Sony DVP-K80P User manual

CD/DVD PLAYER
System
Laser: Semiconductor laser
Signal format system: PAL/NTSC
(See page 16 to switch)
Audio characteristics
Frequency response: DVD VIDEO (PCM
96 kHz): 2 Hz to 44 kHz (±1.0 dB)/
DVD VIDEO (PCM 48 kHz): 2 Hz to
22 kHz (±0.5 dB)/CD: 2 Hz to 20 kHz
(±0.5 dB)
Signal-to-noise ratio (S/N ratio): 115 dB
(LINE OUT L/R (AUDIO) jacks only)
Harmonic distortion: 0.003%
Dynamic range: DVD VIDEO: 103 dB/CD:
99 dB
Wow and flutter: Less than detected value
(±0.001% W PEAK)
Outputs and Input
(Jack name: Jack type/Output level/
Load impedance)
LINE OUT (AUDIO): Phono jack/
2 Vrms/ 10 kilohms
DIGITAL OUT (OPTICAL):
Optical output jack/-18 dBm
(wave length: 660 nm)
DIGITAL OUT (COAXIAL): Phono jack/
0.5 Vp-p/75 ohms
COMPONENT VIDEO OUT (K82P)
(Y, PB/CB, PR/CR): Phono jack/
Y: 1.0 Vp-p, PB/CB,
PR/CR: 0.7 Vp-p/75 ohms
COMPONENT VIDEO OUT
(Y, PB, PR) (K80P)
Phono jack/Y: 1.0 Vp-p/PB, PR:
interlace*1 = 0.648 Vp-p, progressive or
interlace*2 = 0.7 Vp-p/75 ohms
*1 BLACK LEVEL
(COMPONENT OUT) is ON
*2 BLACK LEVEL
(COMPONENT OUT) is OFF
LINE OUT (VIDEO): Phono jack/
1.0 Vp-p/75 ohms
SPECIFICATIONS
S VIDEO OUT: 4-pin mini DIN/
Y: 1.0 Vp-p, C: 0.3 Vp-p (PAL),
0.286 Vp-p (NTSC)/75 ohms
MIC input 1/2: Phone jacks
General
Power requirements:
110–240 V AC, 50/60 Hz
(Except K82P: RUS)
220–240 V AC, 50/60 Hz
(K82P: RUS)
Power consumption: 11 W
Dimensions (approx.):
430 ×55.5 ×243.7 mm
(width/height/depth)
incl. projecting parts
Mass (approx.): 2.04 kg
Operating temperature: 5°C to 35°C
Operating humidity: 25% to 80%
Supplied accessories
See page 14.
Specifications and design are subject to
change without notice.
Photo : DVP-K82P
RMT-D177P
DVP-K80P/K82P
RMT-D177A/RMT-D177P
SERVICE MANUAL
Brazilian Model
EModel
DVP-K80P
Chinese Model
Russian Model
Saudi Arabia Model
Singapore Model
DVP-K82P
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
SECTION 3
BLOCK DIAGRAMS
3-1. OVERALL BLOCK DIAGRAM
3-1 3-2
Notes:
MV-045 mounted PWB must be replaced if IC103
(EEPROM IC) is damaged or not functioning.
The old MV-045 mounted PWB must be completely
disposed.
IC408
IC102
FLASH
MEMORY EEPROM
IC103
IC101
IC406
IC108
IC104
IC407
3.3V REGULATOR IC
VFD DRIVER
CIRCUIT
SDRAM
RESET IC
P-CONT
O/I POWER
TRANSFORMER
SECONDARY
PRIMARY
SW+8V
SW+5V
SW+3.3V
EVER-10V
EVER+5V
EVER+11V
IC201
FOCUS
TRACKING COIL
DRIVE
SPINDLE/SLED
/LOADING
MOTOR DRIVE
IC401
J301
AUDIO/VIDEO OUTPUT
AUDIO LPF
IC402
AUDIO LPF
IC304
VIDEO
BUFFER
DA
CONVERTER
MICROPROCESSOR
RF AMP
SERIAL BUS
IC404
ND401 IC406
IF
MICON
VFD
KEY
FUNCTION
SW-10V
SWITCHING
REGULATOR
EVER +5V
IR RECEIVER
RESET IC
SPINDLE
MOTOR
SLED MOTOR
M
M
MLOADING
MOTOR
CHUCK/TRAY
DETECT
OPTICAL DEVICE
DVD / CD
PDIC
FOCUS
COIL
TRACKING
COIL
INLIMIT
SENSOR
LED
Vkk
EVER 3.3V
MV-045 BOARD
(SEE PAGE 3-5 to 3-13)
IF-131 BOARD
(SEE PAGE 3-17 to 3-20)
BASE UNIT
(DEVICE, OPTICAL
KHM-310CAA/C2RP)
POWER LINE
(SEE PAGE 3-3 to 3-4)
KEY
FUNCTION
LED
INDICATOR
RV501
ECHO VR
RV503
MIC VR
RV502
MIC VR
J502
MIC IN 2
J501
MIC IN 1
IC505
MIC VOL
IC502
MIC AMP
IC507
MIC ADD
IC503
ECHO MIX
CK-151 BOARD
(SEE PAGE 4-25 to 4-28)
MC-155 BOARD
(SEE PAGE 4-21 to 4-24)
IC501
REGULATOR
IC
IC504
ECHO
GENERATOR
• Abbreviation
BR : Brazilian Model
E : Latin America Model
CH: Chinese Model
EA : Saudi Arabia Model
SP : Singapore Model
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-3 3-4
3-2. POWER LINE BLOCK DIAGRAM
Transformer
PC101
Photo Coupler
IC611
Shunt Reg
L312
L512D511
D311
L211 Q211
Q712
Q311
P.CONT
Q501 SW-10V
SW + 5V
SW + 3.3V
MUTE DRIVER
D401
Q401
AU-10V
Q416
+5V Reg
IC403
Audio Buffer
IC401/402
Motor
Driver
IC201
FLD
ND401
3.3 Reg IC
IC407
PROG LED
D401/407
DC-DC CONV
T101
VFD DRIVER CIRCUIT
FUNCTION
KEY Reset IC IC408 IR Receiver IC406 IF MICON IC404
Q401/402
D301-D303
Q301-Q306
CN106
CN401
11
CN101
IC404, 405
Optical Out
Audio DAC
IC406
Coaxial
Q411
RESET IC
IC108 FLASH ROM IC102
EEPROM
IC103
SDRAM
IC104
1.8V Reg
IC110
3.3V Reg
IC 105/7
-5V Reg
IC303
Video Buffer
IC304
MTK IC
IC101
VCC OPTICAL
DEVICE
EVER + 5V
POWER
EVER-10V
SW+5V
SW+3.3V
EVER+5V
EVER+11V AU+11V
SW+8V
CN501
CN405
CN404
CN302
CN201
Q611
L421D411
D211
2 Line
fiters
F101
CN101 L101, L102
ACIN 1
2
T101
8
9
10
6
5
4
3
1
3
1
8
9
10
15 13 11
15 13 11
6
5
4
POWER BOARD (SRV1501WW)
(SEE PAGE 4-29 to 4-32)
MV-045 BOARD
(SEE PAGE 4-5 to 4-16)
IF-131 BOARD
(SEE PAGE 4-17 to 4-20 )
CK-151 BOARD
(SEE PAGE 4-25 to 4-28 )
MC-155 BOARD
(SEE PAGE 4-21 to 4-24 )
66
CN501
3
23
2
IC502IC505IC507
IC503
MIC VR
IC501
IC504
ECHO
GENERATOR
P312
IPD
IC101
D
S
C
Bridge
Rectifier
Diode
PS501
PS502
P311
The components identified by
mark or dotted line with mark
are critical for safety.
Replace only with part
number specified.
Les composants identifiés par
une marque sont critiques
pour la sécurité. Ne les
remplacer que par une pièce
portant le numéro spécifié.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-3. SYSTEM CONTROL/SIGNAL PROCESSOR BLOCK DIAGRAM
3-5 3-6
145
146,147,149~151,158~160
IC102
IC101
CXD9849R
MICROPROCESSOR
AVDECODER
SERVO DSP
16M ROM
IC104
64M SDRAM
RAO~RA11
53~61,67~72,74~76,78,89,92,93
AO~A20
115,117,118,120,121,123~126,128~133,135
RDO-RD15
81~84,86~88,91
HDO – HD7
DQM1
DQMO
BA1
SCL
SDA
113 137143
BA0
140
RAS
139
CAS
138
RWE
142
RCS
156
RCLK
157
CKE
101
110
100
99
98
105
IFSCK
IFSDO
IFBSY
66
77
79
IOWR
IOCS
IOOE
IFSDI
PRST
XIFCS
ACLK
SPDIF
XRST
MIC
XMAMUTE
KRMOD
176
220
225
215
SPDIF
205 MIC
ACLK
ABCK
ALRCK
214
213
ABCK
ALRCK
XMAMUTE
207 KRMOD
C
V MUTE
Y
V
Y/G
CB/B
CR/R
WIDE
196194198200202203209
ASDATA4
222 ASDATA4
C Y CVBS Y/G CB/B CR/R WIDE
229228
XTALI XTALO
XRST
102
103
6
5
IC103
EEPROM
SCL
SDA
IC101 C/BAR PB
5
IC101 C/BAR PB
6
IC101
7
IC101
8202
203 200 198 199 196
IC101 C/BAR PB
4IC101 C/BAR PB
3
IC 108
RESET IC
CN 106
1
MV-045 BOARD
(SEE PAGE 4-7 to 4-8)
TO MV-045
AUDIO
(SEE PAGE 3-9)
TO MV-045
VIDEO
(SEE PAGE 3-11)
IFBSY
IFSCK
IFSDO
XIFCS
IFSDI
XSYSRST
V MUTE
A MUTE
TO IF 131
INTERFACE
(SEE PAGE 3-14)
9
5
7
4
6
2
10
14
A_MUTE
TO MV-045
AUDIO
(SEE PAGE 3-10)
0.7Vp-p
27MHz 3.3Vp-p
IC101
9228
H
0.7Vp-p
H
1Vp-p
H
286 mVp-p (NTSC)
300 mVp-p (PAL)
H
1Vp-p
H
1Vp-p
H
IC101
11 215
3.3Vp-p
24MHz
IC101
10 156
3.3Vp-p
110MHz
X102
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-4. RF/SERVO BLOCK DIAGRAM
3-7 3-8
MV-045 BOARD
(SEE PAGE 4-9 to 4-10)
BASE UNIT
(DEVICE, OPTICAL
KHM-310CAA/C2RP)
BASE UNIT
SLED
MOTOR
SPINDLE
MOTOR
LIMIT
DETECT
CN201
36
37
34
10
13
15
4
1
D01+
D01-
D02+
D02-
24
25 D05+
D05-
22
23
20
21
18
19
MDI2
MDI1
LD01 TSD_M
MUTE
MUTE123
SPFG
TROPENPWM
DMO
FMO
TRO
FOO
LD02
6
DVDRFIP
TPI
TNI
50 49
OCSW CKSW
114
LIMITSW
IN1-
IN2-
IN3-
IN4-
CTL
20
22
MUTE4
TSD_M
7
19
21
6
45
OPO
RES1
RES2
MUTE123
PS
IC201
MOTOR DRIVER IC
IC101 (2/2)
RF AMPLIFIER
LDM+
LDM-
OKSW1
OCSW1
FCS-
FCS+
TRK+
TRK-
LD (780)
LD (650)
PD
RF
F
E
M001
LOADING
MOTOR
S001
CHUCK/TRAY
DETECT
FOCUS
COIL
TRACKING
COIL
DVD/CD
LD MODULE
CN202
DVD/CD
LD DRIVE
Q102
2~5
8~11
C
D
A
B
DVD/CD
PDIC
186
FWD
185
181
183
184
47
39
37
38
41
42
REV
16
FWD
17
REV
35
IC101 6(DVD PB)
5
IC101 6(CD PB)
5
200nsec
100nsec
24
23
22
21
6
2
5
14
10
17
20
19
16
15
CN101
5
4
2
1
1
2
5
6
3
3
4
6
7
MS-203 BOARD
27
28 D04+
D04-
29
30 D03+
D03-
SP-
SP+
SL-
SL+
LIMIT
(0.5Vp-p to
1.1Vp-p)
(0.65Vp-p to
1.48Vp-p)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-9 3-10
3-5. AUDIO BLOCK DIAGRAM
3.5Vp-p
H
3.3Vp-p
H
L
R
R457
R455
R413
IC401
MUTE DRIVER
Q402, Q404, Q405
MUTE DRIVER
Q406, Q409, Q410
AUDIO AMPLIFIER
IC402
AUDIO AMPLIFIER
LINE OUT
Q411
BUFFER
R435
J301
OPTICAL
IC405
COAXIAL
DIGITAL
OUTPUT
XA MUTE
KRMOD
+
–
+
–
D405
Q414
MUTE DRIVER
D IN
+
–
+
–
Q408
MUTE
2
3
5
6
1
7
2
6
3
5
1
7
1
16
1
3
5
7
8
6
2
4
SYSTEM CONTROL
(SEE PAGE 3-5 to 3-6)
IC406
AOUTR-
MCLK
SDTI
PDN
CSN
BICK
LRCK
CCLK
CDTI DZFL
AOUTR
+
AOUTL+
AOUTL-
AUDIO D/A CONVERTER
11
12
10
9
IC406 4(DVD)
13
IC406 4(CD)
12
ACLK
ALRCK
ABCK
XDACS
ASDATA4
XRST
ADSK
ADSOO
XMAMUTE
SPDIF
MV-045 BOARD
(SEE PAGE 4-13 to 4-14)
SYSTEM CONTROL
(SEE PAGE 3-5 to 3-6)
Q417
MIC
D402
R415
MIC
Q407
MUTE
RV503
MIC VR
RV501
ECHO VR
IC504
ECHO
GENERATOR
IC505
MIC VOL
IC502
MIC AMP
IC507
MIC ADD
RV502
MIC VR
J502
MIC IN 2
J501
MIC IN 1
IC503
ECHO MIX
MC-155 BOARD (SEE PAGE 4-21 to 4-24)
4 5
CN501
4 5
CN404
MIC DECTECTION
Q501/Q503
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-11 3-12
3-6. VIDEO BLOCK DIAGRAM
S VIDEO OUT
32
29
27
31
23
25
21
8
11
13
1
16
3
5
Y
C
COMPONENT
VIDEO OUT
Y
C b
C r
C
Y
VVIDEO IN VIDEO OUT
MUTE
Y OUT
Y IN
C IN C OUT
MUTE2
Y IN Y OUT
Y
Cb
Cr
Cb IN
Cr IN
Cb OUT
Cr OUT
VIDEO
COMBO JACK
J501
H2.0Vp-p
IC304 wg
16
H1.4Vp-p
IC304 wa
18
H1.4Vp-p
IC304 wd
17
63.5usec 2.0Vp-p
IC304 wj
14
VIDEO BUFFER
IC304
MV-045 BOARD
(SEE PAGE 4-11 to 4-12)
SYSTEM CONTROL
(SEE PAGE 3-5 to 3-6)
H2.0Vp-p
IC304 wl
15
H1.8Vp-p
IC304 ea
19
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
3-13 3-14E
3-7. INTERFACE CONTROL BLOCK DIAGRAM
3.3V
REGULATOR
IC 407
IC 406
IC 408
80
11
81
2
1
3
40
PROG LED
IR
78
5
VCC
VDD
/RST
VKK
50
69
71
77
12
38
4
11
D401
EVER+3.3V
EVER+3.3V
EVER+3.3V RESET
IR
RECEIVER
VFD DRIVER CIRCUIT
ND401
FLUORESCENT
INDICATOR
TUBE
SW-10V
1 2 40 41
SEG 1-20
DIG 1-7
IC 404
IF CON AD1
AD2
XIN
XOUT
36
34
35
26
27
24
23
17
16
15
14
7
2
3
43
42
41
33
SYSRST
/CS
SI
SO
/SC
/AMUTE
/VMUTE
BUSY
PCONT
37
POWER
O/C
SYSRST
EVER+5V
SW-10V
SW+3.3V
XIFCS
SOO
SIO
SCO
A-MUTE
V-MUTE
XIFBUSY
PCONT
POWER-SWITCH
CN401
S401
OPEN/
CLOSE
R431 R430
S405 S404 S403 S402
R429
R428
S406
S407
PROG
STOP PREV
NEXT
PAUSE
PLAY
X401
8MHz
IF-131 BOARD
(SEE PAGE 4-19 to 4-20)
45
7
5
3
4
6
2
8
16
14
11
12
9
13
5
3
2
4
SYSTEM CONTROL
(SEE PAGE 3-5 to 3-6)
R302
b
b
S303S302S301
R301
CN302CN405
#
#
R304R303 R305
D303 D302 D301
CK-151 BOARD
(SEE PAGE 4-27 to 4-28)
5
3
2
4
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
212 13
11
10
98765
43 14 15
SECTION 4
PRINTEDWIRING BOARDS AND SCHEMATIC DIAGRAMS
4-1 4-2
M
M
SWITCHING
REGULATOR
IF-131 BOARD
CK-151 BOARD
MV-045 BOARD
MS-203 BOARD
BASE UNIT
OPTICAL
DEVICE
SW+8V
SC_IN (N)
2P
AC_IN (L)
2 1
1
1-963-090-11
HARNESS
PM-119
1-830-281-11
FFC
(FIM-011)
1.0 pitch
10P
CN201
10P
CN501
MTR GND 2
EVER+11V 3
EVER+5V 4
SW+3.3V 5
SW+5V 6
GND 7
P-CONT 8
POWER SW 9
EVER-10V 10
SW+8V1
MTR GND2
EVER+11V3
EVER+5V4
SW+3.3V5
SW+5V6
GND7
P-CONT8
POWER SW9
EVER-10V10
GND
POWER_SWITCH
SW-10V
A_MUTE
EVER+3.3V
PCONT
SW+3.3V
V_MUTE
SCO
GND
SOO
SIO
XIFBUSY
XIFCS
3.3V_MNT
SYSRST
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
GND
POWER_SWITCH
SW-10V
A_MUTE
EVER+3.3V
PCONT
TXD
PI TE FE GND RF
5 4 3 2 1
OCSW1 / REV CKSW1 / FWD GND / CTL LDM- LDM+
1 2 3 4 5
OCSW1 / REV
CKSW1 / FWD
GND / CTL
LDM-
LDM+
5 4 3 2 1
RXD
GND
+3.3V
V2REF0
RF MON
1
2
3
4
5
6
SW+3.3V
V_MUTE
SCO
GND
SOO
SIO
XIFBUSY
XIFCS
3.3V_MNT
SYSRST
GND
17P
CN401
17P
* CN106
6P
CN105
5P CN103 TO SERVO JIG
5P CN202
CN001
5P
1-830-280-11
FFC
(FMS-007)
1.0 pitch
24P
CN101
GND (LD) 1
LD (650) 2
N.C 3
N.C 4
PD 5
LD (780) 6
VR (650) 7
VR (780) 8
N.C 9
VoE/e+g 10
Vcc 11
Vc 12
GND (PDIC) 13
VoF/f+n 14
VoB/b 15
VoA/a 16
RF 17
(LO:DVD, HI:CD) MSW 18
VoD/d 19
VoC/c 20
TRK- 21
TRK+ 22
FCS+ 23
FCS- 24
24P
CN101
GND (LD)24
LD (650)23
N.C22
N.C21
PD20
LD (780)19
VR (650)18
VR (780)17
N.C16
VoE/e+g15
Vcc14
Vc13
GND (PDIC)12
VoF/f+n11
VoB/b10
VoA/a9
RF8
(LO:DVD, HI:CD) MSW7
VoD/d6
VoC/c5
TRK-4
TRK+3
FCS+2
FCS-1
1-830-279-11
FFC
(FMO-008)
0.5 pitch
HARNESS
MD-111
1-963-599-11
SP-
SP+
LIMIT
(GND) LIMIT
SL-
SL+
1
2
3
4
5
6
6P
CN201
SP-
SP+
LIMIT
(GND) LIMIT
SL-
SL+
6
5
4
3
2
1
6P
CNXXX SPINDLE
MOTOR
LIMIT
SWITCH
SLIDER
MOTOR
1-963-598-11
HARNESS
IK-053
SW+3.3V
LED_KEY-
LED_KEY0
KEY CONTROL
LED_KEY+
6 5 4 3 2
GND 1
6P
CN302
SW+3.3V LED_KEY- LED_KEY0 KEY CONTROL LED_KEY+
6 5 4 3 2
GND1 6P CN406
MC-155 BOARD
1-963-597-11
MC-086
HARNESS
MIC+ECHO
XMIC
AU+11V
AU-10V
GND_AUDIO
5
4
3
2
1
5P
* CN404
MIC+ECHO
XMIC
AU+11V
AU-10V
GND
5
4
3
2
1
5P
CN501
FRAME SCHEMATIC DIAGRAM
4-1. FRAME SCHEMATIC DIAGRAM
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
4-3 4-4
For printed wiring boards:
• : indicates a lead wire mounted on the component
side.
• : indicates a lead wire mounted on the printed side.
•a: Through hole.
•: Pattern from the side which enables seeing.
(The other layers’ patterns are not indicated.)
For schematic diagrams:
• All capacitors are in µF unless otherwise noted. pF : µµF.
50V or less are not indicated except for electrolytics and
tantalums.
• All resistors are in ohms, 1/4W (Chip resistors : 1/10W)
un-less otherwise specified.
kΩ= 1000Ω, MΩ= 1000kΩ.
• Caution when replacing chip parts.
New parts must be attached after removal of chip.
Be careful not to heat the minus side of tantalum capacitor,
because it is damaged by the heat.
• All variable and adjustable resistors have characteristic
curve B, unless otherwise noted.
•: non flammable resistor.
•: fusible resistor.
•: panel designation.
•f: internal component.
•: adjustment for repair.
• Circled numbers refer to waveforms.
• Voltages are dc between measurement point.
• Readings are taken with a color-bar signal on DVD refer-
ence disc and when playing CD reference disc.
• Readings are taken with a digital multimeter (DC 10MΩ).
• Voltage variations may be noted due to normal production
tolerances.
Caution:
Pattern face side: Parts on the pattern face side seen
from
(Side A) the pattern face are indicated.
Parts face side: Parts on the parts face side seen from
(Side B) the parts face are indicated.
When indicating parts by reference
number, please include the board
name.
Note:
The components identi-
fied by mark or dotted
line with mark are criti-
cal for safety.
Replace only with part
number specified.
Note:
Les composants identifiés par
une marque sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro
spécifié.
4-2. PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
THIS NOTE IS COMMON FOR WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block) MV-045 BOARD
H
H
H
H
IC101 C/BAR PB
IC101 C/BAR PB
IC101 C/BAR PB IC101
9
228
156
215
IC101 6(CD PB)
1
200nsec
IC101 6(DVD PB)
2
100nsec
5
1Vp-p
H
IC101 C/BAR PB
6
1Vp-p
H
IC101
7
0.7Vp-p
H
IC101
8
0.7Vp-p
H
3.3Vp-p
203
202
200
198
194
196
4
1Vp-p
H
3
H
3.3Vp-p
24MHz
IC101
11
3.3Vp-p
110MHz
27MHz
IC101
10
3.5Vp-p
H
3.3Vp-p
H
IC406 4(CD)
12
IC406 4(DVD)
13
IC304 wl C/BAR PB
15
2.0Vp-p
IC304 wg C/BAR PB
16
2.0Vp-p
IC304 wj C/BAR PB
14
2.0Vp-p
IC304 ea C/BAR PB
19
IC304 wd
17
1.4Vp-p
H
IC304 wa
18
1.4Vp-p
H
(0.5Vp-p to
1.1Vp-p)
(0.65Vp-p to
1.48Vp-p)
286 mVp-p
(NTSC)
300 mVp-p
(PAL)
1.8Vp-p
4-3. WAVEFORM
WAVEFORM
MV-045
• Abbreviation
BR : Brazilian Model
E : Latin America Model
CH: Chinese Model
EA : Saudi Arabia Model
SP : Singapore Model
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
D
C
E
F
B
A
125
4
3
CK-151 Board
(KEY CONTROL)
MC-155 Board
(MIC-ECHO)
IF-131 Board
(IF)
MV-045 Board
(CPU, Servo-DSP, AVDEC,
DRIVE, VIDEO, AUDIO, POWER)
Power Board
MV-045 BOARD
SIDE A
IC101 C-4
IC102 B-3
IC103 B-4
IC104 C-5
IC108 A-2
IC110 D-2
IC201 B-2
IC401 E-4
IC402 E-4
IC404 G-5
IC405 G-4
IC406 E-4
Q101 C-4
Q102 D-2
Q103 C-4
Q304 F-3
Q305 F-2
Q307 F-4
Q371 F-1
Q372 F-1
Q373 E-1
Q374 F-1
Q401 E-3
Q402 E-5
Q403 E-3
Q404 E-4
Q405 F-4
Q406 E-5
Q409 E-5
Q410 F-5
Q414 F-3
Q417 F-2
Q501 E-1
Q502 E-1
Q503 D-1
Q504 D-1
D201 A-2
D310 E-2
D501 A-3
D402 E-4
D403 F-4
D405 E-4
SIDE B
IC105 B-3
IC106 D-4
IC107 D-3
IC303 F-5
IC304 F-4
IC403 E-3
IC501 A-3
Q407 F-3
Q408 F-3
Q411 F-1
Q416 E-3
D308 F-4
D309 F-4
D401 E2
D404 E-3
There are a few cases that the part printed on
this diagram isn’t mounted in this model.
For printed wiring board
CPU, Servo-DSP, AVDEC, DRIVE, VIDEO, AUDIO, POWER
MV-045
MV-045 (CPU, Servo-DSP, AVDEC, DRIVE,VIDEO, AUDIO, POWER) PRINTEDWIRING BOARD • : Uses unleaded solder.
MV-045 BOARD SIDE A MV-045 BOARD SIDE B
4-5
D
C
E
F
G
B
A
125
4
3
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
4-7 4-8
CPU, Servo-DSP, AVDEC
MV-045 (1/5)
For Schematic Diagram
• Refer to page 4-5 for printed wiring board of MV-045 board.
• Refer to page 4-4 for waveform
MV-045 BOARD (1/5)
CPU, Servo-DSP, AVDEC
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:REC/PB MODE
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
4-10
DRIVE
MV-045 (2/5)
4-9
For Schematic Diagram
• Refer to page 4-5 for printed wiring board of MV-045 board.
• Refer to page 4-4 for waveform
MV-045 BOARD (2/5)
DRIVE
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:REC/PB MODE
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
4-11 4-12
VIDEO
MV-045 (3/5)
For Schematic Diagram
• Refer to page 4-5 for printed wiring board of MV-045 board.
• Refer to page 4-4 for waveform
MV-045 BOARD (3/5)
VIDEO
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:REC/PB MODE
SIGNAL PATH
VIDEO SIGNAL
CHROMA
PB
Y Y/CHROMA
AUDIO
SIGNAL
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
4-13 4-14
MV-045 BOARD (4/5)
AUDIO
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:REC/PB MODE
For Schematic Diagram
• Refer to page 4-5 for printed wiring board of MV-045 board.
• Refer to page 4-4 for waveform
AUDIO
MV-045 (4/5)
SIGNAL PATH
VIDEO SIGNAL
CHROMA
PB
Y Y/CHROMA
AUDIO
SIGNAL
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
4-15 4-16
POWER
MV-045 (5/5)
For Schematic Diagram
• Refer to page 4-5 for printed wiring board of MV-045 board.
• Refer to page 4-4 for waveform
MV-045 BOARD (5/5)
POWER
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:REC/PB MODE
Note :
The components identified
by mark or dotted line
with mark are critical for
safety.
Replace only with part
number specified.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
4-17 4-18
IF-131 BOARD
SIDE A
IC406 A-2
Q402 A-10
Q403 B-12
Q404 A-12
Q405 A-12
D407 B-11
D409 A-9
D410 A-1
D411 A-1
SIDE B
IC404 A-5
IC407 B-1
IC408 A-3
Q401 A-2
Q402 A-3
D402 A-1
D403 A-1
D404 A-1
D405 A-1
D406 A-2
IF-131 (IF) PRINTED WIRING BOARD
There are a few cases that the part printed on
this diagram isn’t mounted in this model.
For printed wiring board
IF-131 BOARD SIDE A
• : Uses unleaded solder.
IF
IF-131
IF-131 BOARD SIDE B
A
128765
411109 3
A
128765
411109 3
CK-151 Board
(KEY CONTROL)
MC-155 Board
(MIC-ECHO)
IF-131 Board
(IF)
MV-045 Board
(CPU, Servo-DSP, AVDEC,
DRIVE, VIDEO, AUDIO, POWER)
Power Board
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
DVP-K80P/K82P
4-19 4-20
For Schematic Diagram
• Refer to page 4-17 for printed wiring board of IF-131 board.
IF-131 BOARD
IF
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:PB MODE
MARKED:MOUNT TABLE
IF
IF-131
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

DVP-K80P/K82P
4-21 4-22 MIC-ECHO
MC-155
MC-155 BOARD
SIDE A
IC507 B-3
Q501 A-4
Q503 A-3
SIDE B
IC501 A-3
IC502 C-3
IC503 B-1
IC504 B-1
IC505 B-2
Q502 A-3
D501 B-4
D502 B-4
D503 C-4
MC-155 (MIC-ECHO) PRINTEDWIRING BOARD
There are a few cases that the part printed on
this diagram isn’t mounted in this model.
For printed wiring board
MC-155 BOARD SIDE A
• : Uses unleaded solder.
MC-155 BOARD SIDE B
B
C
A
124
3
B
C
A
124
3
CK-151 Board
(KEY CONTROL)
MC-155 Board
(MIC-ECHO)
IF-131 Board
(IF)
MV-045 Board
(CPU, Servo-DSP, AVDEC,
DRIVE, VIDEO, AUDIO, POWER)
Power Board
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

1
A
B
C
D
E
F
G
H
I
J
212 13
11
10
98765
43 14 15
DVP-K80P/K82P
4-23 4-24
MIC-ECHO
MC-155
For Schematic Diagram
• Refer to page 4-21 for printed wiring board of MC-155 board.
MC-155 BOARD
MIC-ECHO
-REF.NO.:1000 SERIES-
XX MARK:NO MOUNT
NO MARK:PB MODE
MARKED:MOUNT TABLE
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com