Stansport 206 Manual

Read all Warnin s and Operatin Instructions
before use and retain for future reference
FOR YOUR SAFETY
IF YOU SMELL GAS:
1. Do Not attempt to li ht appliance.
2. Extin uish any open flame.
3. Disconnect from fuel supply.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Usin it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
Owner’s Manual and Operatin Instructions
for Hi h Output Propane Stove & Grill w/Piezo I niter
Model 206
FOR YOUR SAFETY
Do not store or use asoline or
other liquids with flammable vapors
in the vicinity of this or any other
appliance.
MADE IN CHINA
STANSPORT, INC. LOS ANGELES, CA 90023 - For questions all ustomer servi e: Toll Free [phone]
Limited Warranty
Stansport™ warrants that for the perio of one year this pro uct, will be free from efects in material an workmanship. Stansport™, at its option, will repair or replace this pro uct
or any component of the pro uct foun to be efective uring the warranty perio . Replacement will be ma e with a new or remanufacture pro uct of component. If the pro uct is no
longer available, replacement will be ma e with a similar pro uct of equal or greater value. This is your exclusive warranty.
This warranty is vali for the original retail purchaser from the ate of initial retail purchase an is not transferable. Keep the original sales receipt. Proof of purchase is require to obtain
warranty performance. Stansport™ ealers, service centers, or retail stores selling Stansport™ pro ucts o not have the right to alter, mo ify or in any way change the terms an con i-
tions of this warranty.
This warranty oes not cover normal wear of parts or amage resulting from any of the following: negligent use or misuse of the pro uct, use contrary to the operating instructions,
isassembly, repair or alteration by anyone other than Stansport™ or an authorize service center. Further, the warranty oes not cover acts of Go , such as fire, floo , hurricanes an
torna os.
Stansport™ shall not be liable for any inci ent or consequential amages cause by the breach of any express or implie warranty or con itions. Except to the extent prohibite by
applicable law, any implie warranty of merchantability or fitness for a particular purpose is limite in uration to the uration of the above warranty or con itions. Some states, provinces
or juris ictions o not allow the exclusion or limitation of inci ental or consequential amages or limitations on how long an implie warranty lasts, so the above limitations or exclusion
may not apply to you. This warranty gives you specific legal rights, an you may also have other rights that vary from state to state or province to province.
How to obtain warranty service: o not return this pro uct to the store. Call 1-800-421-6131 toll free or write us at Stansport™, 2801 E. 12th Street, Los Angeles, CA 90023. Be pre-
pare to give your name, a ress, mo el number, escription of the problem, phone number, an proof of retail purchase (sales slip).
PLEASE READ CAREFULLY TO ENSURE YOUR SAFETY:
FOR OUTDOOR USE ONLY
1) Read and follow all instructions.
2) When used in an enclosed area, allow for ample ventilation.
3) Do not expose the propane cylinder to excessive heat.
) Always inspect the stove, propane cylinder and connectors for damage, debris or dirt before attaching the cylinder to the stove.
5) Always attach/detach the propane cylinder away from any open flame or pilot light and only after the stove has cooled.
6) Always inspect the burner holes for obstructions prior to operation. Do not operate if any blockage is found.
7) Do not use or operate if either the stove or propane cylinder is found to be damaged.
8) Always disconnect the propane cylinder when not in use and/or transporting. Store in an upright position and in a cool, well ventilated area.
9) Be sure to tightly secure all connections to the propane cylinder prior to usage.
10) Absolutely never operate the stove near any flammable liquids or vapors and keep all flammable or combustible materials beyond the clearance zone
as indicated on the back panel.
11) Discontinue operation and close valve if:
• Ambient temperature drops below-10ºF.
• There is no fuel remaining in the propane cylinder.
• Lighting cannot be performed quickly and easily.
• Combustion becomes unstable or there are repeated flame-outs.
12) Absolutely do not use as a space heater, or in a tent.
13) Keep out of the reach of children.
CONNECTING THE FUEL CYLINDER:
1) Use only 16. oz propane cylinders as approved by the United States Department of Transportation.
2) Make sure the valve knob is turned off (twist in a clockwise direction).
3) Make sure the rubber seal is clean, undamaged, and in its proper centered position. The rubber seal is part of the valve adapter assembly and
the cylinder connection is to be made to the underside of the valve adapter assembly.
) Screw the propane gas cylinder onto the stove valve adapter. Hand tighten only.
5) Apply soapy water to the connection to check for leakage. (Leaking gas will form bubbles).
6) After determining there is no leakage, draw a flame towards the burner’s center and slowly open valve (twist counter-clockwise). Each burner must
be individually lit. Note that opening a burner valve and not lighting the burner, while the other burner is firing, could result in an explosion and/or
fire.
WARNING
• FOR OUTDOOR USE ONLY.
• Supply plenty of fresh air when using the campstove. Do not obstruct the flow of combustion air or ventilation air.
• Do not use as a space heater.
• Stove produce heat. Keep stove away from burnable materials. Do not place the stove any closer than 2 ” to combustibles.
• Use a flat, level support surface where the stove is safe from accidental tipping.
• Use only 1 .7 or 16. oz. propane cylinders marked per USDOT-39 or TC CAN/CSA B339 standards.
• Use only with propane fuel.
• Use only the 16 psi regulator included with your stove. Do not attempt to alter.
CAUTION
PROPANE FUEL IS HIGHLY FLAMMABLE AND UNDER PRESSURE.
Do not store in temperatures over 120˚F.
Never use a flame to check for leaks. Use soapy water.
Keep out of the reach of children at all times.
Your disposable propane ylinder
will fun tion most effi iently if the
bottle is tilted at a 45˚ degree
angle upward toward the pressure
regulator. This will allow the most
effi ient withdrawal of fuel from
the ylinder under most ondi-
tions.

WARNING:
Propane as is hi hly flammable and under pressure in the cylinder. Do Not store or use asoline or other flammable liq-
uids or vapors in the vicinity of this stove. If you detect the odor of as, immediately evacuate the enclosed area and
contact the appropriate authorities/professionals.
SET UP/ OPERATING/ STORAGE INSTRUCTIONS
PREPARING THE STOVE
1. Place the stove on a flat, level, sturdy surface.
2. Open the lid and align the holes in the windshield with the tabs on the inside of the lid, snap into place.
3. Make sure the burners are in the off position.
. Push regulator assembly firmly into the stove. Tighten nut securely.
5. Screw the portable propane cylinder into the regulator.
(Your disposable propane cylinder will function most efficiently if the bottle is tilted at a 5˚ degree angle upward toward the
pressure regulator. This will allow the most efficient withdrawal of fuel from the cylinder under most conditions).
OPERATING THE STOVE
1. Turn the burner valve on and press the red igniter button until the burner lights.
2. Adjust the flame to the desired height. Flame should be compact and blue in color.
3. Avoid getting dirt into valves, regulator, and burners.
. To shut burner off, turn the valve to off. (clockwise).
CLEANING YOUR STOVE
1. Allow the grill, grate and burner to cool completely.
2. Remove the propane tank from the stove.
3. Remove the grate from the stove.
. Wash with soapy water and rinse thoroughly. Do not use abrasive materials.
5. A thorough cleaning is recommended after every 10 hours of use or sooner if burners become
overly dirty prior to 10 hours of operation.
6. Prior to each use, check to see all gas ports on burner are clean and operating properly.
If not, remove from fuel source and clean before usage.
7. No other maintenance is necessary or recommended by the manufacturer.
STORING YOUR STOVE
1. Do NOT leave the propane tank attached to stove when not in use.
2. To remove the propane cylinder, turn off the stove and allow to cool for 15 minutes. Firmly grasp the fuel
supply line and carefully turn the propane cylinder in a counter clockwise direction.
3. To remove the fuel supply tube, rotate the brass fitting in a counter clockwise direction. A slight “tug”
may be required after it is unscrewed to pull the tube out of the stove.
. Store the fuel supply tube under the grate.
5. Unlock the windshield and fold down.
6. Close the lid and secure latch.
SERVICE AND REPAIR
This product is a sealed unit and is not designed to be repaired by the consumer. Do not attempt to service the stove
in the field. Contact the manufacture for service or warranty questions at 1-800- 21-6131.