Toshiba 14JL7E Administrator Guide

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY
PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL.
CAUTION: The international hazard symbols " " in the schematic diagram and the parts list designate components
which have special characteristics important for safety and should be replaced only with types identical to those in the
original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.
Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this
model. Do not degrade the safety of the receiver through improper servicing.
NOTE:
1. RESISTOR Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5% tolerance
carbon resistor, unless otherwise noted as the following marks.
1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt
1RF = Fuse resistor of 1 watt 10W = Cement of 10 watt
K = ±10% G = ±2% F = ±1%
2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in F, and
the values more than 1 in pF.
All capacitors are ceramic 50V, unless otherwise noted as the following marks.
Electolytic capacitor Mylar capacitor
3. The parts indicated with " " have special characteristics, and should be replaced with identical parts only.
4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with
all controls at normal, line voltage at 220 volts.
5. Waveforms are taken receiving color bar signal with enough sensitivity.
6. Voltage reading shown are nominal values and may vary ±20% except H.V.
SCHEMATIC DIAGRAM
– 53 –
MODEL : 14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
SCHEMATIC DIAGRAM STRUCTURE:
– LCD Circuit MAIN/SUB [ SHEET– 1/2 ] ..................................... 1/8
– IR-AMP [ SHEET– 2/2 ] ..................................... 2/8
– DIGITAL Circuit INPUTS [ SHEET– 1/6 ] ..................................... 3/8
– GM2221_1 [ SHEET– 2/6 ] ..................................... 4/8
– GM2221_2 [ SHEET– 3/6 ] ..................................... 5/8
– GM2221_3 [ SHEET– 4/6 ] ..................................... 6/8
– POWER [ SHEET– 5/6 ] ..................................... 7/8
– DISPLAY [ SHEET– 6/6 ] ..................................... 8/8

–54 –
CIRCUIT BLOCK DIAGRAM
Speaker L Speaker R Head Phone
E1 Input
C
Y V
L
R
E2 Input
C
Y V
L
R
Yc
Sw
Cr
Cb
MM1495 Switching IC
TV_V
Audio Amp
Audio
Monitor
Out
L/R IN L/R MON
SPK OUT
RF INPUT
QA51
Algista Micon:
MN101E02H**
I2C BUS
Cin
Yin/Vin
Cr in
Cb
RGB
Buffers SCALER
Reset
INVERTER
On/Off
Vdim
KEY BOARD
14JL7 AND 20JL7
ANALOG BOARD
SIGNAL BLOCK DIAGRAM
FBP
GENERATOR
Hout
FP pin
HD VD
LCD
DISPLAY
LVDS SIGNAL
Tuner
H001 (EC981W1)
12 18 23
26
17 25
24

–55 –
CIRCUIT BLOCK DIAGRAM (POWER)
3.3V
Q803
SI-8033JD
5V-1
Q854
BA05FP
DC19V
Fuse, F800
250V, 5A
P800,
AC Adapter
AC INPUT: 240Vac
MOSFET Switch
Q817
TPC8105-H
Power ON/OFF switch
Q819, Q816
5V-Panel
Q806
SI-8050SD
9V-2
Q807
BA09FP
9V-1
Q802
SI-8090JD
32V
D826/D827
MA143A
19V Audio
19V Inverter

– 56 –
MEMO

(1/8)
(Low ESR)
(Low ESR)
DC-IN
to pin 35
U901D
C622
C621
RC13
RC15
RC16
RC14
U901A
LOC
RC12
UNIT
L108
L115
L119
L118
L116
RC17
L642
L104
L643
LZ60 SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
14/20JL7E/H
SHORT
SHORT
OPEN
OPEN
TEM2121M
TEM2121M
TEM2121M
14/20JL7R
TRF9240AC
TEM2121M
TRF9240AC
TRF9240AC
1K
1K
1K
1K
1K
1K
0.01u
TEM2121M
TEM2121M
0.01u
DIFFERENTIAL LIST
LOC
QA51 MN101E02HLB MN101E02HLC
20JL7E/H/C/A/T 20JL7R/M
ALL
to pin 35
to pin 35
to pin 35
+
-1%
to pin 35
to pin 35
EXCELSA26T
1%
-
+
GND
INPUT POWER CH UP CH DN
VOL UP VOL DN
U901B KEY BD
CH UP
POWER
VOL DOWN
CH UP
2
POWER
1
VOL UP
VOL UP
46
INPUT
GND
7
VOL DN
5
INPUT
CH DN
3
CH DOWN
connect to IR-AMP P108B
AUD_GND
to pin 35
to pin 35
to pin 35 to pin 35
R OUT STD BY VCC
GND MUTE L OUT NC L IN GND RF R IN NC
R
CONNECT TO MAIN BOARD
LOUT 4
HEADPHONE BD
ROUT SPK 5
LOUT SPK 3
GND
ROUT 2
1
*
U901D
*
RESET
5V
GND
SCL SDA
5432
1
ALL
LCD_MAIN/SUB
U901A ANALOG MAIN
*
*
**
E1
V
V
R
L
E1-S
R
L
E2
*
*
Y
Cr
Cb
AUDIO OUT
Compornent
L
(Low ESR)
SFPB-64 (Low ESR)
*
*
*
GND
CONNECT TO HEADPHONE JACK PANEL
3
5
4
2
1
ON/OFF
VDIM
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
19V
19V
19V
19V
19V
19V
19V
19V
19V
19V
12
11
10
9
8
7
6
5
4
3
2
1
10
9
8
7
6
5
4
3
2
1
TO DC-AC INVERTER
ITT-SDA
ITT-SCL
LOUT
ROUT
(ANALOG)
(RESIZE UNIT)
TO SCALER
GND
BOUT
GND
GOUT
GND
ROUT
HD
GND
GND
VD
GND
SDA
GND
SCL
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
GND
VCC (5V)
PANEL-5V
GND
RESET
LOUT SPK
80
GND
8183
ROUT SPK
82
GND
SENSOR IN
GND NC STANDBY POWER 5V-1
6543217654321
(Low ESR)SFPB-64
(Low ESR)
(2SB1260Q)
(TENTATIVE)
(Low ESR)
ST-BY(LO)
ON(HI)
W-EURO/ASIA
W-US
(23903235 - SOCKET)
(23009495 - IC)
22.9*22.9
EXCELSA24T
(Low ESR)
SFPB-64
9V-2
5V-2
9V-1
9V-1
AUDIO_GND
AUD_VCC
AUD_VCC
3.3V
3.3V
32V
32V
19V
19V
VIDEO
VIDEO
ROUT
CB
M_ROUT
L_AV R_AV
M_LOUT
M_ROUT
TV_V
VD
HD
CR
C_OUT
C_OUT
POWER
L_AV R_AV
A_MUTE
A_MUTE
SCL
SDA
GOUT
BOUT
5V-PANEL
ITT-SDA
ITT-SCL
SDA
5V-1
5V-1
EX_MUTE
SP_MUTE
SP_MUTE
AFT
AFT
9V-2
SDA SCL
M_LOUT
SCL
34
21
OUT
GND
VCC
3
2
1
B E
C
312
24 7610912118531
OUT
GND
VCC
3
2
1
SWOUT ON/OFF GND Vos Vin
24531
SUB
NC
5
43
2
1
GVou
VCC
5678
3412
SWOUT ON/OFF GND Vos Vin
24531
3
2 1
P13,PWM
BEAMIN
ABLIN
FVCOI
AVSS
FPCO
FSCOUT
AVDD
VOUT
EW
AVDD
FBPIN
AVSS
VCOMP
VMOUT
VIREF
ROUT
GOUT
SIREF
BOUT
AVDD
AVSS
VCOI
PDO
OSC1/
OSC2/
/TESTMD
P03,ADIN3
P00,ADIN0
P01,ADIN1
P02,ADIN2
P10,RMIN
/IRQ0
P11/SDA0
P31/IRQ1
P30/NRST
P27,TM1IO
P26,TM01O
P25,SYSCLK
DVSS
DVDD
P24,PWM2
P23,PWM1
P22,PWM0
P21,SCL1
P20,SDA1
P17,SBO0
P16,SBD0
P15,SBT0
P14,VOUT0
P12/SCL0
P04,ADIN4
DVSS
DVDD
P05,ADIN5
P06,ADIN6
P07,ADIN7
'VDD
@Flash
DVDD
SCOMP
FSCIN
HOUT
HDOWN
EHTIN
CREFL CLL MUIN CLH MVIN CREFH MSCIN YREFL MCOMPIN YREFM YREFH AVSS AVDD P42/IRQ6 PIPUIN P41/IRQ5 PIPVIN P40,TM21O PIPYIN P37,PWM5 PIPSW P35,PWM3 VSYNC
P36,PWM4 HSYNC
P34/1RQ4
/IRQ2
P32
P33/1RQ3
5758 56
78
63 61 6062
76
74
72
71
67
64
65
66
68
70
69
73
75
77
59
81
83
84
82
79
80
515354 52 50
33
4748
36
444546
38
40
43
42
41
39
37
34
35
49
29
30
25
26
23
22
24
28
27
32
31
55
765 983 41 2 10 1312 15 20 211816 17 191411
3
2 1
Sync out
04
I/0 3
VinV
RinV2
LinV2
I/0 2
CinS2
RinS2
Y/VinS2
LinS2
I/0 1
CinS1
RinS1
Y/VinS1
LinS1
VinV1
RinV1
LinV1
VinTV
RinTV
LinTV
24
23
29
27
25
26
28
30
31
37
35
32
33
34
36
38
44
43
41
39
40
423
1
2
6
5
7
4
9
8
13
12
16
18
17
15
19
21
22
20
14
10
11
243 1
6758
3
2 1
ADS VIDEO OUT TV-R OUT TV-L OUT SDA IF-OUT RESET R-OUT L-OUT RF-AGC GND R-IN L-IN SCL +5V GND SDA +9V 32V SCL VT NC NC NC 5V RF-AGC
2 4 6 8 10 12 14 16 18 20 22 24 26252321191715131197531
SWOUT ON/OFF GND Vos Vin
24531
D607
C679
C673
D605 D606
D612
C678
R634
C643
C642
C683
C671
C682
L511
C812
R510R509R508
R504
R503
R210
R209
L509
L508
L504
CA48
C672
C512
C511
C510
C400
C216 C215
C214
GR39
L510
R639
R638
R636 R637
GR38
C821
C854
C818
C801
C210
C802
GJ01
F800
P801
GJ02
Z801
LA85
CA85
C212
R203
R200
GR02
GR01
R204
R201
C213
L502
L505
R635
L644
Q854
R833
P105
Q671
L641
D631
L640
C623
R517
R515
C430
R513
Q509
R516
R522
R514
Q508
Q504
R521
L506
C502 C503
L501
R520
R512
C543
P103B
SA05
SA04
SA03
SA02
SA01
SA06
C515 C513C514
R544
R857
R633
GR15
GR16
C560
C561
GR13
GR14
Q610
Q610A
R172
CC25
CC26
C617
C616
PV06
P101
R624
P611B
P661
R625
C622
C621
P107
P103A
C820
C828
C814
C811
C805
QS01
L604
L603
L601 L602
D609
C823
R856
D853
C824
C832 C833 C835C834
Q810
C804
LA72
LA73
TE4
C208
R221
TLC039
TLC038
TLC214
R401
Q507
R545
C547
RA49
CA50
XA03
RA54
R627
R163
C161
Q102
CV06
CC20
CV03
DV02
QS02
CS15
RS01
QS03
RS23
CS10
RS24
CC10
CV11
QV03
RV29
RV05
QV04
TLC288
R220
CV22
Q506Q505
GR12
R507R506R505
GR55
L122
L121
L120
L117
L114
L113
L112
L111
L110
L119
L118
L116
L115
L108
L104
RC12
RC13
RC14
RC15
RC16
RC17
LZ60
L643
L642
P497P496 P499P498
RS06
RS05
RV30
RV14
RV31
RV16
PV03
PV05
PV07
RV08
CV02
RV09
RV22
RV23
RV27
RS21
R623
C619
RS03
RS22
R629
RS02
CS11
RS20
QS04
RS04
CS29
RS19
Q623
RV35
RV34
RV33
PV04
DV01
RV11
RV10
CV20
CS06
RV12
RV13CS07
RS10
RV15
CS12
CV19
RS11
CS13
DV03
RV40
RV92
QV40
RV41
RV42
CV33
CV01
CV40
CV05
RV91
RV90
R816
R815
Q808
R802
R801
C822
R803
R828
GR04
C813
Q807
D810
R805
D852
D854
Q851
R852 Q853
Q852
R853
R854
R855
C853
D811
Q803
D803
C827
ZP03
C826
L802
RA01
DA01
Q104
CA74
CA09
QA10
GR57
GR56
C420
C221
R219
R222 C209
R216
C206
C200
C201
Q202
R207
Q201
C211 R213
C406
R405
C409
C407 L507
D805
C431
RA50
CA49
CA51
RA13
RA57
RA45RA44RA43
RA58
P611A
L608
R673
D673
D672
C670
D674
R675
R674
Q670
D670
D671
R622
Q611
Q612
R628
R620
R621
L610
L609
L612
L611
R609
R610
D610
D611
R607 R608
R107
R106
D608
L105
C105
C106
L607
C102
L102
L107
L101
C101
C103 C104 C614
C108
C612
R103
R102
R101
R105
R104
L109
CC07
CC08
RS07
RS08
R804
P106
PV02
P610A
C840
TE8
C451
L804
L805
P108A
C836
C501
CA54
DB03
QB03
RB07
RB02
RB01
RB03
CB05
RB47 RB46
QB02
RB06RB04
RB08
QB04
RA40RA42 RA41
RA64 RA67 CA53CA52
CA82
CA61
C499 C410
C204
R420
RA02
ZP06
C838
C825
ZP04
R320
RA05
CC28
CC09
Q161
GR03
RA52
R821
LA01
R164
RA69
RV93
C205
C635
D101
C809
TP15
R402
RA12
R166
R121
C202
RA81
RV07
RV43
D851
R205
R109
Q802
R225
CA72
D801
D604
CA15
R177
RS27
TE2
L801
GR80
D807
RA79
GR48
Q819
C401
R410
L103
R100
RA76
ZP01
C109
GR49
R108
R173
L209
C844
C100
R206
C841
TE5
TP12
R110
RV06
Q812
R412
C852
R814
D602
RA80
Q411
TE3
D827
QA51
R413
C107
C500
GR81
R404
R676
ZP02
RA59
R851
C207
D809
R208
RA72
Q410
L160
C408
R167
Q816
L106
C810
C831
CA60
GR50
D828
LA102
C677
R165
TE6
Q205
D603
RA51
L803
R809
RV04
D804
C633
R677
Q162
R411
RA11
QV01
LA02
C842
DV04
D802
R626
RJ01
Q809
R822
Q164
CA14
L208
C636
TE7
R501
R202
C851
RA04
GR51
Q817
D826
H001
D855
C676
R830
CA77
Q806
CA73
C203
D601
L503
CV04
TE1
GR82
C634
R174
10V47
50V4.7u
UDZS 5.6B UDZS 5.6B
50V4.7u
KETSU
16V470uF
16V470uF
KETSU
25V470
25V470
33u
35V470uF
3.9
3.9
3.9
0.1uF
16V100
25V470
KETSU KETSU
SHORT
33u
SHORT
35V470uF
35V470uF
35V470uF
35V470uF
16V100
35V470uF
OPEN
250V 5A
HTJ-020-05AZ1
OPEN
TEM1065AM
47u COLTRF4470AT
16V100
16V10u
4.7K
4.7K
OPEN
OPEN
4.7K
4.7K
16V10u
TRF4330AT
33u
KETSU
2.2
BA05FP-E2
2W10
KETSU (10P L-TYPE)
KTC2020P
10
MA8160-H
10
0.01u
470
470
0.1uF
120
KTA2014Y
150
270
150
KTA2014Y
KTA2014Y
270
TEM2011AA
10V1000 B25V0.01
TRF43R3AT
270
120
16V10u
CFP2507-0101
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
33p 33p33p
5.1K
2R150
560,1/6W
OPEN
SHORT
16V100
B25V0.01
KETSU
SHORT
AN5277
HEAT SINK
1.2k
KETSU
KETSU
KETSU
KETSU
2P JACK
20P
1/6P220
05FE-BT-VK-N
HTJ-035-17A
1/6P220
OPEN
OPEN
PLUG 5P
CFP2507-0101
35V470uF
10V680uF
10V680uF
10V680uF
16V470uF
2SC4116-Y
KETSU KETSU
TEM2121M
TEM2121M
UDZS 5.6B
KETSU
KETSU
KETSU
KETSU
0.01 0.01 KETSU0.01
KETSU
KETSU
SHORT
SHORT
1P
16V22uF 18k
470
KTA2014Y
120
16V100
2.2k
27p
10.0MHz
1k
47k
820
82p
2SC2412K
50V0.047
10p
16V10
MA8091-M
2SC4116-Y
B25V0.01
10k
2SC3326B
1k
16V10
1k
B1000p
B25V0.01
2SC4116-Y
22k
22k
2SC4116-Y
8.2k
0.1uF
KTA2014Y
KTA2014Y
OPEN
150150150
KETSU
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
OPEN
TEM2121M
TEM2121M
TEM2121M
TEM2121M
TEM2121M
TEM2121M
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
1P1P 1P1P
10K
10K
75
100
75
100
MTJ-032-39BBA-432 NILF
MDC-013V1-A LF
100
B25V0.01
22k
22k
75
75
1k
10k
50V0.47
10k
2.2k
100k
100k
16V10
2.2k
2SC3326B
100k
16V22
100
RN2404
75
75
75
MTJ-032-39BBA-752 NILF
MA8091-M
5.6k
100
0.1uF
50V1.0
100
5.6k
50V1.0
5.6k
100
50V1.0
0.1uF
5.6k
50V1.0
MA8091-M
10k
10k
2SC4116-Y
KETSU
1k
B25V0.01
16V100
B25V0.01
16V22
100
100
KETSU
KETSU
KETSU
KETSU
KETSU
KETSU
KETSU
8.2k
SHORT
16V47uF
BA05FP
KETSU
KETSU
1SS355
KETSU
2SC2412K
4.7K
2SA1037AK
2SC2412K
1K
470
1K
16V47uF
KETSU
SI-8033JP
SFPB-64V
KETSU
2000
220P
68u
10K
1SS355
PST9129NR
10V1u
B25V0.01
AT24C08
KETSU
KETSU
B220p
10V1u
6.8k
680
16V22uF
22k
B25V0.01
16V100
10V1u
2SC2412K
820
2SC2412K
10V1u SHORT
B220p
2.2k
0.01
0.1uF
33u
UDZS 5.6B
16V100u
68
16V10u
27p
100
1k
68K22K
10K1k
05FE-STK-VK-N
TEM2130AM
22K
1SS355
1SS355
KETSU
1SS355 100k
10k
2SA1586-Y
1SS355
1SS355
6.8K
2SC3326B
2SC3326B
6.8K
1.8K
1.8K
TEM2121M
TEM2121M
TEM2121M
TEM2121M
100
100
UDZS 9.1B
UDZS 9.1B
100 100
100 100
UDZS 5.6B
47u
16V10
0.1uF
10u
0.01
LQH13CN680K01
TEM2130AM
TEM2130AM
16V220
50V10uF
1000p
16V10
0.1uF
0.01
100
100
KETSU
5.6k
KETSU
TEM2130AM
B1000p
B1000p
10K
10K
1.5K
12P L-TYPE
MDC-013V1-A LF
PLUG 4P
50V0.1u
1P
KETSU
TEM2011AA
TEM2011AA
06FE-STK-VK-N
KETSU
B25V0.01
0.1uF
RD2.7ESAB2
2SA1162-Y
1k
220
270
10k
16V10u
3.3k 1k
2SC2712Y
1k1k
1k
2SC2712Y
68K10K 22K
33K 33K0.01
0.01
16V47uF
16V100
180p 16V10uF
16V47uF
470
100
2000
0.1uF50V0.1
2000
100
100
10p
B1000p
DTC114EUA
OPEN
KETSU
10k
TEM2011AA
820
100
10k
10V1u
25V1000pF
UDZS 33B
16V47uF
470
4.7k
470
4.7k
10V1u
330
10k
1k
MA8100-M
820
100
SI-8090JD
22k
68p
EU2A
KETSU
68p
200
560
68uH
OPEN
KETSU
4.7k
OPEN
2SC2412K
68p
4.7K
TEM2156AM
KETSU
4.7k
2000
10p
OPEN
OPEN
1k
TEM2028AH
220P
50V2.2
4.7K
50V4.7
1P
470
4.7k
KETSU
KETSU
0.1uF
10k
KETSU
330
2SC2412K
MA143A
MN101E02HXX
470
0.1uF
0.1uF
SHORT
68
2.2k
5000
4.7k
680
10V1u
KETSU
4.7K
4.7k
2SC2412K
10u
33p
OPEN
2SC2412K
TEM2121M
KETSU
0.01
10V1u
OPEN
KETSU
SHORT
50V0.1u
470
2SC2412K
KETSU
KETSU
68u
KETSU
100
SFPB-64V
50V2.2
2.2k
2SC4081-Q
4.7K
4.7k
MM1495XF
SHORT
500V220p
MA8091-M
SFPB-64V
47k
OPEN
KETSU
47K
2SA1576A
68p
TEM2028AH
25V1000pF
5.6K
4.7K
16V1u
100
OPEN
TPC8105-H
MA143A
EC981W1
KETSU
50V0.1u
SHORT
10V1u
SI-8050SD
68p
10V1u
KETSU
33u
50V1.0
OPEN
50V2.2
4.7k
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
++
+
+
+
+
+
++
+
M
+
+
+
M
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
++
+
M
+
M
+
+
+
+
+
M
+
+
+
+
M
+
M
+
+
A
A
A
A
A
A
A
A
20JL7E/20JL7C
14JL7C
20JL7C
F800B
1
F800A
1
VDIM
GND
ON/OFF
INVERTER
GND
1
7
4
3
2
6
5
TO DC-AC INVERTER
19V
GND
19V
7PL-TYPE
25V470
P104
C451 +
SCL
RoutTV
LoutTV
Vout2
Vcc
SDA
CLAMP
BIAS
Address
GND
Yin2
Rout2
Cin2
Lout2
Yin1
Cin1
Rout1
Vout1
Lout1
Yout
Cout
05
19V
19V
15 11
12 13 14
39
38
10
9
19
18
7
8
4
3
40
31
41
6
534
33
32
17
16
21
22
27
23
25
24
26
27
37
30
35
28
29
3
456
789
10
38
39
1112
13
14
15
17
18
34
33
19
16
32
31
41 40
21
24
22
25
23
37
26
27
28
293035
5.0V 32V
5.0V
3.3V
3.3V 3.3V 3.3V
3.3V
3.3V
3.3V
3.3V
19V
5V
9.0V
3.2V
3.2V
3.2V
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
LCD (MAIN/SUB)
SHEET-1/2

U901D
C622
C621
RC13
RC15
RC16
RC14
U901A
LOC
RC12
UNIT
L108
L115
L119
L118
L116
RC17
L642
L104
L643
LZ60 SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
SHORT
14/20JL7E/H
SHORT
SHORT
OPEN
OPEN
TEM2121M
TEM2121M
TEM2121M
14/20JL7R
TRF9240AC
TEM2121M
TRF9240AC
TRF9240AC
1K
1K
1K
1K
1K
1K
0.01u
TEM2121M
TEM2121M
0.01u
DIFFERENTIAL LIST
R
U901A ANALOG MAIN
**
R
L
E2
*
*
Y
Cr
Cb
AUDIO OUT
Compornent
L
TV_V
A_MUTE
CC25
CC26
PV06
QS01
Q102
CC20
CV03
DV02
QS02
CS15
RS01
QS03
RS23
CS10
RS24
CC10
QV04
TLC288
CV22
L114
L113
L112
L111
L110
L116
L115
L108
L104
RC14
RC15
RC16
RC17
P497P496 P499P498
PV03
RV08
CV02
RV09
RV22
RV23
RV27
RS21
R623
C619
RS03
RS22
R629
RS02
CS11
RS20
QS04
RS04
CS29
RS19
Q623
RV35
RV34
RV33
PV04
DV01
RV11
RV10
CV20
CS06
RV12
RV13CS07
RS10
RV15
CS12
CV19
RS11
CS13
DV03
RS07
RS08
PV02
CC28
CC09
Q161
RV93
RV07
R109
R177
RS27
R108
TP12
R110
RV06
C107
L
RV04
DV04
Q164
CV04
KETSU
KETSU
2P JACK
2SC4116-Y
2SC2412K
10p
16V10
MA8091-M
2SC4116-Y
B25V0.01
10k
2SC3326B
1k
16V10
1k
B1000p
2SC4116-Y
0.1uF
OPEN
OPEN
OPEN
OPEN
OPEN
TEM2121M
TEM2121M
TEM2121M
TEM2121M
SHORT
SHORT
SHORT
SHORT
1P1P 1P1P
100
B25V0.01
22k
22k
75
75
1k
10k
50V0.47
10k
2.2k
100k
100k
16V10
2.2k
2SC3326B
100k
16V22
100
RN2404
75
75
75
MTJ-032-39BBA-752 NILF
MA8091-M
5.6k
100
0.1uF
50V1.0
100
5.6k
50V1.0
5.6k
100
50V1.0
0.1uF
5.6k
50V1.0
MA8091-M
10K
10K
MDC-013V1-A LF
10p
B1000p
DTC114EUA
10k
10k
100
200
560
OPEN
470
4.7k
0.1uF
100
MA8091-M
2SA1576A
50V1.0
+
+
+
+
+
+
+
+
+
+
1112
13
14
15 28
293035

W-EURO/ASIA
W-US
9V-1
32V
M_ROUT
L_AV R_AV
A_MUTE
SCL
SDA
5V-1
EX_MUTE
SP_MUTE
AFT
SDA SCL
M_LOUT
Sync out
04
I/0 3
VinV
RinV2
LinV2
I/0 2
CinS2
RinS2
Y/VinS2
LinS2
I/0 1
CinS1
RinS1
Y/VinS1
LinS1
VinV1
RinV1
LinV1
VinTV
RinTV
LinTV
24
23
29
27
25
26
28
30
31
37
35
32
33
34
36
38
44
43
41
39
40
423
1
2
6
5
7
4
9
8
13
12
16
18
17
15
19
21
22
20
14
10
11
ADS VIDEO OUT TV-R OUT TV-L OUT SDA IF-OUT RESET R-OUT L-OUT RF-AGC GND R-IN L-IN SCL +5V GND SDA +9V 32V SCL VT NC NC NC 5V RF-AGC
2 4 6 8 10 12 14 16 18 20 22 24 26252321191715131197531
C671
L511
R172
C617
C616
L604
L603
L601 L602
D609
R163
C161
CV06
CV03
C
V22
DV01
RV11
V
10
RV13
RS10
RV15
V
19
RS11
DV03
RV40
RV92
QV40
RV41
RV42
CV33
CV01
CV40
CV05
RV91
RV90
R673
D673
D672
C670
D674
R675
R674
Q670
D670
D671
R622
Q612
R620
R621
L610
L609
L612
L611
R609
R610
D610
D611
R607 R608
R107
R106
D608
L105
C105
C106
L607
C102
L102
L107
L101
C101
C103 C104 C614
C108
C612
R103
R102
R101
R105
R104
L109
CC28
Q161
GR03
R164
RV93
C635
D101
TP15
R166
RV43
L103
R100
C109
R173
C100
RV06
L160
R167
L106
R165 C633
Q162
DV04
R
6
C636
H001
CV04
C634
R174
25V470
33u
1.2k
KETSU
KETSU
KETSU KETSU
TEM2121M
TEM2121M
UDZS 5.6B
820
82p
50V0.047
16V10
0
.1uF
8091-M
5.6k
00
5.6k
5.6k
100
uF
5.6k
MA8091-M
10k
10k
2SC4116-Y
KETSU
1k
B25V0.01
16V100
B25V0.01
16V22
100
100
22K
1SS355
1SS355
KETSU
1SS355 100k
10k
2SA1586-Y
1SS355
1SS355
6.8K
2
S
2SC3326B
1.8K
1.8K
TEM2121M
TEM2121M
TEM2121M
TEM2121M
100
100
UDZS 9.1B
UDZS 9.1B
100 100
100 100
UDZS 5.6B
47u
16V10
0.1uF
10u
0.01
LQH13CN680K01
TEM2130AM
TEM2130AM
16V220
50V10uF
1000p
16V10
0.1uF
0.01
100
100
KETSU
5.6k
KETSU
TEM2130AM
10p
DTC114EUA
OPEN
820
10k
25V1000pF
UDZS 33B
470
1k
TEM2156AM
KETSU
10p
1k
50V2.2
4.7k
10u
OPEN
TEM2121M
470 50V2.2
2SC4081-Q
MM1495XF
MA8091-M
4
7
25V1000pF
EC981W1
50V1.0
50V2.2
4.7k
+
M
+
+
+
+
+
++
+
+
+
+
+
SCL
RoutTV
LoutTV
Vout2
Vcc
SDA
CLAMP
BIAS
Address
GND
Yin2
Rout2
Cin2
Lout2
Yin1
Cin1
Rout1
Vout1
Lout1
Yout
Cout
05
15 11
12 13 14
30
28
29
6
89
5.0V 32V
5.0V

LOC
QA51 MN101E02HLB MN101E02HLC
20JL7E/H/C/A/T 20JL7R/M
ALL
AUD_GND
R OUT STD BY VCC
GND MUTE L OUT NC L IN GND RF R IN NC
CONNECT TO MAIN BOARD
LOUT 4
HEADPHONE BD
ROUT SPK 5
LOUT SPK 3
GND
ROUT 2
1
U901D
*
*
*
GND
CONNECT TO HEADPHONE JACK PANEL
3
5
4
2
1
ITT-SDA
ITT-SCL
LOUT
ROUT
LOUT SPK
80
GND
8183
ROUT SPK
82
GND
(23903235 - SOCKET)
(23009495 - IC)
22.9*22.9
EXCELSA24T
AUDIO_GND
AUD_VCC
ITT-SDA
ITT-SCL
SDA
SP_MUTE
AFT
SCL
B E
C
312
24 7610912118531
SUB
NC
5
43
2
1
GVou
VCC
5678
3412
P13,PWM
S
IREF
BOUT
AVDD
AVSS
VCOI
PDO
OSC1/
OSC2/
/TESTMD
P03,ADIN3
P00,ADIN0
P01,ADIN1
P02,ADIN2
P10,RMIN
/IRQ0
P11/SDA0
P31/IRQ1
P30/NRST
P27,TM1IO
P26,TM01O
P25,SYSCLK
DVSS
DVDD
P24,PWM2
P23,PWM1
P22,PWM0
P21,SCL1
P20,SDA1
P17,SBO0
P16,SBD0
P15,SBT0
P14,VOUT0
P12/SCL0
P04,ADIN4
DVSS
DVDD
P05,ADIN5
P06,ADIN6
P07,ADIN7
'VDD
@Flash
DVDD
CLL
MUIN CLH MVIN CREFH MSCIN YREFL MCOMPIN YREFM YREFH AVSS AVDD P42/IRQ6 PIPUIN P41/IRQ5 PIPVIN P40,TM21O PIPYIN P37,PWM5 PIPSW P35,PWM3 VSYNC
P36,PWM4 HSYNC
P34/1RQ4
/IRQ2
P32
P33/1RQ3
5758 56
78
63 61 6062
76
74
72
71
67
64
65
66
68
70
69
73
75
77
59
81
83
84
82
79
80
515354 52 50 4748 4445464955
765 983 41 2 10 1312 15 201816 17 191411
D607
C679
C673
D605 D606
D612
C678
R634
C643
C642
C683
C671
C682
R504
CA48
C672
R639
R638
R636 R637
LA85
CA85
L502
R635
L644
Q671
L641
D631
L640
C623
Q504
L501
R633
Q610
Q610A
R624
P611B
P661
LA72
LA73
TE4
R545
C547
RA49
CA50
XA03
RA54
R627
R220
GR12
LZ60
L643
L642
RA01
Q104
CA74
CA09
QA10
R219
C200
C201
RA50
CA49
CA51
RA13
RA57
RA58
P611A
L608
R673
R675
R622
Q611
R628
P610A
TE8
C501
CA54
RA64 CA53CA52
CA82
CA61
4
RA02 RA05
RA52
LA01
RA69
RA12
R121
RA81
CA72
D604
CA15
TE2
RA79
RA76
TE5
D602
RA80
TE3
QA51
C500
R676
RA59
C207
RA72
CA60
LA102
C677
TE6
D603
RA51
R677
RA11
LA02
R626
CA14
C636
TE7
RA04
C676
CA77
CA73
D601
TE1
10V47
50V4.7u
UDZS 5.6B UDZS 5.6B
50V4.7u
KETSU
16V470uF
16V470uF
KETSU
25V470
25V470
0.1uF
16V100
47u COLTRF4470AT
16V100
TRF43
3
KETSU
2.2
KTC2020P
10
MA8160-H
10
0.01u
KTA201
560,1/6W
AN5277
HEAT SINK
1/6P220
05FE-BT-VK-N
HTJ-035-17A
SHORT
SHORT
1P
120
16V100
2.2k
27p
10.0MHz
1k
47k
OPEN
SHORT
SHORT
SHORT
10K
PST9129NR
10V1u
B25V0.01
AT24C08
6.8k
0
1
16V100
68
16V10u
27p
100
1k
1k
05FE-STK-VK-N
TEM2130AM
22K
100k
6.8K
2SC3326B
6.8K
PLUG 4P
1P
B25V0.01
0.1uF
33K 0.01
0.01
16V47uF
16V100
7
uF
100 100
KETSU
TEM2011AA
100
u
4.7k
4.7k
u
330
68p
KETSU
68p
4.7k
4.7k
1P
KETSU
330
MN101E02HXX
0.1uF
2.2k
4.7k
10V1u
4.7k
10V1u
SHORT
50V0.1u
KETSU
KETSU
2.2k
4.7k
SHORT
47k
68p
25V1000pF
100
50V0.1u
10V1u
68p
u
KETSU
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
+
M M
A
A
A
A
A
19V
19V
39
38
10
9
19
18
7
8
4
3
6
5
3
45
78
10
38
39
3.3V 3.3V 3.3V
3.3V
3.3V

to pin 35
to pin 35
to pin 35
to pin 35
+
-
1%
to pin 35
to pin 35
EXCELSA26T
1%
-
+
GND
INPUT POWER CH UP CH DN
VOL UP VOL DN
U901B KEY BD
CH UP
POWER
VOL DOWN
CH UP
2
POWER
1
VOL UP
VOL UP
46
INPUT
GND
7
VOL DN
5
INPUT
CH DN
3
CH DOWN
connect to IR-AMP P108B
to pin 35
to pin 35
to pin 35 to pin 35
N
E BD
*
D
*
(ANALOG)
(RESIZE UNIT)
TO SCALER
GND
BOUT
GND
GOUT
GND
ROUT
HD
GND
GND
VD
GND
SDA
GND
SCL
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
GND
VCC (5V)
PANEL-5V
GND
RESET
SENSOR IN
GND NC STANDBY POWER 5V-1
6543217654321
3.3V
ROUT
VD
HD
GOUT
BOUT
5V-PANEL
BEAMIN
ABLIN
FVCOI
AVSS
FPCO
FSCOUT
AVDD
VOUT
EW
AVDD
FBPIN
AVSS
VCOMP
VMOUT
VIREF
ROUT
GOUT
SIREF
BOUT
AVSS
SCOMP
FSCIN
HOUT
HDOWN
EHTIN
CREFL CLL MUIN CLH
33
36
444546
38
40
43
42
41
39
37
34
35
29
30
25
26
23
22
24
28
27
32
31
20 2118 19
R510R509R508
R504
R503
L509
L508
L504
C512
C511
C510
C400
GR39
C210
L502
L505
R517
R515
C430
R513
Q509
R516
R522
R514
Q508
Q504
R521
L506
C502 C503
L501
R520
R512
C543
P103B
SA05
SA04
SA03
SA02
SA01
SA06
C515 C513C514
R544
GR15
GR16
GR13
GR14
P101
4
P661
R625
C622
C621
P103A
TLC039
TLC038
TLC214
R401
Q507
R545
C547
R220
Q506Q505
R507R506R505
GR55
GR57
GR56
C420
C221
C211 R213
C406
R405
C409
C407 L507
D805
C431
RA45RA44RA43
RA58
L804
L805
P108A
DB03
QB03
RB07
RB02
RB01
RB03
CB05
RB47 RB46
QB02
RB06RB04
RB08
QB04
RA40RA42 RA41
RA67
CA53
C499 C410
R420
R320
R402
C401
R410 R412
Q411
R413
C500
R404
Q410
C408
R411
R501
L503
3.9
3.9
3.9
25V470
SHORT
16V100
TRF4330AT
33u
470
470
0.1uF
120
KTA2014Y
150
270
150
KTA2014Y
KTA2014Y
270
TEM2011AA
10V1000 B25V0.01
TRF43R3AT
270
120
16V10u
CFP2507-0101
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
TSKB-2/JP
33p 33p33p
5.1K
OPEN
SHORT
KETSU
SHORT
20P
H
TJ-035-17A
1/6P220
OPEN
OPEN
CFP2507-0101
470
KTA2014Y
120
16V100
8.2k
KTA2014Y
KTA2014Y
150150150
KETSU
KETSU
KETSU
B220p
10V1u
6.8k
10V1u SHORT
B220p
2.2k
0.01
0.1uF
33u
UDZS 5.6B
16V100u
68K22K
10K1k
TEM2011AA
TEM2011AA
06FE-STK-VK-N
RD2.7ESAB2
2SA1162-Y
1k
220
270
10k
16V10u
3.3k 1k
2SC2712Y
1k1k
1k
2SC2712Y
68K10K 22K
33K0.01
180p 16V10uF
470
100
470
68p
4.7K KETSU
2SC2412K
470
0.1uF
68
2SC2412K
33p
4.7K
5.6K
33u
+
+
+
+
+
+
+
+
A
A
A
19
18
34
33
32
17
16
17
18
34
33
19
16
3.3V
3.3V

(Low ESR)
(Low ESR)
DC-IN
*
*
**
E1
V
V
R
L
E1-S
R
L
E2
(Low ESR)
SFPB-64 (Low ESR)
(LSFPB-64
(Low ESR)
(2SB1260Q)
(TENTATIVE)
(Low ESR)
SFPB-64
34
21
OUT
GND
VCC
3
2
1
SWOUT ON/OFF GND Vos Vin
24531
SWOUT GND Vos Vin
2431
243 1
6758
SWOUT ON/OFF GND Vos Vin
24531
C821
C854
C818
C801
C802
GJ01
F800
P801
GJ02
Z801
Q854
R857
C820
C828
C
C823
C824
CV03
CV11
QV03
RV29
RV05
L122
L121
L120
L117
L119
L118
L116
RC12
RC13
RC14
RS06
RS05
RV30
RV14
RV31
RV16
PV03
PV05
PV07
R816
R815
Q808
R802
R801
C822
Q851
D811
Q803
D803
C827
ZP03
C826
L802
CC07
CC08
RS07
C840
ZP06
ZP04
CC09
R821
C809 Q802
D801
L801
Q819
C844
C852
R814
C8
L803
D804
C842
D802
Q809
R822
Q817
R830
Q806
35V470uF
35V470uF
35V470uF
35V470uF
35V470uF
OPEN
250V 5A
HTJ-020-05AZ1
OPEN
TEM1065AM
BA05FP-E2
2R150
35V470uF
10V680uF
10V
KETSU
KETSU
16V10
B25V0.01
2SC4116-Y
22k
22k
OPEN
OPEN
OPEN
OPEN
TEM2121M
TEM2121M
TEM2121M
SHORT
SHORT
SHORT
10K
10K
75
100
75
100
MTJ-032-39BBA-432 NILF
MDC-013V1-A LF
KETSU
KETSU
KETSU
KETSU
KETSU
KETSU
2SC2412K
KETSU
SI-8033JP
SFPB-64V
KETSU
2000
220P
68u
B1000p
B1000p
10K
50V0.1u
2000
2000
B1000p
10k
16V47uF
SI-8090JD
EU2A
68uH
2SC2412K
220P
0.1uF
10k
KE
68u
SFPB-64V
500V220p
SFPB-64V
KETSU
47K
TPC8105-H
SHORT
SI-8050SD
+
+
+
++
+
+
+
+
+
M
+
+
F800B
1
F800A
1
21
23
27
27
3.3V
19V
5V
3.2V

ALL
(Low ESR)
ST-BY(LO)
ON(HI)
(Low ESR)
9V-2
5V-2
9V-1
AUD_VCC
3.3V
32V
19V
VIDEO
M_LOUT
M_ROUT
C_OUT
POWER
L_AV R_AV
5V-1
9V-2
OUT
GND
VCC
3
2
1
ON/OFF GND Vos
453
3
2 1
3
2 1
VinTV
RinTV
LinTV 44
43
423
1
2
3
2 1
ON/OFF Vos
45
C812
R833
C814
C811
C805
R856
D853
C832 C833 C835C834
Q810
C804
CV03
RV92
R803
R828
GR04
C813
Q807
D810
R805
D852
D854
Q851
R852 Q853
Q852
R853
R854
R855
C853
R804
C836
C838
C825
D851
L801
GR80
D807
ZP01
4
4
C841
Q812
C852
D827
GR81
ZP02
R851
D809
Q816
C810
C831
D828
3
R809
QV01
C842
C851
D826
D855
GR82
35V470uF
2W10
10V680uF
10V680uF
16V470uF
KETSU
KETSU
0.01 0.01 KETSU0.01
KETSU
KETSU
16V10
10k
KETSU
8.2k
SHORT
16V47uF
BA05FP
KETSU
KETSU
1SS355
KETSU
2SC2412K
4.7K
2SA1037AK
2SC2412K
1K
470
1K
16V47uF
1.5K
KETSU
0.1uF50V0.1
MA8100-M
SI-8090JD
68uH
OPEN
KETSU
2000
P
50V4.7
KETSU
0.1uF
MA143A
SHORT
5000
680
KETSU
2SC2412K
KETSU
0.01
KETSU
KETSU
MM1495XF
500V220p
16V1u
MA143A
KETSU
OPEN
+
++
+
M
+
+
+
+
M
M
+
+
Yout
Cout
05
22
27
23
25
24
26
37
30
35
22
25
23
37
26
9.0V
3.2V
3.2V
3.2V

RESET
5V
GND
SCL SDA
5432
1
SUB
NC
5
2
1
VCC
765 983 41 2 10 1312 15 201816 17 191411
R210
R209
C216 C215
C214
L510
GR38
C212
R203
R200
GR02
GR01
R204
R201
C213
C560
C561
P107
C208
R220
DA01
Q104
R219
R222 C209
R216
C206
C200
C201
Q202
R207
Q201
C204
RA02 RA05
C205
R121
C202
R205
R225
L209
R206
C207
R208
GR50
Q205
RJ01
R202
RA04
GR51
C203
KETSU KETSU
33u
SHORT
16V10u
4.7K
4.7K
OPEN
OPEN
4.7K
4.7K
16V10u
16V100
B25V0.01
PLUG 5P
16V22uF
1SS355
PST9129NR
6.8k
680
16V22uF
22k
B25V0.01
16V100
10V1u
2SC2412K
820
2SC2412K
16V47uF
100 100
10V1u
4.7k
10V1u
820
22k
TEM2028A
4.7K
10V1u
4.7K
OPEN
2SC2412K
OPEN
4.7K
100
OPEN
10V1u
++
+
++
+
+
8
40
31
41
41
21
24
2
2
25
3.3V

(1/8)
LCD_MAIN/SUB
ON/OFF
VDIM
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
19V
19V
19V
19V
19V
19V
19V
19V
19V
19V
12
11
10
9
8
7
6
5
4
3
2
1
10
9
8
7
6
5
4
3
2
1
TO DC-AC INVERTER
(ANALOG)
19V
VIDEO
CB
CR
C_OUT
20 2118 19
C
214
P105
P101
C208
R221
R220
C221
R207
P106
C451
GR48
GR49
L209
G
R50
L208
GR51
KETSU (10P L-TYPE)
20P
16V22uF 18k
8.2k
10V1u
6.8k
680
820
12P L-TYPE
KETSU
OPEN
OPEN
TEM2028AH
O
PEN
TEM2028AH
O
PEN
+
+
20JL7E/20JL7C
14JL7C
20JL7C
VDIM
GND
ON/OFF
INVERTER
GND
1
7
4
3
2
6
5
TO DC-AC INVERTER
19V
GND
19V
7PL-TYPE
25V470
P104
C451
+
32
31
40
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
LCD (MAIN/SUB)
SHEET-1/2

(2/8)
Vcc
Rout
GND
321
MTZJ3.6A
50V0.022u
MTZJ3.6A
BL-HUB34C-TRB
50V0.022u
KETSU
6FE-BT-VK-N
BL-HGK34C-TRB
RSIP-A3 V4
100
16V100
0.1uF
D999
C999
D998
DB02
C998
DB04
P108B
DB01
KB01
RB09
CB01
CB02
MM
+
U903 IR BD
20JL7 14JL7
20LB20 20JL8
LCD_IR-AMP
connect to P108A in main unit
5V-1
SENSOR IN
POWER
STANDBY
NC
GND
2154
BLUE LED
63
GREEN LED
RED LED
MA8062-M
D997
2
1
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
LCD (IR-AMP)
SHEET-2/2

(3/8)
20JL7 14JL7
20LB20 20JL8
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (INPUTS)
SHEET-1/6 SH.NO
001

(4/8)
20JL7 14JL7
20LB20 20JL8
SH.NO
002
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (GM2221_1)
SHEET-2/6

(5/8)
SH.NO
003
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (GM2221_2)
SHEET-3/6

(6/8)
20JL7 14JL7
20LB20 20JL8
SH.NO
004
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (GM2221_3)
SHEET-4/6

(7/8)
SH.NO
005
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (POWER)
SHEET-5/6

(8/8)
SH.NO
006
14JL7E/14JL7H/14JL7R/20JL7E/20JL7H/20JL7R
DIGITAL (DISPLAY)
SHEET-6/6