.
2. While cleaning your unit, be sure to keep the area around
the burner dryat all times. Do not submerge the control valve
assembly. If the gas control is submerged in water, do NOT use it.It must be replaced.
• Keep the ventilation opening of the cylinder enclosure free and clear from debris.
include:
• Fire pit doesNOT reach the desired temperature.
• Fire pit glowis excessively uneven.
• Fire pit makes popping noises.
use. Clean burner holes by using a heavy-duty pipe cleaner. Compressed air may help clearaway smaller particles.
Note: In a salt-air environment (such as near an ocean), corrosion occurs more quickly than normal.
Frequently check for corroded areas and repair them promptly.
Storage
Between uses:
• Turn Control Knob OFF.
• Store re pit in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris).
Note: Wait until fire pit is cool before covering.
Note: Wait until fire pit is cool before covering.
• Disconnect LP source.
• protect exterior surfaces.
• Store re pit in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris).
•
•
protect exterior surfaces.
During periods of extended inactivity or when transporting:
• Turn Control Knob OFF.
• Disconnect LP source and move to a secure, well-ventilated location outdoors.
• Cover re pit with protective cover to prevent water from accumulating in the Firebowl Pan and to
• Never leave LP cylinder exposed to direct sunlight or excessive heat.
Service
Troubleshooting
WARNING
FOR YOUR SAFETY
minutes after use.
Fire pit is hot to the touch.
pit
PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION
Burner won’t light Propane cylinder is empty Replace propane cylinder
Clear blockage
Control knob is not in ON position Turn control knob to ON
Gas pressure is low
Outdoor temperature is less than 40°F Use a full cylinder
Control knob is fully on
Carbon build-up Clean burner
Thick black smoke Blockage in burner Remove blockage and clean burner inside & outside
1-877-387-3639 | Page 11

CAUTION
Do not operate this re pit if
the Fire Pan and Lava Rocks are wet!
STORAGE
1
2
2. Cover re pit with protective cover to prevent
water from accumulating in the re pan and to
protect exterior surfaces.
Store re pit in an area sheltered from
direct contact with inclement weather
(such as rain, sleet, hail, snow, dust and debris).
1-877-387-3639 | Page 12

one (1) year from the date of purchase.
JAY TRENDS SALES LIMITED ONE (1) YEAR WARRANTY
Conditions and Limitations
Jay Trends warrants its products against manufacturing defects to the original purchaser only, and is subject to the
following conditions and limitations:
This factory warranty is non-transferable and may not be extended what-so-ever by any of our representatives.
The product must be assembled, maintained, and operated in accordance with the printed instructions accompanying it.
environments, accident, alterations, abuse or neglect and parts installed from other manufacturers will nullify this
warranty. Discoloration from chemical cleaners or UV exposure is not covered by this warranty.
Any damages to the product due to weather damage, hail, rough handling, damaging chemicals or cleaners will not be
the responsibility of Jay Trends.
and chemical cleaners, nor chipping on porcelain enamel parts, nor any components used in the installation of the
product.
Should deterioration of parts occur to the degree of non-performance (rusted through or burnt through) within the
duration of the warranted coverage, a replacement part will be provided.
The bill of sale or copy will be required when making any warranty claims from Jay Trends.
All parts replaced under the Limited One (1) Year Warranty Policy are subject to a single claim.
Jay Trends will not be responsible for the installation, labor, or any other costs related to the re-installation of a warranted
part, and such expenses are not covered by this warranty.
Jay Trends reserves the right to have its representative inspect any product or part prior to honoring any warranty claim.
Jay Trends shall not be liable for any transportation charges, labor costs, or export duties.
Replacement Parts
In the event that an item was received missing parts or damaged, either by the manufacturer or in shipping, you may request a
replacement part. Replacement parts are not available for all units and only given at Jay Trends’ discretion. We will assess
available for discontinued items or repackaged (open box) products. Please call Jay Trends Customer Service at 1-877-
387-3639 for replacement parts before returning the damaged item. Please have the following information, which can be
found in your instruction manual, ready before you call Customer Service.
Customer Service: 1-877-387-3639 in USA & Canada
[email protected]
© 2023 Sierra Products, Inc. All rights reserved. Distributed by 4348125 Canada Inc. dba Jay Trends Sales, Dorval, Canada H9P 1J1.
1. Model Number or Item # ______________ .
2. Serial # ______________ & Part # ______________ .
3. Shipping Address ____________________________ .
4. A picture of the damaged item/part/unit.
5. Pictures should be sent to [email protected].
6. Proof of purchase with date______________ .
7. All claims must be received within 30 days of receipt of order.
Jay Trends Sales
1901 Aut. Transcanadienne
Dorval, QC H9P 1J1, Canada
www.jaytrends.com
LIMITED WARRANTY
1-877-387-3639 | Page 13