Sony Walkman D-NE004 User manual

PORTABLE CD PLAYER
US Model
Canadian Model
D-NE005
AEP Model
D-NE004/NE005/NE006
UK Model
D-NE004
E Model
D-NE005/NE0050/NE006
Australian Model
D-NE005
Tourist Model
D-NE006
SPECIFICATIONS
D-NE004/NE005/
NE0050/NE006
Ver. 1.4 2006.03
Model Name Using Similar Mechanism NEW
CD Mechanism Type CDM-3525A/3525AJ
Optical Pick-up Name DAX-25E
9-879-861-05
2006C02-1
© 2006.03
Sony Corporation
Personal Audio Division
Published by Sony Techno Create Corporation
SERVICE MANUAL
Photo: D-NE006
System
Compact disc digital audio system
Laser diode properties
Emission duration: Continuous
Laser output: Less than 44.6 µW (This output is the value measured at a
distance of 200 mm from the objective lens surface on the optical pick-up
block with 7 mm aperture.)
Power requirements
• Two LR6 (size AA) batteries: 1.5 V DC ×2
• AC power adaptor (DC IN 4.5 V jack):
220 V, 50 Hz (NE005: EE,EU8/NE006: EU8, EE, E18)
120 V, 60 Hz (C&SA, MX)
Dimensions (w/h/d) (without projecting parts and controls)
Approx. 139.8 ×28.8 ×139.8 mm
Mass (excluding accessories)
Approx. 200 g
Operating temperature
5°C - 35°C
MPEG Layer-3 audio coding technology and patents licensed from
Fraunhofer IIS and Thomson.
Design and specifications are subject to change without notice.
Supplied accessories
AC power adaptor (1)
(NE005: EE, EU8/NE0050: C&SA, MX/NE006: EU8, EE, E18)
Headphones (1)
Remote control (1) (supplied with D-NE006 only)
Battery life*(approx. hours)
(When the CD player is used on a flat and stable place.)
Playing time varies depending on how the CD player is used.
When using two Sony alkaline batteries LR6 (SG)
(produced in Japan)
G-PROTECTION G-on G-off
Audio CD 16 11
MP3 CD (Recorded at 128 kbps) 23 23
*Measured value by the standard of JEITA (Japan Electronics and
Information Technology Industries Association).
•The indicator sections of roughly show the remaining battery
power. One section does not always indicate one-fourth of the battery
power.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

2
D-NE004/NE005/NE0050/NE006
Notes on chip component replacement
•Never reuse a disconnected chip component.
•Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
•Keep the temperature of the soldering iron around 270 ˚C
during repairing.
•Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
•Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
TABLE OF CONTENTS
1. SERVICING NOTES ................................................ 3
2. GENERAL ................................................................... 3
3. DISASSEMBLY
3-1. Disassembly Flow ........................................................... 4
3-2. Upper Lid Assy, Cabinet (Middle) Assy,
Cabinet (Lower) Assy ...................................................... 4
3-3. Optical Pick-Up (CDM-3525A) ...................................... 5
3-4. JACK Board, MAIN Board ............................................. 5
3-5. LPF Board ....................................................................... 6
4. TEST MODE ............................................................... 7
5. ELECTRICAL ADJUSTMENT ............................. 7
6. DIAGRAMS ................................................................. 8
6-1. Block Diagram ................................................................ 9
6-2. Printed Wiring Board
– MAIN Board (Side A), LPF Board (Side A) – ............. 10
6-3. Printed Wiring Board
– MAIN Board (Side B), LPF Board (Side B),
JACK Board – ................................................................. 11
6-4. Schematic Diagram – MAIN Board (1/2),
JACK Board (1/2) – ........................................................ 12
6-5. Schematic Diagram – MAIN Board (2/2), LPF Board,
JACK Board (2/2) – ........................................................ 13
6-6. IC Pin Function Description ............................................ 15
7. EXPLODED VIEWS
7-1. Upper Lid, Cabinet (Middle) Section .............................. 17
7-2. Cabinet (Lower) Section ................................................. 18
8. ELECTRICAL PARTS LIST .................................. 19
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead-
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
•Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
•Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
•Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK !OR DOTTED LINEWITH
MARK !ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS
QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT
DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS
PUBLIÉS PAR SONY.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

3
D-NE004/NE005/NE0050/NE006
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
During normal operation of the equipment, emission of the laser
diode is prohibited unless the upper lid is closed while turning ON
the S811. (push switch type)
The following checking method for the laser diode is operable.
Fig. 1 Method to push the S811
S811
SECTION 2
GENERAL This section is extracted from
instruction manual.
LOCATING THE CONTROLS
Headphones
P MODE/
VOL +*/–
SOUND/AVLS LINE OUT (European and Tourist model only)
DC IN 4.5V
to an AC outlet
(group)–/+
*(play/pause)
•
AC power adaptor
Display
./>
i(headhpones) jack
OPEN
HOLD (rear)
GROUP
Play mode
MP3 indicator
Track number
Playing time
u
(stop)
Remaining battery power
Group indicator
Sound mode
Bookmark
* The button has a tactile dot.
x
•Method:
Emission of the laser diode is visually checked.
1. Open the upper lid.
2. With a disc not set, turn on the S811 with a screwdriver having
a thin tip as shown in Fig.1.
3. Press the u button.
4. Observing the objective lens, check that the laser diode emits
light.
When the laser diode does not emit light, automatic power
control circuit or optical pick-up is faulty.
In this operation, the objective lens will move up and down 2
times along with inward motion for the focus search.
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

4
D-NE004/NE005/NE0050/NE006
SECTION 3
DISASSEMBLY
•This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
3-2. UPPER LID ASSY, CABINET (MIDDLE) ASSY, CABINET (LOWER) ASSY
Note: Follow the disassembly procedure in the numerical order given.
3-2. UPPER LID ASSY, CABINET (MIDDLE) ASSY,
CABINET (LOWER) ASSY
(Page 4)
3-3. OPTICAL PICK-UP (CDM-3525A)
(Page 5)
3-4. JACK BOARD, MAIN BOARD
(Page 5)
3-5. LPF BOARD
(Page 6)
SET
4 screw
upper lid assy
cabinet (middle) assy
cabinet (lower) assy
3 five screws
2
5 two claws
6 three claws
1 OPEN
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

5
D-NE004/NE005/NE0050/NE006
3-3. OPTICAL PICK-UP (CDM-3525A)
cabinet (lower) assy
3 optical pick-up (CDM-3525A
)
1 CN501
To/From
Optical pick-up
(CDM-3525A)
2 Unsolder four lead wires
MAIN Board (side A)
BLK
ORG
GRY
RED
3-4. JACK BOARD, MAIN BOARD
MAIN Board (side B)
MAIN Board (side B)
JACK Board
(side B)
JACK Board
(side B)
BLK
RED WHT
BLU
IC602
125
26 50
TP412
SGND
BLK
RED
GRY
ORG
4 JACK board
1
5
MAIN board
cabinet (lower) assy
2 Unsolder four lead wires
3 Unsolder four lead wires (AEP, EE, EU8 only)
•Abbreviation
EE : East European
EU8 : European model other than UK, EE
and Russian
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

6
D-NE004/NE005/NE0050/NE006
3-5. LPF BOARD
2 cushion
4 adhesive sheet
3 LPF board
1 Unsolder six lead wires
MAIN Board (side B)
MAIN Board
LPF Board
MAIN Board (side A)
BLK
BRN
ORG
TP843
DVDD
C103(+)
TP842
SEG5
TP841
CDM4
TP844
RCH
TP307
AUGND2
WHT
YEL
RED
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

7
D-NE004/NE005/NE0050/NE006
SECTION 4
TEST MODE
The CD section adjustments are done automatically in this set.
Adjusting Procedure:
1. Perform check in the order given.
2. Use YEDS-18 disc (Part No: 3-702-101-01) unless otherwise
indicated.
3. Power supply voltage requirement :DC4.5 V in DC IN jack.
(J401)
VOLUME button : Minimum
HOLD switch :OFF
Focus Bias Check
Condition:
• Hold the set in horizontal state.
Connection:
Procedure:
1. Make a solder bridge to short SL801 (OPEN) on the MAIN
board side B.
2. Connect the oscilloscope to the test point TP604 (RF) on the
MAIN board side B.
3. Set a disc. (YEDS-18)
4. Press the ubutton.
5. Check the oscilloscope waveform is as shown below.
A good eye pattern means that the diamond shape ( ) in the
center of the waveform can be clearly distinguished.
RF Signal Reference Waveform (Eye Pattern)
To watch the eye pattern, set the oscilloscope to AC range and
increase the vertical sensitivity of the oscilloscope for easy
watch-ing.
6. Stop revolving of the disc motor by pressing the xbutton.
7. SL801 is opened by taking the solder bridge.
S811
(OPEN)
(SIDE B)MAIN BOARD
TP604
(RF)
1
26
25
50
SL801
(OPEN)
BLU
FB605
FB401
R629
C206 R202
R626
R623
FB601
RB301
FB302
R111
R101
D303
C308
C310
C640
R618
R622
C633
S808
C106
C627
C110
R102
R632
C612
R619
R621
R211
L101
VDR101
VDR201
FB301
R617
2
IC602
R416
R417
R418
ORG RED GRY BLK
X601
BLU
BLU
SL801
(OPEN)
oscilloscope
(AC range)
+
–
TP604
(RF)
RF level
1.3
± 0.2 Vp-p
VOLT/DIV : 500 mV (With the 10 : 1 probe in use
)
TIME/DIV : 500ns
SECTION 5
ELECTRICAL ADJUSTMENTS
Procedure:
1. Make a solder bridge to short SL803 (TEST) on the MAIN
board side B.
2. Press the ubutton.
3. Confirm LCD displays all lights.
4. Confirm the version of the microcomputer will be displayed
in 2 or 3 seconds.
5. To exit this mode, stop supplying power.
6. SL803 is opened by taking the solder bridge.
2
140 40
20 21
60
80
61
41
2
01
1
BATT+
(SIDE B)MAIN BOARD
SL803
(TEST)
4
06
8
21
C632
C811
C410
C412
C403
C411
C404 C408
C409
CB414
R823
R820
R802
R409
FB801
C420
L401
IC401
R812 R826
C623
R829
R835
R811
R824
IC801
VDR801
TP841
(CDM4) TP842
SL803
(TEST)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

8
D-NE004/NE005/NE0050/NE006
Note on Printed Wiring Boards.
•X: parts extracted from the component side.
•Y: parts extracted from the conductor side.
•a: Through hole.
•f: internal component
•: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
•Note for Printed Wiring Boards and Schematic Diagrams
Note on Schematic Diagrams.
•All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or
less are not indicated except for electrolytics and tantalums.
•All resistors are in Ωand 1/4W or less unless otherwise specified.
• f: internal tolerance.
•C: panel designation.
•A: B+ Line.
•H: adjustment for repair.
•Power voltage is dc 3.3 V and fed with regulated dc power supply
from battery terminal.
•Voltages and waveforms are dc with respect to ground under no-
signal conditions.
no mark : CD PLAY
•Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production toler-
ances.
•Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production toler-
ances.
•Circled numbers refer to waveforms.
•Signal path.
J: CD PLAY
•Abbreviation
8E : General Asian model
AUS : Australian model
CND : Canadian model
E18 : Singaporean, Indian, Malaysian, Vietnamese and South
African model
EE : East European model
EU8 : European model other than UK, EE and Russian
EA : Saudi Arabia model
JE : Tourist model
Caution:
Pattern face side: Parts on the pattern face side seen from
(Side B) the pattern face are indicated.
Parts face side: Parts on the parts face side seen from
(Side A) the parts face are indicated.
•Indication of transistor.
SECTION 6
DIAGRAMS
C
B
These are omitted.
E
Q
D
G
These are omitted.
S
Q
•Waverforms
1
IC601 ya XO
0.5 V/DIV, 50 ns/DIV
59 ns
1.3 Vp-p
2
IC801 yd XOUT4M
1 V/DIV, 0.1 µ s/DIV
238 ns
3.4 Vp-p
•Abbreviation
8E : General Asian model
AUS : Australian model
CND : Canadian model
E18 : Singaporean, Indian, Malaysian, Vietnamese and South
African model
EU8 : European model other than UK, EE and Russian
EE : East European model
EA : Saudi Arabia model
JE : Tourist model
Note:
The components identified
by mark 0or dotted line
with mark 0are critical for
safety.
Replace only with part
number specified.
Note:
Les composants identifiés
par une marque 0sont
critiques pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

99
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
6-1. BLOCK DIAGRAM
: CD PLAY
• Signal Path
• Abbreviation
EE : East European
EU8 : European model other than UK, EE and Russian
3
80 79
3
5
65
1
767
2
10
4
6
7
13 14 15 16
7563
51
60 33 4961
24 382223505349474839
62
535750515254
3
57
6
9
18
DRIVER
DRIVER
DRIVER
17
19
20
23
22
11
DIGITAL
SIGNAL
PROCESSOR
SERVO
SIGNAL
GEN.
RF
SIGNAL
GEN.
OP IC
DIGITAL SERVO
SIGNAL PROCESSOR
PD
LD
FDOUT TDOUT SDOUT CLVOUT
TRK
FOCUS
56
CLK88 VDD_CORE1 VDD_CORE2
CLK
TRK
SLED
CLV
XO XI SUBSYQ MCK DIN/DOUT R/W RESTB BUSY
CLOCK
OSC
1 BIT
DAC
LINE
AMP
31
36
21
35
SWITCHING
Q404
MUTE DRIVE
Q301
SWITCHING
Q403
17 16 15
39,42-48
19-24,27-32
2,3,5,6,8,9,11,12,39,
40,42,43,45,46,48,49
32-21
MP3 &
ADPCM CORE
4167 68 40
2-21 77-80
65
LCD801
LIQUID
CRYSTAL
DISPLAY
KEY MATRIX
XIN4M
SUBSYQ
55
CLK
MCK
DIN OUT
RW
EE_SCL
XLINE_DET
XLINEOUT_MUTE
EE_SDA/REM_SDA
XXRESET
BUSY
FIFO
56
XHP_MUTE
MMUTE2
XRESET
SEG1 I SEG20 COM1 I COM4
KEY1
COM4
KEY2
OPEN/CLOSE
HOLD
REGB
65
DC IN
66
BATT+
30 DCIN
IC801
SYSTEM
CONTROL
L401
D403
F402
F401
LG
PVCC
+VBAT
VG
DDC
L402
L403
VG
38 VSYS
37 SW
X601
16.9344MHz
RDACO
LDACO
Q602
OUT1
SEG5
COM4
OUT2
Q302
IN1
IN2
SDA SCL
7
WP
2
XMUTE
IC301
HEADPHONE AMP
IC802
EEPROM
IC401 (2/2)
DC/DC CONVERTER
BD
AC
DDC
E
FO+
FO-
TRK-
TRK+
SLED+
SLED-
F
ASY
VBIAS
AMP
10 FOCUS
+VBAT
AMP
8SLED
AMP
7CLV
CLK
TRK
FOCUS
VREF
SLED
CLV
CLK
AMP
RESET
74
2XP.OFF
OFF
76
WREM
Q801
NE006
Q802 VG
70
4
MUTE34
75
5MMUTE1
MUTE1
43
1K_PLAY
SEG5
WP
IC401 (1/2)
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE MOTOR DRIVE
IC602 SDRAM(16M)
RAS CAS WE
RASX
A00-A11
DQ00-07
RFI
EQO
CASX
WEX
LDQM
UDQM
DQ00-07 A0-11
34 35 36 37 38
14 36
LDQM UDQM
35 34
CLK CKE
RCLK
FLAG0
AD_MONI0
RCKE
A13
17 18 19
IC601
RF AMP, SERVO,
DIGITAL SIGNAL PROCESSOR,
SDRAM CONTROLLER,
D/A CONVERTER
IC603
REG
J401
DC IN 4.5V
!
DRY BATTERY
SIZE "AA"
(IEC DESIGNATION LR6)
2PCS. 3V
J301
i
J302
LINE OUT
AEP, EE, EU8, JE
(SLED)
FOCUS
COIL
(SPINDLE)
M
TRACKING
COIL
F+
F-
T+
T-
SLED+
SLED-
DRIVER
25
24
SPID+
SPIN-
M
SPINDLE+
SPINDLE-
OPTICAL
DEVICE
(CDM-3525A/3525AJ)
VCC
+
+
A
B
C
E
F
LD
PD
VC
LD
DRIVER
Q601
DDC
S811
(OPEN)
S812
HOLD
OFF ON
APC
9
8
D803
S801
S802 – S809
+B SWITCH
Q401
DC IN DETECT
Q402
X8 OVER
SAMPLING
DIGITAL FILTER
16K SRAM
5 1
VOUT DDC VIN
L.P.F
Q101 – 104
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1010
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
6-2. PRINTED WIRING BOARD – MAIN BOARD (SIDE A), LPF BOARD (SIDE A) – :Uses unleaded solder.
E
+– +–
(SLED)
M
(SPINDLE)
M
OPTICAL DEVICE
(CDM-3525A/3525AJ)
(1/2)
12
(12)
1-867-954-
1
34
5
11
(11)
1-868-890-
(SIDE A)LPF BOARD
BOARD
MAIN
(SIDE B)
(Page 11)
< 1 >
< 2 >
< 3 >
RB305 RB302
C108
C303
C625
C618
C641
C630
C202
C629
C631
C637
RB304
RB303
FB604
FB602
RB620
1
80
61 41
60 40
21
20
IC601
IC603
C611
C609
C604
D803
D810
D403
D401
R608
R620
R308
R307
R601
R615
C615
C634
R606
R303
R630
R410
R817
Q801
R407
R404
R810
R801
L406
L407
SPINDLE–
SPINDLE+
SLED–
SLED+
R406 R405
R403
R818
R848
R847
R808
R850
C809
C805
TP843
(DVDD)
TP844
(RCH)
TP307
(AUGND2)
1
45
8
IC802
C413
C405
C806
C814
C808
C812
Q401
Q403
Q402
RB806
IC301
C208
C301
BLK
RED
ORG
C102
C210
C624
C619
R613
C606
C605
C626
C802
C813
R843
VDR802
R844
R804
R309
R862
C807
C801
C428
R422
R827
BRN
ORG
RED
BLK
R614
R640
R424
R305R310R311
R607
C620
C201
C101
R201
R103 R104
R204
R203
R304
R624
1
45
8
(SIDE A)BOARDMAIN
23 4 5 6 7
A
1
B
C
D
E
F
8
Q301
EQ602
Q302
E
Q802
E
(AEP,EE,EU8,JE)
(AEP,EE,EU8,JE)
(AEP,EE,
EU8,JE)
(NE006)
(NE006)
(NE006)
(NE004:AEP/NE005:EU8/
NE006:AEP)
(NE004:EE/NE005:US,CND,AEP,EE,E,
8E,AUS,EA/NE0050/NE006:EE,E18,JE)
• Semiconductor
Location
Ref. No. Location
D401 E-6
D403 D-6
D803 D-5
D810 D-5
IC301 A-2
IC601 B-3
IC603 C-4
IC802 E-4
Q301 B-2
Q302 B-2
Q401 D-6
Q402 E-6
Q403 E-7
Q602 B-3
Q801 D-5
Q802 E-7
VDR802 E-5
Ver. 1.3
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1111
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
6-3. PRINTED WIRING BOARD – MAIN BOARD (SIDE B), LPF BOARD (SIDE B), JACK BOARD – :Uses unleaded solder.
E
E
21 40 40
20
22
21
60
80
61
41
20 1
1
1
1
2
15
16
BLK
DC IN–
DC IN+
BATT+
DC IN–
DC IN+
BATT+
BLK
RED
RED
WHT
WHT
OPTICAL DEVICE
(CDM-3525A/3525AJ)
(2/2)
S811
(OPEN)
i
J301
S804
VOL+
J302
LINE OUT
S808
SOUND/
AVLS
S805
VOL–
S806
S806
GROUP
S809
P MODE/
S803
.
S802
>
S807
x
S801
u
S812
HOLD
.
ON
T
OFF
(SIDE B)MAIN BOARD
(SIDE B)
LPF BOARD
23 4 5 6 7 8
A
1
B
C
D
E
F
DC IN 4.5V
DRY BATTERY
SIZE "AA"
(IEC DESIGNATION LR6)
2PCS. 3V
LCD801
LIQUID CRYSTAL
DISPLAY
TP604
(RF)
12
(12)
11
(11)
1-867-954-
1-868-890-
1
26
25
50
SL801
(OPEN)
BOARD
MAIN
(SIDE A)
(Page 10)
BLU
SL803
(TEST)
FB605
FB401
R629
C206 R202
R626
R623
FB601
RB301
FB302
R111
R101
D303
C308
C310
C640
R618
R622
C633
C104
C204
C203
R851
C103
S805
Q101
D101
R101
TP104
BLK
RED
ORG
YEL
BRN
BRN
YEL
WHT
WHT
TP101
TP102
TP103 C102
TP106
C104 C105
R102
TP105
< 1 >
< 2 >
< 3 >
R104 R105
R106R107
R108
Q102
Q103
Q104
S804
S809
S808
C106
C627
C110
R845
R828
R846
CN801
R102
R632
C612
C402
R853
R619
R621
R211
L201
L101
VDR101
VDR201
D404
D406
FB304
FB301
R617
R602
F402
CN401
CN402
F401
L409
L405 L404
C427
R420
L408
FB102 FB202
FB303
IC602
1-867-955-
JACK BOARD
C406
R821
R416
R417
C632
C642
R401
R415
C811
C410
C412
C403
C411
C404 C408
C810
C409
CB414
C417
C407
C416
R849
R823
R820
R802
R409
FB801
R418
R419
R605
C309
ORG
BLU
RED
GRY
BLK
ORG RED GRY BLK
R402
R414
L403
Q404
C419
S801
S803
S802
S807
C420
C401
C420
C209
C306
C109
L401
L402
IC401
R812 R826
C601
C623 C628
C610 C304
C305
C602
R829
R835
R811
R824
IC801
CN501
C607
C603
R852
R854
C105
C205
R604
R603
VDR801
X601
Q601
D402
C421
J401
11
(11)
TP841
(CDM4) TP842
(SEG5)
BLU
BLU
(AEP,EE,EU8,JE)
(AEP,EE,EU8,JE)
(NE006)
(NE006)
(AEP,EE,EU8,JE)
(AEP,EE,EU8,JE)
(AEP,EE,EU8,JE)
(EXCEPT AEP,EE,EU8,JE)
(AEP,EE,EU8,JE)
• Semiconductor
Location
Ref. No. Location
D101 F-7
D303 B-7
D402 C-3
D404 B-2
D406 B-2
IC401 D-3
IC602 B-6
IC801 E-4
Q101 F-7
Q102 F-7
Q103 F-7
Q104 F-7
Q404 E-2
Q601 C-5
VDR801 D-5
Ver. 1.3
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1212
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
6-4. SCHEMATIC DIAGRAM – MAIN BOARD (1/2) , JACK BOARD (1/2) – • See page 8 for Waveforms. • See page 14 for IC Block Diagrams.
/
3525AJ
D401
D403
L406
47uH 47uH
L407
C410
C411
C412
C403
L401
330uH
CB414
R417
R418
R419
R623
C615
C605
C609
C606
R606
R613
R614
C610
C611
C618
C620
C625
R619
R618
RB620
C103
C406
R102
R202
J301
R111
R211
C104
C203
RB301
R101
R201
C110
C210
C301
C204
R406 C413
C626
R305
C603
C604
R304
Q602
R410
C607
CN403
CN404
CN407
CN408
IC401
R403
C409
C404
R405
C305
C628
C624
C206
C106
C108
C208
R407
C303
CN501
IC601
IC602
C109 C209
C306
C309
FB202
FB102
0uH
0uH
0uH
FB303
C630
C629
R632
R811
R629
FB602
FB604
Q301
Q302
R103 R203
C105 C205
C102 C202
C101 C201
RB303 RB304
R307
R308
FB601
C641
Q402
Q401
R605
R603
R604 C601
R602 C623
C602
R615
Q601
DQ01
DQ02
DQ03
DQ04
DQ05
DQ06
A00
A01
A02
A03
A04
A05
A06
A07
A08
A09
A10
A11
A12
A13
IC603
C634
R630
C632
FB605
R617
L201
L101
1uH
1uH
D303
FB302
C310
C308
FB301
FB304
R310
R311
R204
R104
R622
C631
R621
R626
C402
C407
FB401
R409
C408
DQ00
C637
C633
C627 C640
RB302
IC301
X601
R601
R620
R608
R607
R309
R640
J302
C304
R416
RB305
C612
C619 R624
VDR101
VDR201
UDZSTE-176.2B
RB160M-30TR
0.1
470p
1
0.1
0.022
100k
47k
22k
0
2200p
0.1
2200p
0.1
220k
68k
470
4.7 50V
0.22
470p
0.1
2.2
100k
1M
10k
4.7
50V
0.1
2.2
2.2
10
10
220
6.3V
4.7
50V
1k
10
10
1000p
1000p
0.1
220
6.3V
10k 0.022
0.01
220k
0.01
0.1
1M
DTC114TUA-T106
BUFFER
1
47
6.3V
BH6575FV-E2
1k
10
35V
10
35V
12k
47
6.3V
10
35V
0.1
0.22
0.22
470p
470p
27k
1
16P
BU9541AKV
M12L16161A-7T(G)
0.001 0.001
0.1
0.1
10
2.2
0
100k
0
0H
0
DTA114TUA-T106
MUTE DRIVE
UMH8N-TR
MUTE
22k 22k
2.2 2.2
1000p 1000p
2200p 2200p
470 470
0
0
0
0.01
UMH8N-TR
DC IN DETECT
2SB1132-T100Q
+B SWITCH
0
4.7
100k 47
6.3V
2.2
470 6.3V
47 6.3V
68k
2SA1576A-T106-QR
LD DRIVER
BH15FB1WG
1
0
10
C642
135V
0H
100
UDZSTE-176.2B
0H
0.1
0.1
0H
0H
47k
0
0
0
220
0.1
0H
220
0.01
10
0
0
220
6.3V
0.1
0.1
4.7 4.7
22k
BH3544F-FE2
16.9344MHz
10k
10k
10k
10k
0
0
100
6.3V
22k
22k
0.1
0.1 100k
220P
220P
GND
BUS
VCC
PVCC
XLINE DET
GND
B+
D GND
R-CH
L-CH
A01
A02
A03
A10
A11
A00
DQ00
DQ01
DQ02
DQ03
DQ04
DQ05
DQ06
DQ07
WE
CAS
RAS CKE
CLK
9
11
13
14
15
16
18
19
20
21
A04
A05
A06
A07
A08
A09
1
2
4
5
6
7
8
DQ07
WE
CAS
RAS
A00
A01
A02
A03
A04
A05
A06
A07
A08
A09
A10
A11
CLK
CKE
3
DQ00
DQ01
DQ02
DQ03
DQ04
DQ05
DQ06
UDQM
DQ00
DQ01
DQ02
DQ03
DQ04
DQ05
DQ06
DQ07
UDQM
LDQM
LDQM
PVCC
SLED-
SLED+
SPIND-
SPIND+
DPG2
SPRT
SOFT
CT
DCIN
REGB
REGO
PRGND
PGND
LG
VG
SW
VSYS
EI
EO
TRK+
TRK-
FO+
FO-
FIL4
FIL3
FIL2
FIL1
VREF
FOCUS
TRK
SLED
CLV
RESET
MUTE1
MUTE34
CLK
OFF
WP
VSS
DQ15
DQ14
VSSQ
DQ13
DQ12
VCCQ
DQ11
DQ10
VSSQ
DQ9
DQ8
VCCQ
NC
UDQM
CLK
CKE
NC
A9
A8
A7
A6
A5
A4
VSS
VCC
DQ1
VSSQ
DQ2
DQ3
VCCQ
DQ4
DQ5
VSSQ
DQ6
DQ7
VCCQ
LDQM
XWE
CAS
RAS
XCS
A11
A10
A0
A1
A2
A3
VCC
OUT1
XMUTE
IN1
GND
IN2
BIAS
OUT2
VCC
RCLK
RCKE
WEX
CASX
RASX
CLVOUT
SDOUT
TDOUT
FDOUT
FCO
PCO
ASY
LD
PD
F
E
VBIAS
BD
AC
AVDD1
EQO
ANA MONI1
ANA MONI0
TEST
AD MONI1
AD MONI0
AGND2
RDACO
VCDAC
LDACO
AVDD2
XO
XI
16M SDRAM
C
E
A
B
F
VCC
VC
GND
GND
PD
LD
NC
F+
T+
T-
F-
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE MOTOR DRIVE,
DC/DC CONVERTER
DPG1
RFI
AGND1
PROCESSOR,
SD RAM CONTROLLER ,D/A CONVERTER
RF AMP,SERVO,DIGITAL SIGNAL
HEADPHONE AMP
DQ0
(2/2)
(Page 13)
BOARD
MAIN
HPRDAC0
VDD RD
VSS RD
VSS LD
HPLDACO
VDD LD
FLAG0
DVDD2
DGND2
RESTB
CLK88
CLK
SUBSYQ
BUSY
MCK
DI/NDOUT
R/W
VDD CORE
DVDD1
VDD CORE1
LDQM
UDQM
DQ07
DGND
REG
VIN
VSS
CE
VOUT
NC
NE006
AEP,EE,EU8,JE
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1313
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
6-5. SCHEMATIC DIAGRAM – MAIN BOARD (2/2), LPF BOARD, JACK BOARD (2/2) – • See page 8 for Waveforms. • See page 15 for IC Pin Function Description.
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG0
COM1
COM2
COM3
COM4
D402
D404
D803
L402
165uH
C416
C417
R414
R415 C419
L403
10uH
C405
R404
S801
S804
S805
S808
S809
S812
SL801
R820
R823
R829
R824
R826
R812
R828
C805
R808
SL802
R818
C806
RB806
C802
R810
R801
R827
R821
C811
C809
Q801
Q802
C807
Q403
Q404
CN401
CN402
R844
R843
C808
S811
R402
R401
C401
J401
IC801
IC802
R804
C810
R835
D810
C801
C428
R422
D406
L408
F401
L409
C427
S807
S806
S803
S802 R845 R846
R847 R848
R849
R850
R851
R852
R853
R854
C812
C813
R817
VDR801
VDR802
FB801
SEG18
SEG19
SEG20
C420
R862
R424
SL803
R802
F402
L404
L405
R420
C814
R303
C421
Q101
Q102
Q103
Q104
C104 C105
R104 R105
R106
R107
R108
R102
C102
R101
D101
TP101
TP106
TP104
TP105 TP103 TP102
RB160M-30TR
UDZS-TE17-12B
1SS355TE-17
47p
0.1
10
1k 220
6.3V
1000p
100
0
1k
100k
0
0
100k
1k
0.1
100k
100k
0.1
47k
0.01
1M
1M
470k
100k
0.1
0.1
2SK3019TL
SWITCH
DTA114TUA-T106
BUFFER
1
2SD2652T106
SWITCHING
2SD2652T106
SWITCHING
10k
10k
1
(OPEN)
22k
100k
1
BU18704-S1
BR24L02F-WE2
0
22
16V
0H
RB751V-40TE-17
1
0.022
47k
UDZS-TE17-12B
2A
32V
1
10k 10k
00
2.2k
4.7k
22k
2.2k
4.7k
22k
470p
470p
10k
0
470
6.3V
0
0
TEST
0
1.4A
32V
0
470p
1k
0.22
DTC144WUA
UMB2N-TN
2SK3019TL
UMH8N-TR
L.P.F
L.P.F
L.P.F
L.P.F
0.068 0.068
220 220
1M
1M
0
1M
0.1
22k
1SS355TE-17
BUS
VCC
PVCC
XLINE DET
B+
DGND
GND
R-CH
L-CH
COM1
COM2
COM3
COM4
SEG01
SEG02
SEG03
SEG04
SEG05
SEG06
SEG07
SEG08
SEG09
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
2
11
3
4
5
6
7
20
15
13
1
16
8
9
18
21
14
19
SEG19
SEG20
COM4
SEG05
SEG17
SEG18
COM1
COM2
COM3
COM4
SEG01
SEG02
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG03
SEG04
SEG05
SEG06
SEG07
SEG08
SEG09
SEG10
DC IN 4.5V
DRY BATTERY
SIZE"AA"
2PCS,3V
(IEC DESIGNATION R6)
HOLD
ON
OFF
SDA
SCL
WP
VCC
GND
A2
A1
A0
XOUT75
XIN75
TEST0
XRESET
HXP MUTE
TU CTL
CD CTL
XXRESET
VDD
BUSY
RW
MCK
DIN OUT
K STOP
BEEP
K TUNER
KPLAY
INNER
OPEN/CLOSE
XLINEOUT MUTE
EE SCL
PLL CE
PLL CLK
PLL DATA
EE SDA/REM SDA
GND
PLL RST
ST DET
XLINE DET
SUBSYQ
HOLD
MMUE2
MMUE1
XP.OFF
TEST1
SEL DRAM
SEL OPTION
WREM
TEST MODE
BATT+
DC IN
VDD
XOUT4M
XIN4M
GND
LIQUID
CRYSTAL
DISPLAY
SYSTEM CONTROL
MO/ST
EEPROM
BOARD
MAIN
(1/2)
(Page 12)
NC
NC
NC
NC
NC
SEL CEX
NE004:EE/NE005:US,CND,AEP,EE,
NE006
KEY1
KEY2
AEP,EE,EU8,JE
AEP,EE,EU8,JE
AEP,EE,EU8,JE
EXCEPT
1
5
10
15
20
24
AEP,EE,EU8,JE
AEP,EE,EU8,JE
FIFO
E,8E,AUS,EA/NE0050/NE006:EE,E18,JE
NE006:AEP
NE004:AEP/NE005:EU8/
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1414
D-NE004/NE005/NE0050/NE006
D-NE004/NE005/NE0050/NE006
•IC Block Diagrams
IC301 BH3544F-FE2
+
67 58
+
2
1 3 4
OUT 1
XMUTE
MUTE
IN 1
GND
VCC OUT 2 BIAS IN 2
BIAS
TSD 6dB
6dB
90k
90k
IC401 BH6575FV-E2
EO
SYSTEM
ON OSC
SYSTEM
OFF
CLK
30k
30k
DC/DC
CONVERTER
–
+
– +
–
+
VG
CONV
VSYS REG
PRE-DR
VSYS
DETECT
OFF 2
MUTE34 4
CLK 3
MUTE1 5
RESET 6
CLV 7
SLED
TRK 9
VREF 11
FIL1 12
FIL2 13 FIL3 14
DPG1 16
TRK– TRK+
19 20
FIL4 15
WP 140
SPIND– SLED+ SLED– PVCC
24 23 22 21
SPIND+
25
SPRT
27
DPG2
26
SOFT
28
DCIN
30
CT
29
REGO
32
REGB
31
PRGND
33
PGND
34
VG
36
LG
35
VSYS
38
SW
37
EI
39
MUTE34
–
–
+
RESET
MUTE1
– +
8
30k
– +
–
+
–
+
–
+
30k
– +
FOCUS 10
PRE-DR
PRE-DR PRE-DR
FO+ 18
FO– 17
IC601 BU9541AKV
MP3
&
ADPCM
CORE
X8 OVER
SAMPLING
DIGITAL FILTER
DIGITAL
SIGNAL
PROCESSOR
DIGITAL
SERVO
SIGNAL
PROCESSOR
16K SRAM
SERVE
SIGNAL
GENERATOR
RF
SIGNAL
GENERATOR
APC
D CLASS HP
AMPLIFIER
PLL
LINE
AMPLIFIER
1 BIT DAC
AVDD1
AC
BD
VBIAS
AGND1
E
F
PD
LD
ASY
PCO
FCO
FDOUT
TDOUT
SDOUT
CLVOUT
RCLK
RCKE
A13
A12
A11
A10
A09
A08
A07
A06
A05
A04
A03
A02
A01
A00
VDD_CORE1
DGND
RASX
CASX
WEX
LDQM
UDQM
DQ07
SUBSYQ
BUSY
MCK
DIN/DOUT
VDD_CORE2
DQ00
DQ01
DQ02
DQ03
DQ04
DQ05
DQ06
DVDD1
R/W
XI
DGND2
TEST
RESETB
CLK
CLK88
EQO RFI
ANA_MONI1
ANA_MONI0 AD_MONI1 AD_MONI0 VDD_RD HPRDACO VSS_RD
VSS_LD HPLDACO VDD_LD AVDD2 RDACO
VCDAC LDACO AGND2 FLAG0 DVDD2 XO
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
80 79 78 77 76 75 74 73 72 71 70 69
54
53
52
51
49
46
45
44
68 67 66 65 64 63 62 61
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
43
42
41
47
48
50
60
59
58
57
55
56
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

15
D-NE004/NE005/NE0050/NE006
6-6. IC PIN FUNCTION DESCRIPTION
Pin No. Pin name I/O Description
• IC801 BU18704-S1 (SYSTEM CONTROLLER)
1SEG0 O Not used (OPEN)
2 to 21 SEG1 to SEG20 O LCD segment output
22 XLINEOUT_MUTE O LINE OUT muting output
23 EE_SDA/REM_SDA I/O EEPROM data
24 EE_SCL O EEPROM clock
25 PLL_CE O Not used (OPEN)
26 PLL_CLK O Not used (OPEN)
27 PLL_DATA O Not used (OPEN)
28 NC O Not used (OPEN)
29 CEL_CEX O Select model
30 NC O Not used (OPEN)
31 NC I Not used (OPEN)
32 NC I Not used (OPEN)
33 GND – Ground terminal
34 NC I Not used (OPEN)
35 PLL_RST O Not used (OPEN)
36 ST_DET O Not used (OPEN)
37 MO/ST O Not used (OPEN)
38 XLINE_DET I LINE OUT sensing status detection input
39 SUBSYQ I Sub code sync interuption input
40 HOLD I HOLD switch status detection input
41 OPEN/CLOSE I OPEN switch status detection input
42 INNER I Not used (OPEN)
43 K_PLAY I PLAY KEY input
44 K_TUNER I Not used (OPEN)
45 BEEP O Not used (OPEN)
46 NC I Not used (OPEN)
47 DIN OUT I/O Command output , DSP status input, subcode Q input
48 MCK O Serial interface clock output
49 RW O DSP’s serial interface Read/Write signal output
50 BUSY I DSP’s auto sequencer status
51 FIFO O SDRAM initialize output
52 VDD – Power supply for CPU and I/O
53 XXRESET O System reset output
54 CD_CTL O Not used (OPEN)
55 TU_CTL O Not used (OPEN)
56 XHP_MUTE O Headphone IC mute ON/OFF control output
57 XRESET I Microcomputer reset terminal
58 TEST0 I Connect to GND
59 XIN75 I Not used (fixed at “L”)
60 XOUT75 O Not used (OPEN)
61 GND – Ground terminal
62 XIN4M I 4MHz clock input
63 XOUT4M O 4MHz clock output (OPEN)
64 VDD – Power supply for CPU and I/O
65 DC_IN I DC IN voltage monitoring input
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

16
D-NE004/NE005/NE0050/NE006
Pin No. Pin name I/O Description
66 BATT+ I Batt+ terminal voltage monitoring input
67 KEY1 I Key matrix detect input
68 KEY2 I Key matrix detect input
69 TEST MODE I Test mode terminal
70 WREM I Wired remotecontroler key detection input (D-NE006 only)
71 SEL_OPTION I Connect to GND
72 SEL_DRAM I Connect to GND
73 TEST1 I Connect to GND
74 XP_OFF O Power OFF contorol output
75 MMUTE1 O Spindle motor drive mute output
76 MMUTE2 O Focus/Tracking drive mute output
77 to 80 COM1 to COM4 O LCD common output
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

17
D-NE004/NE005/NE0050/NE006
SECTION 7
EXPLODED VIEWS
NOTE:
•-XX and -X mean standardized parts, so they
may have some difference from the original
one.
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
•The mechanical parts with no reference
number in the exploded views are not supplied.
•Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
R R
Parts of Color Cabinet’s Color
•Accessories are given in the last of the electrical parts
list.
•Abbreviation
7CE7 : UK model (without LINE OUT)
8E : General Asian model
AUS : Australian model
CND : Canadian model
E18 : Singaporean, Indian, Malaysian, Vietnamese
and South African model
EE : East European model
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
Les composants identifiés par une
marque 0sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
4
35
7
1
2
6
8
cabinet (lower) sectio
n
12-596-441-01 SPRING (OPEN)
2 2-638-194-01 KNOB (OPEN) (SILVER)
22-638-194-11 KNOB (OPEN) (WHITE)
22-638-194-21 KNOB (OPEN) (BLACK)
22-638-194-31 KNOB (OPEN) (BLUE)
22-638-194-41 KNOB (OPEN) (PINK)
33-254-070-01 SCREW
4X-2067-314-1 LID ASSY (W), UPPER (WHITE) (NE005: US)
4X-2067-316-1 LID ASSY (L), UPPER (BLUE) (NE005: US, CND)
4X-2067-317-1 LID ASSY (B), UPPER (BLACK) (NE005: US, CND)
4X-2067-318-1 LID ASSY (P), UPPER (PINK) (NE005: US, CND)
4X-2067-319-1 LID ASSY (BM), UPPER (METALLIC BLACK)
(NE006)
4X-2067-436-1 LID ASSY (W), UPPER (WHITE) (NE004)
4X-2067-437-1 LID ASSY (L), UPPER (BLUE) (NE004)
4 X-2067-438-1 LID ASSY (SM), UPPER (METALLIC SILVER)
(NE0050)
4X-2067-439-1 LID ASSY (BM), UPPER (METALLIC BLACK)
(NE0050)
4X-2067-440-1 LID ASSY (LM), UPPER (METALLIC BLUE)
(NE0050)
4X-2067-441-1 LID ASSY (PM), UPPER (METALLIC PINK)
(NE0050)
4 X-2067-442-1 LID ASSY (SM), UPPER (METALLIC SILVER)
(NE005: EXCEPT US, CND)
4X-2067-443-1 LID ASSY (BM), UPPER (METALLIC BLACK)
(NE005: EXCEPT US, CND)
4X-2067-444-1 LID ASSY (LM), UPPER (METALLIC BLUE)
(NE005: EXCEPT US, CND)
4 X-2067-446-1 LID ASSY (SM), UPPER (METALLIC SILVER)
(NE006)
4X-2067-447-1 LID ASSY (LM), UPPER (METALLIC BLUE)
(NE006)
4X-2067-448-1 LID ASSY (PM), UPPER (METALLIC PINK)
(NE006)
4X-2067-639-1 LID ASSY (P), UPPER (PINK) (NE004)
52-596-453-03 SPRING (UPPER LID)
62-660-036-01 CABINET (MIDDLE)(GRAY)…(WHITE)
(NE005:US)
62-660-036-11 CABINET (MIDDLE)(WHITE)…
(BLACK, BLUE, PINK)
(NE004:7CE7/NE005:US, CND, E, 8E, AUS, EA/NE0050)
62-660-036-21 CABINET (MIDDLE) (with LINE OUT)
(GRAY)…(WHITE) (NE004)
62-660-036-31 CABINET (MIDDLE) (with LINE OUT)
(WHITE)…(BLACK, BLUE, PINK)
(NE004:AEP, EE/NE005: AEP, EE, EU8/NE006)
72-596-454-03 LID, BATTERY CASE (WHITE)
7 2-596-454-13 LID, BATTERY CASE (BLACK, BLUE, PINK)
82-657-849-01 SHEET (A)
7-1. UPPER LID, CABINET (MIDDLE) SECTION
Ver. 1.3
EU8 : European model other than UK,
EE and Russian
EA : Saudi Arabia model
JE : Tourist model
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

18
D-NE004/NE005/NE0050/NE006
7-2. CABINET (LOWER) SECTION
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
51
52
53
54
57
55
64
65
59
63
60
56
58
61 61
62
not supplied
not supplied
a
a
51 2-638-196-01 BUTTON (B) (SILVER)
51 2-638-196-11 BUTTON (B) (WHITE)
51 2-638-196-21 BUTTON (B) (BLACK)
51 2-638-196-31 BUTTON (B) (BLUE)
51 2-638-196-41 BUTTON (B) (PINK)
52 2-638-197-01 KNOB (HOLD) (SILVER)
52 2-638-197-11 KNOB (HOLD) (WHITE)
52 2-638-197-21 KNOB (HOLD) (BLACK)
52 2-638-197-31 KNOB (HOLD) (BLUE)
52 2-638-197-41 KNOB (HOLD) (PINK)
53 X-2103-043-1 CABINET (LOWER) (S) SUB ASSY (SILVER)
(NE005/NE0050)
53 X-2103-044-1 CABINET (LOWER) (W) SUB ASSY (WHITE)
(NE005: US)
53 X-2103-045-1 CABINET (LOWER) (B) SUB ASSY (BLACK)
(NE005/NE0050)
53 X-2103-046-1 CABINET (LOWER) (L) SUB ASSY (BLUE)
(NE004: 7CE7/NE005/NE0050)
53 X-2103-047-1 CABINET (LOWER) (P) SUB ASSY (PINK)
(NE005/NE0050)
53 X-2103-048-1 CABINET (LOWER) (W) SUB ASSY
(with LINE OUT) (WHITE) (NE004)
53 X-2103-049-1 CABINET (LOWER) (S) SUB ASSY
(with LINE OUT) (SILVER) (NE005)
53 X-2103-050-1 CABINET (LOWER) (L) SUB ASSY
(with LINE OUT) (BLUE) (NE004: AEP, EE/NE005)
53 X-2103-051-1 CABINET (LOWER) (P) SUB ASSY
(with LINE OUT) (PINK) (NE004)
53 X-2103-052-1 CABINET (LOWER) (S) SUB ASSY (SILVER)
(NE006: E18)
53 X-2103-053-1 CABINET (LOWER) (L) SUB ASSY (BLUE)
(NE006:E18)
53 X-2103-054-1 CABINET (LOWER) (P) SUB ASSY (PINK)(NE006)
53 X-2103-055-1 CABINET (LOWER) (B) SUB ASSY (BLACK)
(NE006)
53 X-2103-056-1 CABINET (LOWER) (S) SUB ASSY
(with LINE OUT) (SILVER) (NE006: AEP, EE, JE)
53 X-2103-057-1 CABINET (LOWER) (L) SUB ASSY
(with LINE OUT) (BLUE) (NE006: JE)
54 2-638-195-01 BUTTON (A) (SILVER)
54 2-638-195-11 BUTTON (A) (WHITE)
54 2-638-195-21 BUTTON (A) (BLACK)
54 2-638-195-31 BUTTON (A) (BLUE)
54 2-638-195-41 BUTTON (A) (PINK)
55 2-596-449-01 TERMINAL (RELAY), BATTERY
56 A-1132-884-A MAIN BOARD, COMPLETE
(NE004: 7CE7/NE005: US, CND, E, 8E, EA, AUS/
NE0050: 4E, C4E, C&SA, MX) (TYPE-1/2/3)
56 A-1132-884-B MAIN BOARD, COMPLETE
(NE004: 7CE7/NE005: US, CND, E, 8E, EA, AUS/
NE0050: 4E, C4E, C&SA, MX) (TYPE-4)
56 A-1132-889-A MAIN BOARD, COMPLETE
(NE004: EE/NE005: AEP, EE) (TYPE-1/2/3)
56 A-1132-889-B MAIN BOARD, COMPLETE
(NE004: EE/NE005: AEP, EE) (TYPE-4)
56 A-1132-894-A MAIN BOARD, COMPLETE
(NE004: AEP/NE005: EU8) (TYPE-1/2/3)
56 A-1132-894-B MAIN BOARD, COMPLETE
(NE004: AEP/NE005: EU8) (TYPE-4)
56 A-1132-909-A MAIN BOARD, COMPLETE
(NE006: EU8) (TYPE-1/2/3)
56 A-1132-909-B MAIN BOARD, COMPLETE (NE006: EU8)
(TYPE-4)
56 A-1132-912-A MAIN BOARD, COMPLETE (NE006: EE, JE)
(TYPE-1/2/3)
56 A-1132-912-B MAIN BOARD, COMPLETE (NE006: EE, JE)
(TYPE-4)
56 A-1132-915-A MAIN BOARD, COMPLETE (NE006: E18)
(TYPE-1/2/3)
56 A-1132-915-B MAIN BOARD, COMPLETE (NE006: E18)
(TYPE-4)
57 2-598-320-01 PLATE (SHIELD)
58 A-1132-888-A JACK BOARD, COMPLETE (EXCEPT AEP, EE, EU8, JE)
58 A-1132-893-A JACK BOARD, COMPLETE (AEP, EE, EU8, JE)
58 A-1176-056-A JACK BOARD, COMPLETE (NE004: 7CE7)
59 2-596-448-01 TERMINAL (–), BATTERY
60 2-596-447-01 TERMINAL (+), BATTERY
61 3-245-331-02 INSULATOR
062 A-1112-193-A OPTICAL PICK-UP (CDM-3525A) (EXCEPT JE)
062 A-1115-118-A OPTICAL PICK-UP (CDM-3525AJ) (JE)
63 A-1153-155-A LPF BOARD, COMPLETE (TYPE-1/-2 ONLY)
64 2-659-334-01 SHEET (JACK) (for LINE OUT) (AEP, EE, EU8, JE)
65 3-842-929-01 SPACER, KNOB
Ver. 1.4
Refer to supplement-1 page 2 for
distinguish the type of the main
board.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

19
D-NE004/NE005/NE0050/NE006
SECTION 8
ELECTRICAL PARTS LIST
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
NOTE:
•Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
•-XX and -X mean standardized parts, so they
may have some difference from the original
one.
•RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
•SEMICONDUCTORS
In each case, u: µ, for example:
uA... : µA... uPA... : µPA...
uPB... : µPB... uPC... : µPC...
uPD... : µPD...
•CAPACITORS
uF: µF
•COILS
uH: µH
•Abbreviation
7CE7 : UK model (without LINE OUT)
4E : Chilean and Peruvian model
8E : General Asian model
AUS : Australian model
C4E : Argentina model
C&SA : Central and South American model
CND : Canadian model
E18 : Singaporean, Indian, Malaysian, Vietnamese
and South African model
When indicating parts by reference
number, please include the board.
MAIN
Les composants identifiés par une
marque 0sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
The components identified by mark 0
or dotted line with mark 0are critical
for safety.
Replace only with part number specified.
A-1132-888-A JACK BOARD, COMPLETE
(EXCEPT AEP, EE, EU8, JE)
A-1132-893-A JACK BOARD, COMPLETE (AEP, EE, EU8, JE)
*********************
2-596-447-01 TERMINAL (+), BATTERY
2-596-448-01 TERMINAL (–), BATTERY
< CAPACITOR >
C109 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
(AEP, EE, EU8, JE)
C209 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
(AEP, EE, EU8, JE)
C306 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
(AEP, EE, EU8, JE)
C309 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
(AEP, EE, EU8, JE)
C421 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
(AEP, EE, EU8, JE)
C427 1-100-352-91 CERAMIC CHIP 1uF 20% 16V
< DIODE >
D402 8-719-081-34 DIODE RB160M-30TR
D404 8-719-083-82 DIODE UDZS-TE17-12B
D406 8-719-083-82 DIODE UDZS-TE17-12B
< FUSE >
0F401 1-576-415-21 FUSE 2A 32V
0F402 1-576-406-21 FUSE 1.4A 32V
< FERRITE BEAD >
FB102 1-500-234-22 BEAD, FERRITE (CHIP) (1608) (AEP, EE, EU8, JE)
FB202 1-500-234-22 BEAD, FERRITE (CHIP) (1608) (AEP, EE, EU8, JE)
FB303 1-414-813-11 FERRITE, EMI (SMD) (2012) (AEP, EE, EU8, JE)
FB304 1-414-760-21 FERRITE, EMI (SMD) (1608) (AEP, EE, EU8, JE)
< JACK >
J302 1-819-362-21 JACK, HEADPHONE (LINE OUT)(AEP, EE, EU8, JE)
J401 1-819-364-11 JACK, DC (POLARITY UNIFIED TYPE) (DC IN 4.5V)
< COIL >
*L404 1-469-670-21 FERRITE, EMI (SMD) (2012)
(EXCEPT AEP, EE, EU8, JE)
*L405 1-469-670-21 FERRITE, EMI (SMD) (2012)
(EXCEPT AEP, EE, EU8, JE)
L408 1-400-703-21 (3216, EMI FERRITE (SMD) (AEP, EE, EU8, JE)
L409 1-400-703-21 (3216, EMI FERRITE (SMD) (AEP, EE, EU8, JE)
< RESISTOR >
R420 1-216-864-11 SHORT CHIP 0
*************************************************************
A-1153-155-A LPF BOARD, COMPLETE (FORMER TYPE ONLY)
********************
< CAPACITOR >
C102 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C104 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16V
C105 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16V
< DIODE >
D101 8-719-988-61 DIODE 1SS355TE-17
< TRANSISTOR >
Q101 8-729-905-15 TRANSISTOR DTC144WU
Q102 6-551-375-01 TRANSISTOR UMB2N-TN
Q103 8-729-044-37 TRANSISTOR 2SK3019TL
Q104 6-551-395-01 TRANSISTOR UMH8N-TR
< RESISTOR >
R101 1-216-837-11 METAL CHIP 22K 5% 1/10W
R102 1-216-857-11 METAL CHIP 1M 5% 1/10W
R104 1-216-813-11 METAL CHIP 220 5% 1/10W
R105 1-216-813-11 METAL CHIP 220 5% 1/10W
R106 1-216-857-11 METAL CHIP 1M 5% 1/10W
R107 1-216-857-11 METAL CHIP 1M 5% 1/10W
R108 1-216-864-11 SHORT CHIP 0
*************************************************************
A-1132-884-A MAIN BOARD, COMPLETE
(NE005: US, CND, E, 8E, AUS, EA/NE0050)
A-1132-889-A MAIN BOARD, COMPLETE
(NE004: EE/NE005: AEP, EE)
A-1132-894-A MAIN BOARD, COMPLETE
(NE004: AEP/NE005: EU8)
A-1132-909-A MAIN BOARD, COMPLETE (NE006: AEP)
A-1132-912-A MAIN BOARD, COMPLETE (NE006: EE, JE)
A-1132-915-A MAIN BOARD, COMPLETE (NE006: E18)
*********************
2-598-320-01 PLATE (SHIELD)
JACK LPF
EE : East European model
EU8 : European model other than
UK, EE and Russian
MX : Mexican model
EA : Saudi Arabia model
JE : Tourist model
Ver. 1.3
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
20
D-NE004/NE005/NE0050/NE006
MAIN
< CAPACITOR >
C101 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C102 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C103 1-126-794-11 ELECT 4.7uF 20% 50V
(AEP, EE, EU8, JE)
C104 1-124-635-00 ELECT 220uF 20% 6.3V
C105 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V
C106 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C108 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C110 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C201 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C202 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C203 1-126-794-11 ELECT 4.7uF 20% 50V
(AEP, EE, EU8, JE)
C204 1-124-635-00 ELECT 220uF 20% 6.3V
C205 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V
C206 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C208 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C210 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C301 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C303 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V
C304 1-126-382-11 ELECT 100uF 20% 16V
C305 1-126-513-11 ELECT 47uF 20% 6.3V
C308 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C310 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
(NE006)
C401 1-100-352-91 CERAMIC CHIP 1uF 20% 16V
C402 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C403 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C404 1-126-791-11 ELECT 10uF 20% 35V
C405 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C406 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C407 1-112-342-91 CERAMIC CHIP 10uF 20% 10V
C408 1-124-635-00 ELECT 220uF 20% 6.3V
C409 1-126-791-11 ELECT 10uF 20% 35V
C410 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C411 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C412 1-115-156-11 CERAMIC CHIP 1uF 10V
C413 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C416 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C417 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C419 1-124-635-00 ELECT 220uF 20% 6.3V
C420 1-119-941-41 ELECT 470uF 20% 6.3V
C428 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C601 1-126-513-11 ELECT 47uF 20% 6.3V
C602 1-126-513-11 ELECT 47uF 20% 6.3V
C603 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C604 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C605 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C606 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C607 1-126-513-11 ELECT 47uF 20% 6.3V
C609 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C610 1-126-794-11 ELECT 4.7uF 20% 50V
C611 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C612 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C615 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C618 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C619 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C620 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C623 1-119-941-41 ELECT 470uF 20% 6.3V
C624 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C625 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3V
C626 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C627 1-100-507-91 CERAMIC CHIP 4.7uF 20% 6.3V
C628 1-126-791-11 ELECT 10uF 20% 35V
C629 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V
C630 1-100-966-91 CERAMIC CHIP 10uF 20% 10V
C631 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C632 1-126-791-11 ELECT 10uF 20% 35V
C633 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C634 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V
C637 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C640 1-100-507-91 CERAMIC CHIP 4.7uF 20% 6.3V
C641 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C642 1-100-352-91 CERAMIC CHIP 1uF 20% 16V
C801 1-115-156-11 CERAMIC CHIP 1uF 10V
(NE006)
C802 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C805 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C806 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C807 1-115-156-11 CERAMIC CHIP 1uF 10V
C808 1-115-156-11 CERAMIC CHIP 1uF 10V
C809 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C810 1-126-514-11 ELECT 22uF 20% 16V
C811 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C812 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C813 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C814 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
< COMPOSITION CIRCUIT BLOCK >
CB414 1-112-557-11 CERAMIC CHIP 0.022uF 20% 16V
< CONNECTOR >
CN501 1-774-975-51 CONNECTOR, FFC/FPC 16P
< DIODE >
D303 8-719-069-56 DIODE UDZSTE-176.2B (NE006)
D401 8-719-069-56 DIODE UDZSTE-176.2B
D403 8-719-081-34 DIODE RB160M-30TR
D803 8-719-988-61 DIODE 1SS355TE-17
D810 8-719-060-48 DIODE RB751V-40TE-17 (NE006)
< FERRITE BEAD >
FB301 1-414-813-11 FERRITE, EMI (SMD) (2012)
FB302 1-414-760-21 FERRITE, EMI (SMD) (1608) (NE006)
FB401 1-216-864-11 SHORT CHIP 0
FB601 1-216-864-11 SHORT CHIP 0
FB602 1-414-760-21 FERRITE, EMI (SMD) (1608)
FB604 1-216-864-11 SHORT CHIP 0
FB605 1-414-760-21 FERRITE, EMI (SMD) (1608)
FB801 1-414-760-21 FERRITE, EMI (SMD) (1608)
< IC >
IC301 8-759-588-61 IC BH3544F-FE2
IC401 6-704-047-01 IC BH6575FV-E2
Ver. 1.2
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com