Sony STR-DE315 User manual

STR-DES19/DE415
SERVICE MANUAL AEP Model
UK Model
Photo : STR-DE415 model
Manufactured under license from Dolby Laboratories
Licensing Corporation.
“DOLBY”, “PRO LOGIC” and the double-D symbol
are trademarks of Dolby Laboratories Licensing
Corporation.
SPECIFICATIONS
Amplifier section Inputs BASS BOOST _ + 10dB at 70Hz
Power output Sensitivity Impedance S/N
Stereomode — (DIN I kHz, 4ohms) (Weighting TONE + 8dB at 100Hz and
STR-DE415 : network, 10kHz
80W + 80W input level) ;
STR-DE315 : “PHONO 25mv. 50. ~+74d8.~~=—~—S«*~M tuner section
80W + 80W (MM) Kilohms 72dB*** Tuning range 87.5 - 108.0MHz (OTHER)
Ss id (DIN 1kHz, 4ohms) Sarath ac ae, E )
urroun Z, 4onms it Huropean
mode Front : CD, 200mV_ 50 82dB ee
STR-DE415:70W/ch TAPE/MD, Kilohms 82dB*** — Aerialrange © 75ohms, unbalanced
STR-DE315:60W/ch TV/LD, 150mV (A, 150mV)
Center : VIDEO Sensitivity Mono : 18.3 dBf, 2.2nV
STR-DE415 : 70W ***78 THF /750hms
STR-DE315 : 60W Stereo : 38.3 dBf, 22.5nV
(only in PROLOG Output TAPE/MD REC OUT : /750hms
MODE) Voltage : 150mV,
Rear : Impedance: 10kilohms Usable 11.2 dBf, Inv
STR-DE415: VIDEO AUDIO OUT : sencitivity /75ohms (IHF)
(DIN 1kHz, 4ohms) Voltage : 1SOmV,
70W Impedance: 10kilohms S/N Mono : 76dB
STR-DE315 : MIX AUDIO Stereo : 70dB
(DIN 1kHz, 4ohms) OUT (STR-DE415 only)
60W Voltage : 2V Harmonic Mono : 0.3%
Impedance: 10kilohms _ diatortion at Stereo : 0.5%
Frequency PHOTO : RIAA PHONES : Accepts low 1kHz
response equalization curve and high impedance
+ 0.5dB headphones Separation 45dB at 1kHz
TV/LD, CD, TAPE/MD,
VIDEO : Muting Full mute Frequency 30Hz - 15kHz 2° dB
10Hz - 50kHz + 1dB response — Continued on ext page —
FM STEREO/FM-AM RECEIVER
SONY.

Selecitivity 60dB at 400kHz
AM tuner section
Tuning range 522 - 1611 kHz
Aerial Loop aerial
Usable 50dB/m (at 999kHz)
sensitivity
S/N 54dB (at 50mV/m)
Harmonic 0.5% (50mV/m,
distortion 400Hz)
Selectivity 35dB
General
system Tuner section : PLL
quartz-locked digital
synthesizer system
Preamplifier section :
Low-noise NF type
equalizer
Power amplifier section :
Pure-complimentary
SEPP
Power 230VAC, 50/60Hz
requirements
Power STR-DE415 : 175W
consumption STR-DE315 : 175W
AC outputs Switched 100W
(except for the U,K,
model)
Dimensions 430 x 145 x 295mm
Mass (Approx.) 6.4kg
Supplied FM wire aerial (1)
accessories AM loop aerial (1)
Remote controller
(remote) (1)
Size AA (R6) batteries (2)
Scart adaptor (1)
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK A OR DOTTED LINE WITH
MARK A ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
TABLE OF CONTENTS
Specifications Wiaapdestae seas oue.cendanacadsnecaesecenoeeestsaesccausasusadesysavecestarcaey 1
1. GENERAL
Location and Function of CONtrols ----+<::+-ccssceeseeseeececeesceseeennensensees 3
2. EXPLANATION OF IC TERMINALS ...........---.-.- 5
3. DIAGRAMS
3-1. Circuit Boards Location -e-:-c:eteseterseceeeseseteeseseseseseseenees
3-2. Printed Wiring Boards — Main Section —---
3-3. Schematic Diagram — Main Section — ----.--
3-4. Schematic Diagram — Display Section — «----------+---1++ 16
3-5. Printed Wiring Boards — Display Section —----+----+-+-+++ 19
4. EXPLODED VIEWS
4-1. Front Panel Section -----:::s+:sssseseseeseseeeseteessesseseseseseeesesenees 23
4-2. Chassis Section
5. ELECTRICAL PARTS LIST -:----:--ccccccccceceeee 25

LOCATION AND FUNCTION OF CONTROLS
<FRONT>
SECTION 1
GENERAL
[1] POWER switch
[2] CENTER LEVEL +, — buttons
[3] REAR LEVEL +, — buttons
[4] STANDBY indicator
[5] FUNCTION indicators
[6] MASTER VOLUME control
BALANCE control
TREBLE control
[9] BASS control
[10] BASS BOOST button/indicator
[11] SURROUND ON/OFF button
[12] MODE button
EFFECT/DELAY TIME, SET UP buttons
22
(20) | [18] |[16)| [14
19
21
17} (15) 13
12] 1110] [9] [8
TAPE/MD button
[15] PHONO button
[16] TV/LD button
[17] TUNER button
VIDEO button
CD button
DIRECT button
21] SHIFT button
22] Numeric buttons
[23] Tuner control buttons
PHONES jack
25) SPEAKERS (A/B) buttons
<REAR>
11
(13) 12 10)
[1] WOOFER
[2] AC OUTLET (EXCEPT UK)
[3] AC power cord
[4] FRONT SPEAKERS (A/B)
[5] SURROUND SPEAKERS (CENTER)
[6] SURROUND SPEAKERS (REAR)
VIDEO
TV/LD
[9] TAPE/MD
cD
[11] PHONO
[12] ANTENNA (FM/AM)
[13] SIGNAL GND
SECTION 2
EXPLANATION OF IC TERMINALS
¢ 1C201 uPD78044FGF-064-3B9
Fluorescent indicator tube drive.
Power supply (+5V).
System clock.
System data.
PLL data input from TU001.
Chip enable output.
Chip enable output.
BRIDGE
PROTECT
RESET
Input for model select.
Protector detect input.
Protector detect input.
System reset terminal.
AUTO-STOP
STEREO-IN
AVss
SP-RY
SURR-RY
POWER-RY
SIGNAL
ors
er a
cast
[Ens
A/D2 1
A/D1 I
NC
Vss
ALL
IC. MUTE
PROLOGIC
SIMULATED
H.
T. MUTE
Auto stop detect input.
Stereo detect input.
Power supply (+5V).
Ground.
Plologic LED.
CINEMA STUDIO LED.
HALL LED.
Tuner mute drive output.

vO
Pin Name Description
Pin No.
41
42
VOLUME UP Volume up.
| 42 | — VOLUMEDOWN Volume down.
STANDBY
Standby LED drive.
SYS. POWER System power ON/OFF.
RDS. DATA. IN RDS data input.
RDS. CLK IN| 1 | RDS clocking
Stop signal input from NJM2103D (1C950)
[FowersW [1 | owersvithinputemind
5.1ch LED —_— 5.1ch LED drive.
+5V —_ Power supply (+5V).
oO
O
oO
I
I
I
Key in I.
Feeyouis |
Peyowis |
Peyowt
Preyowio
[eyo
Peete ee
Key out 8.
Key out 7.
Connect to -24V.
Key out 6.
Key out 5.
Key out 4. po ;
Fluorescent indicator tube drive.
Key out 3.
Key out 1.
Fluorescent indicator tube drive.
SECTION 3
DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION
SECONDARY board
PRIMARY board STBY board
MIX board
SW board
MAIN board
SP SW (A) board
DISPLAY board
SP SW (B) board
KEY board
VOLUME board
VR-TONE board

STR-DE315/DE415
3-2. PRINTED WIRING BOARDS — MAIN SECTION —
¢ Semiconductor Location
Reto, [Location [RefNo
C-7
J-12
H-6
H-6
1-6
1-6
Note:
¢ o—— : Parts extracted from the component side.
H-2
G-2
G-2
H-2
D-8
C-9
D-9
© — sees + Pattern on the side which is seen.
¢ Abbreviation
EE : East European
G : German
(CHASSIS)
||
cay soe
se eS A ee Bn 2 ee ae to
401 3402 = 403,
TM60I TM701
TAPE/MD TV/OBS VIDEO SURROUND SPEAKERS FRONT SPEAKERS
REC OUT oy] AUDIO IN] [WiDEO ouT] + [VIDEO IN Rose REARS TE SENTER AME EDANCE USE TB 710.
R L L
©
MAIN TMOOI
BOARD ANTENNA
=
.
eos
e
emenceat
dint of
-
TT
eft
— je
Se Sea aster
_
—
ae
a
an
ee
. SOS _.
eS
aoe
ae = fees
-
VOLUME BOARD —*(C) VOLUME BOARD (A) DISPLAY BOARD
CNS403 (CHASSIS) CNS402 CNS20! (CHASSIS)

7
FRONT SPEAKERS [SECONDARY BOARD]
IMPEDANCE USE 8-I61
lO
© ©
©
ana
8] ® C) © )
T901
POWER
TRANSFORMER
CNU903
[AC OUTLET]
[SW (B) BOARD]
eA Ae
a
emoreau
oS oo
$701
SPEAKERS
ON [1 OFF
[a]
DE4I5
MODEL
(CHASSIS)
1-665-272
=49—

3-3. SCHEMATIC DIAGRAM — MAIN SECTION —
¢ Waveform
IC300 @
Note:
¢ All capacitors are in uF unless otherwise noted. pF: uF S5OWV or
less are not indicated except for electrolytics and tantalums.
¢ All resistors are in Q and 1/4W or less unless otherwise specified.
¢ A __ : Internal component.
° : B+ Line.
° : B-Line.
¢ Voltages and waveforms are dc with respect to ground under no-
signal (detuned) conditions.
No mark: FM
( ): AM
¢ Voltages are taken with a VOM (Input impedance 10MQ).
Voltage variations may be noted due to normal production
tolerances.
¢ Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
¢ Circled numbers refer to waveforms.
* Signal path.
<> :FM
¢ Abbreviation
G : German
EE : East European
The components identified by mark A\ or dotted
line with mark A\ are critical for safety.
Replace only with part number specified.
=
¢ Refer to page 15 for IC Block Diagrams.
(
-———
-— - ——_ - +8595
E415 MODEL
pee cece nee e nee eee eee ene nnn ene e eee e nnn nen e ene eee n nnn nen nnnaeee nnn
¢ When TU001 (TUNER UNIT) becomes defective,
it is exchanged by unit replacement,
and will not be repaired.
R352 100K
| Tuoo! ‘S) Cy
1-233-595-11 (€E)
1-233-594-12 (AEP, UK G)
J601
a/2
168
mm
a
O-
He a
IN
EM
TAPE7MO OUT,
LicH}] y402 O
| (TAPE_MO_IN] uae
TV/7L5_IN| Ow
ik 3s
VISEO OUT O—»—
J403 [ Rie oa.
72) Be
VIBEO_IN ©) —m
tk ed
FUNCTION
SWITCH
4
5403
VisEO_IN
Sl
VIBEQ OUT!
ei
TV7L5_IN
14
Rw 23] TAPE7MO_IN
Reet igs
TAPE7MO_OUT] | GO» —
ik Ss
5k Ow
=
(2/2) [ ge e
3S By Ik
+5. 6V}
8S
Nita ao
7
s
ROS CLOCK IN
ROS DATA
PLL ATA OUT
S.CE (7822, 7213!
PROTECT IN TUNER-MUTE STOP
SIGNAL
-24V
BRIDGE $.CLOCK S.DATA
AUTO-STOP STEREO IN SP-RY SURR-RY POWER-RY
+5.6V
ROS CLK IN ROS OATA IN Sw_®Y) F.MUTE
Pic mure
DISPLAY BOAR®
CNS201

grams.
22 21 20
19 18 17 16 15 14
13
12 11
10
= n
ei
eee a
LT |
CNS702 3
e)
S@SIS! 9228 | SSIS! S7Zé
SOSISI £728 ° 1ye196z >
&
OVER LOAD
RIVE
1¢701
[ MAIN BOARD ]
(ts
eee
CIT)
VOLUME BOAR®
CNS402
VOLUME BOARS
CNS403
8)
SOO0@
-
—
-
——_-
CPC?
tat
+
8s
|
gs
|
Ae,
|
cf
hit
=
a
ie
RELAY 4!
SP 802 a8
ot #5 |S
Se2
|
Gs=
M75
Q721, 722, 723
8C OFFSET SET
620, 770
OVER LOAD
ET
STANDBY
Q603, 604
03, POWER AMP
2488
653, 654
47-4 POWER AMP
POWER AMP
Q753 754
iad
oc
wm
‘
o
:
wy
a
See
by
wn
S-|
SS,
gaa}
—
:
T|
BS
BA51-
GR
TI?
3
=
Fe”)
a)
gas
ee
3s
MATRIX
NECORBER
SOLBY PROLOGIC
HOI 2087
A0S.
1L9°0)
wy
AOS
4249°0,..
azey_L"Y
SURROUND
ROS BECOBER
A 0 cee
R362 10k
SURROUND
AMP
ee
224

7 28 29
come wo NO o N ah
N N N Ww N > N ul ND) o NO
E
SW
BOARD]
wt
a
as
aa
R792 1.2k 1/2
ee ———————
Q721, 722, 723
OC OFFSET SET
CN8O1 CNP80!
( —e-———6
io ome eee] A
Ae | Lea
A= eo fe a PRI MARY
2 RE a 5 6 ES BOARD
i oe Ce 5 | SD a
SS ee a |
fe iee— 1A 8
C2 oa 1 - |
6 Ht.
9809
28C403SP ggo2 a809
RELAY RIVE
rc
t
=o
age
30
31
STR-DE315/DE415
32

STR-DE315/DE415
¢1C BLOCK DIAGRAMS — MAIN SECTION —
1C701, IC702 uPC2581V 1C300 LV1016
O
>
fe)
3
(2H0%)
Ya 1J-NI
4NO9-Wav
=
Ee
=|
ro)
-_
rar)
n
=<
a
ol>
PROTECTOR
=a
weve
)
leo | Te]
<
AW130+7
“2 Roe
| [DISPLAY BOARD }
as
en a
WIYL-S
ALNW/I0A
ASWHd-ANI
1C301 LA2786 1C401 LC7822
NOISE 3 CLK
GENERATER DATA
Oo
vec
LOUT
ROUT
ar
a
Ts
SOUT a
7 =
181
COUT CNS201 a 10K
ee tah [] [ecarhsises |_|
a ee
pr
amet fe }———$_—_}
[ren res }—_ azos Hsises [|
a ee ee
ee
nt
ee Se ee
a ee a
eT er ST
ee eT
IC1 BU1922 eee
ae
j}
Saeed ee er
= ons } pred ed
>
3s a ee es Ve
22
2
2 z [stom | 20. }
22||
of
ae
oS
|l-at
xe
|
82 | 225 38 | remneny 2]
ea]
|*2=
ag
|
wf
2s}
—
i ° [wm —~«saa
z 2 [res exten 28 |
S
Sai
«leah.
|e
7
ee
2s Sze a2 2
2 2
Ess 226 Be & sa
Ss Sax oe # ryge
a ost 3
A fork) aries
CR
RESET
5
1
1S72ls
;
SS
SWITCH
oc
B
2
oj
i
@ cal CNS202 7P
‘Se VSA [—voreom | 14
eee
P Pvo.ue____ [2 +} +} J
& [~sass. soos 3} —+—
2 ar ee ee
8 Ps.9_ ss}
oOuTC (6) VSB/SESIN | ure e7crsum | 6 |}—7-—
[wre ep [71
[—wtee-e |» }—+—~J
[—s.soost tess}
5S [ene 0 J
GND (4) V+ ce
ae
i]
—15—
;
—
16
—

° Waveform ¢ IC BLOCK DIAGRAM — DISPLAY SECTION — Note:
¢ All capacitors are in uF unless otherwise noted. p
less are not indicated except for electrolytics and
Ieeve paces ¢ All resistors are in Q and 1/4W or less unless othe
¢ A __ : Internal component.
. : B+ Line.
° : B-Line.
¢ Voltages and waveforms are dc with respect to gr
signal conditions.
4,19MHz
Ne
mark:
FM
1C201
@
(2-3) =
S = sy 2 S 8 i 5 S
= 2 2 ze &
SECTION —
4
5
6
7
8
9
10
11
12 13
14
15
16 17
| { VOLUME BOARD }
| cnPz0z
7] Geo sd
| 6 | B.BOOST LEB
Ps [ +5.ev |
| 4 |
VOL. UP
[3:4]
[2 |
[1 | VOL. SOWN
bald
STEREO MONO TUNED TA NEWS INFO TUNING PRESE
MEMORY-=
a
a
ee
BASS BOOST Se gs
ON/OFF R444 1M Sov
inn
1Sf88s
=r 35
8
FS
[c.sTuaIo
8201 151585
Li
Zz $201 $202 $203
(ie
a
os
o
6.
23.
5204
Pas
Piss
a
|
!
=
era
oe
rm
REAR
eee
aR
PR
i
ea
ee
ie
—
-—}—}—
24
SECO
iw
$207
3208
ae
[18)
ce
ig
oar
ae
Sr
a
TY
oe
al
eee
el
Oe
ig
au
a
ono
$203 $210 $211 $212
aera
Goa
SAE
TR
EZ
ae
oe
ET
eee
I
ea
88
—ee
5.6
a 6
ee
pos)
PRESET
PRESET
Ty
TUNING
|
|
LTUNINGS
ammo
aia
is
oe
Ne
eT),
SS
ee
;
|
8221 191585 |
Sulceecesen
R211 22
0201 8TAI24ES
5.6 SYSTEM RESET
R214 22%
ag :
—16—
SAT

ION — Note: * Voltages are taken with a VOM (Input impedance 10MQ).
*
All
capacitors
are
in
uF
unless
otherwise
noted.
pF:
uF
SOWV
or
Voltage
variations
may
be
noted
due
to
normal
production
less
are
not
indicated
except
for
electrolytics
and
tantalums.
tolerances.
*
All
resistors
are
in
Q
and
1/4W
or
less
unless
otherwise
specified.
*
Waveforms
are
taken
with
a
oscilloscope.
*
A
__
:
Internal
component.
Voltage
variations
may
be
noted
due
to
normal
production
°
: i
tolerances.
.
:
ad te
*
Circled
numbers
refer to
waveforms.
:
‘
¢ Signal
path.
<>
:FM
* Voltages and waveforms are dc with respect to ground under no-
signal
conditions.
¢
Abbreviation
EE : East European
No mark: FM
@
14 15 16
17 18
19
20
21
22 23
24
i
{
VOLUME
BOARD
}
|
|
-
-
TONE
BOARD
1
-
a
7 | =e
(SS
2
——
=
S69OS5050e}—
———
6550505
4.7
MAIN BOARD
CNS301 MAIN BOARD
CNS701
{ KEY BOARD }
l
ee? ots
@
fe)
28
ie
ia,
——sdr
‘id
wet
sm
>
ase
i]
e}_—_____e 5217 an 5224 5233 Rass
@ ao
=
R:
ig
|B
CENTER
SURROUND
se
ee
oe
is
[12
LEVEL-
I
5
Aas
iseet
te
fie
$205
aS
oP
R248
ig is = i a i) 7" 8 680
Ljie
8226
ve
S235
Rass “aS —— !
aie ar 5 o
i)
I a2 $227 vey S236 re
BELAY TIME
a SB fre
pane
ING
PRESET
PRESET
R242
$237
;
pane
TUNING-
TUNING+
sz20
Ras
522s
!
S28
$215
O90 o_o
1 ta]
on FH | am = FPS
1] 1) R281
oO 2.2% I
Rue
aE
a
t
$222
Pe
R244
2
i;
3!
2.°9
i
245,
a!
ae
Pe
ea
45
!
H
at at
eee
aan ; er ae :
E415 MOBEL (WisEO) [TAPE7#B) oy
I
E
Lame:
es
me
|
I
I
24Be=

3-5. PRINTED WIRING BOARDS — DISPLAY SECTION —
1 2
a ae rome = eee eee © (ARR Te (> Se ee ee
——
_ semnteamrnaraneanror
3 4 5 6 7 8 9 10 11 12 13
(KEY BOARD)
[DISPLAY BOARD]
5203 s2i0.ti(“‘<i‘é S22
- Ens
oo
$208
| [cuaracTer]
MAIN Bq
$207.
[EON] [DISPLAY]
REAR LEVEL Esa
seasons
a nan
MAIN BOARD
CNS204
=
—
20
—

oop
MAIN BOARD
CNS204
an) 4.1:
ra
ee
MAIN BOARD
{VOLUME BOARD) CNS7OI
MAIN BOARD
CNS301
RV404
MASTER VOLUME
ee
¢ Semiconductor Location
[Ret No, [Location] RefNo. [Location
: Parts extracted from the component side.
: Pattern on the side which is seen.
¢ Abbreviation
EE : East European
SOO we
STR-DE315/DE415

Note:
-XX, -X mean standardized parts, so they may
have some differences from the original one.
Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
SECTION 4
EXPLODED VIEWS
The mechanical parts with no reference number
in the exploded views are not supplied.
Hardware (#mark) list is given in the last of
this parts list.
Abbreviation
G : German
EE: East European
4-1. FRONT PANEL SECTION
WA : VOLUME board
Ref. No. Part No. Description Remarks | Ref. No. Part No.
1 4-980-639-01 KNOB (R14) * 9 A-4398-075-A
2 X-4946-873-1 KNOB (R48) ASSY 10 1-773-252-11
3 4-989-844-31 PANEL, FRONT (DE415) 11 1-769-908-11
3 4-989-844-51 PANEL, FRONT (DE315) 12 1-765-314-11
4 4-980-109-01 BUTTON (P-M) 13 4-951-620-01
* 5 4-921-941-01 CUSHION (FL) * 14 A-4392-964-A
* 6 4-943-107-11 HOLDER (FL TUBE) 15 4-977-593-11
* 7 4-980-658-01 CASE (413226) 16 3-008-600-11
8 3-704-366-01 SCREW (CASE) (M3X8) * 17 A-4392-966-A
*Q A-4392-962-A DISPLAY BOARD, COMPLETE(DE415:AEP,UK,G) 18 4-977-358-11
* Q A-4392-971-A DISPLAY BOARD, COMPLETE(DE315:AEP,UK,G) FL201 = 1-517-141-11
* Q A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE)
The components identified by mark A\or
dotted line with mark A\ are critical for safety.
Repiace only with part number specified.
Remarks
DISPLAY BOARD, COMPLETE (DE315:EE)
WIRE (FLAT TYPE) (27 CORE)
WIRE (FLAT TYPE) (9 CORE)
WIRE (FLAT TYPE) (7 CORE)
SCREW (2.6X8), +BVTP
Description
VR-TONE BOARD, COMPLETE
RING (DIA. 50), ORNAMENTAL
EMBLEM (5-AR), SONY
KEY BOARD, COMPLETE
CUSHION (8X12.5)
INDICATOR TUBE, FLUORESCENT
4-2. CHASSIS SECTION
HB : SW (A) board
MIC : SW (B) board
Ref. No.
*
* * &€ KF * *
*
51
52
54
55
56
o7
57
57
37
98
59
59
59
60
51
(including @B and HC)
not supplied
Part No.
A-4392-965-A
4-951-801-01
1-665-273-11
1-665-274-1141
1-665-272-11
A-4392-970-A
A-4392-972-A
A-4398-074-A
A-4398-076-A
3-703-244-21
4-989-901-51
4-989-901-61
4-989-902-31
1-666-496-1141
oe 82a
not supplied :
not oc >
Remarks
Description
SW BOARD, COMPLETE
BUTTON ($)
PRIMARY BOARD
SECONDARY BOARD
STANDBY BOARD
MAIN BOARD, COMPLETE
MAIN BOARD, COMPLETE
MAIN BOARD, COMPLETE
MAIN BOARD, COMPLETE
BUSHING (2104), CORD
DE415:AEP.UK,G)
DE315:AEP.UK,G)
DE415:EE)
DE315:EE)
a Nn ee
PANEL, BACK (DE315:UK)
PANEL, BACK (DE315:AEP,G,EE)
PANEL, BACK (DE415)
MIX BOARD (DE415)
not supplied
Ref. No.
61
62
63
64
* 65
67
70
ATI
A7{\
A\72
AXCNJ903
A\T901
A\T901
SoA
Q603, 604, 653, 654,
Q703, 704, 753, 754
Part No.
1-773-252-11
X-4947-207-1
4-924-098-01
4-812-134-00
4-924-098-21
4-956-370-12
3-905-609-01
1-751-520-11
1-769-744-11
4-770-019-11
1-526-794-11
1-431-260-11
1-431-266-11
Poa EXCEPT DE315:
EXCEPT DE315:UK model
|
|
1
|
|
|
UK model
(ste Gong eee 7
Description Remarks
WIRE (FLAT TYPE) (27 CORE)
FOOT ASSY (F50150S)
HOLDER, PC BOARD
RIVET (DIA.3.5), NYLON
HOLDER, PC BOARD
BAND, PLUG FIXED (DE315:UK)
SCREW (TRANSISTOR)
CORD, POWER (DE315:UK)
CORD, POWER (EXCEPT DE315:UK)
ADAPTER CONVERSION PLUG 3P (DE415:UK)
OUTLET, AC (EXCEPT DE315:UK)
TRANSFORMER, POWER (DE315)
TRANSFORMER, POWER (DE415)
The components identified by mark A or dotted
line with mark A\ are critical for safety.
Replace only with part number specified.

Fe
SECTION 5
ELECTRICAL PARTS LIST DISPLAY DISPLAY
Note:
Ref.No.
Part
No.
Description
Remarks
|
Ref.
No.
Part
No.
Description
Remarks
When indicating parts by reference number, Poe te Oued aC tp ieeeiens ane ie es S211 1-554-937-11 SWITCH, KEY BOARD (PRESET TUNING-) $233 1-554-937-11 SWITCH, KEY BOARD (2)
please
include
the
board
name.
ee
a
Teer
eu
te)
eae
uaa
PERSIE
ue
S212
1-554-937-11_
SWITCH,
KEY
BOARD
(PRESET
TUNING+)
$234
1-554-937-11
SWITCH,
KEY
BOARD
(3)
specified m ie diagrams or e components : Metal-tiim resistor ¥
The
Compo
nonie
annie
GY
ENC
Or
ae
P
ETAL
ORI
AL
Oven:
$213
1-554-937-11
SWITCH,
KEY
BOARD
(FM
MODE)
$235
1-554-937-11
SWITCH,
KEY
BOARD
(4)
dotted line with mark A are critical for safety. + -XX, -X mean standardized parts, so they may F< nonflammablé $214 1-554-937-11 SWITCH, KEY BOARD (FM) $236 —_ 1-554-937-11_ SWITCH, KEY BOARD (5)
Replace
only
with
part
number
specified.
have
some
difference
from
the
original
one.
COILS
$215
—
1-554-937-11
SWITCH,
KEY
BOARD
(AM)
$237
1-554-937-11
SWITCH,
KEY
BOARD
(DIRECT)
* Items marked “*” are not stocked since they uH: pH
-dne eae see a lrionisenaited for goulinsieervee sere SEMICONDUCTORS S216 1-554-937-11 SWITCH, KEY BOARD (MEMORY) $238 1-554-937-11 SWITCH, KEY BOARD (MODE)
G
:
German
delay
should
be
anticipated
when
ordering
these
In
each
case,
u:
p,
for
example:
$239
1-554-937-11
SWITCH,
KEY
BOARD
(CD)
EE:
East
European
items.
uA...
pA...
uPA...
,
UPA...
;
<
SWITCH
>
3
SFA
AC
eg
a
HA
9.
2
2
fe
ae
2
2
2
2
2
2
2
2
oA
A
RO
2
Ck
2
oe
fe
oi
2c
2
oc
ie
ofa
ok
2k
ok
« CAPACITORS: uPB..., UPB... , uPC..., uPC... ,
uF: pF UPD... uPD... W200 1-771-054-11 SWITCH, PUSH (1 KEY) (POWER) * A-4392-970-A MAIN BOARD, COMPLETE (DE415:AEPUK,G)
2 2 2 ig 2 oe kok ic og ok ok Ko oie ok oe oe
RefNo,
PartNo.
Description
Remarks
|
Ref.No.
PartNo.
Description
Remarks
<
VIBRATOR
>
*
A-4392-972-A
MAIN
BOARD,
COMPLETE
(DE315:AEP.UK,)
* A-4392-962-A DISPLAY BOARD, COMPLETE (DE415:AEPUK,G) <COIL> Sean bini oe
HERE
HO
ESSE
O
SESS
DEORE
X201
1-577-101-11
VIBRATOR,
CERAMIC
4.19MHz
*
A-4398-074-A
MAIN
BOARD,
COMPLETE
(DE415:EE)
* A-4392-971-A DISPLAY BOARD, COMPLETE (DE315:AEPUK,G) L401 1-410-509-11 INDUCTOR 10uH FACOG CIC OSORIO I SSG aC ICI CK aK ak kak SO CROC CACR ICR SCO kok kook.
Jocbiircabrinnbanbinobe
iit
*
A-4398-076-A
MAIN
BOARD,
COMPLETE
(DE315:EE)
* A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE) < TRANSISTOR > * A-4392-966-A KEY BOARD, COMPLETE Joico nnrenibt
2 2 2g 2 246 fe of oie oie 2 2g 2k 2c 2 2s 2g 2k 2 2K 2K Ok OOK 2 oe KR ok OK EK ORE OK
«
A-4398-075-A
DISPLAY
BOARD,
COMPLETE
(DE315:EE)
201
—8-729-900-63
TRANSISTOR
DTA124ES
3-905-609-01
SCREW
(TRANSISTOR)
Sparco aoe Hoo obi Q202 —8-729-900-36 TRANSISTOR DTC124ES < CONNECTOR > 4-812-134-00 RIVET (DIA. 3.5), NYLON
Q203 8-729-900-36 TRANSISTOR DTC124ES 7-685-872-09 SCREW +BVTT 3x8 (S)
4-921-941-01 CUSHION (FL) Q231 — 8-729-900-36 TRANSISTOR DTC124ES CNP205 1-779-366-11 CONNECTOR, BOARD TO BOARD 4P
4-943-107-11 HOLDER (FL TUBE) < CAPACITOR >
< RESISTOR > < RESISTOR >
<
CAPACITOR
>
C3:
1-162-286-21
CERAMIC
220PF
10%
—
50V
R200 1-247-863-91 CARBON 22K 5% 1/4 R232 1-249-411-11 CARBON 330 5% 1/4 C4 1-126-961-11 ELECT 2.2uF 20% — 50V
C201
1-104-905-11
CAPACITOR
_—0.22F
5.5V
R201
1-247-903-00
CARBON
1M
5%
1/4W R233
1-249-413-11
CARBON
470
5%
1/4W
FE}
C5
—
1-162-306-11
CERAMIC
O.01uF
20%
—
16V
C202
1-164-159-21
CERAMIC
0.1uF
50V
R202
1-249-429-11
CARBON
10K
5%
1/4
R234
1-249-415-11
CARBON
680
5%
1/4W
F
|
C6
—
1-162-291-31
CERAMIC
560PF
10%
50V
C203
1-124-465-00
ELECT
0.47uF
20%
—
50V
R203
1-249-429-11
CARBON
10K
5%
1/4
R235
1-249-417-11
CARBON
1K
5%
1/4W
F
|
C7
—
1-102-527-11
CERAMIC
82PF
5%
=
SOV
C204 1-164-159-21 CERAMIC O.1uF 50V R204 1-249-425-11 CARBON 47K 5% «= 1/AW OF R236 1-249-419-11 CARBON 15K 5% 1/4W F
C205
1-162-294-31
CERAMIC
0.001UF
10%
50V
C8
——-1-102-852-91
CERAMIC
47PE
5%
~~
-50V
R205 1-249-441-11 CARBON 100K 5% 1/4W R237 -1-249-421-11 CARBON 22K 5% 1/4W F | C302 1-126-934-11 ELECT 220uF 20% ~—=—«16V
C206
1-164-159-21
CERAMIC
0.1uF
50V
R206
1-249-429-11
CARBON
10K
5%
1/4W R238
-1-247-843-11
CARBON
33K
5%
1/4W
C303
1-130-494-11
MYLAR
0.082uF
5%
—
50V
C207
1-126-096-11
ELECT
10uF
20%
©
35V
R207
1-249-429-11
CARBON
10K
5%
1/4
R239
1-249-411-11
CARBON
330
5%
1/4
C304
1-137-367-11
FILM
0.0033uF
5%
50V
R211 1-247-863-91 CARBON 22K 5% 1/4 R240 1-249-413-11 CARBON 470 5% 1/4W F } C305 1-130-494-11 MYLAR 0.082uUF 5% 50V
< CONNECTOR > R212 1-247-863-91 CARBON 22K 5% 1/4 R241 1-249-415-11 CARBON 680 5% 1/4W F
C306 1-126-959-11 ELECT O.47uF 20% +~—-50V
CNS201
1-569-327-11
SOCKET,
CONNECTOR
27P
R213
1-247-863-91
CARBON
22K
5%
1/4
R242
1-249-417-11
CARBON
1K
5%
1/4W
F
|
C307
1-126-964-11
ELECT
1OuF
20%
©
50V
CNS202
1-770-400-11
HOUSING,
CONNECTOR
(PC
BOARD)
7P
R214
1-247-863-91
CARBON
22K
5%
1/4
R243
-1-249-419-11
CARBON
15K
5%
1/4W
F
|]
C308
1-126-964-11
ELECT
1OuF
20%
©
50V
R216
1-247-863-91
CARBON
22K
5%
1/4
R244
1-249-421-11
CARBON
2.2K
5%
1/4W
F
|
C309
1-162-291-31
CERAMIC
560PF
10%
50V
< DIODE > R221 1-247-807-31 CARBON 100 5% 1/4W R245 1-247-843-11 CARBON 33K 5% ~~ 1/4W C310 1-126-962-11 ELECT 3.3uF 20% += 50V
R222 1-247-807-31 CARBON 100 5% 1/4 R246 1-249-411-11 CARBON 330 5% 1/4
D201
8-719-815-85
DIODE
1$1585
C311
1-126-961-11
ELECT
2.2uF
20%
—50V
D202
8-719-815-85
DIODE
1$1585
R223
1-247-807-31
CARBON
100
5%
1/4
R247
1-249-413-11
CARBON
470
5%
1/4W
F
|
C312
1-126-934-11
ELECT
220uUF
20%
~=—«16V
D203
8-719-815-85
DIODE
11585
R224
1-247-807-31
CARBON
100
5%
1/4
R248
1-249-415-11
CARBON
680
5%
1/4W
F
|
C313
1-126-934-11
ELECT
220uF
20%
+~—-16V
D204
—-8-719-815-85
DIODE
181585
R225
1-247-807-31
CARBON
100
5%
1/4
R249
1-249-417-11
CARBON
1K
5%
1/4W
F
|
C314
1-136-165-00
FILM
O.1uF
5%
50V
D211
8-719-815-85
DIODE
181585
R226
1-249-441-11
CARBON
100K
5%
1/4W
R280
1-249-419-11
CARBON
15K
5%
1/4W
F|
C316
1-124-252-00
ELECT
0.33uF
20%
50V
R227 1-249-441-11 CARBON 100K 5% 1/4W R281 1-249-421-11 CARBON 22K 5% 1/4W F
D212
8-719-815-85
DIODE
1$1585
C317
1-126-933-11
ELECT
100UF
20%
~~
16V
D213
8-719-815-85
DIODE
1$1585
R228
1-249-412-11
CARBON
390
5%
1/4W
F
R282
1-247-843-11
CARBON
3.3K
5%
1/4
C318
1-137-363-91
FILM
680PF
5%
—50V
D214
8-719-815-85
DIODE
181585
R229
1-249-410-11
CARBON
270
5%
1/4W
F
322
1-126-962-11
ELECT
3.3uF
20%
~=—-50V
D221
8-719+815-85
DIODE
1$1585
(DE315:EE/DE415:EE)
R230
1-249-410-11
CARBON
270
5%
1/4W
F
<
SWITCH
>
C323.
1-136-173-00
FILM
O.47uF
=
5%
=
SOV
D223
8-719-815-85
DIODE
1$1585
R231
1-249-427-11
CARBON
6.8K
5%
«=
1/4W
OF
C324
1-126-967-11
ELECT
47uF
=
20%
~—«18V
R270 1-247-807-31 CARBON 100 5% 1/4W S217 1-554-937-11 SWITCH, KEY BOARD (SURROUND ON/OFF)
D224
8-719-815-85
DIODE
1$1585
(DE415)
$218
1-554-937-11
SWITCH,
KEY
BOARD
(SET
UP)
C325
1-136-165-00
FILM
O.1uF
5%
50V
D225
8-719-815-85
DIODE
1$1585
(DE315)
R283
1-249-427-11
CARBON
68K
5%
1/4W
F
$219
1-554-937-11
SWITCH,
KEY
BOARD
(EFFECT/DELAY
TIME)
C326
1-136-165-00
FILM
O.1uF
5%
50V
D231
8-719-815-85
DIODE
1$1585
R284
1-249-427-11
CARBON
68K
5%
1/4W
F
$220
1-554-937-11
SWITCH,
KEY
BOARD
(TV/DBS)
C327
1-126-959-11
ELECT
O.47uF
=
-20%
~=—-50V
D235
8-719-313-50
DIODE
SEL6810A-TH12
(HALL)
R286
1-249-437-11
CARBON
47K
5%
1/4W
$221
1-554-937-11
SWITCH,
KEY
BOARD
(TUNER)
C328
1-126-963-11
ELECT
4.7uF
20%
~—-50V
D236
8-719-313-50
DIODE
SEL6810A-TH12
(C.STUDIO)
329
1-126-959-11
ELECT
0.47uF
20%
~=—-50V
< SWITCH > $222 1-554-937-11 SWITCH, KEY BOARD (PHONO)
D237
8-719-313-50
DIODE
SEL6810A-TH12
(PRO
LOGIC)
$223
1-554-937-11
SWITCH,
KEY
BOARD
(VIDEO)
C335
1-136-161-00
FILM
0.047uF
5%
50V
$201 1-554-937-11 SWITCH, KEY BOARD (CENTER LEVEL-) $224 1-554-937-11 SWITCH, KEY BOARD (6) C336 1-126-934-11 ELECT 220uF 20% ~—«16V
< FILTER > $202 1-554-937-11 SWITCH, KEY BOARD (CENTER LEVEL+) $225 1-554-937-11 SWITCH, KEY BOARD-(7) C337 1-126-964-11 ELECT 10uF 20% © 50V
$203
1-554-937-11
SWITCH,
KEY
BOARD
(REAR
LEVEL-)
$226
1-554-937-11
SWITCH,
KEY
BOARD
(8)
C338
1-126-964-11
ELECT
10uF
20%
+=
-50V
FL2011-517-141-11_
INDICATOR
TUBE,
FLUORESCENT
$204
1-554-937-11
SWITCH,
KEY
BOARD
(REAR
LEVEL+)
C339
1-126-964-11
ELECT
10uF
20%
+=
-50V
$205 1-554-937-11 SWITCH, KEY BOARD (CHARACTER) $227 1-554-937-11 SWITCH, KEY BOARD (9)
<IC>
$228
1-554-937-11
SWITCH,
KEY
BOARD
(0)
C340
1-126-964-11
ELECT
10uF
20%
+=
-50V
$206 1-554-937-11 SWITCH, KEY BOARD (DISPLAY) $229 1-554-937-11 SWITCH, KEY BOARD (SHIFT) C341 1-126-934-11 ELECT 220uF «20% ~—=—«16V
10201
8-759-479-19
IC
uPD78044FGF-064-3B9
S207
1-554-937-11
SWITCH,
KEY
BOARD
(EON)
$231
1-554-937-11
SWITCH,
KEY
BOARD
(TAPE/MD)
C342
1-126-962-11
ELECT
3.3uF
20%
+~—-50V
(C202
8-759-962-08
IC
BA6208
$208
1-554-937-11
SWITCH,
KEY
BOARD
(PTY)
$232
1-554-937-11
SWITCH,
KEY
BOARD
(1)
C343
1-126-962-11
ELECT
3.3uF
20%
~—-50V
10203
8-759-332-18
IC
GP1U27XB
(REMOTE
SENSOR)
S209
1-554-937-11
SWITCH,
KEY
BOARD
(TUNING-)
C344
1-136-165-00
FILM
O1uF
5%
50V
S210 1-554-937-11 SWITCH, KEY BOARD (TUNING+)
— 25 — — 26 —

Ref.No. Part No. Description Remarks | Ref.No. Part No. Description Remarks
C345 = 1-136-165-00 FILM 0.1uF 5% 50V C721 =: 1-126-923-11 ELECT 220uF 20% 10V
C346 ~—s: 1-126-959-11 ELECT 0.47uF 20% 50V C722 = 1-126-964-11 ELECT 10uF 20% 50V
C347 ~—s- 1-126-963-11 ELECT 4.7uF 20% 50V C740 ~—s- 1-128-562-11 ELECT 47uF 20% 100V
(348 = 1-126-959-11 ELECT 0.47uF 20% 50V C741 =: 1-128-562-11 ELECT 47uF 20% 100V
C349 = 1-126-963-11 ELECT 4.7uF 20% 50V C742 = 1-126-925-11 ELECT 470uF 20% 10V
C350 ~=—s- 1-124-250-11 ELECT 0.15uF 20% 50V C743, 1-126-925-11 ELECT 470uF 20% 10V
C351. = 1-126-962-11 ELECT 3.3uF 20% 50V C752 =: 1-162-282-31 CERAMIC 100PF 10% 50V
C352. = 1-124-250-11 ELECT 0.15uF 20% 50V C753. 1-126-933-11 ELECT 100uF 20% 10V
C353: 1-164-159-21 CERAMIC 0.1uF 50V C755 ~—- 1-102-233-00 CERAMIC 33PF 10% 500V
(354 ~—- 1-164-159-21 CERAMIC 0.1uF 50V C760 =: 1-126-967-11 ELECT 47uF 20% 16V
(355 =: 1-164-159-21 CERAMIC 0.1uF 50V C761 ~—s- 1-137-372-11 FILM 0.022uF 5% 50V
C356 ~—s- 1-164-159-21 CERAMIC 0.1uF 50V C770 ~—- 1-162-286-21 CERAMIC 220PF 10% 50V
(357 ~—s- 1-164-159-21 CERAMIC 0.1uF 50V C799 ~—s- 1-164-159-21 CERAMIC 0.1uF 50V
C359 = 1-126-963-11 ELECT 4.7uF 20% 50V C801 =: 1-104-664-11 ELECT 47uF 20% 26V
C360 =: 1-126-963-11 ELECT 4,7uF 20% 50V C802. ~—s- 1-104-664-11 ELECT 47uF 20% 256V
C363 =: 1-164-159-21 CERAMIC 0.1uF 50V C803: 1-128-506-11 ELECT 6800uF 20% 50V
C365 =: 1-126-966-11 ELECT 33uF 20% 16V C804 =: 1-128-506-11 ELECT 6800uF 20% 50V
C366 =: 1-164-159-21 CERAMIC 0.1uF 50V C805 =: 1-130-781-00 FILM 0.22uF 10% 100V
C401 ~—- 1-162-286-21 CERAMIC 220PF 10% 50V C806 =: 1-130-781-00 FILM 0.22uF 10% 100V
C402 ~=—s- 1-126-962-11 ELECT 3.3uF 20% 50V C807 ~—s- 1-104-664-11 ELECT 47uF 20% 26V
C403 =: 1-126-966-11 ELECT 33uF 20% 16V C808 =: 1-104-664-11 ELECT 47uF 20% 25V
C404 ~—s-1-162-282-31 CERAMIC 100PF 10% 50V C809 =: 1-126-960-11 ELECT 1uF 20% 50V
C405 =: 1-137-459-11 FILM 0.0056uF 5% 100V C810 = 1-126-960-11 ELECT 1uF 20% 50V
C406 =: 11-164-159-21 CERAMIC 0.1uF 50V C811 =: 1-126-942-61 ELECT 1000uF 20% 25V
C407 —s:«1-137-365-11 FILM 0.0015uF 5% 50V C812) = 1-126-942-61 ELECT 1000uF = 20% 25V
C408 =: 1-162-294-31 CERAMIC 0.001uF 10% 50V C813 1-101-001-00 CERAMIC 0.001 uF 50V
C409 =: 1-126-962-11 ELECT 3.3uF 20% 50V C814 ~—s- 1-101-001-00 CERAMIC 0.001uF 50V
C410 =: 1-164-159-21 CERAMIC 0.1uF 50V C820 ~=—- 1-16 1-494-00 CERAMIC 0.022uF 25V
C412 = 1-162-291-31 CERAMIC 560PF 10% 50V C821 ~=—- 1-161-494-00 CERAMIC 0.022uF 25V
C413: 1-164-159-21 CERAMIC 0.1uF 50V C822 = 1-104-664-11 ELECT 47uF 20% 25V
C415: 1-164-159-21 CERAMIC 0.1uF 50V C823 1-104-664-11 ELECT 47uF 20% 25V
C416 ~—-1-164-159-21 CERAMIC 0.1uF 50V C950 =. 1-126-767-11 ELECT 1000uF 20% 16V
0434 = 1-162-286-21 CERAMIC 220PF 10% 50V C951 = 1-164-097-11 CERAMIC 0.022uF 50V
0435 =: 1-162-286-21 CERAMIC 220PF 10% 50V C952. =: 1-126-960-11 ELECT uF 20% 50V
C451 = 1-162-286-21 CERAMIC 220PF 10% 50V fF (953— 1-124-464-11 ELECT 0.22uF 20% S0V
0452 = 1-126-962-11 ELECT 3.3uF 20% 50V C954 =: 1-126-096-11 ELECT 10uF 20% 36V
0453 =: 1-126-966-11 ELECT 33uF 20% 16V C955 =: 1-164-159-21 CERAMIC 0.1uF 50V
0454 =: 1-162-282-31 CERAMIC 100PF 10% 50V CCO1 =: 1-162-282-31 CERAMIC 100PF 10% 50V
C455 =: 1-137-459-11 FILM 0.0056uF 5% 100V CC02 =: 1-162-282-31 CERAMIC 100PF 10% S50V
0457 =: 1-137-365-11 FILM 0.0015uF 5% 50V CC03 =: 1-162-282-31 CERAMIC 100PF 10% 50V
C459 =: 1-126-962-11 ELECT 3.3uF 20% 50V CC04 =: 1-162-282-31 CERAMIC 100PF 10% 50V
C460 =: 1-164-159-21 CERAMIC 0.1uF 50V CC05 =: 1-162-282-31 CERAMIC 100PF 10% 50V
0602 =: 1-162-282-31 CERAMIC 100PF 10% 50V CCO6 =: 1-162-282-31 CERAMIC 100PF 10% S0V
C603 =: 1-126-933-11 ELECT 100uF 20% 10V CCO7 =: 1-162-282-31 CERAMIC 100PF 10% SOV
C605 =: 1-102-233-00 CERAMIC 33PF 10% 500V CC51 =: 1-162-282-31 CERAMIC 100PF 10% S0V
C610 =: 1-126-967-11 ELECT 47uF 20% 16V CC52 =: 1-162-282-31 CERAMIC 100PF 10% dV
C611: 1-137-372-11 FILM 0.022uF 5% 50V CC53_—s: 1-162-282-31 CERAMIC 100PF 10% 50V
(620 =: 1-162-286-21 CERAMIC 220PF 10% 50V CC54 ~—- 1-162-282-31 CERAMIC 100PF 10% S0V
(652 = 1-162-282-31 CERAMIC 100PF 10% 50V CC55 =: 1-162-282-31 CERAMIC 100PF 10% SOV
(653. =: 1-126-933-11 ELECT 100uF 20% 10V CC56 =: 1-162-282-31 CERAMIC 100PF 10% 50V
(655 —- 1-102-233-00 CERAMIC 33PF 10% 500V CC57 ~—s: 1-162-282-31 CERAMIC 100PF 10% 50V
C660 =: 1-126-967-11 ELECT 47uF 20% 16V
C661. = 1-137-372-11 FILM 0.022uF 5% 50V < CONNECTOR >
(670 =: 1-162-286-21 CERAMIC 220PF 10% 50V
C702 =: 1-162-282-31 CERAMIC 100PF 10% 50V CNP702 1-750-388-11 PIN, CONNECTOR 5P
CNP706 1-764-477-11 PIN, CONNECTOR (PC BOARD) 8P
C703. =: 1-126-933-11 ELECT 100uF 20% 10V CNS204 1-569-327-11 SOCKET, CONNECTOR 27P
(705 =: 1-102-233-00 CERAMIC 33PF 10% 500V CNS301 1-568-442-11 SOCKET, CONNECTOR 9P
C710 =: 1-126-967-11 ELECT 47uF 20% 16V CNS701 1-568-439-11 SOCKET, CONNECTOR 7P
(711 =: 1-137-372-11 FILM 0.022uF 5% 50V
(720. ~=—- 1-162-286-21 CERAMIC 220PF 10% 50V CNS802 1-770-480-11 SOCKET, CONNECTOR PIN 4P
S07 <=

Ref, No.
D610
D710
0721
D722
D723
D724
0725
D801
D802
D804
D810
D811
D812
D813
D814
D815
D817
D818
D820
D821
D822
D823
D901
* G200
* G201
*
G202
C1
1C300
10301
1C302
1C401
10402
10701
16702
1C801
1C802
IC950
J401
J402
J403
ui
L301
L302
L601
L651
L701
L751
Part No.
8-719-815-85
8-719-815-85
8-719-815-85
8-719-815-85
8-719-815-85
8-719-815-85
8-719-815-85
8-719-002-33
8-719-302-38
8-719-010-38
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-815-85
8-719-815-85
8-719-001-31
8-719-815-85
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-815-85
1-537-738-21
1-537-738-21
1-537-738-21
8-759-450-86
8-759-442-97
8-759-442-96
8-759-636-74
8-759-805-14
8-759-636-74
8-759-326-52
8-759-326-52
8-759-231-58
8-759-604-45
8-759-333-83
1-770-614-11
1-770-015-14
1-770-614-11
1-410-521-11
1-410-509-1141
1-410-509-11
1-420-872-00
1-420-872-00
1-420-872-00
1-420-872-00
Description Remarks
< DIODE >
DIODE
DIODE
DIODE
DIODE
DIODE
181585
181585
181585
181585
181585
DIODE
DIODE
DIODE
DIODE
DIODE
181585
181585
UZL-24L
RBV-602-01
UZ-5.1BSB
11ES2
11ES2
11ES2
11ES2
181585
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
181585
UZL-9H3-TA
181585
11ES2
11ES2
DIODE
DIODE
DIODE
11ES2
11ES2
181585
< TERMINAL >
TERMINAL, EARTH
TERMINAL, EARTH
TERMINAL, EARTH
<IC>
IC BU1922
IC LV1016
IC LA2786
IC M5218AP-22
IC LO07822
IC M5218AP-22
IC uPC2581V
IG uPC2581V
IC TA7812S
IC M5F79M12
IC NJM2103D
< JACK >
JACK, PIN 4P (PHONO/CD)
JACK, PIN 6P (TAPE/MD,TV DBS AUDIO IN)
JACK, PIN 4P (VIDEO)
< COIL >
INDUCTOR
INDUCTOR 10uH
INDUCTOR 10uH
COIL, AIR-CORE
COIL, AIR-CORE
100uH
COIL, AIR-CORE
COIL, AIR-CORE
Ref, No.
Q303
Q304
Q307
Q308
Q601
Q602
Q603
Q604
Q610
Q620
0651
Q652
Q653
Q654
Q670
Q701
Q702
Q703
Q704
Q710
Q720
Q721
Q722
Q723
Q751
Q752
Q753
Q754
Q770
Q801
Q802
Q808
Q809
Q951
— 28 —
Part No.
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
8-729-140-82
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-140-82
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
8-729-140-82
8-729-140-82
8-729-140-84
8-729-119-78
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-140-82
8-729-140-97
8-729-119-78
8-729-180-92
8-729-119-78
8-729-030-18
1-249-421-11
1-247-807-31
1-247-807-31
1-247-903-00
1-249-421-11
1-249-421-11
1-249-439-11
1-249-441-11
1-249-436-11
1-247-862-11
1-249-421-14
1-249-421-11
1-249-441-11
1-249-425-11
1-249-425-11
1-249-425-11
1-249-425-11
1-249-441-11
1-249-441-11
1-249-425-11
Description
Remarks
< TRANSISTOR >
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
28D2144S
28021448
28021445
28D2144S
2SA1175-HFE
2803623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR 2SC403SP-51
TRANSISTOR 2SA988-PAFAEA
TRANSISTOR 2SA1175-HFE
TRANSISTOR 28C3623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR 2SA988-PAFAEA
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SC3623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
28C403SP-51
2SA988-PAFAEA
2SA988-PAFAEA
280184 1-PAFAEA
2S0403SP-51
2SA1175-HFE
2S03623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
< RESISTOR >
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
2SA988-PAFAEA
2$B734-34
2SC6403SP-51
2SD809-K
2SC403SP-51
2802525
1/4W OF
1/4W
1/4W
1/4W
1/4W F
2.2K
100
100
1M
2.2K
5%
5%
5%
5%
5%
1/4W OF
1/4W
1/4W
1/4W
1/4W
2.2K
68K
100K
39K
20K
5%
5%
5%
5%
5%
1/4W OF
1/4AW F
1/4W
1/4W OF
1/4W OF
2.2K
2.2K
100K
4.7K
4.7K
5%
5%
5%
5%
5%
1/4W OF
1/4W OF
1/4W
1/4W
1/AW F
4.7K
4.7K
100K
100K
4.7K
5%
5%
5%
5%
5%

Ref. No.
R360
R361
R362
R363
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R411
R412
R413
R414
R415
R416
R417
R420
R435
R442
R443
R447
R448
R449
R451
R452
R453
R454
R455
R456
R457
R458
R459
R460
R461
R462
R463
R465
RAG6
R467
R470
R473
R601
R602
R603
R604
R605
R610
R611
R613
AN R614
AN R615
AA R616
AN R67
R618
AX R619
Part No.
1-247-843-11
1-249-429-11
1-249-429-11
1-249-411-11
1-249-411-11
1-249-421-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-14
1-249-437-14
1-247-897-11
1-249-416-11
1-247-897-11
1-249-437-11
1-249-425-11
1-249-417-11
1-249-417-11
1-247-897-11
1-249-441-11
1-249-418-11
1-249-418-11
1-249-418-11
1-249-416-11
1-249-429-11
1-247-863-91
1-249-411-11
1-249-421-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-11
1-249-437-11
1-247-897-11
1-249-416-11
1-247-897-11
1-249-437-11
1-249-417-11
1-249-417-11
1-247-897-11
1-249-441-11
1-249-437-11
1-249-417-11
1-249-439-11
1-249-414-11
1-249-439-11
1-249-441-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-409-11
1-249-409-11
1-233-352-41
1-249-393-11
1-249-389-14
1-249-405-11
Description
CARBON 3.3K 5%
CARBON 10K 5%
CARBON 10K 5%
CARBON 330 5%
CARBON 330 5%
CARBON 2.2K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 10K 5%
CARBON 47K 5%
CARBON 560K 5%
CARBON 820 5%
CARBON 560K 5%
CARBON 47K 5%
CARBON 4.7K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 560K 5%
CARBON 100K 5%
CARBON 1.2K 5%
CARBON 1.2K 5%
CARBON 1.2K 5%
CARBON 820 5%
CARBON 10K 5%
CARBON 22K 5%
CARBON 330 5%
CARBON 2.2K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 10K 5%
CARBON 47K 5%
CARBON 560K 5%
CARBON 820 5%
CARBON 560K 5%
CARBON 47K 5%
CARBON 1K 5%
CARBON 1K 5%
CARBON 560K 5%
CARBON 100K 5%
CARBON 47K 5%
CARBON 1K 5%
CARBON 68K 5%
CARBON 560 5%
CARBON 68K 5%
CARBON 100K 5%
CARBON 2.2K 5%
CARBON 47K 5%
CARBON 560 5%
CARBON 220 5%
CARBON 220 5%
ENCAPSULATED COMPONENT
CARBON 10 5%
CARBON 47 5%
CARBON 100 5%
Remarks
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
mana")
mn
Tt Fs Te
mn
Ref. No.
R620
R621
A R622
R623
R630
R631
R632
R651
R652
R653
R654
R655
R660
R661
R663
AX R664
A\ R665
A\ R666
A\R667
R668
R670
R671
R672
R673
R701
R702
R703
R704
R705
R710
R711
R713
A\R714
AXR715
A\R716
AR717
R718
A\R719
R720
R721
AR722
R723
R724
R725
R726
R727
R730
R731
R734
A\R740
AR741
R742
R743
R751
R752
—99.—
Part No.
1-249-419-11
1-249-426-11
1-249-403-11
1-249-437-11
1-249-426-11
1-247-887-00
1-249-426-11
1-249-417-11
1-249-439-11
1-249-414-11
1-249-439-11
1-249-441-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-409-11
1-249-409-11
1-233-352-41
1-249-393-11
1-249-389-11
1-249-419-11
1-249-426-11
1-249-431-11
1-249-437-11
1-249-417-11
1-249-439-11
1-249-414-11
1-249-439-11
1-249-441-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-409-11
1-249-409-11
1-233-352-41
1-249-393-11
1-249-389-11
1-249-405-11
1-249-419-11
1-249-426-11
1-249-403-11
1-249-437-11
1-249-425-11
1-249-429-11
1-249-417-11
1-249-427-11
1-249-429-11
1-247-887-00
1-249-429-11
1-249-393-11
1-249-393-11
1-249-425-11
1-249-425-11
1-249-417-11
1-249-439-11
Description
CARBON 1.5K 5%
CARBON 5.6K 5%
CARBON 68 5%
CARBON 47K 5%
CARBON 5.6K 5%
CARBON 220K 5%
CARBON 5.6K 5%
CARBON 1K 5%
CARBON 68K 5%
CARBON 560 5%
CARBON 68K 5%
CARBON 100K 5%
CARBON 2.2K 5%
CARBON 47K 5%
CARBON 560 5%
CARBON 220 5%
CARBON 220 5%
ENCAPSULATED COMPONENT
CARBON 10 5%
CARBON 4.7 5%
CARBON 1.5K 5%
CARBON 5.6K 5%
CARBON 15K 5%
CARBON 47K 5%
CARBON 1K 5%
CARBON 68K 5%
CARBON 560 5%
CARBON 68K 5%
CARBON 100K 5%
CARBON 2.2K 5%
CARBON 47K 5%
CARBON 560 5%
CARBON 220 5%
CARBON 220 5%
ENCAPSULATED COMPONENT
CARBON 10 5%
CARBON 4.7 5%
CARBON 100 5%
CARBON 1.5K 5%
CARBON 5.6K 5%
CARBON 68 5%
CARBON 47K 5%
CARBON 4.7K 5%
CARBON 10K 5%
CARBON 1K 5%
CARBON 6.8K 5%
CARBON 10K 5%
CARBON 220K 5%
CARBON 10K 5%
CARBON 10 5%
CARBON 10 5%
CARBON 4.7K 5%
CARBON 4.7K 5%
CARBON 1K 5%
CARBON 68K 5%
Remarks
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
(DE415)
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
mam”
nam
(DE415)
1/4W
(DE415)
1/4W
1/4W
1/4W
1/4W
1/4W
1/4W
The components identified by mark 4. or dotted
line with mark A\ are critical for safety.
Replace only with part number specified.
F
aT

[MAIN | [Ix | | PRIMARY | [SECONDARY | |STBY |
Ref.No. Part No. Description Remarks
R753 ~—s- 1-249-414-11 CARBON 560 5% 1/4W F
R754 ~—s- 1-249-439-11 CARBON 68K 5% 1/4W
R755 ~—«- 1-249-441-11 CARBON 100K 5% 1/4W
R760 ~—-1-249-421-11 CARBON 2.2K 5% 1/4w F
R761 1-249-437-11 CARBON 47K 5% 1/4W
R763 ~—s«- 1-249-414-11 CARBON 560 5% V/4wW F
A\R764 1-249-409-11 CARBON 220 5% 1/4W F
A\R765 ~—-1-249-409-11 CARBON 220 5% 1/4W OF
A\R766 ~—-1-233-352-41 ENCAPSULATED COMPONENT
A\R767 ~—-:1-249-393-11 CARBON 10 5% 1/4W OF
R768 —_1-249-389-11 CARBON 4.7 5% 1/4W F
R770 __—‘1-249-419-11 CARBON 1.5K 5% 1/4W F
R771 1-249-426-11 CARBON 5.6K 5% 1/4W
R772 1-249-431-11 CARBON 15K 5% 1/4W
R773 1-249-437-11 CARBON 47K 5% 1/4W
R781 1-247-887-00 CARBON 220K 5% 1/4W
(DE415)
A\R803 ~—s- 1-249-389-11 CARBON 4.7 5% 1/4W F
R804 1-249-421-11 CARBON 2.2K 5% W/4w F
R821 1-249-437-11 CARBON 47K 5% 1/4W
R822 1-249-425-11 CARBON 4.7K 5% 1/4W F
R823 1-249-437-11 CARBON 47K 5% 1/4W
R824 1-249-425-11 CARBON 4.7K 5% 1/4W OF
R825 1-249-407-11 CARBON 150 5% 1/4W F
A\R830 1-249-405-11 CARBON 100 5% 1/4W F
AR831 1-249-403-11 CARBON 68 5% 1/4W OF
R950 1-249-421-11 CARBON 2.2K 5% 1/AW F
R951 1-249-429-11 CARBON 10K 5% 1/4W
R952 1-247-843-11 CARBON 3.3K 5% 1/4W
R953 1-247-863-91 CARBON 22K 5% 1/4W
R954 1-249-439-11 CARBON 68K 5% 1/4W
R955 1-249-429-11 CARBON 10K 5% 1/4W
R956 1-247-843-11 CARBON 3.3K 5% 1/4W
R957 1-249-417-11 CARBON 1K 5% 1/4AW F
R958 1-249-401-11 CARBON 47 5% 1/4W F
R960 1-249-429-11 CARBON 10K 5% 1/4W
< RELAY >
RY601 = 1-515-921-11 RELAY (12V)
RY701 = 1-515-921-11 RELAY (12V)
RY801 = 1-755-013-11 RELAY
< TERMINAL >
T™1 1-694-266-11 TERMINAL BOARD, ANT (ANTENNA)
TM601 = 1-537-510-11 TERMINAL BOARD (SPEAKER) (6P)
(SURROUND SPEAKER)
TM701 =‘ 1-537-376-11 TERMINAL BOARD (SPEAKER) (FRONT SPEAKER)
< TUNER >
TU001 1-233-594-12 ENCAPSULATED COMPONENT (AEP.UK,G)
TU001 = 1-233-595-11 ENCAPSULATED COMPONENT (EE)
< VIBRATOR >
x1 1-579-900-21 VIBRATOR, CRYSTAL 4.33MHz
X301 1-579-952-21 VIBRATOR, CERAMIC 8MHz
FIFI ICR OOO IORI IO OGIO ORI OR IO IOIGR IO doi ok 4 kK a
530 <=
Ref.No. Part No. Description Remarks
: 1-666-496-11 MIX BOARD (DE415)
FOR RRR RE
< CONNECTOR >
CNS253 1-691-765-11 PLUG (MICRO CONNECTOR) 3P (DE415)
< JACK >
J253.——1-774-843-11 JACK, PIN 1P (MIX)(DE415)
FECA EGCG OOOO IGG OOOO IGOR GI Kak iar
i 1-665-273-11 PRIMARY BOARD
2 RK RK KK AK
1-533-233-21 HOLDER, FUSE
< FUSE >
A\F901 —_1-532-259-00 FUSE TIME LAG 1.6A
JEG GOS GA CGO CIO GIGI GOI AI GR AGR ie
* 1-665-274-11 SECONDARY BOARD
FOO IA IK
< CONNECTOR >
CNP801 1-764-480-11 PIN, CONNECTOR (PC BOARD) 11P
< RESISTOR >
A\R810 ~—- 1-249-381-11 CARBON 1 5% 1/4W OF
AR811_—s- 1-249-381-11 CARBON 1 5% 1/4W OF
SIRI OR RRO OR RR AOR OK IO OR IK 30K ok a 2 9 Kok akc oe ok akc ae
* 1-665-272-11 STBY BOARD
JR OK OK eK aK
1-533-233-11 HOLDER, FUSE
< CONNECTOR >
CNP802 1-779-495-11 PLUG, CONNECTOR PIN 4P
CNP901 1-564-321-00 PIN, CONNECTOR 2P
CNP903 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P (AEP,G,EE)
< DIODE >
D816 = 8-719-815-85 DIODE 181585
< FUSE >
AF902 1-532-286-00 FUSE TIME LAG 2.5A (AEP.G,EE)
< RELAY >
A\RY901 =: 1-515-720-11 RELAY
< TRANSFORMER >
AT902 —- 1-450-358-11 TRANSFORMER, POWER
FEI ICRF III OOO GIO IORI ORO A IO IO K
The components identified by mark A\ or dotted
line with mark A\ are critical for safety.
Replace only with part number specified.